Caterlite CD562-A User manual

Model
CD562-A
Warming
Tray
Instruction manual
CD562-A_A5_v1_201908020.indb 1 2019/8/20 16:53

2
AU Telephone Helpline: 1300225960
Safety Tips
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components on this product.
• Consult Local and National Standards to comply with the
following:
- Health and Safety at Work Legislation
- Fire Precautions
- Wiring Regulations
- Building Regulations
• DO NOT immerse the appliance in water, or use jet/pressure
washers to clean the appliance.
• DO NOT leave the appliance unattended during operation.
• DO NOT allow the power cord to come into contact with the
hot surface of the appliance.
• Avoid using heavy cast iron vessels with the appliance; these
could damage the glass surface.
• Ensure the vessel base is smooth clean and dry before use.
• Always switch off and disconnect the power supply to the
appliance when not in use.
• Not suitable for outdoor use.
• If the glass surface is cracked disconnect from the power
supply and consult your Caterlite agent or recommended
qualified technician.
• This appliance must only be used in accordance with these
instructions and by persons competent to do so.
• Keep all packaging away from children. Dispose of the
packaging in accordance to the regulations of local authorities.
CD562-A_A5_v1_201908020.indb 2 2019/8/20 16:53

3
AU
Telephone Helpline: 1300225960
• If the power cord is damaged, it must be replaced by a
Caterlite agent or a recommended qualified technician in order
to avoid a hazard.
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience and knowledge, unless they have
been given supervision or instruction concerning use of the
appliance by a person responsible for their safety.
• Children should be supervised to ensure that they do not play
with the appliance.
• Caterlite recommends that this appliance should be periodically
tested (at least annually) by a Competent Person. Testing
should include, but not be limited to: Visual Inspection,
Polarity Test, Earth Continuity, Insulation Continuity and
Functional Testing.
Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of
this machine will provide the best possible performance from your Caterlite product.
Pack Contents
The following is included:
• Caterlite Warming Tray
• Instruction manual
Caterlite prides itself on quality and service, ensuring that at the time of packaging the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your Caterlite dealer immediately.
CD562-A_A5_v1_201908020.indb 3 2019/8/20 16:53

4
AU Telephone Helpline: 1300225960
Operation
Power Switch
Power indicator light
Thermostat
Note: This appliance is designed to keep food warm. DO NOT use it to reheat or
cook food.
1. Connect the appliance to the mains power supply.
2. Turn the power switch to the On [I] position.
3. Turn the temperature control to the desired position.
4. Place the utensil(s) on top of the appliance.
Note: Do not overload the appliance.
Max. Weight: 20kgs
Cleaning, Care & Maintenance
• Disconnect from the power supply and allow the appliance to cool before cleaning.
• Use warm, soapy water and a damp cloth to clean the appliance.
• DO NOT use abrasive cleaners or pads.
• Dry thoroughly after cleaning.
• A Caterlite dealer or qualified technician should carry out repairs if required.
CD562-A_A5_v1_201908020.indb 4 2019/8/20 16:53

5
AU
Telephone Helpline: 1300225960
Troubleshooting
If your Caterlite appliance develops a fault, please check the following table before making a call to the
Helpline.
Fault Probable Cause Solution
The unit is not working The appliance is not switched on Check the appliance is plugged in correctly
and switched on
Plug and lead are damaged Call Caterlite agent or qualified technician
Fuse in the plug has blown Replace the plug fuse
Power supply Check power supply
Internal wiring fault Call Caterlite agent or qualified technician
Technical Specifications
Model Voltage Power Current Max. Load Temperature
range
CD562-A 220-240V~
50/60Hz 230W 1A 20kg 60-105°C
Dimensions
h x w x d mm Weight (kg)
35 x 550 x 350 4.4 kg
CD562-A_A5_v1_201908020.indb 5 2019/8/20 16:53

6
AU Telephone Helpline: 1300225960
Electrical Wiring
The plug is to be connected to a suitable mains socket.
This appliance is wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The product must not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and environmentally safe
recycling process. For further information on how to dispose of this product correctly, contact the product
supplier, or the local authority responsible for waste disposal in your area.
Caterlite parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal authorities.
Caterlite products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of Caterlite.
Every effort is made to ensure all details are correct at the time of going to press, however, Caterlite reserves the right to
change specifications without notice.
CD562-A_A5_v1_201908020.indb 6 2019/8/20 16:53

DECLARATION OF CONFORMITY
Equipment Type
Warming Tray - 550x350x35mm
Model
CD562-A
Legislation
Electrical Safety
Electromagnetic Compatibility
Standards
AS/NZS 60335.1:2011+A1:2012+A2:2014+A3:2015
AS/NZS 60335.2.12:2004 +A1:2009
EN55014-1:2017
EN55014-2:2015
EN61000-3-2:2014
EN61000-3-3:2013
Producer Name
Caterlite
Producer Address
15 Badgally Road,
Campbelltown,
NSW 2560
I, the undersigned, hereby declare that the equipment specified above conforms to the above Legislation and Standard(s).
Date
8th July 2019
Signature
Full Name
Ashley Hooper
Position
Technical & Quality Manager/ Responsible Supplier
CD562-A_A5_v1_201908020.indb 7 2019/8/20 16:53

CD562-A_A5_v1_20190820
CD562-A_A5_v1_201908020.indb 8 2019/8/20 16:53