Getinge Arjohuntleigh Akron Streamline 2 Section User manual

Akron Streamline 2 & 3 Section
...with people in mind
Instruction for Use
792-659_06CN.REG • 06/2018
CFDA license: 20142565936

USER MANUAL
AKRON
®
STREAMLINE
3 SECTION
Models
2231, 2232, 2331, 2332
2231A, 2231B, 2231C
2232A, 2232B, 2232C
,
AKRON
®
STREAMLINE
2 SECTION
Models
2221, 2221A, 2221B, 2221C
2222A, 2222B, 2222C
2223, 2321, 2322, 2323
792-659-04
UM ENGLISH

AKRON STREAMLINE Model No.’s:- 2221, 2221A 2221B, 2221C, 2222, 2222A, 2222B, 2222C, 2223, 2321, 2322, 2323
2231, 2231A, 2231B, 2231C, 2232, 2232A, 2232B, 2232C, 2331, 2332
1
Contents
1. Introduction 1
2. Warnings & Cautions 2
3. Installation 3
4. Operation 5
5. Accessories – Operating Instructions 8
Fold-down Side Supports, Paper Roll Holder
Cyriax Horns, Arm Support, Moulded Arm Support
Head Support, Hole & Horn
Fixation Rails, IV Pole
6. Cleaning and Decontamination 11
7. Troubleshooting 12
8. Maintenance 12
9. Warranty and Service 13
10. Revision Status 14
11 Technical Specification 15
12. Transport and Storage 18
13. Environmental Protection 18
The mark on this product demonstrates conformity with the EC Directive 93/42/EEC.

AKRON STREAMLINE Model No.’s:- 2221, 2221A 2221B, 2221C, 2222, 2222A, 2222B, 2222C, 2223, 2321, 2322, 2323
2231, 2231A, 2231B, 2231C, 2232, 2232A, 2232B, 2232C, 2331, 2332
2
1. Introduction
The STREAMLINE
TM
product range of treatment & examination couches, have been designed to
cover a wide range of disciplines, from simple examination to heavier manipulative and manual
therapy techniques.
The STREAMLINE
TM
couches in this range provide ergonomic solutions to a variety of manual
handling issues, benefiting both the patient and clinician. These products can be further
enhanced with a wide range of additional accessories also available.
However, these products are not designed to be used as a bed and are not suitable for sleeping
on.
Always keep this Operating Manual available for reference.

AKRON STREAMLINE Model No.’s:- 2221, 2221A 2221B, 2221C, 2222, 2222A, 2222B, 2222C, 2223, 2321, 2322, 2323
2231, 2231A, 2231B, 2231C, 2232, 2232A, 2232B, 2232C, 2331, 2332
3
2. Warnings & Cautions
General Warnings
WARNINGS
Warnings identify possible hazards in procedures or conditions which, if not correctly
followed, could result in death, injury or other serious adverse reactions.
CAUTIONS
Cautions identify conditions or procedures which, if not correctly followed, could result in
equipment failure or damage.
WARNINGS
Electrical equipment can be hazardous. These products should only be
operated by suitably qualified/trained personnel.
This equipment should not be used adjacent to other electrical equipment.
If such use is necessary, normal operation of the equipment should be
verified by observation.
Medical Electrical Equipment maybe affected by portable and/or mobile
RF communications equipment (eg mobile telephones).
Use only accessories that have been designed or approved for use with
this couch.
These products are not intended for Patient Transportation.
Do not use electric couches in the presence of flammable gases such as
an anaesthetic agent.
Maximum Load 225 kg (495 lbs) distributed evenly.
Do not concentrate weight on either side of the couch.
Plug acts as a disconnect device.
Do not allow children to play with the couch at any time.
Adequately supervise children in the proximity of the couch.
The patient should not be left on the Couch unattended at any time.
CAUTIONS
Electromagnetic Compatibility (EMC). This product complies with the requirements of
applicable EMC standards. The use of accessories not specified by the manufacturer may
result in increased emissions by, or decreased immunity of, the equipment, affecting its
performance.
Do not exceed the specified duty cycle as stated on the Product Identification Label
USA only - To achieve grounding reliability, ensure that this equipment is connected to a
receptacle marked “Hospital Only” or “Hospital Grade”.

