Hausted UNICARE Series Service manual

THE
UNICARE
SERIES
HYDRAULIC STRETCHERS
625/825 FOOT END CONTROL
626/826 SIDE CONTOL
629/829 X-RAY TRAUMA
İİ” HAUSTED'
OPERATING AND SERVICE MANUAL
927 LAKE ROAD P.O. BOX 710 MEDINA, ОНО 44258
[phone] 1-800-428-7833
P/N 066042-65 (9401)

アナ HAUSTED”
2
3
4
5,6
7,8,9
10,11,12
13,14,15
16,17,18
19,20,21
22,23,24
25,26,27
28
29
30
31
32
33
34
35
36
626 BASE ASSEMBLY
TABLE OF CONTENTS
TABLE OF CONTENTS
UNPACKING INSTRUCTIONS
GENERAL OPERATING INSTRUCTIONS
BRAKE & STEER OPERATION
HEIGHT ADJUSTMENT & TRENDELENBURG OPERATION CONTROL BUTTONS
EMC/FMC FINAL ASSEMBLY — PARTS LIST
GMC/HMC FINAL ASSEMBLY — PARTS LIST
A00/B00 FINAL ASSEMBLY — PARTS LIST
C00/D00 FINAL ASSEMBLY — PARTS LIST
625 BASE ASSEMBLY — PARTS LIST
825 BASE ASSEMBLY — PARTS LIST
— PARTS LIST
826 BASE ASSEMBLY — PARTS LIST
F STYLE FOWLER ASSEMBLY — PARTS LIST
J STYLE FOWLER ASSEMBLY — PARTS LIST
M STYLE FOWLER ASSEMBLY — PARTS LIST
825 PUMP ASSEMBLY — PARTS LIST
826 PUMP ASSEMBLY — PARTS LIST
825 CONTROL VALVE ASSEMBLY — PARTS LIST
826 CONTROL VALVE ASSEMBLY — PARTS LIST
CYLINDER ASSEMBLY — PARTS LIST
RECOMMENDED PREVENATIVE MAINTENANCE
PAGE 1

LI HAUSTED“
Your UNICARE lil stretcher has been carefully
package at the factory to insure safe ship—
ment to your medical facility. There are ‘several
procedures you must follow to put your new
stretcher in service. These procedures only take
a few minutes to complete and are necessary
to Insure proper operation of your new stretcher.
IMPORTANT
IMPORTANT REPORT ANY SHIPPING DAMAGE IMMEDIATELY! INFORM SHIPPER
OF DAMAGES. LEAVE CARTON INTACT. LEAVE THE STRETCHER OR BED IN THE
RECEIVING AREA UNTIL INSPECTION HAS BEEN MADE.
UNPACKING INSTRUCTIONS
STEP 1 — CUT THE TWO METAL BANDS AROUND THE SHIPPING CARTON.
STEP 2 — REMOVE THE TOP HALF OF THE CARTON AND CUT ONE SIDE OF THE
BOTTOM HALF.
STEP
3
~
REMOVE
THE
STRETCHER
FROM
THE
CARTON.
CUT
THE
METAL
BANDS
AROUND
THE
STRETCHER,
STEP 4 — CHECK TO SEE IF ALL FEATURES OF THE STRETCHER WORK PROPERLY.
IF ALL FEATURES WORK GO TO STEP 5. IF ANY OF THE FEATURES OF
THE STRETCHER DOES NOT WORK PROPERLY CALL HAUSTED FOR SERVICE
AT: 1-800-428-7833 OR IN OHIO [phone].
STEP
5
—
CLEAN
THE
STRETCHER
USING
A
MILD
DETERGENT
TO
REMOVE
ANY
DIRT
ACCUMULATED
DURING
SHIPMENT
AND
PLACE
THE
STRETCHER
INTO
SERVICE.
PAGE 2

