IEI Technology KINO-PVN-D5251 User manual

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page i
IEI Technology Corp.
User Manual
KINO-PVN-D5251/D4251
MODEL:
Mini ITX SBC with Intel® Atom™ processor D425/D525
VGA, DVI-DL, HDMI Supported by Nvidia GT218
Dual GbE LAN, Eight USB 2.0, Two SATA 3Gb/s
RS-232, RS-232/422/485, PCIe, PCIe Mini, Audio, RoHS
Rev. 1.01 – 6 July, 2011

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page ii
Revision
Date Version Changes
6 July, 2011 1.01 Added Graphics Driver Installation Reminder to Section
4.10 Software Installation.
28 January, 2011 1.00 Initial release

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page iii
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
All registered trademarks and product names mentioned herein are used for identification
purposes only and may be trademarks and/or registered trademarks of their respective
owners.

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page iv
Table of Contents
1 INTRODUCTION.......................................................................................................... 1
1.1 INTRODUCTION........................................................................................................... 2
1.2 CONNECTORS ............................................................................................................. 4
1.3 DIMENSIONS............................................................................................................... 5
1.4 DATA FLOW................................................................................................................ 6
1.5 TECHNICAL SPECIFICATIONS ...................................................................................... 7
2 UNPACKING............................................................................................................... 10
2.1ANTI-STATIC PRECAUTIONS.......................................................................................11
2.2 UNPACKING PRECAUTIONS........................................................................................11
2.3 PACKING LIST........................................................................................................... 12
2.3.1 Optional Items.................................................................................................. 13
3 CONNECTORS ........................................................................................................... 14
3.1 PERIPHERAL INTERFACE CONNECTORS..................................................................... 15
3.1.1 KINO-PVN-D5251/D4251 Layout................................................................... 15
3.1.2 Peripheral Interface Connectors ..................................................................... 16
3.1.3 External Interface Panel Connectors............................................................... 17
3.2 INTERNAL PERIPHERAL CONNECTORS...................................................................... 17
3.2.1 12V Power Connector...................................................................................... 17
3.2.2 CompactFlash® Slot........................................................................................ 18
3.2.3 Digital I/O Connector...................................................................................... 19
3.2.4 Fan Connector (CPU)...................................................................................... 20
3.2.5 Flash SPI ROM (GT218)................................................................................. 21
3.2.6 Front Panel Connector .................................................................................... 21
3.2.7 Keyboard/Mouse Connector............................................................................ 22
3.2.8 Parallel Port Connector .................................................................................. 23
3.2.9 PCIe Mini Card Slot ........................................................................................ 24
3.2.10 SATA Drive Connectors ................................................................................. 25
3.2.11 SATA Power Connector.................................................................................. 26
3.2.12 Serial Port Connectors (RS-232)................................................................... 27

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page v
3.2.13 Serial Port Connector (RS-232)..................................................................... 28
3.2.14 SMBus Connector .......................................................................................... 29
3.2.15 SPI Flash Connector...................................................................................... 30
3.2.16 USB Connectors............................................................................................. 30
3.3 EXTERNAL PERIPHERAL INTERFACE CONNECTOR PANEL ......................................... 31
3.3.1 Audio Connector .............................................................................................. 32
3.3.2 Ethernet and USB Connector........................................................................... 32
3.3.3 Power Connector............................................................................................. 34
3.3.4 Serial Port Connector...................................................................................... 34
3.3.5 VGA+DVI Port Connector .............................................................................. 35
4 INSTALLATION ......................................................................................................... 37
4.1ANTI-STATIC PRECAUTIONS...................................................................................... 38
4.2 INSTALLATION CONSIDERATIONS.............................................................................. 39
4.2.1 Installation Notices.......................................................................................... 39
4.3 UNPACKING.............................................................................................................. 40
4.4 SO-DIMM INSTALLATION ....................................................................................... 40
4.4.1 SO-DIMM Installation..................................................................................... 41
4.5 COMPACTFLASH®INSTALLATION ............................................................................ 42
4.6 JUMPER SETTINGS .................................................................................................... 43
4.6.1 AT/ATX Power Select Jumper Settings ............................................................ 43
4.6.2 Clear CMOS Jumper........................................................................................ 44
4.6.3 CompactFlash® Card Setup Jumper............................................................... 45
4.6.4 Serial Port Setting Jumper............................................................................... 46
4.7 CHASSIS INSTALLATION............................................................................................ 47
4.7.1 Airflow.............................................................................................................. 47
4.7.2 Motherboard Installation................................................................................. 47
4.8 INTERNAL PERIPHERAL DEVICE CONNECTIONS........................................................ 47
4.8.1 AT/ATX Power Connection.............................................................................. 47
4.8.2 Single RS-232 Cable with Slot Bracket............................................................ 49
4.9 EXTERNAL PERIPHERAL INTERFACE CONNECTION ................................................... 50
4.9.1 Audio Connector .............................................................................................. 51
4.9.2 LAN Connection (Dual Connector)................................................................. 52
4.9.3 Serial Device Connection ................................................................................ 52
4.9.4 USB Connection (Quad Connector) ................................................................ 53

