IEI Technology PM-PV-N4551/D5251 User manual

PM-PV-N4551/D5251 User Manual
Page i
User Manual
MODEL:
PM-PV-N4551/D5251
PCI-104 with Intel® Atom™ Processor N455/D525,
Ethernet, USB, Audio, RS-232, RS-422/485, SATA,
LVDS, CompactFlash®, RoHS Compliant
Rev. 1.02 – August 11, 2016

PM-PV-N4551/D5251 User Manual
Page ii
Revision
Date Version Changes
August 11, 2016 1.02 -- Modified Figure 3-10: LAN Connector Location
-- Deleted N4251 model information
June 10, 2013 1.01 -- Updated Figure 3-13: PCI-104 Connector Location
-- Modified Table 3-4: CompactFlash® Slot Pinouts,
Table 3-6: Fan Connector Pinouts, Table 3-16: Serial Port
Connector Pinouts (COM2)
-- Added Section 3.2.8: LAN Connector
May 24, 2011 1.00 Initial release

PM-PV-N4551/D5251 User Manual
Page iii
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
All registered trademarks and product names mentioned herein are used for identification
purposes only and may be trademarks and/or registered trademarks of their respective
owners.

PM-PV-N4551/D5251 User Manual
Page iv
Manual Conventions
WARNING
Warnings appear where overlooked details may cause damage to the
equipment or result in personal injury. Warnings should be taken
seriously.
CAUTION
Cautionary messages should be heeded to help reduce the chance of
losing data or damaging the product.
NOTE
These messages inform the reader of essential but non-critical
information. These messages should be read carefully as any directions
or instructions contained therein can help avoid making mistakes.
HOT SURFACE
This symbol indicates a hot surface that should not be touched without
taking care.

PM-PV-N4551/D5251 User Manual
Page v
Table of Contents
1 INTRODUCTION.......................................................................................................... 1
1.1 INTRODUCTION........................................................................................................... 2
1.2APPLICATIONS ............................................................................................................ 2
1.3 BENEFITS ................................................................................................................... 2
1.4 FEATURES................................................................................................................... 3
1.5 OVERVIEW.................................................................................................................. 4
1.6 CONNECTORS ............................................................................................................. 5
1.7 DIMENSIONS............................................................................................................... 6
1.8 DATA FLOW................................................................................................................ 8
1.9 TECHNICAL SPECIFICATIONS ...................................................................................... 9
2 UNPACKING................................................................................................................11
2.1ANTI-STATIC PRECAUTIONS...................................................................................... 12
2.2 UNPACKING PRECAUTIONS....................................................................................... 12
2.3 PACKING LIST........................................................................................................... 13
2.4 OPTIONAL ITEMS...................................................................................................... 14
3 CONNECTORS ........................................................................................................... 15
3.1 PERIPHERAL INTERFACE CONNECTORS..................................................................... 16
3.1.1 Layout .............................................................................................................. 16
3.1.2 Peripheral Interface Connectors ..................................................................... 17
3.2 INTERNAL PERIPHERAL CONNECTORS...................................................................... 18
3.2.1 ATX Power Control Connector........................................................................ 18
3.2.2 Audio Kit Connector........................................................................................ 19
3.2.3 CompactFlash® Slot........................................................................................ 19
3.2.4 Digital I/O Connector...................................................................................... 21
3.2.5 Fan Connector................................................................................................. 22
3.2.6 Front Panel Connector .................................................................................... 23
3.2.7 Keyboard/Mouse Connector............................................................................ 24
3.2.8 LAN Connector ................................................................................................ 25
3.2.9 LVDS LCD Connector ..................................................................................... 26

