FarmTek 103446 User manual

103446 TRAILER FRAME
10712
TOOLS REQUIRED
Flat Head Screwdriver
Two Medium Adjustable Wrenches
(Recommend Two People for Assembly)
If you have any questions or need additional instructions, call 1-800-245-9881 Monday through Friday,
9:00 a.m. to 5:30 p.m. EST. or email [email protected] anytime.

PARTS LIST
(4) WHEEL (1) TONGUE (1) BACK AXLE
(1) FRAME ADAPTOR (1) FRONT AXLE
(4) LARGE (4) COTTER (1) COTTER (1) HITCH (4) TONGUE
WASHER PIN KEY PIN WASHER
(3) WASHER (1) SPACER (1) TONGUE (1) 12x80mm (4) HEX (2) 12x70mm
BOLT BOLT NUT BOLT

ASSEMBLY
Remove parts from box and identify items.
DO NOT TIGHTEN NUTS AND BOLTS UNTIL END
STEP 1: Remove Tongue Bolt, Lock Nut, Tongue Washers, and Spacer from the center of the Front Axle.
Align hole in center of axle with hole in center of the Tongue Attachment. Insert Spacer in between the Tongue
Yoke and Axle Frame. Insert Tongue Bolt with Washer through hole. Next, slide on Tongue Washer, smaller
Washer and Lock Nut.
NOTE: Tongue Attachment is shipped secured to the Tie Rods and Front Axles
STEP 2: Slide Wheel onto each side of the Front Axle, followed by a Large Washer and Cotter Pin.
STEP 3: Slide Wheel onto each side of Back Axle, followed by a Large Washer and Cotter Pin.

STEP 4: Position both Front and Back Axles as shown below and insert Frame Adapter into ends of both
Axles. Slide in until you align holes of Frame Adapter with the holes of the Axles. Secure in place using
12x70mm Bolt, Washer, and Lock Nut. Install Bolts from the bottom.
NOTE: There are 2 sets of holes on the Frame Adapter. Determine the desired length and adjust using holes
accordingly.
STEP 5: Align holes on the Tongue with the holes on the Tongue Attachment. Secure in place with a 12x80mm
Bolt, Washer, and Lock Nut.
NOTE: A Hitch Pin with Cotter Key is provided for pulling
STEP 6: Tighten all connections. Check Wheels are at recommended pressure.
NOTE: Periodically check connections to make sure they are tight and secure. Grease any fittings at joints and
Wheels.
CAUTION: Do NOT load the Trailer with more than 2200 lbs. Do NOT allow children to use the Trailer
unsupervised. This cart is not a toy. Do NOT inflate tires more than 35 P.S.I.
Slide Tongue into
groove and secure in
p
lace as shown