Firegear OFP-36COV User manual

REV. A Page 1
Kalea Bay Outdoor Fireplace Cover
Installation and Operating Instructions
IF YOU CANNOT READ OR UNDERSTAND THESE INSTALLATION INSTRUCTIONS
DO NOT ATTEMPT TO INSTALL OR OPERATE THIS APPLIANCE
Models:
OFP-36COV
OFP-48COV
OFP-60COV
OFP-72COV
PN#90057
CALIFORNIA PROPOSITION 65
WARNING
This product can expose you to Chromium, which is
known to the state of California to cause cancer
and birth defects or other reproductive harm.
(For more information, go to www.p65warnings.ca.gov)

REV. A Page 2
Firegear Outdoor Fireplace Cover
Model A B C
OFP-COV-36 35 ¾” 16 ⅜” ⅜”
OFP-COV-48 47 ¾” 16 ⅜” ⅜”
OFP-COV-60 59 ¾” 16 ⅜”” ⅜”
OFP-COV-72 71 ¾” 16 ⅜” ⅜”
A
B
C
FRONT VIEW END VIEW
TOP
Bottom
SPECIFICATIONS
ASSEMBLY
Step 1: Carefully remove the cover from the carton and
peel off the plastic protective coating.
Step 2: Remove handles from package and
install them as shown in Fig. 2 wth screws and washers.
Note: DO NOT OVERTIGHTEN SCREWS.
Fig. 1 Shows cover from front side. End view shows lip at the bottom that sits down inside the replace.
The top side has clearance holes to allow pins to pass through.
Fig. 2 Shows end view installing handles.
Table 1 Specications
DESCRIPTION: Covers are stainless steel and provide a decorative way to protect the interior your Kalea Bay
outdoor replace. Installation is simple, quick and provides all weather protection year round.
TOOLS NEEDED:
Phillips screwdriver

Firegear Outdoor Fireplace Cover REV. A Page 3
Remove two outer screws on OFP-36 & OFP-48. Larger models,
OFP-60 & OFP-72 also require removal of the center screw.
Step 3: Remove the two outer screws from the
underside of the opening or hood.
Note: If you are installing a larger cover on a
OFP-60 or OFP-72 then also remove the center
screw. (total of 3 screws) See Fig. 3.
Fig. 3 Removing screws from hood.
Step 4: Install the brackets with the hood screws using a
Phillips screwdriver. See Fig. 4.
Cover Bracket
Hood Screw
Detailed Close-up
Side View
3rd spacer used with OFP-60 and OFP-72
Hood
Fig. 4. Installing spacers and screws into replace.
Step 5: Install cover, top rst, aligning the holes of the
cover over the spacers, then resting the bottom edge
inside of the opening of the replace (See Fig 5). The
cover should be ush with the outer face of the replace.
Fig. 5. Installing cover into replace.
Install the cover after
replace has cooled down.
WARNING: cover must be removed
before operating the replace.

REV. A Page 4
Firegear Outdoor Fireplace Cover
CLEANING STAINLESS STEEL: Stainless steel may oxidize in the presence of chlorides and suldes, particularly in
coastal areas and other harsh environments, such as the warm, highly humid atmosphere around pools and hot tubs. To
provide stain prevention and removal, wash all stainless steel surfaces every 3-4 weeks or as often as required with fresh
water and/or a stainless steel cleaner.
Do not use abrasive cleaners or steel wool on any stainless steel parts. Doing so will scratch the nish. Exterior surfaces
should be cleaned with warm soapy water. Use a stainless steel or non-abrasive cleaner. Always wipe in the direction of
the grain. If you have any questions call the Technical Support line below.
OFP-
36COV
OFP-
48COV
OFP-
60COV
OFP-
72COV
Description Part # Qty.
x 36” Stainless steel cover only 73226 1
x 48” Stainless steel cover only 74226 1
x 60” Stainless steel cover only 75226 1
x 72” Stainless steel cover only 76226 1
x x x x Handles & Screws HANDLE ASSEMBLY 2
x 36” HT Silcone Strip (1/16” x 1/2”) 2614T62-36 1
x 48” HT Silcone Strip (1/16” x 1/2”) 2614T62-48 1
x 60” HT Silcone Strip (1/16” x 1/2”) 2614T62-60 1
x 72” HT Silcone Strip (1/16” x 1/2”) 2614T62-72 1
REPLACEMENT PARTS
MAINTENANCE
CAUTION: Stainless steel covers can be hot
to the touch when installed on your re pit
due to the sun and outdoor temperatures.
Always use caution when handling.
Warranty information can be found on the Firegear Outdoors web site listed below.
FOR TECHNICAL SERVICE, CALL:
Firegear Outdoors
17322 Gothard Street
Huntington Beach, CA 92647
WEB SITE: www.regearoutdoors.com
[phone]
Table 2