PM-PV-N4551/D5251 User Manual
Page vi
3.2.10 LVDS Backlight Inverter Connector.............................................................. 27
3.2.11 PCI-104 Connector........................................................................................ 27
3.2.12 Power Connector........................................................................................... 29
3.2.13 SATA Drive Connectors ................................................................................. 30
3.2.14 Serial Port Connector (RS-232)..................................................................... 31
3.2.15 Serial Port Connector (RS-232/422/485) ...................................................... 32
3.2.16 USB Connector .............................................................................................. 33
3.2.17 VGA Connector.............................................................................................. 33
4 INSTALLATION ......................................................................................................... 35
4.1ANTI-STATIC PRECAUTIONS...................................................................................... 36
4.2 INSTALLATION CONSIDERATIONS.............................................................................. 37
4.2.1 Installation Notices.......................................................................................... 37
4.2.2 Installation Checklist....................................................................................... 38
4.3 UNPACKING.............................................................................................................. 39
4.4 SO-DIMM INSTALLATION ....................................................................................... 40
4.5 COMPACTFLASH®CARD INSTALLATION .................................................................. 40
4.6 JUMPER SETTINGS .................................................................................................... 41
4.6.1 AT/ATX Power Mode Jumper .......................................................................... 42
4.6.2 Clear CMOS Jumper........................................................................................ 43
4.6.3 CompactFlash® Setup..................................................................................... 44
4.6.4 LVDS Voltage Selection.................................................................................... 44
4.6.5 PCI-104 Voltage Setup..................................................................................... 45
4.6.6 COM 2 Function Select Jumper....................................................................... 46
4.7 CHASSIS INSTALLATION............................................................................................ 47
4.8 INTERNAL PERIPHERAL DEVICE CONNECTIONS........................................................ 48
4.8.1 Keyboard/Mouse Y-cable Connector ............................................................... 48
4.8.2 LVDS LCD Installation.................................................................................... 49
4.8.3 SATA Drive Connection ................................................................................... 51
4.8.4 USB Cable........................................................................................................ 53
4.9 SOFTWARE INSTALLATION ........................................................................................ 54
5 BIOS.............................................................................................................................. 56
5.1 INTRODUCTION......................................................................................................... 57
5.1.1 Starting Setup................................................................................................... 57

PM-PV-N4551/D5251 User Manual
Page vii
5.1.2 Using Setup...................................................................................................... 57
5.1.3 Getting Help..................................................................................................... 58
5.1.4 Unable to Reboot After Configuration Changes.............................................. 58
5.1.5 BIOS Menu Bar................................................................................................ 58
5.2 MAIN........................................................................................................................ 59
5.3ADVANCED............................................................................................................... 60
5.3.1 ACPI Settings................................................................................................... 60
5.3.2 CPU Configuration.......................................................................................... 61
5.3.3 SATA Configuration ......................................................................................... 63
5.3.4 USB Configuration........................................................................................... 64
5.3.5 Super IO Configuration ................................................................................... 65
5.3.5.1 Serial Port n Configuration....................................................................... 66
5.3.6 H/W Monitor.................................................................................................... 69
5.3.7 Serial Port Console Redirection ...................................................................... 72
5.4 CHIPSET ................................................................................................................... 73
5.4.1 Host Bridge Configuration .............................................................................. 74
5.4.1.1 OnChip VGA Configuration..................................................................... 75
5.4.2 South Bridge Configuration............................................................................. 76
5.4.3 Intel IGD SWSCI OpRegion............................................................................. 77
5.5 BOOT........................................................................................................................ 79
5.6 SECURITY................................................................................................................. 80
5.7 EXIT......................................................................................................................... 82
A REGULATORY COMPLIANCE.............................................................................. 84
B PRODUCT DISPOSAL.............................................................................................. 86
C BIOS OPTIONS.......................................................................................................... 88
D TERMINOLOGY ....................................................................................................... 91
E DIGITAL I/O INTERFACE....................................................................................... 95
E.1 INTRODUCTION ........................................................................................................ 96
E.2ASSEMBLY LANGUAGE SAMPLE 1............................................................................ 97
E.3ASSEMBLY LANGUAGE SAMPLE 2............................................................................ 97
F WATCHDOG TIMER................................................................................................. 98
G HAZARDOUS MATERIALS DISCLOSURE....................................................... 101