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page vi
4.9.5 VGA Monitor Connection ................................................................................ 54
4.9.6 DVI Display Device Connection...................................................................... 55
4.10 SOFTWARE INSTALLATION ...................................................................................... 56
5 BIOS SCREENS........................................................................................................... 60
5.1 INTRODUCTION......................................................................................................... 61
5.1.1 Starting Setup................................................................................................... 61
5.1.2 Using Setup...................................................................................................... 61
5.1.3 Getting Help..................................................................................................... 62
5.1.4 Unable to Reboot After Configuration Changes.............................................. 62
5.1.5 BIOS Menu Bar................................................................................................ 62
5.2 MAIN........................................................................................................................ 63
5.3ADVANCED............................................................................................................... 64
5.3.1 ACPI Settings................................................................................................... 65
5.3.2 CPU Configuration.......................................................................................... 66
5.3.3 SATA Configuration ......................................................................................... 67
5.3.4 USB Configuration........................................................................................... 68
5.3.5 Super IO Configuration ................................................................................... 69
5.3.5.1 Serial Port 1 Configuration....................................................................... 70
5.3.5.2 Parallel Port Configuration....................................................................... 74
5.3.6 H/W Monitor.................................................................................................... 76
5.3.7 Serial Port Console Redirection...................................................................... 78
5.4 CHIPSET ................................................................................................................... 79
5.4.1 Host Bridge Configuration .............................................................................. 80
5.4.2 South Bridge Configuration............................................................................. 81
5.5 BOOT........................................................................................................................ 83
5.6 SECURITY................................................................................................................. 85
5.7 EXIT......................................................................................................................... 86
A BIOS OPTIONS .......................................................................................................... 88
B ONE KEY RECOVERY............................................................................................. 91
B.1 ONE KEY RECOVERY INTRODUCTION ...................................................................... 92
B.1.1 System Requirement......................................................................................... 93
B.1.2 Supported Operating System........................................................................... 94
B.2 SETUP PROCEDURE FOR WINDOWS.......................................................................... 95

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page vii
B.2.1 Hardware and BIOS Setup .............................................................................. 95
B.2.2 Create Partitions ............................................................................................. 96
B.2.3 Install Operating System, Drivers and Applications....................................... 99
B.2.4 Build-up Recovery Partition.......................................................................... 100
B.2.5 Create Factory Default Image....................................................................... 102
B.3 SETUP PROCEDURE FOR LINUX.............................................................................. 107
B.4 RECOVERY TOOL FUNCTIONS .................................................................................110
B.4.1 Factory Restore ..............................................................................................112
B.4.2 Backup System................................................................................................113
B.4.3 Restore Your Last Backup...............................................................................114
B.4.4 Manual............................................................................................................115
B.5 OTHER INFORMATION.............................................................................................116
B.5.1 Using AHCI Mode or ALi M5283 / VIA VT6421A Controller........................116
B.5.2 System Memory Requirement .........................................................................118
C TERMINOLOGY ......................................................................................................119
D DIGITAL I/O INTERFACE..................................................................................... 123
D.1 INTRODUCTION...................................................................................................... 124
D.2 DIO CONNECTOR PINOUTS ................................................................................... 124
D.3ASSEMBLY LANGUAGE SAMPLES........................................................................... 125
D.3.1 Enable the DIO Input Function .................................................................... 125
D.3.2 Enable the DIO Output Function.................................................................. 125
E WATCHDOG TIMER............................................................................................... 126
F HAZARDOUS MATERIALS DISCLOSURE........................................................ 129
F.1 HAZARDOUS MATERIALS DISCLOSURE TABLE FOR IPB PRODUCTS CERTIFIED AS
ROHS COMPLIANT UNDER 2002/95/EC WITHOUT MERCURY ..................................... 130

