AAT Movilino Installation and operating instructions

Translation of the original user's manual
Pushing and braking aid movilino
GB

CE-Declaration of conformity
The company AAT Alber Antriebstechnik GmbH herewith declares that the
products of the pushing and braking aid movilino were developed and manu-
factured in concordance with the regulations of the European Union, EEC
Guidelines 2007/47/EG and 2006/42/EG.
This declaration becomes void if the above mentioned devices have been al-
tered without the consent of Alber Antriebstechnik GmbH.
Signature of the manufacturer:
Markus Alber
Managing shareholder
AAT Alber Antriebstechnik GmbH
The pushing and braking aid movilino is
being tested according to the norm DIN EN
12184 and 12182 at the institution for cer-
tification of medical products GmbH, Tech-
nical University Berlin.
2
movilino
AAT Alber Antriebstechnik GmbH
Postfach 10 05 60 · D-72426 Albstadt
Tel.: 0 74 31 - 12 95 0 · Fax: 12 95 35
[e-mail] · www.aat-online.de
3102/50_bg_onilivom

3
movilino
Table of contents
CE declaration of conformity ................ 2
Table of contents ...................... 3
1General information..................... 5
1.1 How to use this user's manual ........... 5
1.2 Instruction .................... 5
1.3 Care and maintenance ............... 5
1.4 Warranty and liability................ 5
2Description of the product.................. 6
2.1 Adequate use ................... 6
2.2 Features of the movilino .............. 7
2.3 Technical data................... 9
2.4 Dimensioned sketch ................ 10
2.5 Standard scope of delivery ............. 11
2.6 Optional accessories ................ 11
3Assembly.......................... 12
3.1 Handle ...................... 12
3.2 Brackets ..................... 14
3.3 Attach the battery pack............... 16
3.4 Detach the battery pack .............. 17
3.5 Adjust the handle ................. 17
3.6 Anti-tilt support .................. 18
3.7 Functional check ................. 19
4Safety instructions ..................... 20
4.1 Special information concerning the operation .... 20
4.2 Instruction .................... 21
4.3 Operation / attendant................ 21
4.4 Wear limit ..................... 22
4.5 Lifting capacity .................. 22
4.6 Care and maintenance ............... 22
4.7 Condition of paths, walkways etc. ......... 22
4.8 Charge of the batteries ............... 22
4.9 Power unit..................... 23
4.10 Transport ..................... 23
4.11 Mounting the brackets ............... 23
4.12 Technical requirements .............. 23
5Operation ......................... 24
5.1 Maximum lifting capacity.............. 24
5.2 Battery pack .................... 24
5.3 Power unit..................... 24

6Control and display elements ................ 25
6.1 Control unit .................... 25
6.2 Charge of battery.................. 26
6.3 Control light to indicate malfunction ........ 27
6.4 Trouble shooting .................. 27
6.5 Transport ..................... 28
7Accessories ........................ 29
7.1 Battery pack .................... 29
7.2 Voltage converter for your vehicle .......... 29
8Care, maintenance and recycling .............. 30
8.1 New user ..................... 30
8.2 Charger ...................... 30
8.3 Battery pack .................... 32
8.4 Fuse ....................... 34
8.5 Cleaning ..................... 34
8.6 Recycling ..................... 34
9Warranty and liability .................... 35
9.1 Warranty ..................... 35
9.2 Liability ...................... 35
4
movilino

