IEI Technology DRPC-W-TGL Series User manual

DRPC-W-TGL
Page I
[MODEL NAME]
User Manual
Fanless System with Intel® Tiger Lake-U Processors, Triple 2.5GbE LAN, HDMI,
DP, 8GB Memory Pre-installed, 12V DC and RoHS
MODEL:
DRPC-W-TGL Series
Rev. 1.00 –January 19, 2023

DRPC-W-TGL
Page II
[MODEL NAME]
Revision
Date
Version
Changes
January 19, 2023
1.00
Initial release

DRPC-W-TGL
Page III
[MODEL NAME]
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
All registered trademarks and product names mentioned herein are used for identification
purposes only and may be trademarks and/or registered trademarks of their respective
owners.

DRPC-W-TGL
Page IV
[MODEL NAME]
Manual Conventions
WARNING
Warnings appear where overlooked details may cause damage to the
equipment or result in personal injury. Warnings should be taken
seriously.
CAUTION
Cautionary messages should be heeded to help reduce the chance of
losing data or damaging the product.
NOTE
These messages inform the reader of essential but non-critical
information. These messages should be read carefully as any directions
or instructions contained therein can help avoid making mistakes.
HOT SURFACE
This symbol indicates a hot surface that should not be touched without
taking care.

DRPC-W-TGL
Page V
[MODEL NAME]
Table of Contents
1 INTRODUCTION.......................................................................................................... 1
1.1 OVERVIEW.................................................................................................................. 2
1.2 FEATURE .................................................................................................................... 3
1.3 MODEL VARIATIONS ................................................................................................... 3
1.4 TECHNICAL SPECIFICATIONS ...................................................................................... 4
1.5 FRONT PANEL............................................................................................................. 5
1.6 TOP PANEL ................................................................................................................. 5
1.7 PHYSICAL DIMENSIONS.............................................................................................. 6
2 UNPACKING................................................................................................................. 7
2.1ANTI-STATIC PRECAUTIONS........................................................................................ 8
2.2 UNPACKING PRECAUTIONS......................................................................................... 8
2.3 UNPACKING CHECKLIST............................................................................................. 9
3 INSTALLATION ......................................................................................................... 12
3.1 INSTALLATION PRECAUTIONS................................................................................... 13
3.2 COVER REMOVAL..................................................................................................... 14
3.3 HARD DISK BRACKET REMOVAL.............................................................................. 14
3.4 STORAGE INSTALLATION .......................................................................................... 14
3.4.1 2.5-inch SSD Installation................................................................................. 15
3.4.2 M.2 SSD Installation........................................................................................ 15
3.5 WI-FI MODULE INSTALLATION (OPTIONAL)............................................................. 16
3.6 EXPANSION I/O INSTALLATION (OPTIONAL)............................................................. 18
3.6.1 Serial Port Installation .................................................................................... 18
3.6.2 GPIO Installation............................................................................................. 19
3.6.3 iDPM Installation ............................................................................................ 20
3.7 COVER INSTALLATION.............................................................................................. 22
3.8 SYSTEM FAN INSTALLATION (OPTIONAL)................................................................. 22
3.9 MOUNTING BRACKETS INSTALLATION ..................................................................... 23
3.10 EXTERNAL PERIPHERAL INTERFACE CONNECTORS................................................. 25