PM-PV-N4551/D5251 User Manual
Page viii
List of Figures
Figure 1–1: PM-PV-N4551/D5251...................................................................................................2
Figure 1-2: Overview ......................................................................................................................4
Figure 1-3: Solder Side Overview .................................................................................................4
Figure 1-4: Dimensions (Top)........................................................................................................6
Figure 1-5: Dimensions (I/O)..........................................................................................................6
Figure 1-6: Dimensions (Bottom)..................................................................................................7
Figure 1-7: Data Flow Block Diagram...........................................................................................8
Figure 3-1: Connector and Jumper Locations (Front Side) .....................................................16
Figure 3-2: Connector and Jumper Locations (Solder Side) ...................................................16
Figure 3-3: ATX Power Supply Enable Connector Location....................................................18
Figure 3-4: Audio Kit Connector Location.................................................................................19
Figure 3-5: CompactFlash® Slot Location.................................................................................20
Figure 3-6: Digital I/O Connector Locations ..............................................................................21
Figure 3-7: Fan Connector Location...........................................................................................22
Figure 3-8: Front Panel Connector Location .............................................................................23
Figure 3-9: Keyboard/Mouse Connector Location....................................................................24
Figure 3-10: LAN Connector Location........................................................................................25
Figure 3-11: LVDS Connector Location......................................................................................26
Figure 3-12: Backlight Inverter Connector Location.................................................................27
Figure 3-13: PCI-104 Connector Location..................................................................................28
Figure 3-14: Power Connector Location ....................................................................................29
Figure 3-15: SATA Drive Connector Location ...........................................................................30
Figure 3-16: Serial Port Connector Location (COM1)...............................................................31
Figure 3-17: Serial Port Connector Location (COM2)...............................................................32
Figure 3-18: USB Connector Pinout Locations.........................................................................33
Figure 3-19: VGA Connector Location .......................................................................................34
Figure 4-1: SO-DIMM Installation................................................................................................40
Figure 4-2: CompactFlash® Card Installation ...........................................................................41
Figure 4-3: AT/ATX Power Mode Jumper Location...................................................................43
Figure 4-4: Clear BIOS Jumper Location ...................................................................................43

PM-PV-N4551/D5251 User Manual
Page ix
Figure 4-5: CompactFlash® Setup Jumper Location ...............................................................44
Figure 4-6: LVDS Voltage Selection Jumper Locations ...........................................................45
Figure 4-7: PCI-104 Voltage Jumper Location...........................................................................46
Figure 4-8: COM 2 Function Select Jumper Location...............................................................47
Figure 4-9: Keyboard/mouse Y-cable Connection....................................................................49
Figure 4-10: LVDS Connector......................................................................................................50
Figure 4-11: Backlight Inverter Connection...............................................................................51
Figure 4-12: SATA Drive Cable Connection...............................................................................52
Figure 4-13: SATA Power Drive Connection..............................................................................52
Figure 4-14: Dual USB Cable Connection..................................................................................53
Figure 4-15: Introduction Screen................................................................................................54
Figure 4-16: Available Drivers.....................................................................................................55

PM-PV-N4551/D5251 User Manual
Page x
List of Tables
Table 1-1: Technical Specifications............................................................................................10
Table 2-1: Package List Contents...............................................................................................14
Table 2-2: Optional Packing List Items.......................................................................................14
Table 3–1: Internal Peripheral Connectors ................................................................................17
Table 3-2: ATX Power Supply Enable Connector Pinouts .......................................................18
Table 3-3: Audio Kit Connector Pinouts.....................................................................................19
Table 3-4: CompactFlash® Slot Pinouts....................................................................................21
Table 3-5: Digital I/O Connector Pinouts....................................................................................22
Table 3-6: Fan Connector Pinouts..............................................................................................22
Table 3-7: Front Panel Connector Pinouts.................................................................................23
Table 3-8: Keyboard/Mouse Connector Pinouts .......................................................................24
Table 3-9: LAN Connector Pinouts.............................................................................................25
Table 3-10: LVDS Connector Pinouts.........................................................................................26
Table 3-11: Backlight Inverter Connector Pinouts....................................................................27
Table 3-12: PCI-104 Connector Pinouts .....................................................................................29
Table 3-13: Power Connector Pinouts........................................................................................30
Table 3-14: SATA Drive Connector Pinouts...............................................................................30
Table 3-15: Serial Port Connector Pinouts (COM1)...................................................................31
Table 3-16: Serial Port Connector Pinouts (COM2)...................................................................32
Table 3-17: USB Port Connector Pinouts...................................................................................33
Table 3-18: VGA Connector Pinouts...........................................................................................34
Table 4–1: Jumper Settings.........................................................................................................42
Table 4-2: AT/ATX Power Mode Jumper Settings.....................................................................42
Table 4-3: Clear BIOS Jumper Settings......................................................................................43
Table 4-4: CompactFlash® Setup Jumper Settings..................................................................44
Table 4-5: LVDS Voltage Selection Jumper Settings................................................................45
Table 4-6: PCI-104 Voltage Jumper Settings .............................................................................46
Table 4-7: COM 2 Function Select Jumper Settings.................................................................46
Table 5-1: BIOS Navigation Keys................................................................................................58

