IEI Technology NANO-PV-D5252 User manual

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page i
User Manual
NANO-PV-D4252/N4552/D5252
MODEL:
EPIC Motherboard with Intel®
A
tom™ Processor
D425/N455/D525, VGA, Dual LVDS, GbE LAN, Eight USB 2.0,
Two SATA 3Gb/s, Four RS-232, RS-232/422/485, PCIe Mini,
PCI-104, RoHS
Rev. 1.12 – November 10, 2015

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page ii
Revision
Date Version Changes
November 10, 2015 1.12 Updated Section 1.3: Dimensions
September 21, 2015 1.11 Updated connector layout and Section 4.5.10
June 18, 2015 1.10 Updated for R11 version
March 2, 2015 1.06 Modified Memory spec on page 7
Updated Chapter 2
December 31, 2011 1.05 Added note to Section 3.1.3 and Section 4.8
August 24, 2011 1.04 Minor revision to pin definitions in the following sections:
4.5.9 LVDS1 Screen Resolution Selection
4.5.10 LVDS2 Screen Resolution Selection
June 17, 2011 1.03 Minor revision to pin definitions in section 3.2.16 Power
Connector
April 18, 2011 1.02 Updated Table 4-7, 4-8, and 4-10 jumper settings.
Updated KEY1 connector to LVDS2 Backlight Adjustment.
January 6, 2011 1.01 Revised Pins 11, 12, 23, 24 in Table 3-14 LVDS2
Connector Pinouts
November 24, 2010 1.00 Initial release

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page iii
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
All registered trademarks and product names mentioned herein are used for identification
purposes only and may be trademarks and/or registered trademarks of their respective
owners.

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page iv
Manual Conventions
WARNING
Warnings appear where overlooked details may cause damage to the
equipment or result in personal injury. Warnings should be taken
seriously.
CAUTION
Cautionary messages should be heeded to help reduce the chance of
losing data or damaging the product.
NOTE
These messages inform the reader of essential but non-critical
information. These messages should be read carefully as any directions
or instructions contained therein can help avoid making mistakes.
HOT SURFACE
This symbol indicates a hot surface that should not be touched without
taking care.

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page v
Table of Contents
1 INTRODUCTION.......................................................................................................... 1
1.1 INTRODUCTION........................................................................................................... 2
1.2 CONNECTORS ............................................................................................................. 3
1.3 DIMENSIONS............................................................................................................... 4
1.4 DATA FLOW................................................................................................................ 6
1.5 TECHNICAL SPECIFICATIONS ...................................................................................... 7
2 UNPACKING................................................................................................................. 9
2.1ANTI-STATIC PRECAUTIONS...................................................................................... 10
2.2 UNPACKING PRECAUTIONS....................................................................................... 10
2.3 PACKING LIST............................................................................................................11
2.3.1 Optional Items.................................................................................................. 12
3 CONNECTORS ........................................................................................................... 14
3.1 PERIPHERAL INTERFACE CONNECTORS..................................................................... 15
3.1.1 NANO-PV-D4252/N4552/D5252 Layout......................................................... 15
3.1.2 Peripheral Interface Connectors ..................................................................... 16
3.1.3 External Interface Panel Connectors............................................................... 17
3.2 INTERNAL PERIPHERAL CONNECTORS...................................................................... 18
3.2.1 Audio Connector .............................................................................................. 18
3.2.2 Battery Connector............................................................................................ 19
3.2.3 CompactFlash® Slot........................................................................................ 19
3.2.4 Digital I/O Connector...................................................................................... 21
3.2.5 Fan Connector (CPU)...................................................................................... 22
3.2.6 Fan Connector (System) .................................................................................. 22
3.2.7 Front Panel Connector .................................................................................... 23
3.2.8 Keyboard/Mouse Connector............................................................................ 24
3.2.9 Backlight Inverter Connector .......................................................................... 25
3.2.10 LVDS Backlight Adjustment (LVDS2)............................................................ 25
3.2.11 LVDS1 LCD Connector.................................................................................. 26

