IEI Technology PCISA-PV-N4551 User manual

1
Half-Size PCISA CPU Card with Intel® Atom™
D425/N455/D525 DDR3 VGA/LVDS Dual PCIe GbE USB
2.0 four COM three SATA II Audio and RoHS
PCISA-PV-D4251/N4551/D5251
Quick Installation Guide
Version 1.0
Oct. 13, 2010
Package Contents:
PCISA-PV-D4251/N4551/D5251 package includes the following items:
1 x PCISA-PV-D4251/N4551/D5251 Single Board Computer
1 x USB Cable
3 x SATA Cable
1 x LPT/RS232 Cable
1 x Audio cable
1 x Mini Jumper Pack
1 x QIG (Quick Installation Guide)
1 x Utility CD
1 x One Key recovery CD
©2006 Copyright
All rights reserved.

2
Specifications:
CPU:
Intel® Atom™ D525 dual-core processor (1.80GHz/1MB L2 cache)
Intel® Atom™ D425 single-core processor (1.80GHz/512KB L2 cache)
Intel® Atom™ N455 single-core processor (1.66GHz/512KB L2 cache)
System Chipset: Intel® ICH8M
BIOS: UEFI BIOS
System Memory:
One 204-pin 800MHz DDR3 SDRAM SO-DIMM Supported
(System max:2GB)
Ethernet:
Dual PCIe GbE by Realtek RTL8111E, LAN1 supports ASF2.0
I/O Interface:
3 x RS-232
1 x RS-232/422/485 with Auto Flow control
1 x LPT
1 x FDD
1 x KB/MS
3 x SATAII
1 x IDE
6 x USB 2.0 (4 by pin-header, 2 on rear side)
1 x Infrared
1 x CF Type II
Digital I/O: 8-bit digital I/O, 4-bit input / 4-bit output
Super I/O: Fintek F81865
TPM (Optional)
On board INFINEON SLB9635TT1.2
SMBus
1 x 4-pin wafer connector
Expansion: 4x PCI bus support
ISA bus support by ITE IT8888G PCI to ISA Bridge
Display:
Analog CRT up to 2048x1536 for D525/ D425, 1400x1050 for
N455, Support CRT hot plug
18-bit Single channel LVDS, resolution support up to WXGA

3
1366x768 or XGA 1024x768
Audio: On board Realtek ALC888 HD codec
Watchdog Timer: Software programmable supports 1~255 sec.
system reset
Power Supply: 5V/12V by PCISA bus, AT/ATX mode support
Power Consumption:
[email protected], 12[email protected] (CPU: D525, 1GB DDR3 1066MHz)
[email protected], 12[email protected] (CPU: D425, 1GB DDR3 1066MHz)
[email protected], 12[email protected] (CPU: N455, 1GB DDR3 1066MHz)
Temperature Operation:
-20°C~60°C with free air, -20°C~70°C with force air for D525 processor
-20°C~65°C with free air, -20°C~70°C with force air for D425 processor
-20°C~70°C with free air, -20°C~75°C with force air for N455 processor
Humidity: Operation: 5%~95% non-condensing
Dimension: 185mm x 127.6mm
Weight: GW: 1000g
Ordering Information:
PCISA-PV-D5251-R10:
Half-size PCISA CPU Card with Intel® Dual Core Atom™ D525 1.80GHz/
1MB L2 Cache, VGA/LVDS, Dual PCIe GbE, USB 2.0, 4 COM, 3 SATA
II and audio, RoHS
PCISA-PV-D5251T-R10:
Half-size PCISA CPU Card with Intel® Dual Core Atom™ D525 1.80GHz/
1MB L2 Cache, VGA/LVDS, Dual PCIe GbE, USB 2.0, 4 COM, 3 SATA
II and audio, TPM, RoHS
PCISA-PV-D4251-R10:
Half-size PCISA CPU Card with Intel® Dual Core Atom™ D425 1.80GHz/
512KB L2 Cache, VGA/LVDS, Dual PCIe GbE, USB 2.0, 4 COM, 3 SATA
II and audio, RoHS
PCISA-PV-D4251T-R10:
Half-size PCISA CPU Card with Intel® Dual Core Atom™ D425 1.80GHz/
512KB L2 Cache, VGA/LVDS, Dual PCIe GbE, USB 2.0, 4 COM, 3 SATA
II and audio, TPM, RoHS
PCISA-PV-N4551-R10:
Half-size PCISA CPU Card with Intel® Dual Core Atom™ N455 1.66GHz/
512KB L2 Cache, VGA/LVDS, Dual PCIe GbE, USB 2.0, 4 COM, 3 SATA
II and audio, RoHS