PM-PV-N4551/D5251 User Manual
Page xi
BIOS Menus
BIOS Menu 1: Main.......................................................................................................................59
BIOS Menu 2: Advanced..............................................................................................................60
BIOS Menu 3: ACPI Settings .......................................................................................................61
BIOS Menu 4: CPU Configuration...............................................................................................62
BIOS Menu 5: IDE Configuration.................................................................................................63
BIOS Menu 6: USB Configuration...............................................................................................64
BIOS Menu 7: Super IO Configuration........................................................................................65
BIOS Menu 8: Serial Port n Configuration Menu.......................................................................66
BIOS Menu 9: Hardware Health Configuration..........................................................................69
BIOS Menu 10: Serial Port Console Redirection.......................................................................72
BIOS Menu 11: Chipset................................................................................................................73
BIOS Menu 12: Host Bridge Chipset Configuration..................................................................74
BIOS Menu 13: OnChip VGA Configuration...............................................................................75
BIOS Menu 14:South Bridge Chipset Configuration.................................................................76
BIOS Menu 15:South Bridge Chipset Configuration.................................................................78
BIOS Menu 16: Boot.....................................................................................................................79
BIOS Menu 17: Security...............................................................................................................81
BIOS Menu 18:Exit........................................................................................................................82

PM-PV-N4551/D5251 User Manual
Page 1
Chapter
1
1 Introduction

PM-PV-N4551/D5251 User Manual
Page 2
1.1 Introduction
Figure 1–1: PM-PV-N4551/D5251
The PCI-104 form factor PM-PV-N4551/D5251 is a highly integrated embedded computer
specifically optimized for multi-media applications requiring minimum installation space.
The PM-PV-N4551/D5251 is particularly suitable for low power and fan-less applications.
The PM-PV-N4551/D5251 supports a full range of functions for an AT compatible
industrial computer in a space-saving 96 mm x 100 mm profile. The PM-PV-N4551/D5251
is equipped with an on-board low-power consumption and high performance Intel®
Atom™ D525 or N455 processor. It also supports a single 204-pin 667/800 MHz DDR3
SO-DIMM (up to 2 GB).
1.2 Applications
The PM-PV-N4551/D5251 has been designed for use in industrial applications where
board expansion is critical and operational reliability is essential.
1.3 Benefits
Some of the PM-PV-N4551/D5251 benefits include,
Operating reliably in harsh industrial environments with ambient temperatures
ranging from -20ºC ~ 60ºC
Rebooting automatically if the BIOS watchdog timer detects that the system is
no longer operating

PM-PV-N4551/D5251 User Manual
Page 3
1.4 Features
Some of the PM-PV-N4551/D5251 motherboard features are listed below:
Complies with RoHS
Embedded Intel®Atom™ D525 or N455 processor
Supports a single 204-pin 667/800 MHz DDR3 SO-DIMM (up to 2 GB)
I/O support
o4 x USB 2.0
o1 x SATA 3Gb/s
o1 x RS-232
o1 x RS-232/422/485
o1 x CompactFlash® card slot
o1 x PS/2 for keyboard and mouse
Supports LVDS 18-bit single-channel up to 1366 x 768 and VGA up to 2048 x
1536 @ 60 MHz

PM-PV-N4551/D5251 User Manual
Page 4
1.5 Overview
Figure 1-2: Overview
Figure 1-3: Solder Side Overview

PM-PV-N4551/D5251 User Manual
Page 5
1.6 Connectors
The PM-PV-N4551/D5251 has the following connectors on-board (described in Chapter
3):
1 x ATX Power Control Connector
1 x Audio Kit Connector
1 x CompactFlash® Slot
1 x Digital I/O Connector
1 x Fan Connector
1 x Front Panel Connector
1 x Keyboard/Mouse Connector
1 x LAN Connector
1 x LVDS LCD Connector
1 x LVDS Backlight Inverter Connector
1 x PCI-104 Connector
1 x Power Connector
1 x SATA Drive Connectors
1 x Serial Port Connector (RS-232)
1 x Serial Port Connector (RS-232/422/485)
2 x USB Connector
1 x VGA Connector

PM-PV-N4551/D5251 User Manual
Page 6
1.7 Dimensions
Figure 1-4: Dimensions (Top)
Figure 1-5: Dimensions (I/O)

PM-PV-N4551/D5251 User Manual
Page 7
Figure 1-6: Dimensions (Bottom)

PM-PV-N4551/D5251 User Manual
Page 8
1.8 Data Flow
The data flow diagram for the PM-PV-N4551/D5251 is shown below.
Figure 1-7: Data Flow Block Diagram