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page vi
3.2.12 LVDS2 LCD Connector ................................................................................. 27
3.2.13 Parallel Port Connector ................................................................................ 28
3.2.14 PCI-104 Connector........................................................................................ 29
3.2.15 PCIe Mini Card Slot ...................................................................................... 30
3.2.16 Power Connector (+12 V, power supply)....................................................... 32
3.2.17 SATA Drive Connectors ................................................................................. 32
3.2.18 SATA Power Connector.................................................................................. 33
3.2.19 Serial Port Connectors (RS-232)................................................................... 34
3.2.20 Serial Port Connector (RS-232/422/485) ...................................................... 35
3.2.21 SMBus Connector .......................................................................................... 35
3.2.22 SPI Flash Connector...................................................................................... 36
3.2.23 USB Connectors............................................................................................. 37
3.3 EXTERNAL PERIPHERAL INTERFACE CONNECTOR PANEL ......................................... 38
3.3.1 Ethernet Connector.......................................................................................... 38
3.3.2 Keyboard/Mouse Connector............................................................................ 39
3.3.3 USB Connectors............................................................................................... 40
3.3.4 VGA Connector................................................................................................ 40
4 INSTALLATION ......................................................................................................... 42
4.1ANTI-STATIC PRECAUTIONS...................................................................................... 43
4.2 INSTALLATION CONSIDERATIONS.............................................................................. 44
4.2.1 Installation Notices.......................................................................................... 44
4.3 UNPACKING.............................................................................................................. 45
4.4 SO-DIMM INSTALLATION ....................................................................................... 45
4.5 JUMPER SETTINGS .................................................................................................... 46
4.5.1 AT Auto Button Power Select Jumper Settings ................................................ 47
4.5.2 AT/ATX Power Select Jumper Settings ............................................................ 48
4.5.3 Clear CMOS Jumper........................................................................................ 48
4.5.4 COM 3 Function Select Jumper....................................................................... 49
4.5.5 COM 3 RS-422/485 Function Select Jumper................................................... 50
4.5.6 COM 3 RS-422/485 Termination Select Jumpers ............................................ 51
4.5.7 CompactFlash® Card Setup............................................................................ 52
4.5.8 CompactFlash® Voltage Selection .................................................................. 53
4.5.9 LVDS1 Screen Resolution Selection................................................................. 53
4.5.10 LVDS2 Screen Resolution Selection............................................................... 54

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page vii
4.5.11 LVDS Voltage Selection.................................................................................. 55
4.5.12 PCI-104 Voltage Setup................................................................................... 56
4.6 CHASSIS INSTALLATION............................................................................................ 57
4.6.1 Airflow.............................................................................................................. 57
4.6.2 Motherboard Installation................................................................................. 57
4.7 INTERNAL PERIPHERAL DEVICE CONNECTIONS........................................................ 57
4.7.1 AT/ATX Power Connection.............................................................................. 57
4.7.2 Audio Kit Installation....................................................................................... 59
4.7.3 Single RS-232 Cable (w/o Bracket) ................................................................. 60
4.8 SOFTWARE INSTALLATION ........................................................................................ 61
5 BIOS SCREENS........................................................................................................... 63
5.1 INTRODUCTION......................................................................................................... 64
5.1.1 Starting Setup................................................................................................... 64
5.1.2 Using Setup...................................................................................................... 64
5.1.3 Getting Help..................................................................................................... 65
5.1.4 Unable to Reboot after Configuration Changes.............................................. 65
5.1.5 BIOS Menu Bar................................................................................................ 65
5.2 MAIN........................................................................................................................ 66
5.3ADVANCED............................................................................................................... 67
5.3.1 ACPI Settings................................................................................................... 68
5.3.2 Trusted Computing........................................................................................... 69
5.3.3 CPU Configuration.......................................................................................... 70
5.3.4 IDE Configuration........................................................................................... 71
5.3.5 USB Configuration........................................................................................... 72
5.3.6 Super IO Configuration ................................................................................... 73
5.3.6.1 Serial Port n Configuration....................................................................... 74
5.3.6.2 Parallel Port Configuration....................................................................... 79
5.3.7 H/W Monitor.................................................................................................... 80
5.3.8 Serial Port Console Redirection ...................................................................... 82
5.4 CHIPSET ................................................................................................................... 84
5.4.1 Host Bridge Configuration .............................................................................. 85
5.4.1.1 OnChip VGA Configuration..................................................................... 86
5.4.2 South Bridge Configuration............................................................................. 86
5.4.3 Intel IGD SWSCI OpRegion............................................................................. 88

