IEI Technology KINO-DQM871-i1 User manual

KINO-DQM871-i1 Mini-ITX SBC
Page i
User Manual
Mini-ITX SBC with 4th Generation 22nm Intel® Core™CPU
Up to 16.0 GB DDR3, HDMI, LVDS, DisplayPort, VGA
Dual GbE, SATA 6Gb/s, USB 3.2 Gen 1, PCIe Mini,
PCIe x16, Intel® AMT 9.0, IPMI 2.0, RoHS
MODEL:
KINO-DQM871-i1
Rev. 1.03 – June 23, 2021

KINO-DQM871-i1 Mini-ITX SBC
Page ii
Revision
Date Version Changes
June 23, 2021 1.03 Deleted i7, i3E and CE SKUs
Updated Section 2.3: Packing List
Updated Chapter 6: Software Drivers
Changed audio IC to ALC888S
September 23, 2015 1.02 Modified the total number of the internal USB 2.0 ports
July 16, 2015 1.01 Updated Section 4.7.1: AT/ATX Mode Selection
June 23, 2014 1.00 Initial release

KINO-DQM871-i1 Mini-ITX SBC
Page iii
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
All registered trademarks and product names mentioned herein are used for identification
purposes only and may be trademarks and/or registered trademarks of their respective
owners.

KINO-DQM871-i1 Mini-ITX SBC
Page iv
Manual Conventions
WARNING
Warnings appear where overlooked details may cause damage to the
equipment or result in personal injury. Warnings should be taken
seriously.
CAUTION
Cautionary messages should be heeded to help reduce the chance of
losing data or damaging the product.
NOTE
These messages inform the reader of essential but non-critical
information. These messages should be read carefully as any directions
or instructions contained therein can help avoid making mistakes.

KINO-DQM871-i1 Mini-ITX SBC
Page v
Table of Contents
1 INTRODUCTION.......................................................................................................... 1
1.1 INTRODUCTION........................................................................................................... 2
1.2 BENEFITS ................................................................................................................... 3
1.3 FEATURES................................................................................................................... 3
1.4 CONNECTORS ............................................................................................................. 4
1.5 DIMENSIONS............................................................................................................... 5
1.6 DATA FLOW................................................................................................................ 6
1.7 TECHNICAL SPECIFICATIONS ...................................................................................... 7
2 PACKING LIST........................................................................................................... 10
2.1ANTI-STATIC PRECAUTIONS.......................................................................................11
2.2 UNPACKING PRECAUTIONS........................................................................................11
2.3 PACKING LIST........................................................................................................... 12
2.4 OPTIONAL ITEMS...................................................................................................... 13
3 CONNECTOR PINOUTS........................................................................................... 14
3.1 PERIPHERAL INTERFACE CONNECTORS..................................................................... 15
3.1.1 Layout .............................................................................................................. 15
3.1.2 Peripheral Interface Connectors ..................................................................... 16
3.1.3 External Interface Panel Connectors............................................................... 17
3.2 INTERNAL PERIPHERAL CONNECTORS...................................................................... 18
3.2.1 ATX Power Signal Connector.......................................................................... 18
3.2.2 Battery Connector............................................................................................ 19
3.2.3 Chassis Intrusion Connector............................................................................ 20
3.2.4 Digital I/O Connector...................................................................................... 21
3.2.5 DisplayPort Connector.................................................................................... 21
3.2.6 EC Debug Connector....................................................................................... 23
3.2.7 Fan Connector (CPU)...................................................................................... 24
3.2.8 Fan Connector (System) .................................................................................. 24
3.2.9 Front Panel Connector .................................................................................... 25
3.2.10 iRIS Module Slot............................................................................................ 26

