CleanSpace HALO User manual

QUICK START
GUIDE
CleanSpace HALO
CleanSpace PRO
CleanSpace ULTRA
CleanSpace Technology Pty Ltd
ABN 24 146 453 554
T: [phone]
Unit 5, 39 Herbert Street
St. Leonards NSW 2065 Australia
www.cleanspacetechnology.com
[e-mail]

CleanSpace Respirator Approved Configurations
NOTE: USA users must consult the NIOSH Respirator Approval Label provided with each CleanSpace Respirator for the NIOSH-approved configurations.
CleanSpace Respirator Approval Information
CleanSpace HALO
Notified Body: BSI (2797); Say Building, John M. Keynesplein, 1066 EP Amsterdam, Netherlands
Standard: EN12942:1998/A2:2008 Regulation: (EU) 2016/425
Classification: TM3 Category: III
DOC: cleanspacetechnology.com/eu2016-425/ Modules: B and D
Approved Body: BSI (0086); Kitemark Court, Davy Avenue, Knowlhill, Milton Keynes, MK5 8PP
Standard: BS EN12942:1998/A2:2008 Regulation: (EU) 2016/425 as brought into UK Law and amended
Classification: TM3 Category: III
DOC: cleanspacetechnology.com/eu2016-425/ Modules: B and D
CleanSpace PRO
CleanSpace ULTRA
Notified Body: Apave Exploitation France SAS (0082); 6 Rue du Général Audran - 92412 COURBEVOIE Cedex - France
Standard: EN12942:1998/A2:2008 Regulation: (EU) 2016/425
Classification: TM3 Category: III
DOC: cleanspacetechnology.com/eu2016-425/ Modules: B and D
Approved Body: PARC (8509); Unit 4, Alverdiscott Road Industrial Estate, Bideford, Devon, EX39 4LQ
Standard: BS EN12942:1998/A2:2008 Regulation: (EU) 2016/425 as brought into UK Law and amended
Classification: TM3 Category: III
DOC: cleanspacetechnology.com/eu2016-425/ Modules: B and D

CleanSpace Respirator Quick Start Guide
Please read the entire CleanSpace Respirator Quick Start Guide before using a CleanSpace Respirator. To view additional
instructions and product information, go to cleanspacetechnology.com/product-resources/. Before use, refer to the
relevant national standards in each local region and review methods to determine that a satisfactory fit test of your
CleanSpace Respirator has been achieved.
1. Warnings & Limitations
CleanSpace is a powered air purifying respirator (PAPR) and should be used with the battery charged and in Power-On
mode. CleanSpace Respirators are intended to protect against substances and mixtures which are hazardous to health.
If your CleanSpace Respirator is intrinsically safe, it will be clearly marked as such. Do not use non-intrinsically safe
respirators in flammable or explosive atmospheres. Do not use in IDLH, or in oxygen enriched or deficient atmospheres.
Do not submerge the respirator in water. Do not use compressed air or a brush to clean the filter.
Operating Conditions: 0% - 90% RH, -10°C to 45°C. Storage Conditions: 0% - 75% RH, 10°C to 30°C.
Manufacturers Minimum Design Condition/Duration: CleanSpace Respirators will maintain positive pressure in the mask
up to 120 l/min. Minimum 4-hour duration. The user must do a Flow Test to check the design condition before each use.
During pre-use visual inspection, if parts are missing or damaged replace them with approved parts before proceeding.
European users should be aware that all markings on the filter refer to the standard EN 12942 (1998) + A2 (2008).
2. System Description
2.1. ALARMS
A. Filter Change Alert –Two (2) beeps, Filter Alarm Light will flash. Change filter before entering the contaminated area.
B. Low Battery Alarm –Three (3) beeps. Less than 15 minutes runtime. Leave the contaminated area immediately.
C. Filter Absent Alarm (CST1002 & CST1012) –Constant beep, Filter Alarm Light will flash. Install filter before entering
the contaminated area.
2.2. BATTERY, FILTERS & PRE-USE PROCESS
Charge Battery Replace Filter Visually inspect all
parts before use Recalibrate Unit Flow Test –Battery &
Filter Lights Flash = FAIL
3. Donning the CleanSpace PAPR
Assemble Turn On Don Adjust
Assemble Turn On Don Adjust
4. Care and Cleaning
Cleaning or disinfectant wipes can be used to wipe down the components. Use a clean cloth to remove any cleaning
residue before use. The mask, harness and neck support can be washed with a mild detergent in warm water (less than
50°C). Power units should not be submerged in water. CleanSpace Filters cannot be cleaned. Unopened filters have a
limited storage life of five (5) years.
S008-7015 Rev 4, 7th March 2023, Released on Change Note ECN1993.
Full Face Mask
Half Mask