Allen-Bradley 140G-H Installation and operation manual

DIR 1000721R0505 Version 02 - 140G-HT_3-_, 140G-HT_4-_, 140G-JT_3-_, 140G-JT_4-_
Publication 140G-IN099C-EN-P - November 2020
WARNING: To prevent electrical shock, disconnect from power source before
installing or servicing. Install in suitable enclosure. Keep free from contaminants.
70E requirements
Per prevenire infortuni, togliere tensione prima dell'installazione o
manutenzione. Installare in custodia idonea. Tenere lontano da contaminanti.
WARNUNG: Vor Installations- oder Servicearbeiten Stromversorgung zur
Vermeidung von elektrischen Unfällen trennen. Die Geräte müssen in einem
passenden Gehäuse eingebaut und gegen Verschmutzung geschützt werden.
AVERTISSEMENT: Avant le montage et la mise en service, couper l'alimentation
secteur pour éviter toute décharge. Prévoir une mise en coffret ou armoire
appropriée. Protéger le produit contre les environnements agressifs.
ADVERTENCIA: Desconéctese de la corriente eléctrica, antes de la instalación o
del servicio, a fin de impedir sacudidas eléctricas. Instálelo en una caja apropiada.
Manténgalo libre de contaminantes.
ATENÇÃO: Para evitar choques, desconectar da corrente elétrica antes de fazer a
instalação ou a manutenção. Instalar em caixa apropriada. Manter livre de
contaminantes.
警告：感電事故防止のため、取付けまたは修理の際は電源から取り外してく
ださい。適切なケース内に取付けてください。また、汚染物質がないことを
確認してください。
警告：为了防止触电，在安装或维修之前必须先切断电源。安装在合适的设备
箱内。防止接触污染物。
Installation - Installazione - Installation - Installation -
Instalación - Instalação - -
Montaggio sganciatori
Auslöser Montage
Assemblage Dèclencheur
Montaje Relé
脱扣器的安装
Required Tools
Trip Unit Installation for 140G-H, 140G-J
Bul. 140G/140MG
EnergySense, PowerSense,
MotorSense (Electronic Trip Unit) Thermal Magnetic Trip Unit
xx lb-in
xx Nm
PH 1
PH 2
140G-J
140MG-J
CLACK
140G-H
140MG-H
xx lb-in
xx Nm
TX 20

2
DIR 1000721R0505 (Version 02)
Publication 140G-IN099C-EN-P - November 2020
Trip Unit Installation for 140G-H, 140G-J
1
4 5
3
2
CLICK
1
2
140G-H, 140G-J2,-J3,-J6
LENGTH M
9.5 mm (0.37") M 4
COMPLETE BREAKER
ONLY
COMPLETE BREAKER
ONLY
2
1
If present
Se presente
Falls vorhanden
Si présent
Si lo hay
如果存在
PH 1
PH 2
1
2
3
4
3
4
If present
Se presente
Falls vorhanden
Si présent
Si lo hay
如果存在
140G-J0,-J20
PH 1
PH 2
12
3
TX 20

3
DIR 1000721R0505 (Version 02)
Trip Unit Installation for 140G-H, 140G-J
6
7
1
PH 2
140G-H, 140G-J2,-J3,-J6 Frame only 140G-J0,-J20 Frame only
COMPLETE BREAKER ONLY
PH 2
8
9
1
1
2
3
Frame only
Publication 140G-IN099C-EN-P - November 2020

4
DIR 1000721R0505 (Version 02)
Trip Unit Installation for 140G-H, 140G-J
10
13
12
11
14
FRAME ONLY 140G-H, 140G-J
OK!
NO!
140G-H
OK!
NO!
140G-J 140G-H, 140G-J
TX 20
TX 20
Publication 140G-IN099C-EN-P - November 2020

5
15
16
DIR 1000721R0505 (Version 02)
Trip Unit Installation for 140G-H, 140G-J
CLICK
4
3
3
2
1
140G-H, 140G-J2,-J3,-J6
140G-H, 140G-J
2
2
1
1
1.1 Nm
9.7 lb-in
3
If present
Se presente
Falls vorhanden
Si présent
Si lo hay
如果存在
PH 1
PH 2
If present
Se presente
Falls vorhanden
Si présent
Si lo hay
如果存在
0.5 Nm
4.4 lb-in
Publication 140G-IN099C-EN-P - November 2020

DIR 1000721R0505 (Version 02)
Copyright © 2020 Rockwell Automation, Inc. A l l Rights Reserved. Printed in USA.
Product certificates are located in the Rockwell Automation Literature Library: rok.auto/certifications.
Rockwell Automation maintains current product environmental compliance information on its website at rok.auto/pec.
EEE Yönetmeliğine Uygundur.
For Technical Support, visit rok.auto/support.
AMERICAS
EUROPE/MIDDLE EAST/AFRICA
ASIA PACIFIC
expanding human possibility
TM
(ECN000084121) - ECN000127783
6Trip Unit Installation for 140G-H, 140G-J
17
Publication 140G-IN099C-EN-P - November 2020
140G-J0,-J20
3
1
2
4
1.1 Nm
9.7 lb-in
1
2
0.5 Nm
4.4 lb-in
5
If present
Se presente
Falls vorhanden
Si présent
Si lo hay
如果存在
PH 1
PH 2
0.5 Nm
4.4 lb-in