Apex Digital Mobi Mesh User manual

Mobi Mesh
Instruction Manual

CONTENTS
English 1
Español 22
Português 44
MODEL NO:9R-001
PLEASE READ ALL INSTRUCTIONS BEFORE USE.

1
Mobi Mesh / English
Dear Customer,
This manual contains important information you must know about the product.
Please read it thoroughly before use. Please always keep this manual with you.The
Nebulizer’s flow rate will be different by different medicine characteristic; Besides,
when medicine is in low temperature that flow rate will be decrease.
INTENDED USE
Medical purpose Intended user
This product is intended to be used for inhaling medication for respiratory disorders.
Legally certified medical experts, such as doctor, nurse and therapist, or healthcare
personnel or patient under the guidance of qualified medical experts.
Environment
This product is intended for use in a medical facility, such as Hospital,clinic and doctor’s
office, in a room of general household, and in open-air environment with a roof.
Warranty
The Mobi mesh is two-year limited warranted (with exception of mouthpiece, medical cup,
mask) to be free from defective workmanship from date of purchase. Any defective part(s)

2Mobi Mesh / English
will be repaired or replaced at APEX Medical’s option if the unit has not been tampered
with or used improperly during that period. Make certain that any malfunction is not due
to inadequate cleaning or failure to follow the instructions. If repair is necessary, contact
your authorized service personnel for instructions.
NOTE-Be sure to retain a dated proof of purchase document to
verify unit is within 2-year warranty period.
NOTE-This warranty does not cover providing a loaner unit or compensating for costs
incurred in rental while said unit is under repair.
Two years shelf life and six month expected service life is recommended of the single
patient use accessories. Precautions Warnings described in the instruction manual
should be observed.
• The mask system does not contain DEHP .

3
Mobi Mesh / English
IMPORTANT SAFETY INSTRUCTIONS
READ THIS BEFORE USING
When using an electronic appliance, basic precautions should always be followed,
including the follwing.
WARNING:
1. Close supervision is necessary when this appliance is used by, on or near
children, handicapped person or invalids. Besides, the dosage and frequency
of the use also has to be specified by the prescribing physician.
2. Do not operate under the blanket or pillow. Excessive heating can occur and
cause fire, electric shock, or injury to persons.
3. Use this appliance only for its intended use as described in this manual.
4. Do not use cotton swabs or other object to touch the mesh; otherwise,
product will not operate.
5. Do not use different type batteries in the same time.
6. Do not carry or store the product which is still remaining medicine in medical
cup.
7. For the type, dose, and regimen of the medication, be sure to follow the
instructions of a doctor.

4Mobi Mesh / English
8. Do not immerse them in water.
9. Do not use disinfection solution containing sodium hypochlorite.
10. Do not inhale by using water in the medical cup.
11. Do not drop or apply strong shock to the Main unit.
12. Do not use any attachments or accessories not recommended by the
manufacturer.
13. Discard the waste batteries and device according to local law.
14. Do not use the device on top of or close to other eletronic device. FEATURE:
15. This product utilizes piezoelectric vibration to turn liquid drug into fine mist which
is then sent to the respiratory tract and oral cavity by a venting system so that
therapeutic result can be achieved.
16. Piezoelectric vibration which produces 100,000 ~120,000 vibrations per second.
17. Compact and easily to carry.
18. After 20 minutes continuously operation or when the medical cup is no medicine ,
the appliance will automatic shutdown. However, the no-medication detector has
the possibility not function if that mesh blocked by medication.
19. Built-in low-battery indicator.
20. No matter use the product in different angle, that still can operate normally in
short term. When put the product upside down, medicine cannot contact to mesh,
the product still can operate normally in few seconds (it can be different if differ-
ent medicine is in using).

5
Mobi Mesh / English
NOTICE FOR SAFETY OPERATION
To ensure safety,please do follow all rules below:
1. Before using
• Use this appliance in the correct manners outlined in this manual.
• This appliance had to operate within the temperature of 10 C ~ 40 C, outside the
temperature range was not suitable to operate the product.
1. The medicine treatment should according to doctor’s advice.
2. If the product operates improperly, please discontinue to use it and send it for
repairing immediately or consult your dealer.
3. If the medical cup is not functioning very well (such as very low flow rate....etc.),
before using, please replace it.
• When this appliance has not been used for a while, if any part (such as medical
cup, mouthpiece or mask) seems dirty, please proceed with cleaning procedure
described in the cleaning and maintenance procedure.
• Do not add medicine over the indicated line marked on medical cup (8c.c marking).
• Do not disassemble or make any modification on this appliance.
2. When using
• Children or disable patients should be assisted by adults or medical personnel
when using this appliance.
• Do not use this appliance under a high humid environment (>85% RH)