KINO-DQM871-i1 Mini-ITX SBC
Page vi
3.2.11 IPMI Active LED Connector.......................................................................... 27
3.2.12 Keyboard/Mouse Connector .......................................................................... 28
3.2.13 LAN Active LED Connector........................................................................... 29
3.2.14 LVDS Connector ............................................................................................ 30
3.2.15 LVDS Backlight Connector............................................................................ 32
3.2.16 PCIe Mini Card Slot ...................................................................................... 32
3.2.17 PCI Express x16 Slot...................................................................................... 34
3.2.18 Power Button (On-board).............................................................................. 36
3.2.19 Power Connector (12V)................................................................................. 37
3.2.20 RS-232 Serial Port Connectors (COM2 ~ COM5)........................................ 37
3.2.21 RS-422/485 Serial Port Connector (COM6).................................................. 39
3.2.22 SATA 6Gb/s Drive Connectors....................................................................... 40
3.2.23 SATA 3Gb/s Drive Connectors....................................................................... 41
3.2.24 SATA Power Connectors................................................................................ 42
3.2.25 SMBus Connector .......................................................................................... 43
3.2.26 SO-DIMM Connectors................................................................................... 44
3.2.27 SPI Flash Connector...................................................................................... 45
3.2.28 SPI Flash Connector (EC)............................................................................. 46
3.2.29 TPM Connector.............................................................................................. 47
3.2.30 USB 2.0 Connectors....................................................................................... 48
3.2.31 USB 3.2 Gen 1 Connector.............................................................................. 50
3.3 EXTERNAL INTERFACE CONNECTORS....................................................................... 51
3.3.1 Audio Connector.............................................................................................. 51
3.3.2 Ethernet and USB 2.0 Connectors................................................................... 52
3.3.3 Ethernet and USB 3.2 Gen 1 Connectors ........................................................ 53
3.3.4 HDMI Connectors............................................................................................ 54
3.3.5 Power Connector (12 V, Power Adapter) ........................................................ 55
3.3.6 Serial Port Connector (COM1) ....................................................................... 56
3.3.7 VGA Connector................................................................................................ 57
4 INSTALLATION ......................................................................................................... 58
4.1ANTI-STATIC PRECAUTIONS...................................................................................... 59
4.2 INSTALLATION CONSIDERATIONS.............................................................................. 59
4.3 COOLING KIT INSTALLATION.................................................................................... 61
4.4 SO-DIMM INSTALLATION ....................................................................................... 63

KINO-DQM871-i1 Mini-ITX SBC
Page vii
4.5 IRIS-1010 MODULE INSTALLATION.......................................................................... 64
4.6 PCIE MINI CARD INSTALLATION .............................................................................. 66
4.7 JUMPER SETTINGS .................................................................................................... 67
4.7.1 AT/ATX Mode Selection ................................................................................... 68
4.7.2 Clear CMOS..................................................................................................... 69
4.7.3 LVDS Voltage Selection.................................................................................... 70
4.7.4 LVDS Resolution Selection .............................................................................. 71
4.8 CHASSIS INSTALLATION............................................................................................ 72
4.8.1 Airflow.............................................................................................................. 72
4.8.2 Motherboard Installation................................................................................. 73
4.9 INTERNAL PERIPHERAL DEVICE CONNECTIONS........................................................ 73
4.9.1 SATA Drive Connection ................................................................................... 73
4.10 IPMI SETUP PROCEDURE ....................................................................................... 74
4.11 INTEL®AMT SETUP PROCEDURE ........................................................................... 74
5 BIOS.............................................................................................................................. 76
5.1 INTRODUCTION......................................................................................................... 77
5.1.1 Starting Setup................................................................................................... 77
5.1.2 Using Setup...................................................................................................... 77
5.1.3 Getting Help..................................................................................................... 78
5.1.4 Unable to Reboot after Configuration Changes.............................................. 78
5.1.5 BIOS Menu Bar................................................................................................ 79
5.2 MAIN........................................................................................................................ 80
5.3ADVANCED............................................................................................................... 81
5.3.1 ACPI Settings................................................................................................... 82
5.3.2 RTC Wake Settings........................................................................................... 83
5.3.3 Trusted Computing........................................................................................... 84
5.3.4 CPU Configuration.......................................................................................... 86
5.3.5 SATA Configuration ......................................................................................... 88
5.3.6 Intel(R) Rapid Start Technology....................................................................... 89
5.3.7 AMT Configuration.......................................................................................... 90
5.3.8 USB Configuration........................................................................................... 91
5.3.9 iWDD H/W Monitor......................................................................................... 92
5.3.9.1 Smart Fan Mode Configuration................................................................ 93
5.3.10 F81866 Super IO Configuration.................................................................... 94

