Elkay EFY8 1A Series Installation manual

97051C (Rev. A - 3/98)
EFY8*1A
PAGE 1
Installation/Care/Use Manual
USES HFC-134A REFRIGERANT
FIG. 1
3, 4
SEE FIG. 4
35
11, 14
34
23
28
20, 26, 27
22
30
31
13
21
16
2
5, 6, 7
24
12
29
32, 33

97051C (Rev. A - 3/98)
EFY8*1A
PAGE 2
FIG. 2
E = INSURE PROPER VENTILATION BY MAINTAINING 4" (102mm) (MIN.) CLEARANCE FROM CABINET LOUVERS TO WALL.
ASEGURE UNA VENTILACIÓN ADECUADA MANTENIENDO UN ESPACIO E 4" (102mm) (MÍN.) DE HOLGURA ENTRE LA REJILLA DE VENTILACIÓN DEL MUEBLE Y LA PARED ASSUREZ-VOUS UNE BONNE VENTILATION EN GARDANT 4" (102mm) (MIN.) ENTRE LES ÉVENTS DE LENCEINTE ET LE MUR.
F = POWER CORD 4 FEET (1219mm) LONG
CABLE ELÉCTRICO DE 4 PIE (1219mm), DE LARGO CORDON DALIMENTATION 4' (1219mm)
G = WALL SCREW HOLES
AGUJEROS DE TORNILLOS DE PARED TROUS DE VIS DU MUR
H = 2 X 4 BLOCKING
BLOQUEO DE 2 X 4 BLOC 2 X 4
FINISHED FLOOR
PISO ACABADO
PLANCHER FINI
LEGEND/LEYENDA/LÉGENDE A = RECOMMENDED WATER SUPPLY LOCATION 3/8 O.D. UNPLATED COPPER TUBE CONNECT STUB 1-1/2 IN. (38mm) OUT
FROM WALL SHUT OFF BY OTHERS
SE RECOMIENDA UBICAR ELTUBO CORTO DE CONEXIÓN AL TUBO DE COBRE SIN CHAPAR DE 3/8" DE DIÁM. EXT. A 1-1/2"
(38mm) FUERA DE LA LLAVE DE PASO EN LAPARED COLOCADAPOR TERCEROS.
EMPLACEMENT RECOMMANDÉ D'ALIMENTATION EN EAU PAR TUBE EN CUIVRE NON PLAQUÉ DE 3/8 PO. (9,5 mm) D.E.
CONNECTANT UNE TUYAUTERIE DE 1-1/2 PO. (38mm) DEPUIS LE ROBINET D'ARRÊT FOURNI PAR D'AUTRES.
B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/4 O.D. DRAIN
UBICACIÓN RECOMENDADA PARA EL DRENAJE DE SALIDADE AGUA, DE 1¼ DE DIÁMETRO. EMPLACEMENT RECOMMANDÉ POUR LE DRAIN DE D.E. 1-1/4" DE SORTIE DEAU.
C = 1-1/4 TRAP NOT FURNISHED**
PURGADOR DE 1¼ NO PROPORCIONADO** SIPHON 1-1/4 NON FOURNI**
D = ELECTRICAL OUTLET LOCATION
UBICACIÓN DE LA TOMA DE ELECTRICIDAD EMPLACEMENT DE LA PRISE DE COURANT

97051C (Rev. A - 3/98)
EFY8*1A
PAGE 3
FIG. 3
FIG. 4
CONDENSER WATER VALVE ADJUSTMENT
The condenser water valve is factory preset for a condenser water outlet temperature of 95° to 105° F.
If actual temperature varies greatly from this, readjust water flow rate at the valve using the following procedures.
1. START UP COMPRESSOR
This can be accomplished by depressing the cooler push button (See Fig. 1 - Item 3). Keep water running
during the entire readjustment procedure.
2. ADJUSTMENT CONDENSER WATER VALVE
Adjust valve by rotating adjustment stem. Rotating stem clockwise will increase water flow. Counterclockwise
rotation will decrease water flow. Increasing water flow will result in a lower condenser outlet temperature, while
decreasing water flow will result in a higher outlet temperature. Proper adjustment is attained when condenser
outlet temperature is 95° to 105° F.
25
10
1, 15, 19
98
STREAM HEIGHT
ADJUSTMENT SCREW ADJUST THIS SCREW TO ELIMINATE
VALVE LEVER "FREE PLAY" OR
CONTINUOUS FLOW FROM BUBBLER
CORRECT STREAM HEIGHT
PUSH BUTTON
VALVE ADJUSTMENT

97051C (Rev. A - 3/98)
EFY8*1A
PAGE 4
ELKAY MANUFACTURING COMPANY  2222 CAMDEN COURT  OAK BROOK, IL
PRINTED IN U.S.A.
PARTS LIST 115V
ITEM NO. PART NO. DESCRIPTION
1
2
3
4
5
6
7
8
9
10
11
12*
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
NS
Nut-Regulator Retaining
Bubbler
Push Button Stem
Cap Push Button
Drain Plug
Strainer Plate
Receptor
Regulator Lever
Pivot Bracket
Regulator Retaining Bracket
Cold Control
Compressor
Valve - Wtr Temp
Electrical Box-Cold Control
Regulator Holder
Condenser Assy
Evaporator
Valve Assy
Regulator
Tailpipe Assy
Drier
Check Valve
Strainer
Electrical Box-Power Connection
Regulator Mounting Bracket
Adaptor-Drain W/O Holes
Nut 1-1/4 Slip Joint
Tee - 1/4 x 1/4 x 1/4
Vacuum Break
Stem Bushing
Elbow - 3/8
Overload
Relay
Left Panel
Right Panel
Front Panel
15005C
45314C
101507531550
101543431640
102639931640
160270508640
171403742590
26860C
26861C
26862C
31513C
35790C
40136C
45340C
50986C
601418151550
66327C
601590351550
61314C
45689C
66202C
75494C
55996C
45347C
55880C
55913C
55885C
70682C
45346C
101452331870
75561C
35797C
35803C
401536342830
401536242830
401507442830
*REPLACE WITH SAME COMPRESSOR USED IN ORIGINAL
ASSEMBLY.
NOTE: All correspondence pertaining to ELKAY water coolers or
orders for repair parts MUST include Model No. and Serial No. of
cooler, name and part number of replacement part.
www.DrinkingFountainDoctor.com 800-518-5388