6Mobi Mesh / English
• Do not use this product if the medical cup without any medicine.
• Keep the appliance in horizontal position and steady during operation to avoid
spillage.
• Do not open the cover of medical cup during operation.
• Keep eyes away from the mist output.
• Treatment period please follow the doctor’s advice.
• Different patients should use individual clean medical cups and mouth pieces to
avoid cross infection.
• Some medicine do not nebulizes well, please consult with your doctor.
• This appliance has a low-battery indicator. When the indicator light is green,
the power is good for working. When the power light turns to orange, the battery
is become low, but you still can useproduct, however you may need to replace
battery soon. If the power light is turns red it means voltage is no power to
operate, please replace the battery immediately.
• During using this appliance, if any irregularity or discomfort is observed, please
discontinue use this appliance.
• This product has a built-in timer which shut off automatically in 20 minutes. If it
cannot be shut off automatically, discontinue using and consult your dealer for
help.

7
Mobi Mesh / English
• If product detects no medicine in the medical cup, the LED indicator will turn red
and flash three times then shut off automatically.
• When using, you can use the product in any angles. But, make sure medicine has
good contact with mesh.Please clean all parts after each usage and do follow
instruction in the manual.Do not immerse this appliance in water when cleaning
to avoid damaging any electrical parts.
WARNING: The turbo mode is for self clean purpose only, it can not be used in normal
daily treatment, please consult your local distributor for further instruction.
3. After using
• Please clean all parts after each usage and do follow instruction in the manual.
• Do not immerse this appliance in water when cleaning to avoid damaging any
electrical parts.
• Do not store this appliance in direct sunlight, outside our suggestion storage
temperature and humidity environment.
• Keep this product from the reach of children.

8Mobi Mesh / English
COMPONENTES
1. Power button: Press to turn on or off the appliance.
2. Indicator Light: Indicate the power condition. (Green for normal/Orange for low/Red
for no power). If there is no medicine inside, indicator light will turn red and flash three
times before turn off automatically. However, the no-medication detector has the
possibility of no function if the mesh is blocked by medication.
3. Medical Cup : Contain the medicine. (Suggestion:Replace a new medical cup per year)
4. Push button : Push here to release the medical cup from the main body.
5. Medical cup cover : Open here to pour the medicine.
6. Mouthpiece or Mask.
7. Mesh
8. Battery cover : Open here to replace batteries.

9
Mobi Mesh / English
HOW TO USE
1. Make sure that all parts such as mouthpiece or mask, medical cup are clean, or
clean the above three parts before using.
2. Open the battery cover and put in batteries. (The battery life varied by using
different brands of battery)
Main BODY
Mask Mouthpiece
Medical cup

10 Mobi Mesh / English
1. Remove batteries if the unit is not in use for long periods. Failure to
do so could result in damage due to battery leakage.
2. Discard the waste batteries according to local law.
3. Open the medical cup cover and pour the medicine into medical cup
and close the cover completely.
4. Install mask or mouthpiece properly and start using the appliance.
3 2
• When the power button is pressed and the appliance starts working, the green light will
on (sometimes, in orange and which depend on battery power remained) and the built-in
timer will start to countdown.
• If the indicator turns orange, it shows the battery is low power. If the appliance is
activated and the power indicator turns to red, it means the batteries are no power and the
appliance cannot operate properly. Please replace with new battery immediately.
• If there is no medicine inside the medical cup, indicator light will turn red and flash
three times before appliance turning off automatically.

11
Mobi Mesh / English
CLEAN AND MAINTENANCE NOTICE
Before and after each using, please clean the following parts:
1 2 3
1. Remove the medical cup and mouthpiece or mask.
Discard all remaining medicine in the cup.
• Open the medical cap and discard all remaining medicine.
• Pour in some hot water and close the cover completely.
• Press the power button and operate 1~2minutes to discard all remaining medicine
completely.
Ensure medicine be cleaned completely after each using, otherwise, mesh can be
blocked.
2. Clean the surface of main body of appliance with cotton swabs or a piece of fine
cotton fabrics.
Please clean the electrode in the main body and medical cup, ensure normally
electrical conduction.
Please do not use easily volatility liquid to clean the electrode, ex.benzene, thinner.

12 Mobi Mesh / English
3. Clean the medical cup, mouthpiece and mask with clean water and store at a
safety place after cleaning the surface with ethanol.
Suggestion: Use a new medical cup for different illness or patients to avoid cross
infection.
DISINFECTION
Medical cup can be disinfected by boiling in hot water (90°C):1 min, Validated number
of cycles are 20. After 1 minute boiling, shake off excessive water from the cup, and
let dry on a clean, lint free(paper) towel. Main unit, mask, mouth piece cannot be
boiled.