DRPC-W-TGL
Page VI
[MODEL NAME]
3.10.1 HDMI/DP Connector..................................................................................... 25
3.10.2 LAN Connectors............................................................................................. 25
3.10.3 Power Connector........................................................................................... 27
3.10.4 USB 3.2 Gen 2 (10Gb/s) Connectors............................................................. 27
3.11 INTERNAL PERIPHERAL INTERFACE CONNECTORS (OPTIONAL).............................. 28
3.11.1 Digital I/O Connector .................................................................................... 28
3.11.2 M.2 Slot, B-key............................................................................................... 29
3.11.3 M.2 Slot, A-key ............................................................................................... 31
3.11.4 USB 2.0 Connector......................................................................................... 33
3.11.5 IDPM1 Display Connector .............................................................................. 34
3.11.6 Audio Connector ............................................................................................ 36
3.12 POWERING ON/OFF THE SYSTEM ........................................................................... 37
3.13AVAILABLE DRIVERS .............................................................................................. 38
3.13.1 Driver Download........................................................................................... 39
3.14 MAINTENANCE....................................................................................................... 40
3.14.1 Flash Descriptor Security Override Jumper.................................................. 41
3.14.2 Clear CMOS Button....................................................................................... 42
3.14.3 AT/ATX Power Mode Setting ......................................................................... 43
4 SYSTEM MOTHERBOARD ..................................................................................... 44
4.1 PERIPHERAL INTERFACE CONNECTORS..................................................................... 45
4.1.1 DRPC-W-TGL Series Layout........................................................................... 45
4.1.2 Peripheral Interface Connectors ..................................................................... 45
4.1.3 External Interface Panel Connectors............................................................... 46
4.2 INTERNAL PERIPHERAL CONNECTORS...................................................................... 47
4.2.1 Battery Connector............................................................................................ 47
4.2.2 Digital I/O Connector...................................................................................... 49
4.2.3 Fan Connector................................................................................................. 50
4.2.4 Front Panel Connector .................................................................................... 51
4.2.5 LAN LED Connectors...................................................................................... 52
4.2.6 iDPM Connector.............................................................................................. 53
4.2.7 M.2 Slot, B-key................................................................................................. 55
4.2.8 M.2 Slot, A-key................................................................................................. 57
4.2.9 DDR4 SO-DIMM Socket.................................................................................. 59
4.2.10 Power Connector ........................................................................................... 60

DRPC-W-TGL
Page VII
[MODEL NAME]
4.2.11 Power Button Connector................................................................................ 61
4.2.12 Reset Button Connector ................................................................................. 62
4.2.13 RS-232 Serial Port Connector....................................................................... 63
4.2.14 RS-232/422/485 Serial Port Connector......................................................... 64
4.2.15 SATA 6Gb/s Drive Connector ........................................................................ 65
4.2.16 SATA Power Connector.................................................................................. 66
4.2.17 SMBus/I2C Connector.................................................................................... 67
4.2.18 USB 2.0 Connector ........................................................................................ 68
4.3 EXTERNAL PERIPHERAL INTERFACE CONNECTOR PANEL ......................................... 69
4.3.1 HDMI Connectors............................................................................................ 70
4.3.2 DP Connector .................................................................................................. 71
4.3.3 LAN Connectors............................................................................................... 72
4.3.4 USB 3.2 Gen 2 Connectors.............................................................................. 73
4.4 DRIVER DOWNLOAD ................................................................................................ 74
4.5AVAILABLE DRIVERS ................................................................................................ 76
5 BIOS.............................................................................................................................. 77
5.1 INTRODUCTION......................................................................................................... 78
5.1.1 Starting Setup................................................................................................... 78
5.1.2 Using Setup...................................................................................................... 79
5.1.2.1 Keyboard Navigation................................................................................ 79
5.1.2.2 Touch Navigation...................................................................................... 80
5.1.3 Getting Help..................................................................................................... 81
5.1.4 Unable to Reboot after Configuration Changes.............................................. 81
5.1.5 BIOS Menu Bar................................................................................................ 81
5.2 MAIN........................................................................................................................ 82
5.3ADVANCED............................................................................................................... 85
5.3.1 CPU Configuration.......................................................................................... 86
5.3.2 Trusted Computing........................................................................................... 90
5.3.3 F81216 Super IO Configuration...................................................................... 91
5.3.3.1 Serial Port 1 Configuration....................................................................... 92
5.3.3.2 Serial Port 2 Configuration....................................................................... 93
5.3.3.3 Serial Port 3 Configuration....................................................................... 94
5.3.4 IT5571 H/W Monitor........................................................................................ 96
5.3.4.1 Smart Fan Mode Configuration................................................................ 97

