Breville the Dose Control Pro User manual

the Dose Control™Pro
Instruction Book – BCG


IMPORTANT
SAFEGUARDS
READ ALL
INSTRUCTIONS BEFORE
USE AND SAVE FOR
FUTURE REFERENCE
•Remove and safely
discard any packaging
material and promotional
labels before using the
Breville®Dose Control™
Pro for the first time.
•To eliminate a choking
hazard for young children,
remove and safely discard
the protective cover
fitted to the power plug
of the Breville®Dose
Control™ Pro.
•Do not place the Breville®
Dose Control™ Pro near
the edge of a bench or
table during operation.
•Do not place the Breville®
Dose Control™ Pro on
or near a hot gas burner,
electric element or
where it could touch
aheated oven.
 Breville®Recommends Safety First
 Components
 Functions
 Care & Cleaning
 Coee Making Tips
 Troubleshooting
 Warranty
BREVILLE®
RECOMMENDS
SAFETY FIRST
At Breville® we are very
safety conscious. We design
and manufacture consumer
products with the safety of you,
our valued customer, foremost
in mind. In addition we ask
that you exercise a degree of
care when using any electrical
appliance and adhere to the
following precautions.
Contents


•Do not operate the
Breville®Dose Control™
Pro on a sink drain board.
•Ensure that the surface
is level, clean and
free of water.
•The Breville®Dose
Control™ Pro is not
intended to be operated
by means of an external
timer or separate remote
control system.
•To protect against electric
shock, do not immerse the
grinder base, power cord
or power plug in water or
allow moisture to come in
contact with these parts.
•Always switch the
Breville®Dose Control™
Pro o at the power outlet
and unplug if Breville®
Dose Control™ Pro is to
be left unattended, if not
in use, before cleaning,
before attempting to
move, disassembling,
assembling and
when storing.
•Do not use attachments
other than those provided
with the Breville®Dose
Control™ Pro.
•Do not operate the
Breville®Dose Control™
Pro without locking
the bean hopper lid in
position. Keep fingers,
hands, hair, clothing
and utensils away
from the bean hopper
during operation.
•The coee grinder should
not be switched on until
the bean hopper and
hopper lid are locked
into position in the
grinding chamber.
•Do not operate the
Breville®Dose Control™
Pro, continuously for
longer than 2 minutes
as this could cause
overheating. Allow the
Breville®Dose Control™
Pro to cool down
for 20 minutes after
long operation.
•Do not use the Breville®
Dose Control™ Pro for
any other purpose than
grinding coee beans.


•Do not use pre ground
coee in bean hopper.
TheBreville®Dose
Control™ Pro will not
grind food that is sticky,
orextremely hard, or
make pastes of any fruits,
seeds or herbs i.e. curry
pastes, nut butters.
•Keep the Breville®
Dose Control™ Pro and
accessories clean. Follow
the Care and Cleaning
instructions.
•This appliance shall not
be used by children. Keep
the appliance and its cord
out of reach of children.
•Appliances can be used
by persons with reduced
physical, sensory or
mental capabilities or
lack of experience and
knowledge if they have
been given supervision
or instruction concerning
use of the appliance
in a safe way and if
they understand the
hazards involved.
•Children should be
supervised to ensure that
they do not play with
the appliance.
IMPORTANT
SAFEGUARDS FOR
ALL ELECTRICAL
APPLIANCES
•Unwind the power cord
fully before use.
•Do not let the power
cord hang over the edge
of a bench or table or,
touch hot surfaces or
become knotted.
•To protect against electric
shock, do not immerse
the appliance, power cord
or power plug in water or
any other liquid.
•It is recommended
to regularly inspect
the appliance. Do not
use the appliance if
the power cord, power
plug or appliance
becomes damaged in
any way. Return the
entire appliance to
the nearest authorised


