Zephyr AK9440AS Installation guide
LIUHTXLUHGE\ORFDOFRGHV
M4 x 6mm (8)
Wire Caps (3)
#8 x 1/2” (12) 3/16” x 3/8” (10)
Remote Holder (1)RF Remote Control (1)
Duct pieces To t a l
Equivalent number
length x used =
3-1/ 4” x 10”
Rect.,
straight
1 Ft. x ( ) = Ft.
7”-10” Round,
straight
1 Ft. x ( ) = Ft.
3-1/ 4” x 10”
Rect.900
elbow
15 Ft. x ( ) = Ft.
3-1/ 4” x 10”
Rect.450
elbow
9 Ft. x ( ) = Ft.
3-1/ 4” x 10”
Rect.900
flat elbow
24 Ft. x ( ) = Ft.
3-1/ 4” x 10”
Rect.
wall cap
with damper
30 Ft. x ( ) = Ft.
3-1/ 4” x 10”
Rect.to
6” round
transition
5 Ft. x ( ) = Ft.
3-1/ 4” x 10”
Rect.to
6” round
transition
900elbow
20 Ft. x ( ) = Ft.
6” Round,
900elbow
15 Ft. x ( ) = Ft.
6” Round,
450elbow
9 Ft. x ( ) = Ft.
Ft.
6” Round,
straight
1 Ft. x ( ) = Ft.
Subtotal column 1 =
Duct pieces To t a l
Equivalent number
length x used =
6” Round
wall cap
with damper
30 Ft. x ( ) = Ft.
Round
wall cap
with damper
30 Ft. x ( ) = Ft.
7” - 10”
Round,
900elbow
15 Ft. x ( ) = Ft.
7” - 10”
7” - 10”
Round,
450elbow
9 Ft. x ( ) = Ft.
Ft.
Ft.
Ft.
6” Round,
roof cap
30 Ft. x ( ) = Ft.
7” - 10”
Round,
roof cap
30 Ft. x ( ) = Ft.
Subtotal column 2 =
Subtotal column 1 =
Total ductwork =
6” round to
3-1/ 4” x 10”
rect.
transition
1 Ft. x ( ) = Ft.
6” round to
3-1/ 4” x 10”
rect.
transition
900elbow
16 Ft. x ( ) = Ft.
7” round to
3 1/ 4” x 10”
rect.
transition
8 Ft. x ( ) = Ft.
7” round to
3-1/ 4” x 10”
rect.
transition
900elbow
23 Ft. x ( ) = Ft.
26” min.
36” max.
36”
side wall cap
w/ gravity damper side wall cap
w/ gravity damper
Soffit or crawl space
Roof Pitch w/
Flashing & Cap
8”round or
3-1/4”x10” rect.
horizontal ducting 8”round
vertical ducting
8”round
vertical ducting
Top View
3/4 View
Back View
(34”)17-1/4”
(40“)20-1/4”
5-5/8”
1-
1/2
”
C/L
(34”)12”
(40“)15”
2”
elec.
k/o
Ø
7
-
3
/
4
”
10-3/8”
(34”)12”
(40“)15”
elec.
k/o
9-7/8”
C/L
3-1/4”
5-1/2”
7-3/4”
12”
2
2
-
1
/2
”
1
2
”
3”
28-
3/8
”
, 34-3/
8
”
34-
3/8
”, 40-
3/8”
remote
antenna
Cable Lock
LIDSSOLFDEOH
CAUTION: At least two installers are required
due to the weight and size of the insert.
!
34
-
1/
2
” or 40-
1
/2
”
2
2
-
5/
8”
cut out
(AK9434) (AK9440)
9”
9
”
C/L
CABINET BACK
8in Round
4”
11”
5-1/2”
C/L
CABINET BACK
3-1/4in x 10in Rectangular
5-1/2”
1/4”
1-1/8”
1
2
11
2
1
2
11
2
AA
B
C
C
B
1
2
1
LED Lights On/Dim/Off
LCD Screen (speed level, delay off, filter clean,clean air)
Adjust 6 Speed Levels
Power / Delay Off
Power / Delay Off Button
Power Button Function
- Button will turn power on and off for entire insert (fan and lights).
- The insert controls will remember the last speed and light level it was turned off at.
(Example: Press Button to turn off insert when on fan Speed 4 and high lights. Press Button again and the
insert will turn back on at Speed 4 and high lights level.)
Delay Off Button Function
- Press and hold Button for two-three seconds and the fan will turn on Speed 1. The Graphic will illuminate. After five
minutes the fan and lights will automatically turn off.
- Pressing Button while Delay Off Function is enabled will turn the insert off and cancel the Delay Off Function.
Speed Selection Buttons
Fan Speed Decrease Button
- Press this button to decrease fan speed. 6 (burst), 5, 4, 3, 2, 1.
- If fan is on Speed 1 and this button is pressed, fan will power off.
Fan Speed Increase Button
- Press this button to increase fan speed. Fan On, 1, 2, 3, 4, 5, 6 (burst).