DRPC-W-TGL
Page VIII
[MODEL NAME]
5.3.5 RTC Wake Settings........................................................................................... 99
5.3.6 Serial Port Console Redirection .................................................................... 101
5.3.6.1 Console Redirection Settings.................................................................. 103
5.3.7 NVMe Configuration...................................................................................... 106
5.4 CHIPSET ................................................................................................................. 107
5.4.1 System Agent (SA) Configuration .................................................................. 108
5.4.1.1 Memory Configuration ........................................................................... 109
5.4.1.2 Graphics Configuration............................................................................110
5.4.2 PCH-IO Configuration ...................................................................................112
5.4.2.1 PCI Express Configuration ......................................................................114
5.4.2.1.1 PCIe Root Port Setting........................................................................114
5.4.2.2 SATA Configuration.................................................................................117
5.4.2.3 HD Audio Configuration..........................................................................119
5.5 SECURITY............................................................................................................... 120
5.6 BOOT...................................................................................................................... 121
5.6.1 Boot Configuration ........................................................................................ 121
5.6.2 Boot Option Priorities.................................................................................... 122
5.7 SAVE &EXIT.......................................................................................................... 123
A REGULATORY COMPLIANCE............................................................................ 125
B PRODUCT DISPOSAL............................................................................................ 127
C BIOS OPTIONS........................................................................................................ 129
D WATCHDOG TIMER .............................................................................................. 133
E ERROR BEEPCODE............................................................................................... 136
E.1 PEI BEEP CODES.................................................................................................... 137
E.2 DXE BEEP CODES ................................................................................................. 137
F HAZARDOUS MATERIALS DISCLOSURE........................................................ 138
F.1 ROHS II DIRECTIVE (2015/863/EU) ...................................................................... 139
F.2 CHINA ROHS.......................................................................................................... 140

DRPC-W-TGL
Page IX
[MODEL NAME]
List of Figures
Figure 1-1: DRPC-W-TGL Series ...................................................................................................2
Figure 1-2: Front Panel ..................................................................................................................5
Figure 1-3: Top Panel.....................................................................................................................5
Figure 1-4: Physical Dimensions ..................................................................................................6
Figure 3-1: Remove the Cover.....................................................................................................14
Figure 3-2: Take out the Disk Bracket ........................................................................................14
Figure 3-3: HDD Installation ........................................................................................................15
Figure 3-4: Inserting the M.2 Module into the Slot at an Angle................................................15
Figure 3-5: Securing the M.2 Module..........................................................................................16
Figure 3-6: Inserting the WLAN Module .....................................................................................16
Figure 3-7: Securing the WLAN Module.....................................................................................17
Figure 3-8: Connecting RF Cables..............................................................................................17
Figure 3-9: Securing SMA Connector and External Antenna Installation ..............................18
Figure 3-10: Connect the serial cable to the serial connector.................................................18
Figure 3-11: Knock out the reserved holes................................................................................19
Figure 3-12: Connect the GPIO cable to the GPIO connector..................................................19
Figure 3-13: Knock out the reserved holes................................................................................20
Figure 3-14:Inserting the M.2 Module into the Slot at an Angle ..............................................20
Figure 3-15: Securing the M.2 Module........................................................................................21
Figure 3-16: Connect the VGA cable to the VGA connector ....................................................21
Figure 3-17: Knock out the reserved holes................................................................................21
Figure 3-18: Install the cover.......................................................................................................22
Figure 3-19: External Fan Module Installation...........................................................................23
Figure 3-20: Align the retention screw holes.............................................................................23
Figure 3-21: Secure the brackets................................................................................................24
Figure 3-22: Mounting the system ..............................................................................................24
Figure 3-23: HDMI/DP Connection ..............................................................................................25
Figure 3-24: LAN Connection......................................................................................................26
Figure 3-25: RJ-45 Ethernet Connector......................................................................................26
Figure 3-26: Power Connector ....................................................................................................27