BRAKING
AND
STEERING
OPERATION
FIGURE 1
APPLYING THE BRAKES
THE FOUR WHEEL CENTRAL BRAKING
SYSTEM IS ACTIVATED BY DEPRESSING
THE RED PEDAL,(TO APPROXIMATELY
45°), AT ANY CORNER OF THE STRET 一
CHER. THIS ACTION LOCKS ALL FOUR
CASTER WHEELS FROM ROTATING AND
SWIVELING. (FIGURE 1)
RELEASING THE BRAKES
DEPRESS THE GREEN PEDAL AT ANY
CORNER TO A HORIZONTAL POSITION.
ALL FOUR CASTER WHEELS SHOULD
SWIVEL AND ROLL FREELY.
NOTE: ALWAYS APPLY BRAKES WHEN
STRETCHER IS NOT BEING
TRANSPORTED.
APPLYING THE STEER LOCK
FROM THE HEAD END OF THE
STRETCHER DEPRESS THE GREEN
PE 一
DAL DOWNWARD,(TO APPROXIMATELY
45°), AND PUSH THE STRETCHER
FORWARD. (FIGURE 2) ONE CASTER
WHEEL AT THE OPPOSITE END OF THE
STRETCHER LOCKS INTO A NON—
SWIVELING POSITION THAT ENABLES
STRAIGHT TRACKING AND STEERING BY
ATTENDANT.
RELEASING STEER LOCK
DEPRESS THE RED PEDAL TO A
HORIZONTAL POSITION. ALL FOUR
CASTER WHEELS SHOULD SWIVEL
ROLL FREELY.
AND
FIGURE 2
PAGE 3

HEIGHT ADJUSTMENT-LOWERING— TRENDELENBURG OPERATION
BUTTON CONTROL
SA
FIGURE 3
LOWERING LITTER TOP
TO LOWER LITTER TOP, PRESS CONTROL
BUTTONS AT THE SAME TIME, LOCATED ON
BOTH SIDES OF THE STRETCHER, UNTIL THE
DESIRED HEIGHT IS OBTAINED.
(FIGURE 4)
NOTE: CONTROL_BUTTONS MAY BE LOCATED
AT THE FOOT END OF YOUR UNIT.
FIGURE 5
PAGE 4
HEIGHT ADJUSTMENT
TO ELEVATE LITTER TOP, PUMP_LARGE
FOOT PEDAL LOCATED ON BOTH SIDES OF
THE STRETCHER, UNTIL DESIRED HEIGHT IS
OBTAINED. USE SMOOTH FULL STOKES TO
INSURE PATIENT COMFORT.
(FIGURE 3)
NOTE: A_PUMP PEDAL MAY BE LOCATED
AT THE FOOT END OF YOUR UNIT.
©
WEP
©
FIGURE 4
TRENDELENBURG ADJUSTMENT.
TO POSITION LITTER TOP INTC TRENDE—
LENBURG
OR REVERSE TRENDELENBURG,
PRESS EITHER HEAD OR FOOT CONTROL
BUTTON, AND ELEVATE. TO DESIRED HEIGHT.
(FIGURE 5)
OR ELEVATE UTTER TOP TO FULL HEIGHT
AND PRESS EITHER HEAD OR FOOT CONTROL
BUTTON TO LOWER UNIT TO DESIRED POSI-
NOTE: CONTROL BUTTONS MAY BE LOCATED
AT THE FOOT END OF YOUR UNIT.