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page viii
List of Figures
Figure 1-1: KINO-PVN-D5251/D4251 Front view..........................................................................2
Figure 1-2: KINO-PVN-D5251/D4251 Solder view........................................................................2
Figure 1-3: Connectors Front view...............................................................................................4
Figure14: Connectors Solder view ...............................................................................................4
Figure 1-5: KINO-PVN-D5251/D4251 Dimensions (mm)..............................................................5
Figure 1-6: Data Flow Block Diagram...........................................................................................6
Figure 3-1: Connector and Jumper Locations Front view........................................................15
Figure32: Connector and Jumper Locations Solder view........................................................15
Figure 3-3: 12 V Power Connector..............................................................................................18
Figure 3-4: CompactFlash® Slot Location.................................................................................18
Figure 3-5: Digital I/O Connector Locations ..............................................................................19
Figure 3-6: CPU Fan Connector Location..................................................................................20
Figure 3-7: Flash SPI ROM (GT218) Connector Location.........................................................21
Figure 3-8: Front Panel Connector Location .............................................................................22
Figure 3-9: Keyboard/Mouse Connector Location....................................................................22
Figure 3-10: Parallel Port Connector Location..........................................................................23
Figure 3-11: PCIe Mini Card Slot Location.................................................................................24
Figure 3-12: SATA Drive Connector Locations .........................................................................25
Figure 3-13: SATA Power Connector Locations .......................................................................26
Figure 3-14: SATA Power Connector Locations .......................................................................27
Figure 3-15: Serial Port (COM1) Connector Pinout Locations.................................................27
Figure 3-16: Serial Port (COM3) Connector Pinout Locations.................................................28
Figure 3-17: Serial Port (COM2) Connector Location...............................................................28
Figure 3-18: SMBus Connector Locations.................................................................................29
Figure 3-19: SPI Flash Connector...............................................................................................30
Figure 3-20: USB Connector Pinout Locations.........................................................................31
Figure 3-21: KINO-PVN-D5251/D4251 External Peripheral Interface Connector....................32
Figure 3-22: Audio Connector.....................................................................................................32
Figure 3-23: RJ-45 Ethernet Connector......................................................................................33
Figure 3-24: VGA Connector .......................................................................................................35

