Broyhill A102010903 User manual

A102010903/A102010904
810490386/810490387
CASTLE PINES HARD TOP GAZEBO

WARNINGS:
GENERAL BEST PRACTICES FOR ASSEMBLY:
• Please read and understand this entire manual before attempting to assemble or install the product.
• Before beginning assembly of product, make sure all parts are present. Compare parts with package contents list and
hardware contents list. If any part is missing or damaged, do not attempt to assemble the product.
• The assembled gazebo should be located at least 6 feet from any obstruction such as fence, garage, house, overhanging
branches, laundry lines or electrical wires.
• Some parts may contain sharp edges. Wear protective gloves if necessary, during assembly.
• This unit is heavy. For safety, do not assemble this item alone. Four people are recommended for safe assembly.
• Check all nuts and bolts periodically for tightness and, when required, tighten them again.
• Pay attention to the parts orientation
• Install the gazebo on level ground.Stakes are provided to secure the gazebo to the ground.
•Do not assemble the gazebo on sandy, muddy or loose soil, as stakes do not have enough anchorage in these types of
soil.
• If you wish to secure the gazebo to a wood deck or concrete surface, use anchors suited to these surfaces.
• Snow must be cleared off regularly during snowy days.Remove the snow at the roof top when it is thicker than 2 inches.
In order to avoid damage, use a plastic snow rake to remove excessive snow and ice buildup from roof and keep away
from falling debris.
• Do not leave the gazebo where there is a risk of high wind, as possible damage will occur to the structure.
• Any assembly or maintenance of the product must be carried out by adults only.
• Keep all flame and heat sources away from the tent fabric. This tent is made with fabric that meets CPAI-84
specifications for flame resistance. It is not fire proof. The fabric will burn if right in continuous contact with any flame
source.
• Steel components for this gazebo are treated with rust inhibiting paint that protects it from rusting. However, due to the
nature of steel, surface oxidation (rusting) will occur if these protective coatings are scratched. This is not a defect and thus
not covered by the warranty.
• To minimize this condition, it is recommended to use care when assembling and handling the product to prevent scratching
the paint. Should any scratching or damage occur, it is recommended to cover the scratch immediately with rust inhibiting
paint (not included).
• Surface rust can also be easily removed with a very light application of regular cooking oil or WD-40. If surface oxidation
(rusting) occurs and if no measure is taken to prevent this, the oxidation may start dripping onto deck or patio and caused
damaging stains, which may be difficult to remove. This can be prevented if the above-mentioned measures are taken to
keep the product from oxidizing.
• Do not use bleach, acid, or other abrasive cleaners on the roof or frame parts.
• Keep instruction manual for future reference.
• Keep the original packaging to store the gazebo.
• Periodically check and ensure that all bolts are well-tighten during use
WARRANTY:
WHAT IS COVERED ?
The limited warranty is extended to the original purchaser and applies to material and manufacturer’s defect provided
the item is maintained with care and used only for personal, residential purposes.
Warranty: 1 Year
MAINTENANCE:
2/29

EXPLODED DRAWING
3/29

Label Part Number Description Qty Part Image
A P000200557 Post 4
BP006100206 Base cover 4
C P000100405 Baseplate 4
D P000501514 Connector for
slant beam 4
E P000401082 Short screen12
F P000401083 Short screen22
G P000401080 Long screen1 2
JP000401081 Long screen2 2
K P005700789 Short netting tube 4
L P005700787 Long netting tube 4
M P000501515 Connector for
middle beam 4
N P000500239 Big top connector 4
P P000500238 Big roof frame
short side 2
Q P000500237 Big roof frame
long side 2
R P000600327 Slanting beam 4
S P000600355 Middle beam 4
T P000501541 Small connector
for small roof 1
U P000600388 Slant beam for
small roof 4
4/29

V P005800001 Hook 1
W P000600523 Small roof top
beam (short side)2
X P000600537 Small roof top
beam (long side)2
Y P000700889 Small roof cover1 4
AA P000700891 Small roof middle
cover 2
AB P000700890 Small roof cover2 4
AC P000800320 Small roof sloping
beam cover plate 4
AD P000700888 Small top cover 1
AE P000600577 Big roof short
beam1 4
AF P000600713 Big roof left lower
beam(short side)2
AG P000600744 Big roof long
beam 1 4
AJ P000601306 Big roof left lower
beam(long side)2
AK P000600715
Big roof right
lower beam(short
side)
2
AL P000601307
Big roof right
lower beam(long
side)
2
AM P000700892 Big roof middle
cover 1 2
AN P000700893 Big roof middle
cover 2 4
5/29