5
39Vd
AMOHS
069590#
5NLAVaQ
=
NIGNGSSV
IVNIA
OW
4/ON4

EMC /FMC
FINAL ASSEMBLY
i NOTE:
i Your base may not be shown in the
i picture, but is listed below.
i 065425 |825 FOOT CONTROL BASE ASSEMBLY
i 065405 | 625 FOOT CONTROL BASE ASSEMBLY
i 065400 | 626 SIDE CONTROL BASE ASSEMBLY
DRAWING #065890
45 | 065057 [TOP COVER SHEET 12]
44 | 065895 | FOWLER BACKREST ASSEMBLY iat
43 | 065892 | UNIVERSAL TOP WELDMENT | 11
REGULAR WIDTH PARTS i i
42 | 065434 | PUSH TAB LABEL {2
41 | 065844 {#4 x .375 SHEET METAL SCREW 1 2
40 | 065845 | BUMPER LABEL PLATE | 그
39 | 052041 [#10-32 x .250 CUP PT SOC SET SCREW! 2
38 | 063022 [SERVICE LABEL 1
37 | 031457 | UNIVERSAL SERIAL NUMBER LABEL i
36 | 052044 |DORMAN WIRE STOP £100-013 2
35 | 085074 | RAIL STOP CAP 2
34 | 035116 |.313 x .375 SHOULDER BOLT la
33 | 035122 |.250—20 x 1.625 HEX HD CAP SCREW | 12
32 | 035138 |RETRACTO RAIL PIVOT SPACER 12
31 | 068025 | U-IV RETRACTO RAIL ASS'Y — LEFT 1:
30 | 066024 |U-Iv RETRACTO RAIL ASS'Y — RIGHT 1!
29 | 065561 [.313 x 3.000 SHOULDER BOLT 1
28 | 065569 [GAS SPRING 1
27 | 031412 |.250-20 x 1.750 HEX HD CAP SCREW 2
26 | 065560 | ACTUATOR COVER 1
25 | 065551 | FOWLER ACTUATOR 1
24 | 065729 [GAS SPRING PIVOT PLATE 1 1
23 | 061153 | ACTUATOR PIN 1
22 | 065553 [TRIGGER CHAMBER ASSEMBLY 1
21 | 062037 |.500 x 2.000 SHOULDER BOLT 2
20 | 065896 | EXTRA WIDE FOWLER BACKREST ASS'Y 1
19 | 061097 | GRAY RUBBER BUMPER
18 | 065727 | FOWLER STOP ASSEMBLY 25
17 | 031055 |.250—20 LOCK NUT 21
16 | 031325 |.250—20 x „500 BUT SOC HD CAP SCW | 4
15 | 000848 | HEYCO MOUNTING PLATFORM 2
14 ¡ 031076 1.250 USS FLAT WASHER PLATED 6
13 | 065116 | 410-24 x .250 TRUSS HD MACH SCW 4
12 | 065076 | SIDE SKIRT SUPPORT 2
11 | 065011 [SIDE SKIRT - SIDE CONTROL 2
10 | 031186 [POP RIVET 2
э | 031212 İVELCRO HOOK RADIUS CORNERS 2
8 | 000849 [CABLE TIE .063' 11
7 | 055213 | .250 × .500 CHERRY RIVET 12
6 | 065058 |EXTRA WIDE TOP COVER SHEET — 826 2
5 -500° WIDE BLACK TAPE 2
4
| 051118 | 188 х 1.000 SPRING PIN 4
3 [062073 | ТОР RETAINING PLUG 4
2 | 065889 [EXTRA WIDE STRAIGHT TOP WELDMENT 1
1
[065420 [826 SIDE CONTROL BASE ASSEMBLY 1
ITEM [PART No, | DESCRIPTION Giy. ci
PAGE 6

