JVC KD-G828 Guide

C
Sleeve
外套機殼
KD-G828
Installation/Connection Manual
安裝/連接手冊
GET0377-004A
[UF]
0506DTSMDTJEIN
EN, CS
ENGLISH
This unit is designed to operate on 12 V DC, NEGATIVE ground electrical systems. If your vehicle does
not have this system, a voltage inverter is required, which can be purchased at JVC car audio dealers.
1
© 2006 Victor Company of Japan, Limited
Parts list for installation and connection
The following parts are provided for this unit. If any item is missing, consult your JVC car audio dealer
immediately.
WARNINGS
To prevent short circuits, we recommend that you disconnect the battery’s negative terminal and make all
electrical connections before installing the unit.
•Be sure to ground this unit to the car’s chassis again after installation.
Notes:
• Replace the fuse with one of the specified rating. If the fuse blows frequently, consult your JVC car audio
dealer.
• It is recommended to connect to the speakers with maximum power of more than 50 W (both at the rear
and at the front, with an impedance of 4 Ωto 8 Ω). If the maximum power is less than 50 W, change
“Amp Gain” setting to prevent the speakers from being damaged (see page 18 of the INSTRUCTIONS).
• To prevent short-circuit, cover the terminals of the UNUSED leads with insulating tape.
• The heat sink becomes very hot after use. Be careful not to touch it when removing this unit.
PRECAUTIONS on power supply and speaker connections:
•DO NOT connect the speaker leads of the power cord to the car battery; otherwise, the unit
will be seriously damaged.
• BEFORE connecting the speaker leads of the power cord to the speakers, check the speaker wiring in
your car.
中文
本機僅可使用直流12 V 、負極接地的電源系統é如果您的車輛沒有這一電源系統，則需要一個電
壓變換器，可以在JVC汽車音響分銷商處買到。
警告
為防止短路，建議在安裝本機之前，斷開電池的負極，並把所有電路都連接好。
ë安裝完畢後務必將本機的地線重新接至車身。
注意:
ë把保險絲更換為額定負荷值的保險絲。如果保險絲經常燒壞，請向JVC汽車音響分銷商詢問。
ë後置和前置揚聲器的最大輸入功率應大於50 W，其阻抗為4Ω - 8 Ω。如果最大功率小於
50 W，請調校“Amp Gain”設定值，以防止揚聲器損壞。(參閱使用說明書的第18頁。)
ë為防止電源短路，請用絕緣帶包住未使用電線的端子。
ë本機使用後，散熱片會很熱。因此，在移出本機時，小心不要觸摸散熱片。
Heat sink
散熱片
電源和揚聲器接線注意事項:
ë切勿把揚聲器導線接頭接至電池，否則本機將會嚴重損壞。
ë在把揚聲器導線接頭接至揚聲器之前，檢查您汽車上的揚聲器線路。
用於安裝和連接的零件裹
下列零件隨本機提供。若有任何遺漏，請立刻咨詢您的JVC汽車音響經銷商。
J
Handles
板條型把手
F
Washer (ø5)
墊圈(ø5)
G
Lock nut (M5)
鎖定螺母(M5)
H
Mounting bolt (M5 ×20 mm)
緊固螺栓(M5 ×20 mm)
I
Rubber cushion
橡膠防震墊
A/ B
Hard case/Control panel
硬盒/控制面板
D
Trim plate
裝飾框
E
Power cord
電路連接用的配線束
K
Remote controller
遙控器
L
Battery
電池
Install1-4_KD-G828[UF]1.indd 1Install1-4_KD-G828[UF]1.indd 1 5/24/06 4:32:14 PM5/24/06 4:32:14 PM

When installing the unit without using the sleeve / 若不使用外套機殼安裝本機
In a Toyota car for example, first remove the car radio and install the unit in its place.
以豐田牌(TOYOTA) 汽車為例: 首先取出汽車收音機，然後將本機裝入其空出的位置。
When using the optional stay / 若選用支撐架
Note : When installing the unit on the mounting bracket, make sure to use the 8 mm-long screws. If longer screws are
used, they could damage the unit.
注意!把本機安裝在托座上時，務必使用8 mm長的螺絲釘。如使用過長的螺絲釘，會損壞本機。
*2Not supplied for this unit.
*2不隨本機提供。
Flat type screws (M5 ×8 mm)*2
平頭螺絲釘 (M5 ×8 mm)*2
Pocket
空殼
Flat type screws (M5 ×8 mm)*2
平頭螺絲釘 (M5 ×8 mm)*2
Screw (option)
螺絲釘 (選用的)
Stay (option)
支撐架 (選用的)
Fire wall
防火板
Dashboard
儀表板
Install the unit at an angle of less than 30˚.
將本機安裝在少於30˚的角度。
2
Bracket*2
托座*2
Removing the unit
Before removing the unit, release the rear section.
Insert the two handles, then pull them as
illustrated so that the unit can be removed.
按圖所示，將兩片板條型把手插入卡槽，然
後輕穩地從兩側向外拉兩片把手，本機隨之
拉出。
Do the required electrical connections.
