Courtyard Creations TRS66LG User manual

ASSEMBLY INSTRUCTIONS
ATTENTION: THIS PRODUCT IS NOT FOR COMMERCIAL USE
INTENDED FOR RESIDENTIAL USE ONLY.
Step 1:
Place the table top (#1) onto a non-abrasive surface,
such as a carpet, with its underside facing upwards.
Fasten the legs (#2) to the underside of the table top
(#1) rim by using bolts (#4) and washers (#6). Keep the
bolts loose. See Figure 1.
FIGURE 1
1
2
2
2
2
COURTYARD CREATIONS INC.
PAGE 1 OF 2
SERVICE CENTER TOLL FREE NO.
TEL: [phone]
FAX: [phone]
Attention:
Make sure that each bolt needed for all steps matches
the corresponding figure to ensure proper assembly.
Use the correct bolts as indicated. Do not tighten any of the bolts until the table is completely assembled.
Do not sit or stand on this table.
A weighted umbrella base must be used when using an umbrella with this table.
Do not discard of any of the packaging until you have checked that you have all of the parts and
fittings required.
Keep children away during assembly. This item contains small parts that can be swallowed by
children. Children should always be under direct adult supervision while using this product.
Retain these assembly instructions for future reference.
Quote the following FQC NO. when contacting the service center.
!
!
!
!
!
!
!
LEG
TABLE TOP
TRS66LG
PARTS LIST
PART
NO. MATERIAL CODE PART Q’TY PART NO. MATERIAL CODE PART Q’TY
1
2
3
4
1
4
1
5
7
6
8
9
10
TRS66LG-CS05-1
TRS66LG-CS04-1
CENTER
CONNECTOR WITH RING
62TGS65LDY101
4
BOLT M6*25
17C33A0709001Y4
BOLT M6*16
8
17C01A0706001Y4
BOLT CAP M6
BOLT CAP
WASHER d6.5*D13*1.0
4
8
12
17FA05040301-Y4
18000337004
18000337001
HEX.KEY WRENCH 4MM
1
17KAA0101----Y4
16
#4 BOLT M6*16
4
6
7
4
6
7
STOP DON’T RETURN TO STORE!
1
1404025
TOUCH-UP
PAINT FOR TABLE TOP

25
#5 BOLT M6*25
PAGE 2 OF 2
The store where you made your purchase
does not stock parts for this item.
If you need parts,
whether they are missing or damaged,
STOP!
Missing A Part?
No Need To Go Back To
The Store
Call us between 9:00 AM and 4:30 PM
Eastern Time Monday through Friday
For further assistance,
please visit us at
[email protected]
Call Toll Free:
TEL: [phone]
FAX: [phone]
READ THESE INSTRUCTIONS COMPLETELY BEFORE STARTING ASSEMBLY
SEPARATE AND IDENTIFY ALL PARTS, MAKING SURE THAT YOU
HAVE ALL OF THEPARTSLISTED.
IF YOU DO NOTLOCATE ALL OF THE PARTS LISTED, INSPECT THE
PACKING MATERIAL FOR SMALL PARTSTHAT MAYHAVEBECOME
SEPARATED DURING SHIPMENT.
IF YOU EXPERIENCEANY DIFFICULTY DURING ASSEMBLYOR IF ANY
PARTS ARE MISSING OR DAMAGED,CALL THE HELP LINE AT
1-877-539-7436 BEFORERETURNING THIS ITEM TO THE STORE.
PROVIDE THEFOLLOWING INFORMATION WHEN CALLING:
1-MODEL NUMBER OF THEPRODUCT.
2-PARTNUMBER AND MATERIAL CODE OF THE PARTFROM THE PARTS
LIST.
MOST PROBLEMS CAN BERESOLVED WITHOUT RETURNING THIS
PRODUCT TO THERETAILER.
Warranty
• This product is covered by Courtyard Creations Inc. One–year limited warranty.
• Proof of purchase (dated register receipt) is required for warranty claims.
• It remains the customer’s responsibility for freight and packing charges to and from over service center.
Step 3:
Turn the table to its upright position. See Figure 3.
Step 2:
Fasten the center connector with ring (#3) to the middle
of the legs (#2) by using bolts (#5) and washers (#6).
Make sure that all of the bolts have been tightened
completely and cover them with bolt caps (#7 and #8).
See Figure 2.
5
8
6
Note:
The arrow mark on the center connector with ring (#3)
must coincide to ensure proper assembly.
FIGURE 3FIGURE 2
2
2
2
3
2
Note:
1. To use an umbrella with this table, remove the plastic
center plug and put the umbrella pole through the table
top and center connector ring.
2. To repair any scratches on the table top, use the
touch-up paint for table top (#10) provided.
Cleaning and Maintenance
• Wash frame parts with mild soap and water, rinse thoroughly, and dry completely. Do not use bleach, acid,
or other solvents on the frame parts.
• Inspect and tighten all bolts and fasteners on a regular basis to ensure the proper performance and safety of
your table.
• When moving the table, remove the umbrella and lift. Do not drag this table.
• We recommend the use of furniture covers when not in use.
• In order to prolong the life and beauty of your table, we recommend that it be stored in a dry and protected
area during off season periods.
• The umbrella should be lowered and/or removed in windy conditions.
STOP DON’T RETURN TO STORE!