AKRON STREAMLINE Model No.’s:- 2221, 2221A 2221B, 2221C, 2222, 2222A, 2222B, 2222C, 2223, 2321, 2322, 2323
2231, 2231A, 2231B, 2231C, 2232, 2232A, 2232B, 2232C, 2331, 2332
4
3. Installation
Adjustable Foot
Electric Models
Ensure mains supply cable is not stretched when connected.
Ensure, during couch use, no obstacles are in its path.
Ensure hand / foot switch tubes or leads are not trapped by moving parts of the couch.
WARNING
Lock castors before adjusting.
A) Lock castors first.
B) Adjust foot.
C) Lock foot by tightening half nut.
WARNING
Do not insert the 2-pin mains connector directly into a UK style, BS1363,
3-pin 13A mains outlet. Always use the adapter provided.
Plug acts as a disconnect device.
Use adapter if UK style, BS1363, 3-pin 13A
plug is required.
(Order reference 5S0409Z)
CAUTION
When not in use, switch couch off, by unplugging from the power socket/receptacle. Note that
models with battery back-up will still operate.
CAUTION
Do NOT Insert Hands or Feet into the Mechanism as this
could result in serious injury!

AKRON STREAMLINE Model No.’s:- 2221, 2221A 2221B, 2221C, 2222, 2222A, 2222B, 2222C, 2223, 2321, 2322, 2323
2231, 2231A, 2231B, 2231C, 2232, 2232A, 2232B, 2232C, 2331, 2332
5
4. Operation
Elevation Controls
Hydraulic Models
Hydraulic Pedal
Electric Models
Hanning Handswitch
Hanning Handswitch
Hanning Footswitch
Foot bar switch (FBS) –
Available only on models 2222A, 2222B, 2222C, 2232A, 2232B, 2232C
WARNING
Safely position patient before elevating couch.
Position all electrical cables away from the moving parts.
Position Hand/Foot switch where accidental operation is not possible.
PUMP PEDAL TO
RAISE COUCH LIFT PEDAL TO LOWER COUCH
Press tube down to raise couch
Lift tube upwards to lower couch
Press to raise couch.
Press to lower couch.
Press to raise couch.
Press to lower couch.
Linak Handswitch
(Models 2223, 2323,
2233, 2333 only)

AKRON STREAMLINE Model No.’s:- 2221, 2221A 2221B, 2221C, 2222, 2222A, 2222B, 2222C, 2223, 2321, 2322, 2323
2231, 2231A, 2231B, 2231C, 2232, 2232A, 2232B, 2232C, 2331, 2332
6
4. Operation
Wheel Locking
Castors (RWB – Retractable Wheel Base)
Castors locked Castors unlocked
Wheels (LWB - Large Wheel Base)
Wheels Locked Directional Lock Wheels Unlocked
Breathing Hole and Plug
WARNING
Lock couch wheels/castors prior to patient transfer or treatment.
These couches are not designed for the transportation of patients.
Disconnect and coil electrical cord away from moving parts prior to
repositioning couch.
Remove plug for patient prone position.
Press out from underneath.
WARNING
Lock table wheels prior to patient transfer or treatment.

AKRON STREAMLINE Model No.’s:- 2221, 2221A 2221B, 2221C, 2222, 2222A, 2222B, 2222C, 2223, 2321, 2322, 2323
2231, 2231A, 2231B, 2231C, 2232, 2232A, 2232B, 2232C, 2331, 2332
7
4. Operation
Head & Foot Sections
A & B Type Head Section Operating Lever
C Type Head Section Operating Lever
Foot Section Operating Lever
C Type Head Section Arm Rests
CAUTION
Support upholstery section while manually altering the angle.
A) Press lever UP to alter section angle.
B) Support section when altering angle.
C) Release lever to lock section in position.
Angles A Type = +80°-20°B Type = +45°-20°
A) Press lever UP to alter section angle.
B) Support section when altering angle.
C) Release lever to lock section in position.
Angles C Type = +45°-23°
A) Press lever UP to alter section angle.
B) Support section when altering angle.
C) Release lever to lock section in position.
Foot Section Angles = +80°-0°
A) Tilt Armrest towards Head Section.
B) Move Armrest into position.
C) Release Armrest to lock into position.

AKRON STREAMLINE Model No.’s:- 2221, 2221A 2221B, 2221C, 2222, 2222A, 2222B, 2222C, 2223, 2321, 2322, 2323
2231, 2231A, 2231B, 2231C, 2232, 2232A, 2232B, 2232C, 2331, 2332
8
5. Accessories – Operating Instructions
Fold Down Side Supports
Raised Side Support Lowered Side Support
1. To raise the Side Support when in the down position, lift and rotate towards you, through
180°. Once upright, push the Side Support downwards into the moulded block until
located fully.
2. To lower the Side Support from the upright position, lift out of the moulded block, and
rotate through 180°into the down position.
Paper Roll Holder
Cyriax Horns
Replace paper roll by:-
A) Gently spring bracket out.
B) Insert paper roll rod between brackets.
C) Load paper roll and release brackets to secure.
Adjust Cyriax Horns to suit patient by:-
A) Unlocking the locking knobs.
B) Adjust position of horns.
C) Tighten locking knobs.
CAUTION
Ensure Fold down Side Supports are fully engaged into moulded block prior to use.