KINO-DQM871-i1 Mini-ITX SBC
Page viii
5.3.10.1 Serial Port n Configuration..................................................................... 95
5.3.11 Serial Port Console Redirection................................................................... 100
5.3.12 iEi Feature ................................................................................................... 104
5.4 CHIPSET ................................................................................................................. 105
5.4.1 PCH-IO Configuration .................................................................................. 106
5.4.1.1 PCI Express Configuration..................................................................... 108
5.4.2 System Agent (SA) Configuration .................................................................. 109
5.4.2.1 Graphics Configuration........................................................................... 109
5.4.2.2 NB PCIe Configuration............................................................................112
5.4.2.3 Memory Configuration ............................................................................113
5.5 BOOT.......................................................................................................................114
5.6 SECURITY................................................................................................................116
5.7 SAVE &EXIT...........................................................................................................116
6 SOFTWARE DRIVERS.............................................................................................118
6.1AVAILABLE DRIVERS ...............................................................................................119
6.2 DRIVER DOWNLOAD ...............................................................................................119
A REGULATORY COMPLIANCE............................................................................ 121
B PRODUCT DISPOSAL............................................................................................ 123
C BIOS OPTIONS........................................................................................................ 125
D DIGITAL I/O INTERFACE..................................................................................... 128
E WATCHDOG TIMER............................................................................................... 131
FADDRESS MAPPING............................................................................................... 134
F.1 DIRECT MEMORY ACCESS (DMA) ......................................................................... 135
F.2 INPUT/OUTPUT (IO) ............................................................................................... 136
F.3 INTERRUPT REQUEST (IRQ) ................................................................................... 139
F.4 MEMORY ................................................................................................................ 140
G ERROR BEEP CODE .............................................................................................. 142
G.1 PEI BEEP CODES.................................................................................................... 143
G.2 DXE BEEP CODES ................................................................................................. 143
H HAZARDOUS MATERIALS DISCLOSURE....................................................... 144

KINO-DQM871-i1 Mini-ITX SBC
Page ix
H.1 ROHS II DIRECTIVE (2015/863/EU) ..................................................................... 145
H.2 CHINA ROHS......................................................................................................... 146

KINO-DQM871-i1 Mini-ITX SBC
Page x
List of Figures
Figure 1-1: KINO-DQM871-i1 .........................................................................................................2
Figure 1-2: Connectors ..................................................................................................................4
Figure 1-3: KINO-DQM871-i1 Dimensions (mm)..........................................................................5
Figure 1-4: Data Flow Diagram......................................................................................................6
Figure 3-1: Connector and Jumper Locations...........................................................................15
Figure 3-2: ATX Power Signal Connector Location..................................................................18
Figure 3-3: Battery Connector Location.....................................................................................19
Figure 3-4: Chassis Intrusion Connector Location...................................................................20
Figure 3-5: Digital I/O Connector Location................................................................................21
Figure 3-6: DisplayPort Connector Location.............................................................................22
Figure 3-7: BIOS Debug Port Location.......................................................................................23
Figure 3-8: CPU Fan Connector Location..................................................................................24
Figure 3-9: System Fan Connector Location.............................................................................25
Figure 3-10: Front Panel Connector Location...........................................................................26
Figure 3-11: iRIS Module Slot Location......................................................................................27
Figure 3-12: IPMI Active LED Connector....................................................................................28
Figure 3-13: Keyboard/Mouse Connector Location..................................................................29
Figure 3-14: LAN Active LED Connector Location....................................................................30
Figure 3-15: LVDS Connector Location......................................................................................31
Figure 3-16: LVDS Backlight Inverter Connector......................................................................32
Figure 3-17: PCIe Mini Card Slot Location.................................................................................33
Figure 3-18: PCIe x16 Slot Location ...........................................................................................34
Figure 3-19: On-board Power Button Location .........................................................................36
Figure 3-20: Power Connector Location ....................................................................................37
Figure 3-21: RS-232 Serial Port Connector Location................................................................38
Figure 3-22: RS-422/485 Serial Port Connector Location.........................................................40
Figure 3-23: SATA 6Gb/s Drive Connector Locations..............................................................41
Figure 3-24: SATA 3Gb/s Drive Connector Locations..............................................................42
Figure 3-25: SATA Power Connector Locations .......................................................................43
Figure 3-26: SMBus Connector Location...................................................................................44