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page viii
5.5 BOOT........................................................................................................................ 90
5.6 SECURITY................................................................................................................. 91
5.7 SAVE &EXIT............................................................................................................ 92
A REGULATORY COMPLIANCE.............................................................................. 94
B BIOS MENU OPTIONS............................................................................................. 96
C TERMINOLOGY ....................................................................................................... 99
D DIGITAL I/O INTERFACE..................................................................................... 103
D.1 INTRODUCTION...................................................................................................... 104
D.2ASSEMBLY LANGUAGE SAMPLE 1.......................................................................... 105
D.3ASSEMBLY LANGUAGE SAMPLE 2.......................................................................... 105
E WATCHDOG TIMER............................................................................................... 106
F HAZARDOUS MATERIALS DISCLOSURE........................................................ 109
F.1 HAZARDOUS MATERIAL DISCLOSURE TABLE FOR IPB PRODUCTS CERTIFIED AS ROHS
COMPLIANT UNDER 2002/95/EC WITHOUT MERCURY.................................................110

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page ix
List of Figures
Figure 1-1: NANO-PV-D4252/N4552/D5252 ..................................................................................2
Figure 1-2: Connectors ..................................................................................................................3
Figure 1-3: NANO-PV-D4252/N4552 Dimensions (mm)...............................................................4
Figure 1-4: NANO-PV-D5252 Dimensions (mm) ..........................................................................5
Figure 1-5: Data Flow Block Diagram...........................................................................................6
Figure 3-1: Connector and Jumper Locations...........................................................................15
Figure 3-2: Audio Connector Location.......................................................................................18
Figure 3-3: Battery Connector Location.....................................................................................19
Figure 3-4: CompactFlash® Slot Location.................................................................................20
Figure 3-5: Digital I/O Connector Locations ..............................................................................21
Figure 3-6: CPU Fan Connector Location..................................................................................22
Figure 3-7: +12V Fan Connector Locations...............................................................................23
Figure 3-8: Front Panel Connector Location .............................................................................23
Figure 3-9: Keyboard/Mouse Connector Location....................................................................24
Figure 3-10: Backlight Inverter Connector Location.................................................................25
Figure 3-11: LVDS2 Backlight Adjustment Connector Location .............................................26
Figure 3-12: LVDS1 Connector Locations .................................................................................26
Figure 3-13: LVDS2 Connector Location ...................................................................................27
Figure 3-14: Parallel Port Connector Location..........................................................................28
Figure 3-15: PCI-104 Connector Location..................................................................................29
Figure 3-16: PCIe Mini Card Slot Location.................................................................................31
Figure 3-17: CPU 12V Power Connector Location....................................................................32
Figure 3-18: SATA Drive Connector Locations .........................................................................33
Figure 3-19: SATA Power Connector Locations .......................................................................34
Figure 3-20: COM Connector Pinout Locations ........................................................................34
Figure 3-21: Serial Port Connector Location.............................................................................35
Figure 3-22: SMBus Connector Locations.................................................................................36
Figure 3-23: SPI Flash Connector...............................................................................................36
Figure 3-24: USB Connector Pinout Locations.........................................................................37
Figure 3-25: NANO-PV-D4252/N4552/D5252 External Peripheral Interface Connector.........38

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page x
Figure 3-26: RJ-45 Ethernet Connector......................................................................................39
Figure 3-27: PS/2 Pinout and Configuration..............................................................................39
Figure 3-28: VGA Connector .......................................................................................................41
Figure 4-1: SO-DIMM Installation................................................................................................45
Figure 4-2: AT Auto Button Select Jumper Settings.................................................................47
Figure 4-3: AT/ATX Power Select Jumper Location..................................................................48
Figure 4-4: Clear CMOS Jumper .................................................................................................49
Figure 4-5: COM 3 Function Select Jumper Location...............................................................50
Figure 4-6: COM 3 RS-422/485 Function Select Jumper Location ..........................................51
Figure 4-7: COM 3 RS-422 and RS-485 Termination Select Jumper Location .......................52
Figure 4-8: CompactFlash® Setup Jumper Location ...............................................................52
Figure 4-9: CompactFlash® Voltage Selection Jumper Location ...........................................53
Figure 4-10: LVDS1 Screen Resolution Jumper Location........................................................54
Figure 4-11: LVDS2 Screen Resolution Jumper Location........................................................55
Figure 4-12: LVDS Voltage Selection Jumper Locations .........................................................56
Figure 4-13: PCI-104 Voltage Jumper Location.........................................................................56
Figure 4-14: Power Cable to Motherboard Connection............................................................58
Figure 4-15: Connect Power Cable to Power Supply................................................................59
Figure 4-16: Audio Kit Cable Connection ..................................................................................60
Figure 4-17: Single RS-232 Cable Installation ...........................................................................61
Figure 4-18: Introduction Screen................................................................................................62
Figure 4-19: Available Drivers.....................................................................................................62