進行所需的電路連接。
*1When you stand the unit,
be careful not to damage the
fuse on the rear.
*1您豎起本機時，小心不要
損壞底部的保險絲。
Bend the appropriate tabs to hold the
sleeve firmly in place.
弄彎機殼的突舌，把外套機殼牢固在儀
表板內。
INSTALLATION (IN-DASH MOUNTING)
The following illustration shows a typical installation. If you have any questions or require information
regarding installation kits, consult your JVC car audio dealer or a company supplying kits.
• If you are not sure how to install this unit correctly, have it installed by a qualified technician.
Bracket*2
托座*2
TROUBLESHOOTING
• The fuse blows.
*Are the red and black leads connected correctly?
• Power cannot be turned on.
*Is the yellow lead connected?
• No sound from the speakers.
*Is the speaker output lead short-circuited?
• Sound is distorted.
*Is the speaker output lead grounded?
*Are the “–” terminals of L and R speakers grounded in common?
• Noise interfere with sounds.
*Is the rear ground terminal connected to the car’s chassis using shorter and thicker cords?
• This unit become hot.
*Is the speaker output lead grounded?
*Are the “–” terminals of L and R speakers grounded in common?
• This unit does nos work at all.
*Have you reset your unit?
安裝 (裝設、固定在儀表板內)
下面的圖解表示了典型的安裝程序。如果您有問題，或需要有關配套元件的資料，請向JVC
汽車音響分銷商或配套元件供應公司詢問。
·如果您不能確定如何正確地安裝本機，應請合格的技術人員來安裝。
故障排除
•保險絲燒斷。
*檢查紅色導線接頭和黑色導線接頭是否接觸正確?
•電源不能接通。
*檢查黃色導線接頭是否接上?
•揚聲器沒有聲音。
*檢查揚聲器輸出導線接頭是否短路?
•聲音失真。
*檢查揚聲器輸出端子是否接地?
*檢查揚聲器的左(L)、右(R) 端子的負極 (–) 是否共同接地?
•噪音干擾音響。
*後接地端子與車身是否使用較短和較厚的電線連接?
•本機發熱。
*檢查揚聲器輸出端子是否接地?
*檢查揚聲器的左(L)、右(R) 端子的負極(–) 是否共同接地?
•本機完全不能操作。
*您是否已經重設您的機組?
拆卸本機
在拆卸本機前，應將本機後部的固定和連接部分鬆開。
Install1-4_KD-G828[UF]1.indd 2Install1-4_KD-G828[UF]1.indd 2 5/11/06 2:09:29 PM5/11/06 2:09:29 PM

Fuse block
保險絲單元
3
Typical connections / 典型的接線方法
Before connecting: Check the wiring in the vehicle carefully. Incorrect connection may cause serious
damage to this unit.
The leads of the power cord and those of the connector from the car body may be different in color.
1Connect the colored leads of the power cord in the order specified in the illustration below.
2Connect the antenna cord.
3Finally connect the wiring harness to the unit.
Purple
紫色
Purple with black stripe
紫色帶有黑色條紋
Green
綠色
Green with black
stripe
綠色帶有黑色條紋
Gray
灰色
Gray with black stripe
灰色帶有黑色條紋
White
白色
White with black stripe
白色帶有黑色條紋
ENGLISH
A
ELECTRICAL CONNECTIONS
To the automatic antenna if any (250 mA max.)
接至自動天線 (若有裝設) (最大250 mA)
To the remote lead of other equipment (200 mA max.)
接至其他裝置上的遙控導線 (最大200 mA )
To metallic body or chassis of the car
接至金屬體或汽車底盤
To a live terminal in the fuse block connecting to the car battery
(bypassing the ignition switch) (constant 12 V)
接至保險絲單元內的附屬端子，保險絲單元於車裝電池相連接
(用於旁路點火開關) (恆定12 V)
To an accessory terminal in the fuse block
接至保險絲單元內的附屬端子
Right speaker (rear)
右揚聲器 (後置)
Left speaker (rear)
左揚聲器 (後置)
Right speaker (front)
右揚聲器 (前置)
Left speaker (front)
左揚聲器 (前置)
*2 Before checking the operation of this unit prior to
installation, this lead must be connected, otherwise
power cannot be turned on.
*2 本機未安裝時，進行工作狀況檢查之前，
必須把這導線接上，否則不能開啟電源。
15 A fuse
15 A保險絲
Line out (see diagram )
輸出端子 (參閱圖表 )
Rear ground terminal
本機後背接地端子
Black
黑色
Blue with white stripe
藍色帶有白色條紋
Red
紅色
Yellow *2
黃色*2
Blue
藍色
To subwoofer (see diagram )
接至超重低音揚聲器 (參閱圖表 )
To CD changer or another external component (see diagram )
連接至CD 換碟器或其他外接組件 (參閱圖表 )
Brown
褐色
Orange with white stripe
橙色帶有白色條紋 To car light control switch
接至汽車車燈控制開關
To cellular phone system
接至手機系統
中文
接線前:仔細檢查汽車內的線路。不正確的接線會導致本機嚴重損壞。
電力線的引線和車身的連接器引線在顏色上可能有所不同。
1依照下圖所示之次序連接電源線的顏色導線。
2將天線的電線連接起來。
3最後，把配線束的插頭插在本機上。
電路連接
Ignition switch
點火開關
*1Not supplied for this unit.