Breville®Service
Centre for examination
and/ or repair.
•Any maintenance,
other than cleaning,
should be performed at
an authorised Breville®
Service Centre.
•This appliance is for
household use only.
Donot use this appliance
for anything other than
its intended use. Do not
use in moving vehicles
or boats. Do not use
outdoors. Misuse may
cause injury.
•The installation of
a residual current
device (safety switch)
is recommended to
provide additional safety
protection when using
electrical appliances.
It is advisable that a
safety switch with a
rated residual operating
current not exceeding
30mA be installed in
the electrical circuit
supplying the appliance.
See your electrician for
professional advice.
•The appliance is not
intended to be operated
by means of an external
timer or separate remote
control system.
•Connect only to a 220
-240V power outlet.
FOR HOUSEHOLD USE ONLY
SAVE THESE INSTRUCTIONS


Components
B
C
D
E
F
G
I
HK
L
J
A


A. Bean Hopper Lid.
Air tight seal to maximise bean freshness.
B. Bean Hopper
340g bean hopper with locking system for
easy removal and bean transfer.
C. Precision Conical Burrs
Maximise particle size for full flavour
potential.
- Removable and Adjustable Upper Burr
D. Grind Size Collar
60 grind settings, from espresso to plunger.
E. GRIND TIME Dial
Adjusts amount to increase or decrease
dose.
F. START|CANCEL Button
Starts, pauses and cancels operation.
G. Grind Outlet
H. 50mm blade
I. Grind Tray
Catches grind overflow. Removable for
easy cleaning and accessing the Razor™
Dose Trimming Tool
ACCESSORIES
J. Adjustable Razor™ Dose Trimming Tool
Trims the puck to the right level for a
consistent extraction.
K. Portafilter Cradle 50–54mm
L. Portafilter Cradle 58mm
NOT SHOWN
Grinding Chamber
Minimises static before dispensing.
Automatic Thermal Safety Shut O
Protects motor from overheating.
Power Saving/Sleep Mode
Unit powers down to standby after
5 minutes of non use.


Functions
GRINDER OVERVIEW
Your Dose Control™ Pro uses Precision Conical
Burrs and can grind whole bean coee suitable
for a range of brewing methods, from the finest
setting for Espresso to the coarsest setting for
Plunger.
The grind amount (dose) for all coee types is
controlled by an electronic timer. The dose for
each brew method can be adjusted by rotating
the GRIND TIME dial and changing the time
the grinder will run. You can grind directly
into a Portafilter, Container or Drip Coee
filter basket.
Within each brew method, Espresso,
Percolator, Drip or Plunger, there is a range of
grind size settings; the grind settings will dier
between each brew method. This is because
each method requires dierent grind sizes for
optimum extraction. Experiment with dierent
grind size settings until you achieve the brew
that best suits your taste.
Rotating the Bean Hopper will turn the Grind
Size Collar to adjust grind size.
BEFORE FIRST USE
Remove and safely discard all promotional
labels and packing materials attached to your
Breville® product. Wash hopper, and cradles in
warm soapy water and dry thoroughly. Wipe
exterior of grinder with a soft damp cloth and
dry thoroughly. Place grinder on flat level
surface and plug power cord into 220-240V
outlet and switch Power 'ON'.
ASSEMBLING YOUR BREVILLE®
CONTROL DOSE™ PRO
Bean Hopper
Align tabs on the base of the bean hopper
and insert hopper into position. Holding the
hopper, press down firmly and turn the bean
hopper dial 45° to lock into position.
A "click" sound will be heard when the hopper
is properly locked in place.
Ensure the hopper and the Grind Size
Collar is aligned properly.
Fill with fresh coee beans and secure lid on
top of bean hopper.
NOTE
If the bean hopper has not been locked into
position, the GRIND TIME dial will not be il-
luminated. This is to disable grinder operation
for safety reasons.


The bean hopper can be removed by
holding the hopper and turning the Dial
anti-clockwise and lifting hopper to remove.
The locking system allows you to remove
and transfer beans in the hopper to a storage
container safely.
GRINDING FOR ESPRESSO COFFEE
Use single wall filter baskets when grinding
fresh coee beans. Use the finer 1–25 settings in
the ESPRESSO range.
ESPRESSO

FINE
0 5 10 15 20
󾙔󾙗
Step 1:
Insert the appropriate portafilter cradle size.
Insert your portafilter into the cradle.
50-54mm
58mm
CRADLES
PUSH
Step 2:
Selecting Grind Amount
Select the desired amount of ground coee
required by turning the GRIND TIME dial.
As a guide, start with 5 secs for a single shot
filter basket or 9 secs for a double shot filter
basket. This will vary depending on the
individual size of your filter basket. Refer to
the Coee Chart as a guide. Rotate the GRIND
TIME dial to adjust the grind time until the
correct dose is achieved. Increasing the time
will increase the dose and decreasing the time
will decrease the dose.
Step 3:
Tamping the Ground Coee
After dosing the portafilter with freshly ground
coee, tamp down with between 15-20kg of
pressure. The amount of pressure is not as
important as consistent pressure every time.


