Dancover 5.4m Series User manual

5.4m serie
Garage tent
Manual
23-12-2013

Safety Advice
Attention
In some countries approval is needed to set up a marquee/tent larger than 75 m2. It
is your responsibility to comply with local rules and regulations and to ensure that
the marquee/tent is assembled correctly.
In case of bad weather conditions, it is your responsibility to ensure the
marquee/tent is safely secured and that the marquee/tent does not cause damage
to others.
close to the tent.
The marquee/tent must be safely secured. We recommend you secure your
marquee/tent with straps and pegs as soon as it is assembled.
Make sure to check if the marquee/tent is covered by your home contents insurance.
Marquees/tents must be evacuated under extreme weather conditions.
In the event of snow always remove snow from the roof of the marquee/tent
regularly to prevent snow from building on the roof as heavy snow can cause the
marquee/tent to collapse.
In the event of rain there is a risk of rain puddles building up on top of the roof of the
marquee/tent. Heavy rain puddles can cause the roof to collapse. It is your responsi-
bility to ensure rain puddles do not build up. As a precaution, make sure theroof of
the marquee/tent is stretched out properly and adequately over the side frames of
the marquee/tent and remove rain water regularly.
Please always check our website for the latest safety advice and manuall.

Part
no. Description 6m
7,5m 9m 10,5m
1
Corner Arch
10 12 14 16
2
Female brace
60’’
7 7 7 7
3 Leg
10 12 14 16
4
Center Arch
5 6 7 8
5
Male Door
Rail
5 6 7 8
6
Female Door
Rail
5 6 7 8
7 T-Bar
5 6 7 8
8
Male brace
63’’
21
28 35 42
9
Diagonal 80’’
4 4 4 6
10 Pipes holder
10 12 14 16
11 S Hook
32 32 32 32
12
Big Door Rail
Hook
28 28 28 28
13
Elastic
Bungee
32 32 32 32
14
Floor Bracket
8 8 8 8
15 Nail
16 16 16 16
16
Carriage Bolts
1 ¾’’
6 7 8 9
17
Carriage Bolts
2 1/2’’
11
13 15 17
18
Carriage Bolts
4’’
27 33 38 43
19 Wing nuts
55 66 77 88
20
Big Plastic
Caps for legs
10 12 14 16
21
Small Plastic
Caps for cross pipe
14 14 14 14
22 Roof 1 1 1 1
PARTLIST FOR 5.4m series
23-12-2013

DEAR CUSTOMER
Please use gloves when assembling the metal frame portion of this unit.The metal components of this
product have been treated with a rust preventive coating that may feel oily to the touch. This coating is
not dangerous, but may dirty your hands during assembly. We recommend that you wipe metal parts
clean with a mixture of warm water and dish detergent prior to assembly. Should your hands become
dirty, simply was with soap and water.
ASSEMBLY INSTRUCTIONS
1. Take a Center Arch ( no.4 ) and on each end of it, assemble a Corner Arch ( no.1 ).
Secure the Male and Female Door ( no.5 ) and ( no.6 )to the arch ( no.1 ) with the pipes
holder ( no.10 ).
2. Slide the Rail Hooks over the Door Rails before tightening. Add the T-Bar(no.7 ) to the
Door Rails and the center arch.

3. On each end of (no.1), install the Leg (no.3). Repeat step 1 for all frames.
4. At this point stand up the front or back frame and add 7 male connecting pipes ( no.8 ).
Then stand up another frame and add 7 female connecting pipes ( no.2 ). For the remaining
frames use the male connecting pipes ( no.8 ).
5. Add the diagonals (no.9) to the rst and last legs (no.3 ).
Note : Make sure all screws are tight. Do not over-tighten.
6. ROOF ASSEMBLY
Take the roof and place it over the structure. Make sure that
the windows are on the two sides of the shelter, at front or at
back as your choice. Make sure ties are inside.
Tie all the ties around the pipes. Take the straps and pass
them underneath the pipes, pull up and tighten through metal
buckle.
7. SHELTER REINFORCEMENT
Before you install the oor brackets, make sure the distance
between the legs is 18 feet wide.
Place the oor brackets (14) at each end of the shelter. Then
drive in nails (15) into ground, gravel or asphalt. Other
material surfaces require other types of anchoring (cement
blocks, sand bags, screws and bolts, etc). Permanent anchors
are not provided with this unit.
8. DOOR INSTALLATION
Install doors at each end. Use elastics (13) to attach the door
to the roof with hooks (11). Close the end of hook on to the
elastic so it won’t fall on out. Use the rail hooks to attach
door the door rails. When closing at the front, make sure all
elastics are attached on the inside and outside of the shelters.

Contact information
Head office:
Dancover A/S
Nordre Strandvej 119 G
3150 Hellebæk
Denmark
For more information
please visit:
www.dancovershop.com
National contact
Denmark:
[e-mail]
UK:
[e-mail]
Spain:
[e-mail]
Italy:
[e-mail]
Germany:
[e-mail]
Switzerland:
[e-mail]
France:
[e-mail]
Austria:
[e-mail]
Sweden:
[e-mail]
Finland:
[e-mail]
Nederland:
[e-mail]
Poland:
[e-mail]
Ireland:
[e-mail]
Luxembourg:
[e-mail]
Belgium:
[e-mail]
Norway:
[e-mail]