- If hood is off and this button is pressed, fan will turn on Speed 1.
Burst Mode
- This speed level is intended to be used as a quick burst of air extraction when excess cooking fumes and smoke are
generated. After 3 minutes the fan will automatically change to Speed 5.
Lights Button
- The Zephyr Bloom LED Lights are two levels, High and Low.
- From off, press one time for High. LCD will show the words “lights hi” for 2 seconds then fade away.
- Press again for Low. LCD will display the words “lights lo” for 2 seconds then fade away.
- Press again to power lights off.
LCD Screen
- Displays status information, see Page 16 for more information.
clean mesh filter
clean air
®
Mesh Filter Clean Indicator (always enabled)
- After 30 hours of fan usage the Graphic and words “clean mesh filter” will illuminate indicating it is time to clean
the mesh filters. Graphic and words will remain illuminated until reset.
- To reset: With insert off, hold the Button for three seconds, after three seconds the Graphic and words “clean mesh
filter” will turn off and the 30 hour timer will reset.
Clean Air Indicator
- Clean Air is a feature that turns the fan on every 4 hours for 10 minutes to remove stagnant air in the kitchen.
- To enable Clean Air Function:
- With insert off, hold the Button and Button simultaneously for three seconds. The Graphic and
words “clean air” will illuminate and the fan will turn on speed 1 for 10 minutes. After 10 minutes the fan
will turn off and the 4 hour timer will begin.
- Graphic will remain on when Clean Air Function is enabled, even if fan is not on.
- To disable Clean Air Function:
- With insert off, hold the Button and Button simultaneously for three seconds until Graphic
turns off.
- If the user changes the fan speed while the Clean Air Function is in use, the words “clean air” will turn off but the Graphic
will remain illuminated. If the user presses the Button at any time the 4 hour clean air timer will reset.
Blower On / Speed Selection
Press to power on blower and cycle through all six blower speeds.
Blower On / Power Off
By pressing , the blowers will power on at the last speed setting. Press
again and the entire hood will power off, including lights.
Delay Off
Lights On / Dim / Off
Switch lights On by pressing once, again to dim and again to switch Off.
Blower On/
Speed Selection 1
1
2
3
4
Blower On/
Power Off
2
5 Min Delay Off 3Lights On/Dim/Off
4
By pressing , the blower and lights will enter Delay Off mode. The
graphic will illuminate indicating the function is on. The blower will change to
speed 1 and shut down after 5 minutes.
A
-
+
FCC Caution: To assure continued compliance, any changes or modifications not expressly approved by the party responsible for compli-
ance could void the user’s authority to operate this equipment. (Example - use only shielded interface cables when connecting to computer
or peripheral device. This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions. (1) This device
may not cause harmful interference, and (2) This device must accept any interference received, including interference that may cause
undesired operation.
1
2
11
2
This manual suits for next models
1
Table of contents
Other Zephyr Ventilation Hood manuals
Zephyr
Zephyr AK1200CW Installation guide
Zephyr
Zephyr Twister Installation guide
Zephyr
Zephyr ZRO-E30BS User manual
Zephyr
Zephyr Spruce AK9834BS Installation guide
Zephyr
Zephyr Cypress AK7836CS Installation guide
Zephyr
Zephyr AK2100AS Installation guide
Zephyr
Zephyr ZMO-E30BS Installation guide
Zephyr
Zephyr Verona ZVO-M90AG Installation guide
Zephyr
Zephyr Milano Wall ZMI-M90BS Installation guide
Zephyr
Zephyr EAL-E42ASX User manual
Zephyr
Zephyr Roma ZRO-E36AS Use Installation guide
Zephyr
Zephyr AK7500BS Installation guide
Zephyr
Zephyr Siena Installation guide
Zephyr
Zephyr ARC ALA-M90ABX User manual
Zephyr
Zephyr Ombra ZOM-E30ABS Installation guide
Zephyr
Zephyr AK9234AS Installation guide
Zephyr
Zephyr Breeze II Installation guide
Zephyr
Zephyr Cypress AK7836ASX Operating manual
Zephyr
Zephyr Slope ESL-M90AS Installation guide
Zephyr
Zephyr AK7000AS Installation guide
Popular Ventilation Hood manuals by other brands
Spagna Vetro
Spagna Vetro E2 Series Installation guide and user's manual
Artusi
Artusi CAID95X Operation manual
Dacor
Dacor DHI361 installation instructions
Sonofresco
Sonofresco COFFEE ROASTER VENTILATION HOOD Installation and operating instructions
Broan
Broan QS130WW instructions
Kuppersbusch
Kuppersbusch IKD 9380.0 GE Instructions for use and installation
THERMEx
THERMEx HeatVex Basic instruction manual
Wolf
Wolf W422418 Planning information
Bosch
Bosch DWK85DK60 User manual and installation instructions
ROBINHOOD
ROBINHOOD RWE3CL6SS Installation and operating instructions
AEG
AEG Electrolux DD8692-M instruction manual
privileg
privileg SY-6010BS-P1-C83-L41-600 user manual