DRPC-W-TGL
Page X
[MODEL NAME]
Figure 3-27: USB Connection......................................................................................................28
Figure 3-28: Digital I/O Connector Location ..............................................................................28
Figure 3-29: M.2 B key Slot Location..........................................................................................29
Figure 3-30: M.2 A-key Slot Location..........................................................................................31
Figure 3-31: USB Connector Location........................................................................................33
Figure 3-32: iDPM Slot Location .................................................................................................34
Figure 3-33: Audio Connector Location.....................................................................................36
Figure 3-34: Power Input & Button & LED .................................................................................37
Figure 3-35:Power Button............................................................................................................38
Figure 3-36: IEI Resource Download Center..............................................................................38
Figure 3-37: ME Override Setting Jumper Locations................................................................41
Figure 3-38: Clear CMOS Location .............................................................................................42
Figure 4-1: Connector and Jumper Locations...........................................................................45
Figure 4-2: Battery Connector Location.....................................................................................48
Figure 4-3: Digital I/O Connector Location ................................................................................49
Figure 4-4: Fan Connector Location...........................................................................................50
Figure 4-5: Front Panel Connector Location .............................................................................51
Figure 4-6: LAN LED Connector Locations................................................................................52
Figure 4-7: iDPM Connector Location ........................................................................................53
Figure 4-8: M.2 B-key Slot Location............................................................................................55
Figure 4-9: M.2 A-key Slot Location............................................................................................57
Figure 4-10: DDR4 SO-DIMM Socket Location ..........................................................................59
Figure 4-11: +12V DC-IN Power Connector Location................................................................60
Figure 4-12: Power Button Connector Location........................................................................61
Figure 4-13: Reset Button Connector Location.........................................................................62
Figure 4-14: RS-232 Serial Port Connector Location................................................................63
Figure 4-15: RS-232/422/485 Connector Location.....................................................................64
Figure 4-16: SATA 6Gb/s Drive Connectors Location ..............................................................65
Figure 4-17: SATA Power Connector Location .........................................................................66
Figure 4-18: SMBus Connector Location...................................................................................67
Figure 4-19: USB Connector Location........................................................................................68
Figure 4-20: External Peripheral Interface Connector ..............................................................69
Figure 4-21: HDMI Connector Pinout Locations........................................................................70
Figure 4-22: DP Connector Pinout Locations............................................................................71
Figure 4-23: LAN Connector........................................................................................................72

DRPC-W-TGL
Page XI
[MODEL NAME]
Figure 4-24: USB 3.2 Gen 2 Port Pinouts...................................................................................73
Figure 4-25: IEI Resource Download Center..............................................................................76
Figure 5-1: BIOS Starting Menu ..................................................................................................78
Figure 5-2: BIOS On-screen Navigation Keys ...........................................................................80
Figure 5-3: BIOS Options and Configured USB Ports ............................................................114

DRPC-W-TGL
Page XII
[MODEL NAME]
List of Tables
Table 1-1: DRPC-W-TGL Series Model Variations.......................................................................3
Table 1-2: Technical Specifications..............................................................................................4
Table 3-1: RJ-45 Ethernet Connector LEDs...............................................................................26
Table 3-2: Power Connector Pinouts..........................................................................................27
Table 3-3: Digital I/O Connector Pinouts....................................................................................29
Table 3-4: M. 2 B key Slot Pinouts ..............................................................................................31
Table 3-5: M.2 A-Key Slot Pinouts ..............................................................................................33
Table 3-6: USB Connector Pinouts.............................................................................................33
Table 3-7: iDPM Connector Pinouts............................................................................................35
Table 3-8: Audio Connector Pinouts ..........................................................................................36
Table 3-9: ME Override Setting Jumper Pinouts.......................................................................41
Table 3-10: Clear CMOS Pinouts.................................................................................................42
Table 3-11: AT/ATX Power Mode Switch Pinouts......................................................................43
Table 4-1: Peripheral Interface Connectors...............................................................................46
Table 4-2: Rear Panel Connectors ..............................................................................................46
Table 4-3: Battery Connector Pinouts ........................................................................................48
Table 4-4: Digital I/O Connector Pinouts....................................................................................49
Table 4-5: Fan Connector Pinouts ..............................................................................................50
Table 4-6: Front Panel Connector Pinouts.................................................................................51
Table 4-7: LAN LED Connector Pinouts.....................................................................................52
Table 4-8: iDPM Connector Pinouts............................................................................................54
Table 4-9: M.2 B-Key Slot Pinouts ..............................................................................................56
Table 4-10: M.2 A-Key Slot Pinouts ............................................................................................58
Table 4-11: +12V DC-IN Power Connector Pinouts...................................................................60
Table 4-12: Power Button Connector Pinouts...........................................................................61
Table 4-13: Reset Button Connector Pinouts............................................................................62
Table 4-14: RS-232 Serial Port Connector Pinouts ...................................................................63
Table 4-15: RS-232/422/485 Serial Port Connector Pinouts.....................................................64
Table 4-16: DB-9 RS-232/422/485 Pinouts..................................................................................65
Table 4-17: SATA Power Connector Pinouts.............................................................................66