4
PCISA-PV-N4551T-R10:
Half-size PCISA CPU Card with Intel® Dual Core Atom™ N455 1.66GHz/
512KB L2 Cache, VGA/LVDS, Dual PCIe GbE, USB 2.0, 4 COM, 3 SATA
II and audio, TPM, RoHS
32200-000058-RS: FDD cable w/o bracket
19800-000075-RS: KB/MS cable with bracket
32200-000052-RS: IDE Cable
32102-000100-200-RS: SATA Power Cable
19FTS00032100-000001-RS: CPU Fan

5
Jumpers setting and Connectors:
LABEL FUNCTION
J_CMOS1 CMOS state setting jumper
JCF1 CF Card Master/Slave jumper
J_VLVDS1 LVDS1 Voltage Selection jumper
JP1 PCIe Configuration Selection jumper
JP2 RS232/422/485 Selection
ATXCTL1 AT/ATX1 mode setting
JP3 LVDS Panel Selection
COM1 RS-232
COM2 RS-232/422/485
COM3,COM4 RS-232 Pin Header
USB0_1,USB2_1
Internal USB Pin Header
USB_C1,USB_C2
USB Port
F_PANEL1 Power button / Reset / Power LED / HDD LED
LVDS1 LVDS Panel Connector
KB_MS1 6-pin Header KB/MS Connector
IR1 Infrared Interface Connector
INV1 5-pin Header Inverter Connector
AUDIO1 Audio Connector
BAT1 Battery connector
DIO1 Digital I/O Connector
SATA1
SATA2
SATA3 Serial ATA Connectors
CPU_FAN1 Fan Connector
LAN1
LAN2 RJ-45 LAN Connectors
VGA1 VGA Connector
LPT1 LPT Connector
CN1 SMBUS Connector
SPI1 Flash SPI ROM connector

6
J_CMOS1 : Clear CMOS Setup
J_CMOS1
DESCRIPTION
Short 1-2
Keep CMOS Setup
Short 2-3
Clear CMOS Setup
J_VLVDS1
: Set The Panel Voltage
PIN DESCRIPTION
Short 1-2 +3.3V
Short 3-4 +5V
Short 5-6 12V
JCF1
:
Configure CF Card type
JCF1 DESCRIPTION
Open Slave
Short 1-2 Master
JP1
:
PCI
e
Configuration
JP1 DESCRIPTION
Short PCIe x1
Open PCIe x4
JP3
LVDS Panel Selection
PIN DESCRIPTION
N/A 640*480 18bits
1-2 800*480 18bits
3-4 800*600 18bits
5-6 1280*1024 18bits
1-2, 3-4 1024*768 18bits
1-2, 5-6 1366*768 18bits
3-4,5-6 1280*800 18bits
1-2,3-4,5-6
1280*600 18bits
ATXCTL1: AT/ATX Mode S
etting
PIN DESCRIPTION
Short 2-3 AT mode
Use PS_ON#
& 5VSB Cable
ATX mode
COM1: Serial Port Connector(RS-232)
PIN NO.
DESCRIPTION
PIN NO.
DESCRIPTION
1 NDCD1 2 NDSR1
3 NRX1 4 NRTS1
5 NTX1 6 NCTS1
7 NDTR1 8 NRI1
9 GND 10 NC
JP2：
：：
：RS232/422/485 Selection
PIN DESCRIPTION
Short 1-2
RS232
Short 3-4
RS422
Short 5-6
RS485

7
COM2 : Serial Port Connector (RS-232/422/485)
PIN HEADER 2*7,14PIN, P:2.0mm
PIN
DESCRIPTION
PIN
DESCRIPTION
1 -NDCDB 2 -NDSRB
3 NSINB 4 -NRTSB
5 NSOUTB 6 -NCTSB
7 -NDTRB 8 -XRI2
9 GND 10 GND
11 TXD485+ 12 TXD485-
13 RXD485+ 14 RXD485-
USB0_1、
、、
、USB2_1: Internal USB Connector
PIN HEADER, 2x4PIN, 180°
°°
°，
，，
，P=2.54MM.
PIN
DESCRIPTION PIN
DESCRIPTION
1 VCC(+5V) 2 GND
3 DATA- 4 DATA+
5 DATA+ 6 DATA-
7 GND 8 VCC(+5V)
COM3, COM4:RS-232 PIN HEADER 2*5,10PIN,180D,P:2.0mm
PIN NO.
DESCRIPTION PIN NO.
DESCRIPTION
1 NDCD3/4 2 NDSR3/4
3 NRX3/4 4 NRTS3/4
5 NTX3/4 6 NCTS3/4
7 NDTR3/4 8 NRI3/4
9 GND 10 NC
USB_C1、
、、
、USB_C2: USB Port
PIN
DESCRIPTION PIN
DESCRIPTION
1 VCC(+5V) 5 GND
2 DATA- 6 GND
3 DATA+ 7 GND
4 GND 8 GND

