Hans Grohe Axor Montreux 16560XX1 Installation guide

Montreux
16540XX1
Montreux
16560XX1
Installation Instructions / Warranty

2
Technical Data
Operating pressure: max. 145 psi
Recommended operating pressure: 14.5 - 72 psi
Hot water temperature: max. 176° F*
Recommended hot water temperature: 120°F - 140°F*
Center distance: 6
3/4 “ ± 1 3/4 “
Connections ½" female: cold right
hot left
Tub filler flow rate @ 45 psi
approx. 5.8 gpm
Flow rate for handshower 2.5 gpm
Backflow prevention provided by check valve.
This unit is not anti-scald. If required by local plum-
bing code, install with remote pressure balance valve
13418181.
*Know and follow all applicable local plumbing codes when setting the
temperature on the water heater.
Montreux
Wall-Mount Tub Filler 16540XX1
Wall-Mount Shower Mixer 16560XX1
16540XX1 16560XX1

3
Installation
During rough-in, install two 1/2” female threaded
fittings, recessed 3/16” behind the surface of the
finished wall. The fittings should be 6 3/4” apart on
center.
Flush the hot and cold supplies thoroughly.
Wrap the threads on the offset adapters with
TeflonTM thread tape. Screw the adapers into the
female fittings. The adapters should extend 1
7/16” - 1 5/8” outside the surface of the finished
wall.
Adjust the offset adapters so that the distance
between the centers is 6 3/4”, and they are level.
Seal the wall around the adapters with water-
proof bathroom sealant.
1 7/16” - 1 5/8”

4
Install the escutcheons.
Install the washers and the mixer. Tighten the
nuts.
Place a hose washer in one end of the hand-
shower hose. Screw it to the handshower outlet.
Place the other hose washer in the other end of
the hose. Screw it to the handshower.
Place the handshower in the holder.
User Instructions:
Turn the handles to turn the water on. The right
handle controls the cold water, the left handle
controls the hot water.
When the diverter is in the forward position,
water will come from the spout.

5
Push the diverter to the rear to obtain water from
the handshower.
The check valve should be removed and checked yearly.
Replacement Parts
16560XX1
1
2
3
5
6
8
9
10

6
1 handle 16597XXX
2 screw cover cold / hot water 97987000
3 sleeve 97993XXX
4 aerator 98575XXX
5 valve cartridge 94149000
6 check valve 94074000
7 diverter assembly 98591000
8 escutcheon 98595XXX
9 noise reduction 96429000
10 offset adapters 98592001
11 sliding gear lever 98594XXX
12 cover caps 98593XXX
13 shower base 98590XXX
14 handshower 16320XX1
15 hose 28112000
16 screen washer 94246000
XXX = Colors
000chrome plated
820brushed nickel
830polish nickel
16540XX1
1
2
3
4
5
6
7
8
9
10
11
12
13 14
15
16
11

7
Cleaning Recommendation for Hansgrohe Products
Modern faucetry and shower products utilize a combination of materials to comply with the needs of the
market with regard to design and functionality.
To avoid damage, it is necessary to use some caution when cleaning. Damage caused by improper treatment
is not covered under the Hansgrohe warranty.
Cleaning Materials for Faucets and Showers
•To remove lime scale, use only products made specifically for that purpose. Always follow the
manufacturer’s instructions when using.
•Do not use cleaners that contain hydrochloric, formic, acetic, or phosphoric acids, as these will cause
considerable damage to finishes and to plastic components.
•Never mix cleaning materials.
•Never use cleaners containing abrasives. Do not use abrasive cleaning cloths, pads, or sponges.
Cleaning Procedures
•Clean your faucets and shower products as and when required. Regular cleaning will prevent scale
buildup and water spotting.
•Follow the label instructions. Do not allow any cleaner to remain on the product for longer than
necessary.
•When using spray cleaners, spray first onto a sponge or cloth – do not spray directly onto the product.
•After cleaning, rinse thoroughly with clear water to remove any cleaner residue.
Important
•Soap and shampoo residue can also cause damage to the product. Rinse well with clean water after use.
•If the surface is already damaged, harsh cleaning materials will cause further damage.
Limited Lifetime Consumer Warranty
This product has been manufactured and tested to the highest quality standards by Hansgrohe, Inc. (“Hansgrohe”). This warranty is limited to
Hansgrohe products which are purchased by a consumer in the United States after March 1, 1996, and installed in either the United States or
Canada.
WHO IS COVERED BY THE WARRANTY
This warranty extends to the original consumer purchaser only.
WHAT IS COVERED BY THE WARRANTY
This warranty covers only your Hansgrohe manufactured product. Hansgrohe warrants this product against defects in material or workmanship
as follows: Hansgrohe will repair at no charge for parts only or, at its option, replace any product or part of the product which proves defective
because of improper workmanship and/or material, under normal installation, use, service and maintenance. If Hansgrohe is unable to provide a
replacement and repair is not practical or cannot be timely made, Hansgrohe may elect to refund the purchase price in exchange for the return of
the product.
LENGTH OF WARRANTY
Replacement or repaired parts of products will be covered for the term of this warranty as stated in the following two sentences. If you are a
consumer who purchased the product for use primarily for personal, family, or household purposes, this warranty extends for as long as you own
the product and the home in which the product is installed. If you purchased the product for use primarily for any other purpose, including, without
limitation, a commercial purpose, this warranty extends only (i) for 1 year, with respect to Interaktiv and Retroaktiv products, and (ii) for 5 years,
with respect to AXOR, ShowerPower and Pharo products.