DRPC-W-TGL
Page XIII
[MODEL NAME]
Table 4-18: SMBus Connector Pinouts ......................................................................................67
Table 4-19: USB Connector Pinouts...........................................................................................68
Table 4-20: HDMI Connector Pinouts .........................................................................................70
Table 4-21: DP Connector Pinouts..............................................................................................71
Table 4-22: LAN Pinouts ..............................................................................................................72
Table 4-23: RJ-45 Ethernet Connector LEDs.............................................................................72
Table 4-24: USB 3.2 Gen 2 Port Pinouts.....................................................................................73
Table 5-1: BIOS Navigation Keys................................................................................................79

DRPC-W-TGL
Page XIV
[MODEL NAME]
BIOS Menus
BIOS Menu 1: Main (1/2)...............................................................................................................82
BIOS Menu 2: Main (2/2)...............................................................................................................82
BIOS Menu 3: Advanced..............................................................................................................85
BIOS Menu 4: CPU Configuration (1/3).......................................................................................86
BIOS Menu 5: CPU Configuration (2/3).......................................................................................87
BIOS Menu 6: CPU Configuration (3/3).......................................................................................87
BIOS Menu 7: PCH-FW Configuration........................................................................................90
BIOS Menu 8: F81966 Super IO Configuration ..........................................................................91
BIOS Menu 9: Serial Port 1 Configuration Menu.......................................................................92
BIOS Menu 10: Serial Port 2 Configuration Menu.....................................................................93
BIOS Menu 11: Serial Port 3 Configuration Menu.....................................................................94
BIOS Menu 12: IT5571 H/W Monitor............................................................................................96
BIOS Menu 13: Smart Fan Mode Configuration ........................................................................97
BIOS Menu 14: RTC Wake Settings (1/2)....................................................................................99
BIOS Menu 15: RTC Wake Settings (2/2)..................................................................................100
BIOS Menu 16: Serial Port Console Redirection (1/2).............................................................101
BIOS Menu 17: Serial Port Console Redirection (2/2).............................................................102
BIOS Menu 18: COM Console Redirection Settings ...............................................................103
BIOS Menu 19: NVMe Configuration.........................................................................................106
BIOS Menu 20: Chipset..............................................................................................................107
BIOS Menu 21: System Agent (SA) Configuration..................................................................108
BIOS Menu 22: Memory Configuration.....................................................................................109
BIOS Menu 23: Graphics Configuration...................................................................................110
BIOS Menu 24: PCH-IO Configuration......................................................................................112
BIOS Menu 25: PCI Express Configuration .............................................................................114
BIOS Menu 26: PCIe Slot Configuration Submenu .................................................................115
BIOS Menu 27: SATA Configuration.........................................................................................117
BIOS Menu 28: HD Audio Configuration ..................................................................................119
BIOS Menu 29: Security.............................................................................................................120
BIOS Menu 30: Boot...................................................................................................................121

DRPC-W-TGL
Page XV
[MODEL NAME]
BIOS Menu 31: Save & Exit........................................................................................................123

DRPC-W-TGL
Page 1
Chapter
1
1Introduction

DRPC-W-TGL
Page 2
1.1 Overview
Figure 1-1: DRPC-W-TGL Series
The DRPC-W-TGL Series is an embedded system for wide range temperature
environments. It is powered by Intel® Tiger Lake-U processor, and pre-installed 8GB
DDR4 SO-DIMM memory (up to 32GB). The DRPC-W-TGL Series includes two HDMI,
one DP, three 2.5GbE LAN ports, four USB 3.2 Gen2 ports, and one external fan
connector.