KINO-DQM871-i1 Mini-ITX SBC
Page xi
Figure 3-27: SO-DIMM Connector Locations.............................................................................45
Figure 3-28: SPI Flash Connector Location...............................................................................46
Figure 3-29: EC SPI Flash Connector Location.........................................................................47
Figure 3-30: TPM Connector Location........................................................................................48
Figure 3-31: USB 2.0 Connector Locations ...............................................................................49
Figure 3-32: USB 3.2 Gen 1 Connector Location ......................................................................50
Figure 3-33: External Interface Connectors...............................................................................51
Figure 3-34: Audio Jacks.............................................................................................................52
Figure 3-35: Ethernet Connector.................................................................................................52
Figure 3-36: Ethernet Connector.................................................................................................54
Figure 3-37: HDMI Connector......................................................................................................55
Figure 3-38: 4-pin Power Mini-DIN Connection.........................................................................56
Figure 3-39: Serial Port Pinouts..................................................................................................56
Figure 3-40: VGA Connector .......................................................................................................57
Figure 4-1: Install Support Bracket.............................................................................................61
Figure 4-2: Align the Cooling Kit.................................................................................................62
Figure 4-3: Secure the Cooling Kit..............................................................................................63
Figure 4-4: SO-DIMM Installation ................................................................................................64
Figure 4-5: iRIS-1010 Module Installation..................................................................................65
Figure 4-6: iRIS-1010 Module Installation..................................................................................66
Figure 4-7: PCIe Mini Card Installation.......................................................................................67
Figure 4-8: AT/ATX Mode Selection Jumper Location..............................................................69
Figure 4-9: Clear CMOS Jumper Location .................................................................................70
Figure 4-10: LVDS Voltage Selection Jumper Location ...........................................................71
Figure 4-11: LVDS Resolution Selection Jumper Location......................................................72
Figure 4-12: SATA Drive Cable Connection...............................................................................73
Figure 6-1: IEI Resource Download Center..............................................................................119