13
Mobi Mesh / English
TROUBLE SHOOTING
After checking the followings, if any problem still persists, please return the appliance
to your dealer for servicing.
Q1. Press the power button, but no operation
1. Check if the battery voltage is sufficient? When the
appliance’s red indicator light is on, the battery is no power.
Please replace the battery immediately.
2. Discard the waste batteries according to local law.
• Check the battery is installed correctly?
Open battery cover and check if the battery electrode is rusted or not.
Q2. Cannot nebulize or not enough mist output
1. Check if the medical cup is filled with appropriate amount of medicine?
2. The mesh in medical cup blocked by remaining medicine. Cleaning medical cup, if
still can’t solve problem, please replace a new medical cup.
3. The mesh surface(mesh output)has covered by water or medication. Remove
water or medication from mesh surface.
4. Medical cup is not installing properly. Release the medical cup from main body and
push it back again.
Suggestion : Replace a new medical cup per year.

14 Mobi Mesh / English
THE ACCESSORIES
Item Mode no. Size Single patient
reusable
Child Mask 9R-001MS 87.22 x 64.35 x 57 mm YES
Adult Mask 9R-001ML 124 x 77 x 68.5 mm YES
Mouth Piece 9R-001MP 43 x 27.5 mm YES
Medical Cup (Gray) 9R-001MCG 54 x 43.99 x 38.50 mm YES
Adaptor (USA),(not included) 9R-AU 90 x 76 x53 mm N/A
Adaptor (EU),(not included) 9R-AE 90 x 76 x53 mm N/A
Note: In order to provide the optimal performance and avoid device damage, please
use our Genuine AC adaptor. * Our adaptor polarity is represented by the following
symbol.

15
Mobi Mesh / English
ELECTROMAGNETIC COMPATIBILITY
Due to numbers of electronic devices are used in your near environment and when
medical device is in use which may be susceptible to electromagnetic interference
from these electronic devices. Electromagnetic interference may cause incorrect
operation of the medical device and could generate unsafe situation. In order to
prevent unsafe situations, the device is designed and tested following EN60601-1-
2 standard which defines the levels to immunity to electromagnetic interference
as well as maximum levels of electromagnetic emissions for medical device. Even
though the electromagnetic emissions of the device are extremely low, special
precaution still need to be observed:
• It is recommended that you do not place the device on top of or close to
other devices (such as mobile phone). Should you notice any interference
with other electrical devices, keep the device away from those electronic
devices.

16 Mobi Mesh / English
SYMBOLS DESCRIPTION
Class II
Attention, should read the instructions.
Protected against solid foreign objects of 12,5 mm and greater; Protection
against vertically falling water drops .when the enclosure is tilted at an angle up
to 15° from its normal position.
BF symbol, which indicates that this product complies with degree of protection
against electric shock for type BF equipment.
Direct current
Read the documentation symbol
Batch Symbol (yyymmddxxx)
yyy:ROC calender year,mm:month,d:day,xxx:lot no.
Serial number Symbol

17
Mobi Mesh / English
Manufacturer
Authorised representative in the European community.
Refer to instruction manual
CE mark and notified body registration number, the Annex II, excluding Section
4 of EC directive 93/42/EEC have been met.
Reference number
Disposal of Electrical & Electronic Equipment (WEEE):
This product should be handed over to a suitable collection point for
the recycling of electrical and electronic equipment. For more detailed
information about the recycling of this product, please contact your local
city council, household waste disposal service or the retail store where you
purchased this product.
Temperature limitation/temperature range
Humidity limitation/Humidity range

18 Mobi Mesh / English
TECHNICAL DATA
Model Number 9R-001
Power Supply 1.5VX 2, AA size alkaline battery
AC adaptor (Input: 100~240VAC, 0.3-0.15A, 50-
60Hz/ Output: 3VDC, 1.33A)
Power Consumption < 2W
Viberating Frequency 103~123 kHz ±1K
Battery life Up to 1.5 hr if use continously
2 weeks if daily use for 6 min treatment cycle
Battery Indication Full (green), Low (orange), No power (red)
Flow Rate 0.35 ±0.1 mL/min
Particle Size <5μm
AUTO-OFF Time 20 min
Nebulizer AUTO-OFF No medication and no power
Medical Cup Volume 8mL (max.)
Weight 138g (exclude battery)
Dimension 44.5mm (L) x 53.4mm (W) x 121.8mm (H)
Medical Cup Volum 8mL (max.)
Accessory Medical cup, mask (adalt & child), mouthpiece
Operation environment 10~40°C, 30~80%RH
Storage/Transportation -20~70°C, ≤85%RH
Sound Noise level(at 1m distance) 50 dB
Performance may vary with drug such as suspensions or high
viscosity .
More information can be obtained from the relevant medicine
manufacturer.