Caterlite CR912-A User manual

Model:
CR912-A
Pizza Oven
Instruction manual
CR912-A_A5_v1_20230609.indb 1CR912-A_A5_v1_20230609.indb 1 2023/6/9 17:322023/6/9 17:32

2
EN Telephone Helpline: 1300225960
Safety Instructions
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components on this product.
• Consult Local and National Standards to comply with the
following:
- Health and Safety at Work Legislation
- Fire Precautions
- IEE Wiring Regulations
- Building Regulations
• DO NOT immerse the appliance in water.
• Caution, hot Surface!
• The temperature of accessible surfaces may be
high when the appliance is operating. Always wear
oven mittens when removing food.
• The appliance are not intended to be operated by means of an
external timer or separate remote-control system.
• DO NOT obstruct or cover the appliance in any way when in
use.
• DO NOT leave the appliance unattended during operation.
• The appliance should not come into contact or be covered with
easily flammable materials, like curtains, textiles, walls and
the like. Always ensure sufficient safety distance to flammable
materials.
• Always switch off the appliance, disconnect the power supply
and allow to cool before cleaning or carrying out maintenance.
• Always switch off and disconnect the power supply to the
appliance when not in use.
CR912-A_A5_v1_20230609.indb 2CR912-A_A5_v1_20230609.indb 2 2023/6/9 17:322023/6/9 17:32

3
AUEN
Telephone Helpline: 1300225960
• Not suitable for outdoor use.
• Keep all packaging away from children. Dispose of the
packaging in accordance to the regulations of local authorities.
• If the power cord is damaged, it must be replaced by a
Caterlite agent or a recommended qualified technician in order
to avoid a hazard.
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience or knowledge, unless they have been
given supervision or instruction concerning the use of the
appliance by a person responsible for their safety.
• Children should be supervised to ensure that they do not play
with the appliance.
• Caterlite recommend that this appliance should be periodically
tested (at least annually) by a Competent Person. Testing
should include, but not be limited to: Visual Inspection,
Polarity Test, Earth Continuity, Insulation Continuity and
Functional Testing.
Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of
this machine will provide the best possible performance from your Caterlite product.
Pack Contents
The following is included:
• Caterlite Pizza Oven
• Instruction manual
Caterlite prides itself on quality and service, ensuring that at the time of unpacking the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your Caterlite dealer immediately.
CR912-A_A5_v1_20230609.indb 3CR912-A_A5_v1_20230609.indb 3 2023/6/9 17:322023/6/9 17:32

4
EN Telephone Helpline: 1300225960
Installation
1. Remove the appliance from the packaging. Make sure that all protective plastic film and coatings are
thoroughly removed from all surfaces.
2. Maintain a distance of 20cm (7 inches) between the unit and walls or other objects for ventilation.
Before first time use:
• Let the appliance run at the highest temperature (300°C) for 5 minutes to
burn off any manufacturing residues.
• After cooling down, clean the interior and the 2 removable trays with soapy
water then dry well.
Operation
Baking tray
Heating
element
Timer
Power switch with
indicator light
Thermostat
Crumb
tray
1. Insert the baking tray then close the door. Ensure the crumb tray is in place.
2. Connect the appliance to the mains power supply.
3. Set the thermostat to the desired temperature.
4. Turning on: Set the power switch to “I” (on position). The indicator light illuminates indicating the
appliance begins to heat up.
5. The indicator light goes out when the set temperature is reached. Pull the baking tray to put food
then push back into place.
6. Set the timer to the desired baking time. The time can be adjusted during the baking process.
• During use, the indicator light keeps on and off constantly, indicating the set
temperature is kept.
• The timer is just a reminder. Even after it returns to OFF, the appliance is still running.
7. Turning off: Set the thermostat to “0” and power switch to “O” consecutively. Then disconnect from
the power supply.
CR912-A_A5_v1_20230609.indb 4CR912-A_A5_v1_20230609.indb 4 2023/6/9 17:322023/6/9 17:32

5
AUEN
Telephone Helpline: 1300225960
Cleaning, Care & Maintenance
Switch off and disconnect the appliance from the power supply. Allow to cool
down before cleaning.
• Clean the interior of the appliance as often as possible.
• Do not use abrasive cleaning agents. These can leave harmful residues.
• For stains on the interior walls, wipe with a cloth damped with some mild soapy solution. Ensure no
moisture enters the inside of the cabinet.
• Always wipe dry after cleaning.
Cleaning the 2 removable trays
• After each use, remove the trays from the oven for cleaning.
• Clean using warm, soapy water. Rinse thoroughly and dry well.
• Re-locate into the oven.
Troubleshooting
A qualified technician must carry out repairs if required.
Fault Probable Cause Solution
The unit is not working The unit is not switched on Check the unit is plugged in correctly
and switched on
Plug or lead is damaged Replace plug or lead
Mains Power supply fault Check Mains Power supply
Appliance heats up but indicator
light does not come on
Bulb has expired Contact a qualified technician
Indicator light comes on but
appliance does not heat up
Faulty thermostat Contact a qualified technician
Faulty heating elements Contact a qualified technician
Thermostat set incorrectly Check thermostat
Appliance slow to heat up Cooking surface not clean Clean cooking surface
Faulty heating elements Contact a qualified technician
Technical Specifications
Note: Due to our continuing program of research and development, the specifications herein may be
subject to change without notice.
Model Voltage Power Pizza size Dimensions
h x w x d mm Weight
CR912-A 220-240V~ 50/60Hz 1130W 12”/305mm (Ø) 188 x 486 x 380 8.2kg
CR912-A_A5_v1_20230609.indb 5CR912-A_A5_v1_20230609.indb 5 2023/6/9 17:322023/6/9 17:32