KINO-DQM871-i1 Mini-ITX SBC
Page xii
List of Tables
Table 1-1: Technical Specifications..............................................................................................9
Table 2-1: Packing List.................................................................................................................12
Table 2-2: Optional Items.............................................................................................................13
Table 3-1: Peripheral Interface Connectors...............................................................................17
Table 3-2: Rear Panel Connectors..............................................................................................17
Table 3-3: ATX Power Signal Connector Pinouts......................................................................18
Table 3-4: Battery Connector Pinouts........................................................................................20
Table 3-5: Chassis Intrusion Connector Pinouts......................................................................20
Table 3-6: Digital I/O Connector Pinouts....................................................................................21
Table 3-7: DisplayPort Connector Pinouts ................................................................................22
Table 3-8: EC Debug Port Pinouts..............................................................................................23
Table 3-9: CPU Fan Connector Pinouts......................................................................................24
Table 3-10: System Fan Connector Pinouts..............................................................................25
Table 3-11: Front Panel Connector Pinouts...............................................................................26
Table 3-12: IPMI Active LED Connector Pinouts.......................................................................28
Table 3-13: Keyboard/Mouse Connector Pinouts .....................................................................29
Table 3-14: LAN Active LED Connector Pinouts.......................................................................30
Table 3-15: LVDS Connector Pinouts.........................................................................................31
Table 3-16: Backlight Inverter Connector Pinouts....................................................................32
Table 3-17: PCIe Mini Card Slot Pinouts ....................................................................................34
Table 3-18: PCIe x16 Side A Pinouts ..........................................................................................35
Table 3-19: PCIe x16 Side B Pinouts ..........................................................................................36
Table 3-20: Power Connector Pinouts........................................................................................37
Table 3-21: COM2 Pinouts ...........................................................................................................38
Table 3-22: COM3 Pinouts ...........................................................................................................38
Table 3-23: COM4 Pinouts ...........................................................................................................39
Table 3-24: COM5 Pinouts ...........................................................................................................39
Table 3-25: RS-422/485 Serial Port Connector Pinouts............................................................40
Table 3-26: D-sub 9 RS-422/485 Pinouts....................................................................................40
Table 3-27: SATA 6Gb/s Drive Connector Pinouts....................................................................41

KINO-DQM871-i1 Mini-ITX SBC
Page xiii
Table 3-28: SATA 3Gb/s Drive Connector Pinouts....................................................................42
Table 3-29: SATA Power Connector Pinouts.............................................................................43
Table 3-30: SMBus Connector Pinouts ......................................................................................44
Table 3-31: SPI Flash Connector Pinouts..................................................................................46
Table 3-32: EC SPI Flash Connector Pinouts ............................................................................47
Table 3-33: TPM Connector Pinouts...........................................................................................48
Table 3-34: USB1 Pinouts............................................................................................................49
Table 3-35: USB2 Pinouts............................................................................................................49
Table 3-36: USB3 Pinouts............................................................................................................50
Table 3-37: USB 3.2 Gen 1 Connector Pinouts..........................................................................51
Table 3-38: LAN2 Pinouts ............................................................................................................52
Table 3-39: Connector LEDs........................................................................................................53
Table 3-40: External USB 2.0 Port Pinouts ................................................................................53
Table 3-41: LAN1 Pinouts............................................................................................................53
Table 3-42: Connector LEDs........................................................................................................54
Table 3-43: External USB 3.2 Gen 1 Port Pinouts .....................................................................54
Table 3-44: HDMI Connector Pinouts .........................................................................................55
Table 3-45: Serial Port Pinouts....................................................................................................56
Table 3-46: VGA Connector Pinouts...........................................................................................57
Table 4-1: Jumpers.......................................................................................................................68
Table 4-2: LVDS Voltage Selection Jumper Settings................................................................70
Table 4-3: LVDS Resolution Selection Jumper Settings..........................................................72
Table 5-1: BIOS Navigation Keys................................................................................................78