*1不隨本機提供。
Antenna Connector
天線連接器
Install1-4_KD-G828[UF]1.indd 3Install1-4_KD-G828[UF]1.indd 3 5/11/06 2:09:38 PM5/11/06 2:09:38 PM

Connecting the external amplifiers and/or subwooferƅ連接外接放大器和ƅ或超重低音揚聲器
You can connect amplifiers to upgrade your car stereo system.
• Connect the remote lead (blue with white stripe) to the remote lead of the other equipment so that it
can be controlled through this unit.
• Disconnect the speakers from this unit, connect them to the amplifier. Leave the speaker
leads of this unit unused.
– The line output level of this unit is kept high to maintain the hi-fi sounds reproduced from this
unit.
When connecting an external amplifier to this unit, turn down the gain control on the
external amplifier to obtain the best performance from this unit.
您可以連接放大器以升級您的汽車立體聲系統。
•將遙控導線 (藍色帶有白色條紋) 和其他裝置上的遙控導線連接起來，以便可以通過本機進
行遙控。
•將揚聲器和本機斷開，再接上功率放大器。將本機的揚聲器接線放置不用。
– 本機的輸出端子水平保持高水平以保留高度傳真音響效果再次產生。
 當連接外部功率放大器至本機時，轉低外部功率放大器的安培計控制以便獲取本機所發揮的
最佳效果。
B
Rear speakers
後置揚聲器
Remote lead
遙控導線
Remote lead (Blue with white stripe)
遙控導線 (藍色帶有白色條紋)
To the remote lead of other equipment or auto antenna if any
接至其他裝置上的遙控導線或自動天線 (若有裝設)
Y-connector (not supplied for this unit)
Y-型連接導線 (不隨本機提供)
Front speakers
前置揚聲器
JVC Amplifier
JVC
功率放大器
Front speakers
前置揚聲器
Subwoofer
超重低音揚聲器
*3Firmly attach the ground wire to the metallic body
or to the chassis of the car—to the place uncoated
with paint (if coated with paint, remove the paint
before attaching the wire). Failure to do so may cause
damage to the unit.
*3將地線與金屬車體或者汽車底盤緊密連接，連接
處應該沒有被油漆覆蓋 (如果已塗上油漆，在連接
電線前，將油漆刮去)。如果不這樣做，可能會損
壞本機。
*4 Signal cord (not supplied for this unit)
*4 信號電纜 (不隨本機提供)
Connecting the external components / 連接其他外接組件
C
CD changer, Apple iPod®, or JVC D. player / CD換碟器éApple iPod® 或JVC D. player
• Set “Changer” for the external input setting (See page 18 of the INSTRUCTIONS.) / 將外接輸入設定設至“Changer” (換碟器) (參閱使用說明書的第18 頁。)
You can connect these components as illustrated below.
The iPod*5or D. player can be connected using an interface adapter (not supplied)—KS-PD100 (for iPod) or KS-PD500 (for D. player).
您可以從下圖所示連接這些組件。
您可以使用界面適配器 (不配備)—KS-PD100 (iPod用)或KS-PD500(D. player用)連接iPod*5 或D. player。
CAUTION / 小心：
Before connecting the external components , make sure that the unit is turned off.
連接外接組件之前，先確定本機已經關閉。
Other external component / 其他外接組件
• Set “Ext In” for the external input setting (See page 18 of the INSTRUCTIONS.) / 將外部輸入設定設至“Ext In” (外部輸入) (參閱使用說明書的第 18 頁。)
CD changer jack
CD換碟器插座
*5 iPod is a trademark of Apple Computer, Inc., registered in the U.S. and other countries.
*5 iPod 是Apple Computer, Inc. （蘋果電腦公司）在美國及其他國家注冊的商標。
*6Connecting cord supplied for your CD changer
*6您的CD 換碟器配備的連接電纜
External component
外接組件
External component
外接組件
CD changer jack
CD換碟器插座
*7Line Input Adapter KS-U57 (not supplied for this unit)
*7線性輸入適配器KS-U57 (不隨本機提供)
*8AUX Input Adapter KS-U58 (not supplied for this unit)
*8AUX輸入適配器KS-U58 (不隨本機提供)
3.5 mm stereo mini plug
3.5 mm 立體聲迷你插座
4
JVC Amplifier
JVC
功率放大器
JVC Amplifier
JVC
功率放大器
JVC CD changer
JVC CD換碟器
Apple iPod (separately purchased)
Apple iPod (另外購置)
JVC D. player (separately purchased)
JVC D. player (另外購置)
or
或
Install1-4_KD-G828[UF]1.indd 4Install1-4_KD-G828[UF]1.indd 4 5/11/06 2:09:45 PM5/11/06 2:09:45 PM