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page xi
List of Tables
Table 1-1: Technical Specifications..............................................................................................8
Table 3-1: Peripheral Interface Connectors...............................................................................17
Table 3-2: Rear Panel Connectors..............................................................................................17
Table 3-3: Audio Connector Pinouts ..........................................................................................18
Table 3-4: Battery Connector Pinouts........................................................................................19
Table 3-5: CompactFlash® Slot Pinouts....................................................................................21
Table 3-6: Digital I/O Connector Pinouts....................................................................................21
Table 3-7: CPU Fan Connector Pinouts......................................................................................22
Table 3-8: +12V Fan Connector Pinouts.....................................................................................23
Table 3-9: Front Panel Connector Pinouts.................................................................................24
Table 3-10: Keyboard/Mouse Connector Pinouts .....................................................................24
Table 3-11: Backlight Inverter Connector Pinouts....................................................................25
Table 3-12: LVDS2 Backlight Adjustment Connector Pinouts.................................................26
Table 3-13: LVDS1 Connector Pinouts.......................................................................................27
Table 3-14: LVDS2 Connector Pinouts.......................................................................................28
Table 3-15: Parallel Port Connector Pinouts................................................................29
Table 3-16: PCI-104 Connector Pinouts .....................................................................................30
Table 3-17: PCIe Mini Card Slot Pinouts ....................................................................................32
Table 3-18: CPU 12V Power Connector Pinouts........................................................................32
Table 3-19: SATA Drive Connector Pinouts...............................................................................33
Table 3-20: SATA Power Connector Pinouts.............................................................................34
Table 3-21: COM Connector Pinouts..........................................................................................35
Table 3-22: Serial Port Connector Pinouts ................................................................................35
Table 3-23: SMBus Connector Pinouts ......................................................................................36
Table 3-24: SPI Flash Connector Pinouts ..................................................................................37
Table 3-25: USB Port Connector Pinouts...................................................................................37
Table 3-26: LAN Pinouts ..............................................................................................................38
Table 3-27: RJ-45 Ethernet Connector LEDs.............................................................................39
Table 3-28: Keyboard Connector Pinouts..................................................................................40
Table 3-29: USB Port Connector Pinouts...................................................................................40

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page xii
Table 3-30: VGA Connector Pinouts...........................................................................................41
Table 4-1: Jumpers.......................................................................................................................47
Table 4-2: AT Auto Button Power Select Jumper Settings ......................................................47
Table 4-3: AT/ATX Power Select Jumper Settings....................................................................48
Table 4-4: Clear CMOS Jumper Settings....................................................................................49
Table 4-5: COM 3 Function Select Jumper Settings.................................................................50
Table 4-6: COM 3 RS-422/485 Function Select Jumper Settings.............................................50
Table 4-7: COM 3 RS-422 Termination Select Jumper Settings ..............................................51
Table 4-8: COM 3 RS-485 Termination Select Jumper Settings ..............................................51
Table 4-9: CompactFlash® Setup Jumper Settings..................................................................52
Table 4-10: CompactFlash® Voltage Selection Jumper Settings............................................53
Table 4-11: LVDS1 Screen Resolution Jumper Settings..........................................................54
Table 4-12: LVDS2 Screen Resolution Jumper Settings..........................................................55
Table 4-13: LVDS Voltage Selection Jumper Settings..............................................................55
Table 4-14: PCI-104 Voltage Jumper Settings ...........................................................................56
Table 5-1: BIOS Navigation Keys................................................................................................65