Hansgrohe, Inc. •1490 Bluegrass Lakes Parkway •Alpharetta, GA 30004
Tel. [phone] •Fax [phone]
www.hansgrohe-USA.com
US - Installation Instructions •Part No. 90575021 •Revised 08/2008
THIS WARRANTY DOES NOT COVER, AND HANSGROHE WILL NOT PAY FOR:
A. Conditions, malfunctions or damage not resulting from defects in material or workmanship.
B. Conditions, malfunctions or damage resulting from (1) improper installation, improper maintenance, misuse, abuse, negligence, accident
or alteration, or (2) the use of abrasive or caustic cleaning agents or “no rinse” cleaning products, or the use of the product in any manner
contrary to the product instructions.
C. Labor or other expenses for the disconnection or return of the product for warranty service, or for installation or reinstallation of the product.
D. Accessories or related products not manufactured by Hansgrohe.
TO OBTAIN WARRANTY SERVICE
Contact your Hansgrohe retailer, or write to Technical Service at:
Hansgrohe Inc.
1492 Bluegrass Lakes Parkway
Alpharetta GA 30004
Or, call Hansgrohe toll-free at [phone].
In requesting warranty service, you will need to provide
1. The sales receipt or other evidence of the date and place of purchase.
2. A description of the problem.
3. Delivery of the product or the defective part, postage prepaid and carefully packed and insured, to Hansgrohe Inc. 1492 Bluegrass Lakes
Parkway, Alpharetta, Georgia 30004, Attention: Technical Service, if required by Hansgrohe.
When warranty service is completed, any repaired or replacement product or part will be returned to you postage prepaid.
EXCLUSIONS AND LIMITATIONS
REPAIR OR REPLACEMENT (OR, IN LIMITED CIRCUMSTANCES, REFUND OF THE PURCHASE PRICE) AS PROVIDED UNDER THIS WARRANTY IS
THE EXCLUSIVE REMEDY OF THE PURCHASER. HANSGROHE NEITHER ASSUMES NOR AUTHORIZES ANY PERSON TO CREATE FOR IT ANY
OBLIGATION OR LIABILITY IN CONNECTION WITH THIS PRODUCT.
HANSGROHE SHALL NOT BE LIABLE TO PURCHASER OR ANY PERSON FOR ANY INCIDENTAL, SPECIAL, OR CONSEQUENTIAL DAMAGES,
ARISING OUT OF BREACH OF THIS WARRANTY OR ANY IMPLIED WARRANTY (INCLUDING MERCHANTABILITY).
Some States do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not apply to
you.
This warranty gives you specific legal rights, and you may have other rights which vary from State to State.
You may be required by law to give us a reasonable opportunity to correct or cure any failure to comply before you can bring any action in
court against us under the Magnuson-Moss Warranty Act.
PRODUCT INSTRUCTIONS AND QUESTIONS
Upon purchase or prior to installation, please carefully inspect your Hansgrohe product for any damage or visible defect. Prior to installing,
always carefully study the enclosed instructions on the proper installation and the care and maintenance of the product. If you have questions
at any time about the use, installation, or performance of your Hansgrohe product, or this warranty, please call or write to us at the toll-free
number and address printed above.