(3
ATENISSV
TYNIA
ONH/OND

839vd
NMOHS
Z
JO
>
JI33HS
i69590#
ONIMVAC
CRS
ATANASSV
ПУХ
ONH/ON9

GMC/HMC FINAL ASSEMBLY
|
| Your base may not be shown in the
| picture, but is listed below.
i : 065425 825 FOOT CONTROL BASE ASSEMBLY |
! | 065405 . 625 FOOT CONTROL BASE ASSEMBLY 1
! i 065400 : 626 SIDE CONTROL BASE ASSEMBLY 1
DRAWING #065891 SHEET 2 OF 2
44 | 062261 | EXTRA WIDE FOOT SECTION COVER SHEET
43 | 033050 JEXTRA WIDE KNEE SECTION COVER SHEET!
42 | 062255 [EXTRA WIDE SEAT SECTION COVER SHEET
40 | 062254 [EXTRA WIDE FOOT FRAME SUPP'T ASS'Y
39 | 065629 | EXTRA WIDE FOOT FRAME ASSEMBLY
1
1
1
41 | 065254 {EXTRA WIDE CRANK SUPPORT BAR 1
1
1
1
38 | 065626 |EXTRA WIDE KNEE FRAME ASSEMBLY
EXTRA WIDE PARTS
37 | 065250 | CRANK SUPPORT BAR
36 | 065258 {LOCKING COTTER PIN
=|nl-|-
, 35 | 065844 (44 x .375 SHEËT METAL SCREW
DRAWING #065891 SHEET 1 OF 2 34 | 065845 [BUMPER CONNECTING LABEL
32 | 065896 [EXTRA WIDE FOWLER BACKREST ASS'Y 1 33 | 061097 [GREY RUBBER BUMPER
31. | 065894 [EXTRA WIDE UNIVERSAL TOP WELDMENT | 1 32 | 000849 [CABLE TIE .063” 4
EXTRA WIDE PARTS 31 | 000848 [HEYCO MOUNTING PLATFORM 2
30 | 000849 | CABLE TIE .063" 9 30 500" WIDE BLACK TAPE i
29 | 065569 | GAS SPRING 1 29 | 031325 |.250—20 x .500 BUT SOC HD CAP SCW | 2
28 | 031412 |.250—20 x 1.750 НЕХ HD CAP SCREW | 2 28 | 031076 |.250 USS FLAT WASHER PLATED i 6
27 | 065560 | ACTUATOR COVER 1 27 | 065116 [#10-24 x .250 TRUSS HD MACH SCREW] 4
26 | 065551 | FOWLER ACTUATOR 1 26 | 065076 {SIDE SKIRT SUPPORT 2
25 | 065729 [GAS SPRING PIVOT PLATE 1 1 25 | 065011 [SIDE SKIRT 1 1
24 | 061153 | ACTUATOR PIN it 24 | 000794 |BSP 64 CHERRY RIVET W/STEEL 114
23 | 065553 | TRIGGER CHAMBER ASSEMBLY 1 23 | 062226 [FOOT SECTION COVER SHEET ia
22 22 | 033013 [LEG SECTION COVER SHEET nt
21 | 063022 | SERVICE LABEL 1 21 | 031435 [CHERRY RIVET 4341-8-06 | 4
20 | 031457 [UNIVERSAL SERIAL NUMBER LABEL 7 20 | 062215 SEAT SECTION COVER SHEET it
19 | 085074 [RAIL STOP CAP 2 19 | 030918 「.375-16 HEX NUT 125-6635 11
18 | 035116 | .313 x .375 SHOULDER BOLT 4 18 | 030923 :.375 LOCK WASHER i
17 | 035122 |.250-20 x 1.625 HEX HD CAP SCREW [12 17 | 030919 | SHOULDER BOLT 1
16 | 035138 |RETRACTO RAIL PIVOT SPACER 1 12 16 | 065257 :CLEVIS PIN 11
15 | 066025 [U-IV RETRACTO RAIL ASS'Y — LEFT | 1 15 | 065345 {ELEVATING CRANK ASS'Y KNEEFLEX it
14 | 066024 [U-IV RETRACTO RAIL ASS'Y — RIGHT 1 14 | 031327 |.250—20 x 1.000 BUT SOC HD CAP SCW 4
13 | 052044 [DORMAN WIRE STOP 4100-013 2 13 | 051364 |.250 SAE FLAT WASHER 12
12 | 052041 [410-32 x .250 CUP PT, SOC SET SCW | 2 12 | 065060 {RATCHET PLATE ASSEMBLY — RIGHT it
11 .500” WIDE BLACK TAPE 5 13 1 065061 | RATCHET PLATE ASSEMBLY — LEFT ny
10 10 1 031055 1.250-20 LOCK NUT ! 6
9 | 062037 |.500 x 2.000 SHOULDER BOLT 2 9 | 062128 |.250-20 x 1.250 BUT SOC HD CAP SCW! 2
8 | 065895 [FOWLER BACKREST ASSEMBLY 1 8 | 062211 ¡FOOT FRAME SUPPORT ASSEMBLY ma
7 | 065728 |LEG SECTION SUPPORT 2 7 İ 062209 İKNEEFLEX CROSSBAR SHAFT | 2
6
| 065727 [FOWLER STOP ASSEMBLY 2 6 | 031213 1.250 x .750 SPRING PIN 12
5 | 031055 |.250-20 LOCK NUT 18 5 | 065646 [FOOT FRAME ASSEMBLY it
4 | 031118 1.188 x 1.000 SPRING PIN 2 4 | 031314 :.188 x .750 SPRING PIN_PLATED i 2
3
| 062073 [TOP RETAINING PLUG 4 3 | 065622 : UNIVERSAL KNEE FRAME ASSEMBLY ia
2 | 065892 | UNIVERSAL TOP WELDMENT 1 2 | 031212 | VELCRO HOOK 2.00" x 12.00 12
1 | 065420 [826 LOW HT. SIDE CNT'L BASE ASS'Y 1 1 | 065891 [SHEET 1 OF 2 | 1
ITEM | PART No. | DESCRIPTION Oty. ITEM | PART No. DESCRIPTION i Oty.
PAGE 9

0}
3993
NAOHS
2
JO
1
LITHS
00GS90/
DNIMVUA
y м
ο m a ts a = т
Е o E 三
E 5 o 2
= = 본
IN ASSEMBLY. THESE THREE PIECES
NOTCH AT THE DIMENSIONS SHOWN.
ARE PLACED ON THE SIDE ANGLE
.062 ABOVE THE CASSETTE TRAY
STRETCHER BASE REMOVED FOR CLARITY.
OLD STYLE RETRACTO RAIL SHOWN.