Step :
Trimming the Dose
The adjustable Razor™ Dose Trimming Tool
allows you to trim the puck to the right level
for a consistent extraction.
Select the correct width blade of the Razor™
tomatch the diameter of your filter basket.
TheRazor™ has three blades of varying widths:
mm, mm and mm. The mm and
mm are already fitted within the Razor™
body. The mm is separate.
If you require the mm blade, turn the
adjustment dial past  until the mm blade
is fully extended and able to be pulled from
the body.
ADDITIONAL BLADE
54mm 50mm
If you require the mm blade, turn the
Adjustable Dial past  until the mm blade
isfully extended and able to be pulled from
the body.
54mm
NOTE
The Adjustable Dial may feel tight as you
continue to wind it towards the end of its travel.
Insert the mm blade into the body. Wind
the Adjustable Dial until the blade is retracted
past . Press the mm and mm blades at
the same time, towards the centre of the body
until a “click” sound can be heard.
50mm
‘CLICK’
Adjust the Razor™ to the setting in the table
below for your Breville®espresso machine.
Thisis a starting point for your dose height.
Breville®Espresso
Machine Portafilter Size Dose Height
BES/BES mm 
BES mm .
BES mm .
BESBSS mm .
ES mm 
BES mm 
After tamping the coee, insert the Razor™
into the filter basket until it rests on the rim of
the basket. The blade of the dosing tool should
penetrate the surface of the tamped coee.
If the blade does not penetrate the surface
of the tamped coee, your coee is under
dosed. Increase the amount of dosed coee
byadjusting the GRIND TIME dial.
Rotate the Razor™ back and forth while holding
the portafilter on an angle over the knock box
to trim o a little excess coee.


Refer to the Coee Chart forapproximate
grind size guide.
You will need to extract a shot of espresso
to determine if a change in grind size
and/or grind amount is necessary to achieve
the correct rate of flow. Traditionally, a
single shot of espresso is defined as ~ mls
in  seconds and a double shot of espresso
as ~ mls in  seconds.
NOTE
If the Grind Size Collar is tight, run the
grinder by pressing the START|CANCEL
button while turning the Hopper. This will
release coee grounds caught between
theburrs.
GRINDING INTO A GRINDS
CONTAINER OR COFFEE FILTER
Step :
Remove cradle by sliding out from under the
grind outlet.
PULL
Place your container or coee filter directly
under grind outlet.
Your filter basket is now dosed with the correct
amount of coee for your Breville®espresso
machine.
If using the Razor™ with a non Breville®
espresso machine, you will need to adjust the
depth of the trimmed coee by trial and error
until you achieve approximately a mm gap
between the group head dispersion screen and
the surface of the trimmed coee. Start with a
dose that is too high, i.e. the dispersion screen
leaves an imprint on the surface of the trimmed
coee when inserted and removed from the
group head WITHOUT extracting. Adjust
the height of the dose in small steps until you
achieve this clearance. You will then have the
correct dose height for your espresso machine.
Adjust grind size only until you get the right
rate of espresso flow, while keeping the Razor™
dose height and tamp pressure consistent.
Step :
Select Your Grind Size
For espresso, we recommend starting with
grind size setting  and rotating the Hopper
(to adjust the Grind Size Collar) either
coarser or finer until your preferred flavour
profile is achieved. This should be done in
conjunction with setting the grind amount
(dose).