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page xiii
BIOS Menus
BIOS Menu 1: Main.......................................................................................................................66
BIOS Menu 2: Advanced..............................................................................................................67
BIOS Menu 3: ACPI Settings .......................................................................................................68
BIOS Menu 4: TPM Configuration...............................................................................................69
BIOS Menu 5: CPU Configuration...............................................................................................70
BIOS Menu 6: IDE Configuration.................................................................................................71
BIOS Menu 7: USB Configuration...............................................................................................72
BIOS Menu 8: Super IO Configuration........................................................................................73
BIOS Menu 9: Serial Port n Configuration Menu.......................................................................74
BIOS Menu 10: Parallel Port Configuration Menu.....................................................................79
BIOS Menu 11: H/W Monitor Configuration ...............................................................................81
BIOS Menu 12: Serial Port Console Redirection.......................................................................82
BIOS Menu 13: Chipset................................................................................................................84
BIOS Menu 14: Host Bridge Chipset Configuration..................................................................85
BIOS Menu 15: OnChip VGA Configuration...............................................................................86
BIOS Menu 16:South Bridge Chipset Configuration.................................................................87
BIOS Menu 17:South Bridge Chipset Configuration.................................................................88
BIOS Menu 18: Boot.....................................................................................................................90
BIOS Menu 19: Security...............................................................................................................91
BIOS Menu 20: Save & Exit..........................................................................................................92

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page 1
Chapter
1
1 Introduction

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page 2
1.1 Introduction
Figure 1-1: NANO-PV-D4252/N4552/D5252
The NANO-PV-D4252/N4552/D5252 EPIC motherboard is an Intel® Atom™ processor
D525, D425 or N455 platform. Up to one 2.0 GB or 4.0 GB 800 MHz DDR3 SDRAM
SO-DIMM is supported by the NANO-PV-D4252/N4552/D5252.
The integrated Intel® ICH8M chipset supports a GbE LAN port through the Realtek
RTL8111E Ethernet controller (with ASF 2.0 support). The NANO-PV-D4252/N4552/D5252
also supports two SATA 3Gb/s drives and provides 5 V SATA power.
The NANO-PV-D4252/N4552/D5252 supports dual display via VGA and two internal
LVDS LCD connectors. Eight USB 2.0 channels, one PCIe Mini socket, one PCI-104 slot
and internal one parallel port connector provide flexible expansion options. High Definition
Audio (HDA) support ensures HDA devices can be easily implemented on the
NANO-PV-D4252/N4552/D5252. Serial device connectivity is provided by a RS-232 serial
port, three internal RS-232 and one internal RS-232/422/485 connectors.

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page 3
1.2 Connectors
The connectors on the NANO-PV-D4252/N4552/D5252 are shown in the figures below.
Figure 1-2: Connectors

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page 4
1.3 Dimensions
The dimensions of the board are listed below:
Figure 1-3: NANO-PV-D4252/N4552 Dimensions (mm)

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page 5
Figure 1-4: NANO-PV-D5252 Dimensions (mm)

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page 6
1.4 Data Flow
5Figure 1-5 shows the data flow between the two on-board chipsets and other components
installed on the motherboard and described in the following sections of this chapter.
Figure 1-5: Data Flow Block Diagram

NANO-PV-D4252/N4552/D5252 EPIC SBC
Page 7
1.5 Technical Specifications
NANO-PV-D4252/N4552/D5252 technical specifications are listed in table below.
Specification NANO-PV-D4252/N4552/D5252
Form Factor EPIC
CPU options Intel® Atom™ processor D525, 1.8 GHz/1 MB L2 cache
Intel® Atom™ processor D425, 1.8 GHz/512 KB L2 cache
Intel® Atom™ processor N455, 1.66 GHz/512 KB L2 cache
Express Chipset Intel® ICH8M
Memory One 204-pin 800 MHz DDR3 SDRAM SO-DIMM supported
D525/D425: System max. 4.0 GB
N455: System max. 2.0 GB
Audio Realtek ALC662 HD audio codec
LAN One Realtek RTL8111E PCIe GbE controller with ASF 2.0
support
Super I/O Fintek F81865
Digital I/O 8-bit digital I/O
BIOS AMI BIOS label
Watchdog Timer Software programmable supports 1~255 sec. system reset
Expansion
PCIe One PCIe Mini slot
PCI One PCI-104 slot
I/O Interface Connectors
Audio Connector One internal audio connector (10-pin header)
Display Ports One VGA port (2048x1536)
One internal 24-bit dual-channel LVDS connector by Novatek
NT68660BUFG (up to 1920x1080)
One internal 18-bit single-channel LVDS connector (up to
1024x768 or 1366x768)