Carel CloudGate User manual

NO POWER
& SIGNAL
CABLES
TOGETHER
READ CAREFULLY IN THE TEXT!
TECHNICAL LEAFLET
Cloudgate
+0500151ML
Up to date version available on
www.carel.com
Cloudgate
Electrical panel assembly instruction

3
Cloudgate +0500151ML rel 1.0 28.04.2021
ML
GENERAL WARNINGS
CAREL bases the development of its products on decades of experience in HVAC, on continuous investments in technological innovations to products, procedures and strict
quality processes with in-circuit and functional testing on 100% of its products, and on the most innovative production technology available on the market. CAREL and its
subsidiaries/affiliates nonetheless cannot guarantee that all the aspects of the product and the software included with the product respond to the requirements of the final
application, despite the product being developed according to start-of-the-art techniques.The customer (manufacturer, developer or installer of the final equipment) accepts all
liability and risk relating to the configuration of the product in order to reach the expected results in relation to the specific final installation and/or equipment. CAREL may, based
on specific agreements, act as a consultant for the successful commissioning of the final unit/application, however in no case does it accept liability for the correct operation of
the final equipment/system.The CAREL product is a state-of-the-art product, whose operation is specified in the technical documentation supplied with the product or can
be downloaded, even prior to purchase, from the website www.carel.com. Each CAREL product, in relation to its advanced level of technology, requires setup/configuration/
programming/commissioning to be able to operate in the best possible way for the specific application. Failure to complete such operations, which are required/indicated in
the user manual, may cause the final product to malfunction; CAREL accepts no liability in such cases. Only qualified personnel may install or carry out technical service on the
product.The customer must only use the product in the manner described in the documentation relating to the product. In addition to observing any further warnings described
in this manual, the following warnings must be heeded for all CAREL products:
• prevent the electronic circuits from getting wet. Rain, humidity and all types of liquids or condensate contain corrosive minerals that may damage the electronic
circuits. any case, the product should be used or stored in environments that comply with the temperature and humidity limits specified in the manual;
• do not install the device in particularly hot environments. Too high temperatures may reduce the life of electronic devices, damage them and deform or melt the
plastic parts. In any case, the product should be used or stored in environments that comply with the temperature and humidity limits specified in the manual;
• do not attempt to open the device in any way other than described in the manual;
• do not drop, hit or shake the device, as the internal circuits and mechanisms may be irreparably damaged;
• do not use corrosive chemicals, solvents or aggressive detergents to clean the device.
• do not use the product for applications other than those specified in the technical manual. All of the above suggestions likewise apply to the controllers, serial cards,
programming keys or any other accessory in the CAREL product portfolio. CAREL adopts a policy of continual development. Consequently, CAREL reserves the right
to make changes and improvements to any product described in this document without prior warning.The technical specifications shown in the manual may be
changed without prior warning. The liability of CAREL in relation to its products is specified in the CAREL general contract conditions, available on the website www.
carel.com and/or by specific agreements with customers; specifically, to the extent where allowed by applicable legislation, in no case will CAREL, its employees
or subsidiaries/affiliates be liable for any lost earnings or sales, losses of data and information, costs of replacement goods or services, damage to things or people,
downtime or any direct, indirect, incidental, actual, punitive, exemplary, special or consequential damage of any kind whatsoever, whether contractual, extra-con-
tractual or due to negligence, or any other liabilities deriving from the installation, use or impossibility to use the product, even if CAREL or its subsidiaries/affiliates
are warned of the possibility of such damage.
NO POWER
& SIGNAL
CABLES
TOGETHER
READ CAREFULLY IN THE TEXT!
Separate as much as possible the probe and digital input cables from cables to inductive loads and power cables, so as to avoid
possible electromagnetic disturbance. Never run power cables (including the electrical panel cables) and signal cables in the same
conduits.
Fig. 1 Fig. 2
DISPOSAL: INFORMATION FOR USERS
Please read and keep.
With reference to European Union directive 2012/19/EU issued on 4 July 2012 and related national legislation, please note that:
1. Waste Electrical and Electronic Equipment (WEEE) cannot be disposed of as municipal waste but must be collected separately so as to allow subsequent recycling,
treatment or disposal, as required by law;
2. users are required to take Electrical and Electronic Equipment (EEE) at end-of-life, complete with all essential components, to theWEEE collection centres identified
by local authorities.The directive also provides for the possibility to return the equipment to the distributor or retailer at end-of-life if purchasing equivalent new
equipment, on a one-to-one basis, or one-to-zero for equipment less than 25 cm on their longest side;
3. the equipment may contain hazardous substances: the improper use or incorrect disposal of such may have negative effects on human health and on the environment;
4. the symbol (crossed-out wheeled bin, see Figure 1), is shown on the product or on the packaging, indicates that the equipment must be disposed of separately at end-of-life;
5. if at end-of-life the EEE contains a battery (Figure 2), this must be removed following the instructions provided in the user manual before disposing of the equip-
ment. Used batteries must be taken to appropriate waste collection centres as required by local regulations;
6. in the event of illegal disposal of electrical and electronic waste, the penalties are specified by local waste disposal legislation.
Warranty on materials: 2 years (from production date, excluding consumables).
Approval: the quality and safety of CAREL INDUSTRIES S.p.A. products are guaranteed by the ISO 9001 certified design and production system.