Step :
Select the required amount of ground coee
byrotating the GRIND TIME dial.
Refer to Coee Chart for approximate grind
amount guide for various brew methods.
Step :
Select Your Grind Size
Rotate the Hopper to adjust the Grind Size
Collar until it reaches the required brewing
method range. Within each brew method,
Percolator, Filter or Plunger, there is a range of
grind size settings. We recommend you start in
the centre of each range, then experiment with
grind size within each range until you get the
flavour balance that suits you.
FEATURES OF YOUR BREVILLE
DOSE CONTROL™ PRO
Pause Function
You can pause the grinder during operation,
allowing you to collapse or settle the coee
inthe Portafilter.
• Press the START|CANCEL button
tostart the grinding operation.
• During grinding, press the
START|CANCEL button to pause
thegrinding operation for up
to  seconds.
The START|CANCEL button will
slowlyflash while paused.
• Press START|CANCEL again within
this time to resume grinding the
remaining dose. Or press and hold
the START|CANCEL button for
 second to cancel.
Manual
Grinding manually allows you to have
complete control over how much coee
is dispensed. Press and hold the
START|CANCEL button to grind for
aslongas you require.
Release START|CANCEL button
tostopgrinding.


COFFEE CHART
Brewing Method Espresso Percolator Drip French Press
or Plunger
Grind Size Fine Medium Medium Coarse Coarse
Grind Setting - - - -
Amount
(Shot/Cup)
mm Portafilter
 secs per shot
 secs per  shots
 secs per cup  secs per cup  secs per cup
mm Portafilter
 secs per shot
 secs per  shots
ADJUSTING CONICAL BURRS
Some types of coee may require a wider grind range to achieve an ideal extraction or brew.
A feature of your Dose Control™ Pro is the ability to extend this range with an adjustable upper
burr. We recommend making only one adjustment at a time.
Hold hopper over container & turn
dial to release beans into container
Align hopper
into position
Run grinder
until empty
Remove hopper
Unlock hopper
1 2 3 4 5
Move adjustable
top burr, 1 number,
coarser or finer
Default setting
is 6
Remove wire
handle from both
sides of the burr
Align the number
with the handle
opening
Remove upper
burr
6
998877 10
Insert wire
handle from both
sides of the burr
11
Push upper burr
firmly into
position
12
Lock upper burr
13
15
Press down
firmly & rotate to
lock into position
16
Check your
extraction
F
I
N
E
C
O
A
R
S
E
3
4
5
6
7
8
F
I
N
E
C
O
A
R
S
E
14
Align hopper
into position
F
I
N
E
C
O
A
R
S
E
4
5
6
7
8
F
I
N
E
C
O
A
R
S
E
4
5
6
7
8
F
I
N
E
C
O
A
R
S
E
3
4
5
6
7
8
AIR TIGHT
CONTAINER
DRIP
30 35


Care & Cleaning
CARE, CLEANING & STORAGE
1. Empty beans from the hopper and grind
out any excess beans (see below).
2. Unplug power cord from power outlet
before cleaning.
3. Wash the hopper lid and bean hopper
in warm soapy water, rinse and dry
thoroughly.
4. Wipe and polish exterior of appliance
with a soft damp cloth.
CLEANING CONICAL BURRS
Regular cleaning helps the burrs achieve consistent grinding results which is especially important
when grinding for espresso coee.
NOTE
Do not use alkaline or abrasive cleaning
agents, steel wool or scouring pads, as these
can damage the surface.
NOTE
Please do not clean any grinder parts
oraccessories in the dishwasher.
Hold hopper over container & turn
dial to release beans into container
Align hopper
into position
Run grinder
until empty
Remove hopper
Unlock hopper
1 2 3 4 5
Clean grind
outlet with
brush
Clean lower
burr with
cleaning brush
Clean upper
burr with a
brush
Push upper
burr firmly into
position
Remove upper
burr
6
998877 10
Lock upper burr
11
Align hopper
into position
12
Lock hopper
13
AIR TIGHT
CONTAINER
DRIP
30 35