外
39vd
NAOHS
2
JO
ㅎ
43388
009990#
DNIMVYG
ATANASSV
TVNI4
008/00V
STRETCHER BASE REMOVED FOR CLARITY.
OLD STYLE RETRACTO RAIL SHOWN.
NOTE:

A00/B00 FINAL ASSEMBLY |
NOTE:
Alternate Base Assembiy
|
065400
1626
SIDE
CONTROL
BASE
ASSEMBLY
[1
50 | 000794 [ESP 64 CHERRY RIVET W/STEEL 21
49 | 031326 [#10-24 x .250 BUT SOC HD CAP SCR |
48 | 031416 [SELF TAPPING SCREW TYPE A as
47 | 031421 [410-24 LOCK NUT ZINC PLATED 4 i
46 | 031461 |.250-20 x .750 BUT SOC HD CAP SCR | 2 !
45 | 062627 | BLIND RIVET i 2 |
44 | 065071 {826 CROSSTUBE HANGER (NOT SHOWN) : 2
43 | 065541 |GAS SPRING SUB-ASSEMBLY 11
42 .500 BLACK TAPE 17
41 | 052041 | #10-32 x .250 CUP PT SOC SET SCREW| 2 i
40 i 031076 |.250 USS FLAT WASHER 8
39 | 065915 | CASSETTE TRAY ASSEMBLY i
38 | 052044 [DORMAN WIRE STOP i 2
37 | 063022 | SERVICE LABEL (NOT SHOWN) a
36 | 031327 |.250-20 x 1.000 BUT SOC HD CAP SCR| 4
35 | 031412 |.250-20 x 1.750 HEX HO CAP SCREW 2
34 | 035114 [.313 x .750 SHOULDER BOLT 4
33 | 035122 |.250-20 x 1.625 HEX HD CAP SCREW [12
32 | 061870 | 210-24 x .375 BUT SOC HD CAP SCREW 4
31 030237 | RADIOLUCENT TABLE TOP LABEL 1
30 | 031325 |.250-20 « .500 BUT SOC HD CAP SCR | 10
29 | 031055 |.250-20 LOCK NUT 27
28 | 062073 | ТОР RETAINING PLUG (NOT SHOWN) 4
27 | 031457 [SERIAL NUMBER LABEL (NOT SHOWN) 1
26 | 031118 [.188 x 1.000 SPRING PIN (NOT SHOWN) | 4
25 | 000849 |.063' x 8.000" CABLE TIE 13
24 | 031074 |.188 SAE FLAT WASHER 4
23 | 062037 |.500 x 2.000 SHOULDER BOLT 2
22 | 061097 | RUBBER BUMPER
21 | 055213 | CHERRY RIVET .250 x .500 10
20 | 031212 | VELCRO HOOK RADIUS CORNERS 2
19 | 065568 | SIDE SKIRT RIGHT HEAD 1
18 | 065567 |SIDE SKIRT LEFT HEAD 1
17 | 065566 | SIDE SKIRT RIGHT FOOT 1
16 | 065565 [SIDE SKIRT LEFT FOOT 3
15 | 065434 | PUSH TAB LABEL 2
14 | 065612 | CASSETIE LABEL 2
13 | 065560 [ACTUATOR COVER 1
12 1 062311 | FOWLER STOP ASSEMBLY 2
11 | 065561 1.313 x 1.000 SHOULDER BOLT 1
10 | 065729 [GAS SPRING PIVOT PLATE 1
9 | 065726 | GLIDE TUBE SUPPORT ASSEMBLY 4
8
| 065534 |GLIDE TUBE 2
7
| 065912 | CASSETTE CARRIER ASSEMBLY 1
6 | 065025 |UIV RETRACTO RAIL ASSEMBLY LEFT 1 { 56 ] 065924 [EXTRA WIDE CASSETTE TRAY ASSEMBLY 1
5 | 066024 |UIV_RETRACTO_RAIL ASSEMBLY RIGHT 1 55 | 065921 [EXTRA WIDE CASSETTE CARRIER ASSY 1
4 | 065540 | メーRAY TOP FOOT END 1 54 | 065742 [EXTRA WIDE FOWLER BACKREST ASSY 1
3 | 065722 |FOWLER BACKREST ASSEMBLY 1 53 | 065741 | EXTRA WIDE TOP WELDMENT 1
2 | 065721 | TOP WELDMENT 1 52 | 065577 |EXTRA WIDE X-RAY TOP FOOT END i
T | 065420 [826 BASE ASSEMBLY (NOT SHOWN) 1 51 | 065072 | EXTRA WIDE CROSSTUBE HANGER (N.S.) | 2
ITEM | PARTNO. | DESCRIPTION OTY EXTRA WIDE PARTS |
PAGE 12

Eb
BOVd
NAOHS
2
40
[
LAAHS
022G90£
DNIMVÁT
OLD STYLE RETRACTO RAIL SHOWN.
STRETCHER BASE REMOVED FOR CLARITY.
NOTE:
VIANASSY
TFNIT
000/009