8
KB_MS1
:
6
-
pin Header
,
P
=2.0MM
PIN DESCRIPTION
1 VCC5
2 Mouse DATA
3 Mouse CLK
4 Keyboard DATA
5 Keyboard CLK
6 GND
IR1
: IrDA connector
PIN
DESCRIPTION
1 VCC
2 NC
3 IRRX
4 GND
5 IRTX
LVDS1: LVDS
Connector
PIN NO.
DESCRIPTION PIN NO.
DESCRIPTION
1 GND 2 GND2
3 LVDSA_DATA0+
4 LVDSA_DATA0-
5 LVDSA_DATA1+
6 LVDSA_DATA1-
7 LVDSA_DATA2+
8 LVDSA_DATA2-
9 LVDS_CLK+ 10 LVDSA_CLK-
11 NC 12 NC
13 GND 14 GND
15 L_DDC_DATA 16 L_DDC_CLK
17 VCC_LCD 18 VCC_LCD
19 VCC_LCD 20 VCC_LCD
F_PANEL1: PWR & RST Buttons and Indicators panel
PIN
DESCRIPTION
PIN
DESCRIPTION
1
PWR_BTN+
2
PWR_LED+
PWRBTN
3
PWR_BTN- 4
PWR_LED- Power LED
5
HDD_LED+ 6
RESET+HDD
LED 7
HDD_LED- 8
RESET- RESET
INV1: 5-pin Header Inverter Connector
PIN DESCRIPTION
1 BRIGHTNESS Adjust
2 GND
3 +12V
4 GND
5 BACKLIGHT ENABLE

9
AUDIO1: Audio Module Connector
PIN HEADER 2*5,10PIN, P:2.0mm
PIN
DESCRIPTION
PIN
DESCRIPTION
1
SPEAKOUT_R
2
LINEIN_R
3
GND 4
GND
5
SPEAKOUT _L
6
LINEIN_L
7
GND 8
GND
9
MICIN_R 10
MICIN_L
DIO1: Digital Input / Output Connector
PIN
DESCRIPTION
PIN
DESCRIPTION
1
GND 2
VCC
3
OUTPUT 3 4
OUTPUT 2
5
OUTPUT 1 6
OUTPUT 0
7
INPUT 3 8
INPUT 2
9
INPUT 1 10
INPUT 0
CPU_FAN1: CPU Fan Connector
PIN
DESCRIPTION
1 GND
2 +12V
3 Sense
4 Control
BAT1 : Battery Connector
PIN
DESCRIPTION
1 BAT+
2 BAT-(GND)
SATA1/2/3：
：：
：SATA Connector
PIN
DESCRIPTION
1 GND
2 SATATXP#
3 SATAXN#
4 GND
5 SATARXN0
6 SATARXP0
7 GND
L
AN
1
,LAN2
:
RJ45
Connector
PIN NO.
DESCRIPTION
PIN NO.
DESCRIPTION
1 LAN#_MDI0+ 10 LAN_MDI3-
2 LAN#_MDI0- 11 LAN#_LINK100
3 LAN#_MDI1+ 12 LAN#_LED3/EEDO
4 LAN#_MDI1- 13 LAN#_ACT-1
5 GND 14 VCC
6 GND 15 GND
7 LAN#_MDI2+ 16 GND
8 LAN#_MDI2- 17 NC
9 LAN#_MDI3+ 18 NC

10
VGA1:D-SUB VGA,15PIN,90°,P=2.29MM
PIN NO.
DESCRIPTION
PIN NO.
DESCRIPTION
1 RED 9 VCC
2 GREEN 10 DISPLAY_GND
3 BLUE 11 NC
4 NC 12 5VDDCDA
5 GND 13 HSY
6 GND 14 VSY
7 GND 15 5VDDCLK
8 GND
LPT1: LPT PIN HEADER 2X13,26PIN,180°
°°
°,P=2.0MM
PIN NO.
DESCRIPTION
PIN NO.
DESCRIPTION
1 -STB 2 -AFD
3 PTD0 4 -ERR
5 PTD1 6 -INIT
7 PTD2 8 -SLIN
9 PTD3 10 GND
11 PTD4 12 GND
13 PTD5 14 GND
15 PTD6 16 GND
17 PTD7 18 GND
19 -ACK 20 GND
21 BUSY 22 GND
23 PE 24 GND
25 SLCT 26 NC
CN1:SMBUS Connector
PIN
DESCRIPTION
1 GND
2 SMB_DATA
3 SMB_CLK
4 VCC
SPI1: SPI Connector
PIN HEADER2*3,6PIN,180 ,P:2.0MM)
PIN
DESCRIPTION
PIN
DESCRIPTION
1
SPI_VCC 4
SPI_CLK
2
GND 5
SPI_SO
3
SPI_CS 6
SPI_SI