MAKING BETTER QUALITY COFFEE
• Freshly ground coee is the key to making
coee with more flavour and body.
• Coee flavour and strength is a personal
preference. Vary the type of coee beans,
amount of coee and grind size to achieve
the flavour you prefer.
• Use freshly roasted coee beans with
a‘roasted on’ date to maximise flavour,
nota use-by or best before date.
• Use coee beans between  and  days
after the ‘roasted on’ date for optimal
freshness.
• Store coee beans in a dark, cool and
dry place. Vacuum seal if possible.
• Buy in small batches to reduce the
storage time.
• Once coee is ground, it quickly loses
itsflavour and aroma. For the best results,
grind beans immediately before brewing.
• Do not store beans in the bean hopper.
Place them back in an airtight container.
• When storing the appliance, run grinder
empty to clear ground beans left
inchamber.
• Run grinder for  seconds to purge some
coee before each use, for maximum
freshness.
• Clean the bean hopper and conical burrs
regularly.
FRENCH PRESS/PLUNGER
Follow these easy steps for a great cup:
. Using a variable temperature kettle, heat
the appropriate volume of water to C.
This is an ideal temperature for brewing
coee. Do not use boiling water.
. Select grind size setting .
. Select the Grind Amount for the number
ofcups you are brewing. Refer to Coee
Chart.
. Place the ground coee in the plunger
vessel.
. Pour the heated water into the plunger in
a swirling manner to ensure all the ground
coee is soaked and the plunger vessel
isfull. The ‘bloom’ (expanding coee and
gases) should reach the top of the plunger.
. Using a timer, wait  minutes.
. Using a spoon, break the ‘crust’ (the bloom
becomes dense and a bit hard).
. Insert the plunger and carefully press
down.
. Do not press too hard. Gently release
pressure by pulling up slightly and press
down again if you have pressed too hard.
Coee Making Tips


Troubleshooting
PROBLEM POSSIBLE CAUSE WHAT TO DO
Grinder does not
start after pressing
START|CANCEL button
•
Grinder not plugged in.
•
Plug power cord into
power outlet.
•
Bean hopper not
attached correctly.
•
Lock bean hopper into position.
Refer to the Bean Hopper section.
•
Grinder has overheated.
•
Remove power plug from power outlet.
Leave for  minutes to cool down
before using again.
Motor starts but no ground
coee coming from
grind outlet
•
No coee beans in bean
hopper.
•
Fill bean hopper with fresh
coee beans.
•
Grinder/bean hopper
is blocked.
•
Remove bean hopper. Inspect bean
hopper and burrs for blockage. Refer to
the Cleaning Conical Burrs section.
Can’t adjust the
Grind Size Collar
•
Grind Size Collar too
tight.
•
Rotate the Bean Hopper to turn the
Grind Size Collar to adjust grind
settings.
•
Coee beans and grinds
caught in the burrs
•
Run the grinder by pressing the
START|CANCEL button while turning
the Hopper.
•
Hopper not installed
correctly.
•
Unlock the hopper and install as per
instruction. Refer to the Bean Hopper
section.
Unable to lock bean
hopper into position
•
Coee beans
obstructing bean
hopper locking device.
•
Remove bean hopper. Clear coee beans
from top of burrs. Re-lock the hopper
into position & try again.
Not enough/too
much coee grind
•
Grind amount requires
adjustment.
•
Use GRIND TIME dial to fine tune the
amount more or less.
Portafilter overfills
•
It is normal for the correct amount
of coee to appear overfilled in your
portafilter. Untamped coee has
approximately three times the volume
oftamped coee.
Emergency stop?
•
Press the START|CANCEL button
topause operation.
•
Unplug power cord from
power outlet.


Warranty
 YEAR WARRANTY
Breville provides product warranty
fordomestic use in specified territories
foryear from date of purchase by faulty
workmanship and materials. During this
warranty period, Breville will provide repairs
and replacement for any defective product
(based on Breville’s Warranty Policy).
Also, all legal warranty rights under
Korea’slegislation will be protected and
willnot be impaired by our warranty. For
fullterms and conditions on the warranty,
aswell as instructions on how to make
aclaim, please visit www.breville.com/kr