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page ix
Figure 4-1: SO-DIMM Installation................................................................................................41
Figure4-2: SO-DIMM Connector Location..................................................................................41
Figure 4-3: CompactFlash® Card Installation ...........................................................................42
Figure 4-4: AT/ATX Power Select Jumper Location..................................................................44
Figure 4-5: Clear CMOS Jumper .................................................................................................45
Figure 4-6: CompactFlash® Setup Jumper Location ...............................................................46
Figure 4-7: Serial Port Jumper Locations..................................................................................46
Figure 4-8: Power Cable to Motherboard Connection..............................................................48
Figure 4-9: Connect Power Cable to Power Supply..................................................................49
Figure 4-10: Single RS-232 Cable Installation ...........................................................................50
Figure 4-11: Audio Connector.....................................................................................................51
Figure 4-12: LAN Connection......................................................................................................52
Figure 4-13: Serial Device Connector.........................................................................................53
Figure 4-14: USB Connector........................................................................................................54
Figure 4-15: VGA Connector .......................................................................................................55
Figure 4-16: DVI Connector .........................................................................................................56
Figure 4-17: Introduction Screen................................................................................................57
Figure 4-18: Available Drivers.....................................................................................................58
Figure 4-19: Graphics Driver Installation Reminder .................................................................59
Figure B-1: IEI One Key Recovery Tool Menu ...........................................................................92
Figure B-2: Launching the Recovery Tool.................................................................................96
Figure B-3: Recovery Tool Setup Menu .....................................................................................97
Figure B-4: Command Mode........................................................................................................97
Figure B-5: Partition Creation Commands.................................................................................98
Figure B-6: Launching the Recovery Tool.............................................................................. 100
Figure B-7: System Configuration for Windows .................................................................... 100
Figure B-8: Build-up Recovery Partition................................................................................. 101
Figure B-9: Press any key to continue.................................................................................... 101
Figure B-10: Press F3 to Boot into Recovery Mode............................................................... 102
Figure B-11: Recovery Tool Menu ........................................................................................... 102
Figure B-12: About Symantec Ghost Window........................................................................ 103
Figure B-13: Symantec Ghost Path ......................................................................................... 103
Figure B-14: Select a Local Source Drive ............................................................................... 104
Figure B-15: Select a Source Partition from Basic Drive ...................................................... 104
Figure B-16: File Name to Copy Image to ............................................................................... 105

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page x
Figure B-17: Compress Image.................................................................................................. 105
Figure B-18: Image Creation Confirmation............................................................................. 106
Figure B-19: Image Creation Complete................................................................................... 106
Figure B-20: Image Creation Complete................................................................................... 106
Figure B-21: Press Any Key to Continue ................................................................................ 107
Figure B-22: Partitions for Linux.............................................................................................. 108
Figure B-23: System Configuration for Linux......................................................................... 109
Figure B-24: Access menu.lst in Linux (Text Mode).............................................................. 109
Figure B-25: Recovery Tool Menu ........................................................................................... 110
Figure B-26: Recovery Tool Main Menu.................................................................................. 111
Figure B-27: Restore Factory Default...................................................................................... 112
Figure B-28: Recovery Complete Window.............................................................................. 112
Figure B-29: Backup System.................................................................................................... 113
Figure B-30: System Backup Complete Window ................................................................... 113
Figure B-31: Restore Backup ................................................................................................... 114
Figure B-32: Restore System Backup Complete Window..................................................... 114
Figure B-33: Symantec Ghost Window ................................................................................... 115

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page xi
List of Tables
Table 1-1: Technical Specifications..............................................................................................9
Table 3-1: Peripheral Interface Connectors...............................................................................16
Table 3-2: Rear Panel Connectors..............................................................................................17
Table 3-3: 12 V Power Connector Pinouts .................................................................................17
Table 3-4: CompactFlash® Slot Pinouts....................................................................................19
Table 3-5: Digital I/O Connector Pinouts....................................................................................20
Table 3-6: CPU Fan Connector Pinouts......................................................................................20
Table 3-7: Flash SPI ROM (GT218) Connector Pinouts ............................................................21
Table 3-8: Front Panel Connector Pinouts.................................................................................22
Table 3-9: Keyboard/Mouse Connector Pinouts .......................................................................23
Table 3-10: Parallel Port Connector Pinouts .............................................................................24
Table 3-11: PCIe Mini Card Slot Pinouts ....................................................................................25
Table 3-12: SATA Drive Connector Pinouts...............................................................................26
Table 3-13: SATA Power Connector Pinouts.............................................................................26
Table 3-14: SATA Power Connector Pinouts.............................................................................27
Table 3-15: Serial Port Connector Pinouts ................................................................................28
Table 3-16: Serial Port (COM2) Connector Pinouts...................................................................29
Table 3-17: SMBus Connector Pinouts ......................................................................................29
Table 3-18: SPI Flash Connector Pinouts ..................................................................................30
Table 3-19: USB Port Connector Pinouts...................................................................................31
Table 3-20: LAN Pinouts ..............................................................................................................33
Table 3-21: RJ-45 Ethernet Connector LEDs.............................................................................33
Table 3-22: USB Pinouts..............................................................................................................34
Table 3-23: Power Connector Pinouts........................................................................................34
Table 3-24: Serial Port Pinouts....................................................................................................35
Table 3-25: VGA Connector Pinouts...........................................................................................36
Table 3-26: DVI Connector Pinouts.............................................................................................36
Table 4-1: Jumpers.......................................................................................................................43
Table 4-2: AT/ATX Power Select Jumper Settings....................................................................44
Table 4-3: Clear CMOS Jumper Settings....................................................................................45