4Cloudgate +0500151ML rel 1.0 28.04.2021
ML
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
Project description E.P. CLOUDGATE MOBILE 4G EUROPE
Project code
STD_F26_001
CM000SP041
Supply voltage 1P+E - 230V - 50Hz
Rated current 6A
Auxiliary voltage 24Vac
Designed by Luca Quaggia
Checked by
06/02/2020
NOT ALLOWED DELIVER TO THIRD PARTIES OR REPRODUCE THIS DOCUMENT NOT USE THE CONTENT OR OTHERWISE MAKE KNOWN TO THIRD PARTIES
WITHOUT OUR EXPRESS PERMISSION. ANY INFRINGEMENT WILL RESULT IN DAMAGES SUFFERED. And it MADE SUBJECT TO ALL RIGHTS UNDER PATENTS OR
MODELS
on
Approved by
on
on
Luca Tessaro 14/02/2020
Luca Tessaro 14/02/2020
Rev
Operating temperature 40°C
2
Carel Industries SPA
Via dell'Industria, 11
35020 Brugine, Padova - Italy
tel. [phone]
info: [email protected]
1 2
3
4
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
Project description E.P. CLOUDGATE MOBILE 4G EUROPE
Project code
STD_F26_001
CM000SP041
Supply voltage 1P+E - 230V - 50Hz
Rated current 6A
Auxiliary voltage 24Vac
Designed by Luca Quaggia
Checked by
06/02/2020
NOT ALLOWED DELIVER TO THIRD PARTIES OR REPRODUCE THIS DOCUMENT NOT USE THE CONTENT OR OTHERWISE MAKE KNOWN TO THIRD PARTIES
WITHOUT OUR EXPRESS PERMISSION. ANY INFRINGEMENT WILL RESULT IN DAMAGES SUFFERED. And it MADE SUBJECT TO ALL RIGHTS UNDER PATENTS OR
MODELS
on
Approved by
on
on
Luca Tessaro 14/02/2020
Luca Tessaro 14/02/2020
Rev
Operating temperature 40°C
2
Carel Industries SPA
Via dell'Industria, 11
35020 Brugine, Padova - Italy
tel. [phone]
info: [e-mail]
1 2
3
4
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
Project description E.P. CLOUDGATE MOBILE 4G EUROPE
Project code
STD_F26_001
CM000SP041
Supply voltage 1P+E - 230V - 50Hz
Rated current 6A
Auxiliary voltage 24Vac
Designed by Luca Quaggia
Checked by
06/02/2020
NOT ALLOWED DELIVER TO THIRD PARTIES OR REPRODUCE THIS DOCUMENT NOT USE THE CONTENT OR OTHERWISE MAKE KNOWN TO THIRD PARTIES
WITHOUT OUR EXPRESS PERMISSION. ANY INFRINGEMENT WILL RESULT IN DAMAGES SUFFERED. And it MADE SUBJECT TO ALL RIGHTS UNDER PATENTS OR
MODELS
on
Approved by
on
on
Luca Tessaro 14/02/2020
Luca Tessaro 14/02/2020
Rev
Operating temperature 40°C
2
Carel Industries SPA
Via dell'Industria, 11
35020 Brugine, Padova - Italy
tel. [phone]
info: [e-mail]
1 2 3
4

5
Cloudgate +0500151ML rel 1.0 28.04.2021
ML
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
1
2

6Cloudgate +0500151ML rel 1.0 28.04.2021
ML
3
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
G
G0
24V~/24V
20VA/9W
IP
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
3
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
G
G0
24V~/24V
20VA/9W
IP
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
4
3

7
Cloudgate +0500151ML rel 1.0 28.04.2021
ML
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
PE
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
GND
+
–
G
G0
LAN FIELD
24V~/24V
20VA/9W
LN
3a
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
3c
3b
5

8Cloudgate +0500151ML rel 1.0 28.04.2021
ML
2
LAN FIELD
IP
A
D
F
E
B
C
G
G0
2
LAN FIELD
2G
24V~/24V
20VA/9W
IP
G
G0
2
LAN FIELD
24V~/24V
20VA/9W
IP
6
Only for Antenna remoting
Optional kit
code CM000K0001

9
Cloudgate +0500151ML rel 1.0 28.04.2021
ML
6a 6b
6c 6d
a
d
D
e
A
b
B
B
B
c
C1 C2
6a 6b
6c 6d
a
d
D
e
A
b
B
B
B
c
C1 C2

10 Cloudgate +0500151ML rel 1.0 28.04.2021
ML
D
2
LAN
FIELD
2G
2
LAN FIELD
2G
e
D
F
7
8

CAREL INDUSTRIES - Headquarters
Via dell’Industria, 11 - 35020 Brugine - Padova (Italy)
Tel. [phone] - Fax [phone]
e-mail: [email protected] - www.carel.com Cloudgate +0500151ML rel 1.0 28.04.2021