까
3908
NMOHS
Z
dO
Z
J33HS
0zLS90#
ONIMVUC
一
~
一
UMPER ENDS ARE TO MEET IN THE MIDDLE OF THE HEAD
ENO. AND ARE FASTENED TOGETHER WITH ITEMS
680 69
L
NOTE:
B
ITEM 67 IS CUT INTO THREE PIECES
IN ASSEMBLY. THESE THREE PIECES
ARE PLACED ON THE SIDE ANGLE
NOTCH AT THE DIMENSIONS SHOWN.
:062 ABOVE THE CASSETTE TRAY
ATANASSY
TYNII
000/009
STRETCHER BASE REMOVED FOR CLARITY.
OLD STYLE RETRACTO RAIL SHOWN.
NOTE:

C00/DOO FINAL ASSEMBLY
NOTE:
Alternate Base Assembly
| 065400 |626 SIDE CONTROL BASE ASSEMBLY la
42 | 065731 |KNEE FRAME TUBE ASSEMBLY 2 83 | 065924 | CASSETTE TRAY ASS'Y EXTRA WIDE 1
41 | 065071 | 826 CROSSTUBE HANGER (NOT SHOWN) 2 82 | 065921 | CASSETTE CARRIER ASS'Y EXTRA WIDE ! 41
40 | 062627 | BLIND RIVET i 2 81 | 065746 | PUSH ARM GUIDE TUBE EXTRA WIDE 11
39 | 065541 | GAS SPRING SUB~ASSEMBLY 1 BO | 065745 | FRAME SUPPORT ASS'Y EXTRA WIDE 1
38 | 000749 | BSP_64 CHEERY RIVET W/STEEL 2 79 | 065744 | FOOT FRAME TUBE ASS'Y EXTRA WIDE it
37 | 052041 1110-32 κ .25 SOC CUP PT. SET SCREW! 2 78 | 065742 | FOWLER BACKREST ASS'Y EXTRA WIDE 1
36 | 063022 | SERVICE LABEL (NOT SHOWN) 1 77 | 065741 |TOP WELDMENT EXTRA WIDE it
35 | 031457 | SERIAL NUMBER LABEL (NOT SHOWN) 1 76 | 065709 {SEAT SECTION COVER EXTRA WIDE it
34 .500" WIDE BLACK ELECTRICAL TAPE 7 75 | 065708 |LEG SECTION COVER EXTRA WIDE 1 1
33 | 000849 | .063" x 8.000" CABLE TIE 9 74 | 065707 | FOOT SECTION COVER EXTRA WIDE 1
32 | 052044 | DORMAN WIRE STOP 2 73 | 065072 |826 CROSSTUBE HANGER X-W (N.S.) 2
31 | 065074 | RAIL STOP CAP 4 [EXTRA WIDE PARTS !
30 | 035114 |.313 x _.375 SHOULDER BOLT 4 72 | 065434 | PUSH TAB LABEL | 2
29 | 035122 |.250-20 x 1.625 HEX HD CAP SCREW 12 71 { 061097 [RUBBER BUMPER |
28 | 035138 | RETRACTO RAIL PIVOT SPACER 12 70 | 030237 | RADIOLUCENT TOP LABEL il
27 | 066025 |Ulv RETRACTO RAIL ASSEMBLY — LEFT 1 69 | 031212 | VELCRO HOOK RADIUS CORNERS 2
26 | 066024 |UIV RETRACTO RAH ASSEMBLY — RIGHT 1 68 | 065915 | CASSETTE TRAY ASSEMBLY 1
25 | 065561 |.313 x 1.000 SHOULDER BOLT 1 67 | 065612 | CASSETTE LABEL 2