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page xii
Table 4-4: CompactFlash® Setup Jumper Settings..................................................................45
Table 4-5: Serial Port Jumper Settings.......................................................................................46
Table 5-1: BIOS Navigation Keys................................................................................................62

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page xiii
BIOS Menus
BIOS Menu 1: Main.......................................................................................................................63
BIOS Menu 2: Advanced..............................................................................................................64
BIOS Menu 3: ACPI Settings .......................................................................................................65
BIOS Menu 4: CPU Configuration...............................................................................................66
BIOS Menu 5: IDE Configuration.................................................................................................67
BIOS Menu 6: USB Configuration...............................................................................................68
BIOS Menu 7: Super IO Configuration........................................................................................69
BIOS Menu 8: Serial Port n Configuration Menu.......................................................................70
BIOS Menu 9: Parallel Port Configuration Menu.......................................................................74
BIOS Menu 10: Hardware Health Configuration........................................................................76
BIOS Menu 11: Serial Port Console Redirection.......................................................................78
BIOS Menu 12: Chipset................................................................................................................79
BIOS Menu 13: Host Bridge Chipset Configuration..................................................................80
BIOS Menu 14: South Bridge Chipset Configuration................................................................81
BIOS Menu 15: Boot.....................................................................................................................83
BIOS Menu 16: Security...............................................................................................................85
BIOS Menu 17:Exit........................................................................................................................86

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page xiv

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page 1
Chapter
1
1 Introduction

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page 2
1.1 Introduction
Figure 1-1: KINO-PVN-D5251/D4251 Front view
Figure 1-2: KINO-PVN-D5251/D4251 Solder view

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page 3
The KINO-PVN-D5251/D4251 EPIC motherboard is an Intel® Atom™ processor D525 or
D425 platform. Up to two 4.0 GB 800 MHz DDR3 SDRAM SO-DIMMs are supported by
the KINO-PVN-D5251/D4251.
The integrated Intel® ICH8M Chipset supports two GbE LAN ports through two Realtek
RTL8111E Ethernet controllers (with ASF 2.0 support). The KINO-PVN-D5251/D4251
also supports two SATA 3Gb/s drives and provides 5 V SATA power.
The KINO-PVN-D5251/D4251 supports dual display via HDMI and VGA, HDMI and DVI,
VGA and DVI, or VGA and VGA (by DVI to VGA adapter). Eight USB 2.0 channels, one
PCI slot, one PCIe Mini socket, and one PCIe x1 slot provide flexible expansion options.
High Definition Audio (HDA) support ensures HDA devices can be easily implemented on
the KINO-PVN-D5251/D4251. Serial device connectivity is provided by three internal
RS-232 ports and one internal RS-232/422/485 connector.

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page 4
1.2 Connectors
The connectors on the KINO-PVN-D5251/D4251 are shown in the figure below.
Figure 1-3: Connectors Front view
Figureٛ1ٛ4: Connectors Solder view

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page 5
1.3 Dimensions
The dimensions of the board are listed below:
Length: 170 mm
Width: 170 mm
Figure 1-5: KINO-PVN-D5251/D4251 Dimensions (mm)

KINO-PVN-D5251/D4251/ Mini ITX SBC
Page 6
1.4 Data Flow
5Figure 1-6 shows the data flow between the two on-board chipsets and other components
installed on the motherboard and described in the following sections of this chapter.
Figure 1-6: Data Flow Block Diagram