1General information
Congratulations! The movilino is a pushing and braking aid operated by an
assistant. Special brackets make it possible to mount the movilino easily to
almost any type of wheelchair.
movilino supports the assistant in pushing and braking a wheelchair. It faci-
litates driving on slopes and brakes automatically when going downhill
providing safety.
With the movilino one person could be carried safely and without any effort
up to a increase of 18%. The movilino is suitable for the transportation on
level base; he is compact, light and versatile.
The sticker with the device's serial number is located on the side of the hou-
sing.
1.1 How to use this user's manual
The user's manual is part of the delivery package and instruct you step by
step about the safe and adequate use of the movilino. Operating the movili-
no takes a certain skill.
Please read this user’s manual carefully and particularly take note of the sa-
fety instructions before you use the movilino for the first time.
After reading, please store this user's manual at an appropriate place for
further reference.
1.2 Instruction
In the interest of your safety the movilino a only be operated by trained per-
sonnel.
Instruction on how to operate the device is part of the delivery package and
takes place with your authorized dealer or an AAT representative.
Please read this user’s manual carefully and particularly take note of the sa-
fety instructions before you use the movilino for the first time.
1.3 Care and maintenance
One of the most important aspects concerning the maintenance of the movi-
lino is charging the seal lead acid batteries. They are part of the battery pack
and must be charged every time after using the device.
Other than that your movilino does not need much care or maintenance.
More extensive instructions you find in chapter 8.
1.4 Warranty and liability
For damage that was caused by inadequate use disregarding this manual we
assume no liability whatsoever. (Please read chapter 9 for more detailed in-
formation concerning warranty and liability).
5
movilino

6
movilino
2Description of the product
2.1 Adequate use
Please use the braking and pushing aid movilino exclusively for the trans-
portation of physically disabled persons.
Said person should be able to sit properly without help, otherwise you
should secure them with a safety belt. The latter is an accessory available at
AAT Alber Antriebstechnik GmbH.
In addition, the arms of the person to be transported should not protrude
over the arm rests of the wheelchair during the transportation process.
FIn the interest of your safety you may not use the movilino on escala-
tors or moving belts!
FTransporting other kinds of loads is explicitly prohibited!
FOnly authorized operators may use the movilino. Therefore never
leave the movilino unattended.
FDue to safety reasons the movilino may only be operated by trained
personnel who are physically and intellectually capable to handle
the device in all situations of operation.
FPlease note the wheelchair manufacturer's specifications (wheels'
air pressure, maximum approved total weight, maximum incline,
etc.) when using the movilino. You may under no circumstances ex-
ceed the specified limiting values!
FYou should avoid operating the device on unfortified grounds (sand,
mud, loose gravel, ice or snow) as well as crossing deep puddles
(maximum depth approximately 2.5 cm) with it.

2.2 Features of the movilino
= handle
= column
= brackets
= power unit
= battery pack
7
movilino

2.2.1 Control unit
= safety chip for the engine immobiliser
= ON/OFF switch
= rocker switch forward/backward
= speed control
2.2.2 Overview
= control unit
= tightening knob for the handles' height adjustment
= tightening knob for the column
= light emitting diode
= drive wheels
= small wheels
= lower rod
= recessed handle
= upper rod
= socket for the power cable
= handle
8
movilino

2.3 Technical data
* Limiting values stipulated by the wheelchair manufacturers must be noted
and observed.
** Braking and climbing capacity depend among other things on the weight
of the person to be transported as well as the ground profile, terrain, tempe-
rature, etc.
*** According to ISO 7176-4 the range depends among other things on the
person’s weight, the ground, territory, temperature, etc.
In the interest of progress we reserve the right for technical changes.
9
movilino
measurements
heigth = min. 926 mm, max. 1128 mm
width: handle = 636 mm, power unit= 230 mm
depth: handle = 233 mm, power unit = 307,5 mm
weight
power unit= 11,2 kg
handle unit = 2,4 kg
battery pack = 10,2 kg
power cable = 0,2 kg
bag for batteries plus velcro straps = 0,2 kg
charger = 0,3 kg
total weight = 24,5 kg
limits for mounting the device on a wheelchair seat width of 32 cm or more
max. approved total weight 170 kg (person, wheelchair, movilino)*
speed
continually adjustable
6 km / h forward
3 km / h backward
running-in, slowing period approximately 10 seconds
braking and climbing capacity up to 18 %**
capacity with one battery charge over 21 km***
batteries 2 x 12 V / 16 Ah
direct current motor 24 V / 200 W
storing and operating temperature - 20° C to + 60° C / - 10° C to + 50° C
noise level the device’s A weighted noise level lies typically below
60 dB
vibration specifications the weighted RMS value of acceleration the upper body
is exposed to lies typically below 2,5 m/s².

2.4 Dimensioned sketch
10
movilino