24 | 031412 |.250-20 x 1.750 HEX HD CAP SCREW 2 66 | 065568 |829 SIDE SKIRT RIGHT HEAO (N.S.) 1
23 | 065560 | ACTUATOR COVER i 65 | 065567 |829 SIDE SKIRT LEFT HEAD (N.S.) 1
22 | 065729 | GAS SPRING PIVOT PLATE 1 64 | 065566 {829 SIDE SKIRT RIGHT FOOT (N.S.) 1
21 | 062037 1.500 x 2.000 SHOULDER SOLT 4 63 | 065565 1829 SIDE SKIRT LEFT FOOT (N.S.) 1
20 | 065722 | FOWLER BACKREST ASSEMBLY 1 62 | 035419 | CUSHION HOSE 1
19 | 065728 |LEG SECTION SUPPORT 2 61 | 031186 |.188" x .500" POP RIVET 12
18 | 062311 | FOWLER STOP ASSEMBLY 2 60 | 065684 | FOOT SECTION COVER 1
17 | 031055 |.250-20 LOCK NUT 31 59 | 065685 |LEG SECTION COVER 1
16 | 031325 |.250-20 x .500 BUT SOC HD CAP SCR | 14 58 | 055213 |.250 x .500 CHERRY RIVET 4
15 | 031327 |.250-20 x 1.000 BUT SOC HO CAP SCR| 4 57 | 065686 | SEAT SECTION COVER 1
14 | 065726 |GLIDE TUBE SUPPORT ASSEMBLY 4 56 | 031314 |,188 x .750 SPRING PIN 3
13 | 065912 | CASSETTE CARRIER ASSEMBLY i 55 | 061870 1410-24 x .375 BUT SOC HD CAP SCR 4
12 | 065691 | GLIDE TUBE 2 54 | 065671 | PUSH ARM GLIDE 2
1} | 051416 |SELF TAPPING SCREW TYPE A 1 55 | 065737 | PUSH ARM GUIDE TUBE i
10 | 031421 | #10-24 LOCK NUT 1 52 | 031057 | .313-18 LOCK NUT 4
3 03326 |#10-24 x .250 BUT SOC HD CAP SCR 4 51 | 031010 |.313—18 x .750 HEX HD CAP SCREW 4
8 031461 |.250-20 x .750 BUT SOC HD CAP SCR 2 50 | 065662 | RATCHET PLATE 2
7
065683 |829 CRANK COVER 1 49 | 062128 |.250-20 x 3.250 BUT SOC HD CAP SCR| 2
6 065674 |829 CRANK ASSEMBLY 1 48 | 065735 | FRAME SUPPORT ASSEMBLY 1
5 065673 |CRANK MOUNTING PLATE 1 47 | 065688 |HINGE WASHER 2
4
031118 1.188 x 1.000 SPRING PIN 8 45 | 031028 |.250-20 x 1.500 FLAT SOC HD SCR 12
3 062073 [TOP RETAINING PLUG (NOT SHOWN) 4 45 | 065733 | CRANK PUSH ARM ASSY — LEFT hı
2 065721 |TOP WELOMENT 1 44 | 065734 ! CRANK PUSH ARM ASS'Y — RIGHT 1 1
1 065420 [826 BASE ASSEMBLY (NOT SHOWN) 1 43 | 065732 | FOOT FRAME TUBE ASSEMBLY i
ITEM | PARTNO. | DESCRIPTION OY ITEM | PARTNO. | DESCRIPTION OTY
PAGE 15