Notes

󻻀󻠡󻺸 – BCG
the Dose Control™Pro


󼚭󼐰󼋤󼖠󼝜󼰄
󻹈󼑅󽋴󺯌󾘥󼖠󼍬󾘥󻡄󻉼󾘥󼝜󼰄󼓠󾘥
󼔙󺩼󾘥󺸴󼚭󼍬󾘥󼧔󼘌󽋼󾘥󻾴󾘥󼔤󻅠󻗹󾘥
󻪐󺪜󽋴󼁸󺯌󾘥󻦰󻔩󻁤󻂀
󾘥󾘥󾘥󾘥
󻜘󾘥󼨴󼓨󾘥󻹈󼑅󽋴󺯌󾘥󼖠󼍬󾘥
󻡄󻉼󾘥󽆈󼕁󼕈󼏜󾘥󽂬󼪥󾘥󻔘󻩄󼓠󾘥
󼖸󺨌󽋴󺩼󾘥󼋤󼖠󽋴󺨨󾘥
󽅬󺯌󽋴󼁸󺯌󾘥󻦰󻔩󻁤󻂀󾘭󾘥
󾘥󼍐󻝌󼔐󼓴󾘥󼝤󼁹󾘥󼒠󽍴󼓠󾘥
󻧅󼝜󽋴󺯌󾘥󼒠󽌐󾘥󾘥
󾘥󾘥󼓴󾘥
󼖠󼑬󾘥󽊨󻖈󺮔󼍬󾘥󼕁󼧅󻆸󾘥󻪐󽏔󾘥
󼲀󻨠󻜘󾘥󼖸󺨌󽋴󺩼󾘥󼋤󼖠󽋴󺨨󾘥
󽅬󺯌󽋴󼁸󺯌󾘥󻦰󻔩󻁤󻂀󾘭󾘥
󾘥󼔭󻅵󾘥󼚭󾘥󾘥󾘥
󾘥󻜘󾘥󼘌󻝈󻂜󺸴󾘥
󼻨󼔐󻮰󾘥󺦜󼕁󼔬󻝈󾘥󺮘󼨴󼍬󾘥
󻇬󼁸󻠐󾘥󼋤󾘥󻇅󻁤󻂀󾘭󾘥
󾘥󺩼󼋱󾘥󺦜󼁀󺸴󾘥󼖠󼎐󺯌󾘥󼒠󾘥
󻎬󻀰󾘥󺮘󼨴󾘫󾘥󺦜󼎐󻆸󾘥󼏀󻮬󼍬󾘥
󻂛󼓠󾘥󻾴󾘥󼔤󻀰󾘥󺪏󼍬󾘥󾘥
󾘥󾘥󻜘󾘥
󺼯󼓘󻠐󾘥󼋤󾘥󻇅󻁤󻂀󾘭󾘥
󾘥󾘥󾘥
󾘥󻜘󾘥󼂍󼸈󻂜󾘥
󼓜
󼋤󼖠󼓠󼫸󼑌󻺼󼓘󻗸
󽌅󻁤󻂀
󼓜󾘥󼋤󼖠󼓠󾘥󻞀󼑌󾘥
󼚭󼐰󽋴󺨨󾘥󻹹󺦝󽌅󻁤󻂀󾘭󾘥󻼨󼚭󽋸󾘥
󺩼󺦹󼓴󾘥󼋤󼖠󼓠󾘥󼫸󼑌󻺼󼓘󻗸󾘥
󻹹󺦝󽋴󼎈󾘥󼖸󽈤󼓠󾘥󻻀󺩠󽋴󺩼󾘥
󼖸󼘌󽌅󻁤󻂀󾘭󾘥󼋠󼑔󻖈󾘥󼖠󺯌󾘥󼖸󽈤󼓠󾘥
󻹈󼑅󽋼󾘥󻋨󻀰󾘥󺦝󻩠󽋸󾘥󼚘󼓴󻜘󾘥
󺯌󼑔󼔐󺩼󾘥󻂀󼓨󼓴󾘥󼎤󻧅󾘥󼘌󼯴󻜘󾘥
󼚜󻾴󽌐󾘥󼚘󼁸󺯌󾘥󻦰󻔩󻁤󻂀󾘭
 󼓜󾘥󼋤󼖠󼓠󾘥
󼫸󼑌󻺼󼓘󻗸󾘥󽌅󻁤󻂀
 󼖸󽈤󾘥󺬈󼘌
 󺯌󻁁
 󺪜󻝈󾘥󻦫󾘥󼩉󻼨
 󼲀󽋘󾘥󻝨󻊀󺯌󾘥󽂝
 󻣔󼖸󾘥󽌐󺩌
 󻪐󼜹
󻡅󼧄