KINO-DQM871-i1 Mini-ITX SBC
Page xiv
BIOS Menus
BIOS Menu 1: Main.......................................................................................................................80
BIOS Menu 2: Advanced..............................................................................................................82
BIOS Menu 3: ACPI Settings .......................................................................................................82
BIOS Menu 4: RTC Wake Settings..............................................................................................83
BIOS Menu 5: Trusted Computing..............................................................................................85
BIOS Menu 6: CPU Configuration...............................................................................................86
BIOS Menu 7: SATA Configuration.............................................................................................88
BIOS Menu 8: Intel(R) Rapid Start Technology.........................................................................89
BIOS Menu 9: AMT Configuration...............................................................................................90
BIOS Menu 10: USB Configuration.............................................................................................91
BIOS Menu 11: iWDD H/W Monitor .............................................................................................92
BIOS Menu 12: Smar Fan Mode Configuration..........................................................................93
BIOS Menu 13: F81866 Super IO Configuration........................................................................94
BIOS Menu 14: Serial Port n Configuration Menu.....................................................................95
BIOS Menu 15: Serial Port Console Redirection.....................................................................101
BIOS Menu 16: iEi Feature.........................................................................................................104
BIOS Menu 17: Chipset..............................................................................................................105
BIOS Menu 18: PCH-IO Configuration......................................................................................106
BIOS Menu 19: PCI Express Configuration .............................................................................108
BIOS Menu 20: System Agent (SA) Configuration..................................................................109
BIOS Menu 21: Graphics Configuration...................................................................................110
BIOS Menu 22: NB PCIe Configuration ....................................................................................112
BIOS Menu 23: Memory Configuration.....................................................................................113
BIOS Menu 24: Boot...................................................................................................................114
BIOS Menu 25: Security.............................................................................................................116
BIOS Menu 26: Save & Exit........................................................................................................117

KINO-DQM871-i1 Mini-ITX SBC
Page 1
Chapter
1
1 Introduction

KINO-DQM871-i1 Mini-ITX SBC
Page 2
1.1 Introduction
Figure 1-1: KINO-DQM871-i1
The KINO-DQM871-i1 is a Mini-ITX SBC with a 4th generation 22nm Intel® Core™
i5-4402E processor and Intel® QM87 Express Chipset. Storage on the board is handled
by two SATA 6Gb/s ports, two SATA 3Gb/s ports and one PCIe Mini socket.
The KINO-DQM871-i1 features Intelligent Platform Management Interface (IPMI) that
helps lower the overall costs of server management by enabling users to maximize IT
resource, save time and manage multiple systems. The KINO-DQM871-i1 supports
IPMI 2.0 through the optional iRIS-1010 module.
The board has four types of graphics outputs that support triple independent display. A
VGA output connects to a VGA monitor. One LVDS connector supports 18/24-bit
dual-channel display. Two HDMI connectors support HDMI 1080p display and an internal
DisplayPort connector supports DisplayPort displays.
Other slots and connectors include RS-232 ports, RS-422/485 port, Gigabit Ethernet, USB
3.2 Gen 1 (5Gb/s) ports, USB 2.0 ports, TPM, SMBus and digital I/O.

KINO-DQM871-i1 Mini-ITX SBC
Page 3
1.2 Benefits
Some of the KINO-DQM871-i1 motherboard benefits include:
Low power consumption
Wide range of I/O interfaces
Triple independent display support
1.3 Features
Some of the KINO-DQM871-i1 motherboard features are listed below:
Mini-ITX form factor
RoHS compliant
4th generation 22mm Intel® Core™ i5-4402E processor
1066/1333/1600MHz dual-channel DDR3 SDRAM
Supports IPMI 2.0 via IEI iRIS-1010 module
Intel® AMT 9.0 support
Dual GbE
Supports VGA, HDMI, LVDS and DisplayPort interface for triple independent
display (HDMI V1.4a compliant)
12 USB ports (eight USB 2.0, four USB 3.2 Gen 1)
Five RS-232 serial ports and one RS-422/485 serial port
One full-size PCIe Mini card slot for mSATA installation
One PCIe x16 slot

KINO-DQM871-i1 Mini-ITX SBC
Page 4
1.4 Connectors
The connectors on the KINO-DQM871-i1 are shown in the figure below.
Figure 1-2: Connectors

KINO-DQM871-i1 Mini-ITX SBC
Page 5
1.5 Dimensions
The main dimensions of the KINO-DQM871-i1 are shown in the diagram below.
Figure 1-3: KINO-DQM871-i1 Dimensions (mm)

KINO-DQM871-i1 Mini-ITX SBC
Page 6
1.6 Data Flow
Figure 1-4 shows the data flow between the system chipset, the CPU and other
components installed on the motherboard.
Figure 1-4: Data Flow Diagram