91
39vd
Z
40
I
LAZHS
S0PS90#
DNIMVYC
ATaGSSY
SV
229
у
©

625 BASE ASSEMBLY
DRAWING #065405 SHEET 2 OF 2
PAGE 17

625 BASE
DRAWING #065405 SHEET 2 OF 2
ASSEMBLY ©
[ 53 | 065072 [EXTRA WIDE CROSSTUBE HANGER 2
52 | 062931 {STOP WASHER 2
51 | 062743 | FT. END CONTROL BUTTON 1
50 | 062742 |HD. END CONTROL BUTTON 1
49 | 065403 |CABLE HE 2
DRAWING #065405 SHEET 1 OF 2 48 | 062961 | WIRE SIDE BASKET 2
48 1 031097 |#6 x .250 SHEET METAL SCREW 1 47 | 062941 [SIDE BASKET HANGER 4
47] 051311 | GROUNDING SPRING тт 46 | 040910 [COCHEM #74 HYDRAULIC OIL
46 | 052275 |LONG SPACER 2 PARTS NEEDED BUT NOT SHOWN
45 | 45 1 067227 1.250 0.D. x 21.750 KOSE 1
24. 052041 |#10~32 x .250 CUP PT. SET SCREW 2 4477 062076 14.00 COLUMN CAP — BLACK 1
43 1 052044 |DORMAN WIRE STOP 2 43 | 065615 | SMALL CYLINDER COVER PLATE 1
42 | 062640 | CABLE CLIP 2 42 | 065093 |TRIM-LOK FOR 5.00” COLUMN 1
41 | 065094 | CONTROL CABLES 2 41 | 031417 |.250-20 x .750 FLAT HD. SCREW 8
40 | 062958 | CONTROL VAVLE ASSEMBLY 1 40 | 031342 |.250-20 x .750 SQ. HD. SET SCREW 2
39 | 031416 | #8 x .500 SELF TAPPING SCREW 4 39 | 031054 |.250-20 FREE THREAD HEX МОТ 2
38
|
031074
|.500
0.D.
x_.188
LD.
FLAT
WASHER
4
38
|
065071
|
CROSSTUBE
HANGER
2
37
|
066931
|.250°
NPF
VENT
BREATHER
1
37
|
031403
|
48-32
x
.625
SELF
TAPPING
SCREW
2
36
|
031579
|.250
x
.850
RIVET
1
36
i
35 | 062804 | NYLOX BUSHING 4 35
34 | 062930 | BLOW MOLDED RESERVOIR 1 34 | 062809 | HD. END COVER ASSEMBLY 2 !
33
|
031334
[.313-18
x
2.000
MEX
HD
CAP
SCREW
|
4
33
|
062807
|
BOTTOM
COVER
17
32
|
031009
|.313-18
x
.500
HEX
HD
CAP
SCREW
4
32
|
031416
|#8
x
.500
SELF
TAPPING
SCREW
EE
31 | 031092 |.313 INTERNAL TOOTH LOCK WASHER 4 31 | 052315 |.250" 0.D. x 24.250 HOSÉ Ti
30 | 054061 |PUMP BASE SUPPORT 2 30 |
29 | 065165 [ЕТ. END CONTROLLED PUMP ASSEMBLY | 1 29 |
38 | 065408 [SHORT PUMP PEDAL ASSEMBLY 1 28 | 067226 |.250 0.D. x 6.500 HOSE 2
27 | 052210 | AXLE BEARING BRACKET 2 27
26
26 | 062694 |.250' 0.D. x 31.000 HOSE 1
25 | 031055 |.250-20 LOCK NUT 4 25 | 052036 |HOSE CLAMP 8
24 | 031076 |.250 USS FLAT WASHER 12 24 | 054141 [.375 I.D. x 8.625 HOSE 2
23 | 031321 |.250-20 x 2.000 HEX HD CAP SCREW | 8 23 | 062920 |INLET NON-PRESSURE FILTER 2
22 | 065421 [LOW HEIGHT COLUMN TUBE ASSEMBLY 2 22 1 054013 1.375 4D. x 12.000" HOSE 2
21 | 031101 |.250-20 KNURL PT. SOC SET SCREW 4 21 | 082759 | VINYL CYLINDER CAP — 4.250” 2
20 | 062666 |CASTER STEM CAP 4 20 | 051097 | POLY FOAM — 4.250” 2
19 19 | 062070 |HAUSTED LABEL 2
18 | 066508 [RIGHT BRAKE PEDAL ASSEMBLY 2 18
17 | 066507 [LEFT BRAKE PEDAL ASSEMBLY 2 17 [ 081164 | PUMP PEDAL PAD i
76
|
065056
[HEX
BRAKE
ROD
2
16
|
062814
[TOP
COVER
1
15 | 031466 | COTTER PIN 2 15 | 054089 |FOAM FOR COVER 1
14 | 031081 |.500 0.0. x -313 LD. SHIMM WASHER 2 14
T3 | 062686 [LINK PIN 2 13 | 054065 [CLEVIS PIN 2
12 | 062690 |CROSS LINK TUBE 1 12 | 031081 |.500 0D. x 313 LD, SHIM WASKER 2
71
|
062684
[SHORT
CAM LEVER
2
11
|
031375
[HITCH
PIN
4
10 | 052306 | COMPRESSION ALIGN NUT 6 10 | 065168 |РОМР LINK 2
9
| 031057 |.313—18 PREVAILIN LOCK NUT 8 9 | 062810 [END COVER ASSEMBLY 2
8 | 031080 |.875 0.0. x 313 LD. FLAT WASHER 12 B | 031164 |CHERRY RIVET - AA—62F 12
7] 031058 1.313-18 FREE THREAD HEX NUT 4 7 | 062080 | BROOM CLIP 2
6
| 065041 |.313-18 EYE BOLT 826 4 6 | 062967 [SNAP IN PLUG 1
5 | 062685 |M8 x 1.25 x 12,00 HEX HD CAP SCREW! 5 5 | 052300 [MALE ELBOW 2
4
| 062659 | CASTER BOLT LOCK PLATE 4 4 | 062736 [CYLINDER JAM NUT 2
3_| 062671 |TENTE CASTER — SWIVEL LOCK & BRAKE| 1 3 | 031503 |WAVE SPRING WASHER 2
2
| 062672 [TENTE CASTER — BRAKE 3 2 | 031501 [FINGER SPRING WASHER 2
1 | 065035 [826 BASE FRAME ASSEMBLY 1 1 | 065087 |CYLINDER ASSEMBLY - FT. END 2
ITEM
|
PARTNO.
|
DESCRIPTION
ory
ITEM
|
PARTNO.
|
DESCRIPTION
OTY
PAGE 18

61
3900
2
40
1
LAAHS
G24G907%
ONIAVYG
ATANISEV
ASVA
S38
Y