6
EN Telephone Helpline: 1300225960
Electrical Wiring
The plug is to be connected to a suitable mains socket.
This appliance is wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The product must not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and environmentally safe
recycling process. For further information on how to dispose of this product correctly, contact the product
supplier, or the local authority responsible for waste disposal in your area.
Caterlite parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal authorities.
Caterlite products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of Caterlite.
Every effort is made to ensure all details are correct at the time of going to press, however, Caterlite reserve the right to
change specifications without notice.
CR912-A_A5_v1_20230609.indb 6CR912-A_A5_v1_20230609.indb 6 2023/6/9 17:322023/6/9 17:32

DECLARATION OF CONFORMITY
• Conformiteitsverklaring • Déclaration de conformité • Konformitätserklärung • Dichiarazione di conformità •
• Declaración de conformidad
Equipment Type • Uitrustingstype • Type d'équipement • Gerätetyp
• Tipo di apparecchiatura • Tipo de equipo
Model • Modèle • Modell • Modello
• Modelo
Pizza Oven
CR912 (-E &-A)
Application of Territory
Legislation & Council
Directives(s)
Toepassing van Europese
Richtlijn(en) • Application de
la/des directive(s) du Conseil •
Anwendbare EU-Richtlinie(n) •
Applicazione delle Direttive
• Aplicación de la(s) directiva(s)
del consejo
Low Voltage Directive (LVD) - 2014/35/EU
Electrical Equipment (Safety) Regulations 2016
(BS) EN 60335-1:2012 +A11:2014 +A13:2017 +A1:2019
+A14:2019 +A2:2019
(BS) EN 60335-2-36:2002 +A1:2004 +A2:2008
+A11:2012
(BS) EN 62233:2008
Electro-Magnetic Compatibility (EMC) Directive
2014/30/EU - recast of 2004/108/EC
Electromagnetic Compatibility Regulations 2016 (S.I.
2016/1091)
(BS) EN 55014-1:2017
(BS) EN 55014-2:2015
(BS) EN IEC 61000-3-2: 2019
(BS) EN 61000-3-3: 2013 +A1:2019
Restriction of Hazardous Substances Directive (RoHS)
2015/863 amending Annex II to Directive 2011/65/EU
Restriction of the Use of Certain Hazardous
Substances in Electrical and Electronic
Equipment Regulations 2012 (S.I. 2012/3032)
Electrical Safety
IEC 60335-1:2010 +A1:2013
+A2:2016
IEC 60335-2-36:2002 +A1:2004
+A2:2008
Electromagnetic Compatibility
EN 55014-1:2017
EN 55014-2:2015
EN IEC 61000-3-2: 2019
EN 61000-3-3: 2013 +A1:2019
Producer Name • Naam fabrikant • Nom du producteur • Name des Herstellers
• Nome del produttore • Nombre del fabricante
Caterlite
I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation, Directive(s)
and Standard(s).
Ik, de ondergetekende, verklaar hierbij dat de hierboven gespecificeerde uitrusting goedgekeurd is volgens de bovenstaande
Richtlijn(en) en Standaard(en).
Je soussigné, confirme la conformité de l'équipement cité dans la présente à la / aux Directive(s) et Norme(s) ci-dessus
Ich, der/die Unterzeichnende, erkläre hiermit, dass das oben angegebene Gerät der/den oben angeführten Richtlinie(n) und
Norm(en) entspricht.
Il sottoscritto dichiara che l'apparecchiatura di sopra specificata è conforme alle Direttive e agli Standard sopra riportati.
El abajo firmante declara por la presente que el equipo arriba especificado está en conformidad con la(s) directiva(s) y
estándar(es) arriba mencionadas.
Date • Data • Date • Datum •
Data • Fecha
8th June 2023
Signature • Handtekening •
Signature • Unterschrift Firma •
Firma
Full Name • Volledige naam •
Nom et prénom • Vollständiger
Name • Nome completo •
Nombre completo
Ashley Hooper
Eoghan Donnellan
Brendan Denmeade
Position • Functie • Fonction •
Position • Qualifica • Posición
Technical & Quality
Manager
Commercial Manager/
Importer
Commercial Manager/ Responsible
Supplier
Producer Address • Adres
fabrikant • Adresse du
producteur • Anschrift des
Herstellers • Indirizzo del
produttore • Dirección del
fabricante
Fourth Way,
Avonmouth,
Bristol,
BS11 8TB
United Kingdom
Unit 9003,
Blarney Business Park,
Blarney,
Co. Cork
Ireland
15 Badgally Road,
Campbelltown
NSW 2560
DocuSign Envelope ID: 26462E7E-1623-4555-9739-56790C8B12CE
CR912-A_A5_v1_20230609.indb 7CR912-A_A5_v1_20230609.indb 7 2023/6/9 17:322023/6/9 17:32

CR912-A_A5_v1_2023/06/09
CR912-A_A5_v1_20230609.indb 8CR912-A_A5_v1_20230609.indb 8 2023/6/9 17:322023/6/9 17:32