DRPC-W-TGL
Page 3
1.2 Feature
The DRPC-W-TGL Series features are listed below:
▪Supported CPU:
Intel® Core® i7-1185G7E 1.8 GHz (up to 4.4 GHz, quad-core, TDP 15W)
Intel® Core® i5-1145G7E 1.5 GHz (up to 4.1 GHz, quad-core, TDP 15W)
Intel® Core® i3-1115G4E 2.2 GHz (up to 3.9 GHz, dual-core, TDP 15W)
Intel® Celeron® 6305 1.8 GHz (dual-core, TDP 15W)
▪Support three independent display
▪3 x 2.5GbE ports
▪1 x M.2 A Key
▪1 x M.2 B Key (with SIM card slot)
1.3 Model Variations
The model variations of the DRPC-W-TGL Series are listed below (Table 1-1).
Model No.
CPU
DRPC-W-TGL-U-CC-R10
Intel ® Celeron™ 6305 1.8GHz
(dual core, TDP 15W)
DRPC-W-TGL-U-i3C-R10
Intel ® Core™ i3-1115G4E 2.2 GHz
(up to 3.9 GHz, dual-core, TDP 15W)
DRPC-W-TGL-U-i5C-R10
Intel ® Core™ i5-1145G7E 1.5 GHz
(up to 4.1 GHz, quad-core, TDP 15W)
DRPC-W-TGL-U-i7C-R10
Intel ® Core™ i7-1185G7E 1.8 GHz
(up to 4.4 GHz, quad-core, TDP 15W)
Table 1-1: DRPC-W-TGL Series Model Variations

DRPC-W-TGL
Page 4
1.4 Technical Specifications
The DRPC-W-TGL Series technical specifications are listed in Table 1-2
Model Name
DRPC-W-TGL-U-i7C-R10
DRPC-W-TGL-U-I5C-R10
DRPC-W-TGL-U-i3C-R10
DRPC-W-TGL-U-CC-R10
Chassi
s
Color
Black
Dimensions
（WxDxH)(mm）
176x116x67.8
System Fan
Fanless
Chassis
Construction
Extruded aluminum alloys
Mother
board
CPU
Intel® Core™ i7-1185G7E
1.8GHz (up to 4.4GHz,
quad-core, TDP 15W)
Intel® Core™ i5-1145G7E
1.5GHz (up to 4.1GHz,
quad-core, TDP 15W)
Intel® Core™ i3-1115G4E
2.2GHz (up to 3.9GHz,
dual-core, TDP 15W)
Intel® Celeron™ 6305
1.8GHz (dual-core, TDP
15W)
Chipset
SOC
Memory
1x DDR4 3200MHz SO-DIMM (pre-installed 8GB) (up to 16GB)
Storage
HDD Bay
1 x 2.5” SATA 6Gb/s HDD bay
IO
Interfac
es
USB
4 x USB3.2
LAN
3 x 2.5GbE
Display
1 x DP, 2 x HDMI
Others
1 x Power button, 1 x Reset button, 1 x Power LED, 1 x HDD LED, 1 x System fan connector
Internal
Expans
ions
M.2
1 x M.2 A Key 2230 for WIFI & BT(optional)
1 x M.2 B Key(PCIe x2) 3042/3052 w/SIM slot for 5G(optional）
Power
Power Input
12V
Power
Consumption
[email protected] (Intel i5-1145G7E with 8GB DDR4 Memory)
Reliabil
ity
Mounting
DIN-Rail
Operating
Temperature
-20°C ~ 60°C with airflow, 10% ~ 95% non-condensing
Storage
Temperature
-30C°C ~ 85°C, 10% ~ 95% non-condensing
Operating Shock
Half-sine wave shock 5G, 11ms, 100 shocks per axis
Operating
Vibration
10-500 Hz,1.04 Grms, random, 1 hr/axis
Weight
（Net/Gross）
0.98/1.2 KG
Safety/EMC
CE/FCC
Watchdog Timer
Programmable 1 ~ 255 sec/min
OS
Supported OS
Microsoft ® Windows 10 / Windows 11, Linux
Table 1-2: Technical Specifications

DRPC-W-TGL
Page 5
1.5 Front Panel
The front panel of the DRPC-W-TGL Series has the following features.
Figure 1-2: Front Panel
1.6 Top Panel
The top panel of the DRPC-W-TGL Series is shown below.
Figure 1-3: Top Panel