LDR Cetra F100W, LED 3200K User manual

01101000
01101100
01102000
01102100
CetraF100W,LED3200K,
CetraF100C,LED5600K
CetraPC100W,LED3200K
CetraPC100C,LED5600K
istruzioniperl'uso
operatinginstructions
Bedienungsanleitung
instruccionesdemanejo
moded'emploi
gebruiksaanwijzing
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredomnItaly.tel+390376771777‐fax+390376772140‐email[email protected]

CetraF&PC100LEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
1
ENGLISH–TABLEOFCONTENTS
INTRODUCTION
1.Importantsafetynorms……….………………………………………………………………………….2
2.Boxcontents……………………………………………………………………………………………………3
3.Weightanddimensions…………………………………………………………………………………..3
4.Importantnoticebeforetheinstallation/installation…………………….………………..4
5.Mechanicaloperation……………………………………………………………………………………..4
6.Wiring…………………..……………………………………………………………………………………..4
7.Voltage…………………….……………………………………………………………………………………..5
8.Frequency…………………..…………………………………………………………………………………..5
9.Connecttothepowersupply………………………………………………………………………….5
10.Localcontrolpanelandoperation…………………………………………………………………5

CONTROLANDOPERATION
11.Localcontrolpanelandoperation.........................................................5
11.1DMXormanual....................................................................................5
11.2DMXaddress........................................................................................6
11.3Dimmerresolution...............................................................................6
11.4DMXfrequencycontrol.......................................................................6
11.5LostDMXsignal...................................................................................6
11.6Strobe..................................................................................................6
11.7Strobespeed........................................................................................7
11.8Dimmingcurve.....................................................................................7
11.9Cutoffdimmingresponse...................................................................7
11.10Dimmingbehaviour.........................................................................7
11.11LEDfrequencyadjustment...............................................................8
11.12LCDretroillumination.......................................................................8
11.13SoftwareversionandLEDtemperature............................................8
11.14PRO–BASIC......................................................................................8
11.15Reset..................................................................................................8

MAINTENANCE
12Cleaningandmaintenance.....................................................................9
13Spareparts..............................................................................................9
14Warranty.................................................................................................9

SUMMARYOFCONTROLANDOPERATION
15SummaryoftheCETRAfunction..........................................................10
16DMXChart…………………………………………………………………………………………11

LDRConformityCertificate–CertificatodiConformità–Konformitätserklärung Page12
Complaintform–Modulodireclamo–Reklamationsformular………………………….Page13
WEEEDirective–DirettivaRAEE–WEEERichtlinie……………………………………………Page14





CetraF&PC100LEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
2

ENGLISH
ThankyouforchoosingaqualityproductfromLucidellaRibaltasrl.Wetrustourproductsandservicesmeetyour
requirements,butshouldthisnotbethecasepleasecontactusdirectlyusingtheattachedfeedbackformtohelpusimprove
thequalityofourservice.
Thisspotlighthasbeenmanufacturedwithgreatcareandleftourfactoryinperfectconditions,butifithasbeendamagedin
transportpleasecontactyourdealerinthefirstinstance.Afeedbackformisappended.Ourwarrantycoversallmanufacturing
andcomponentdefectsfor2yearsfromthedateyoureceivedtheproduct.
Ourproductsaredesignedfortheuseofprofessionaltechnicians,andtheinstructionsprovidedhereensureasafeandcorrect
operationofthisproduct.LucidellaRibaltasrlwillnotacceptanyresponsibilitywheredamagehasbeencausedtotheproduct
orpersonsthroughimproperuseoftheproductand/ornon‐compliancewiththeregulationsdescribedherein.

IMPORTANT:Readtheseuserinstructionsbeforeusingthislightingunit

Theinstructionsgivenhereensureasafeandcorrectusageofthisproduct.Auser’sfailuretocomplywiththeinstallation,
operating,maintenanceandsafetyproceduresmentionedinthismanual,aswellasthosegenerallyapplicabletothislighting
equipment,maycausetheluminairenottoperformasexpected.
LucidellaRibaltaacceptsnoliabilityfordirect,indirect,incidental,specialorconsequentialdamagesresultingfromthe
customer’sfailuretofollowtheinstallation,operating,maintenanceandsafetyproceduresinthismanualorthosegenerally
applicabletolightingequipments.
Thelimitationextendstodamagesforpersonalinjury,propertydamage,lossofoperations,lossofprofits,lossofproductor
lossoftime,whetherincurredinbythecustomer,thecustomer’semployeesorathirdparty.
Apartfromtheinstructionsgivenonthismanual,allrelevantsafetyandhealthstandardsoftheappropriateEUDirectivesor
thelocalsafetyandhealthstandardsofthecountrywheretheunitisinstalled,mustbecompliedwith.


1. IMPORTANTSAFETYNORMS

ThisproductisratedIP20andisthereforedesignedforinterioruseonly.Fordetailsonmaximumambient
temperatureandtiltanglepleaserefertowhatindicatedontheproductlabelorscreen‐printingonthesideofthe
lens‐tubeortherearoftheLED‐house
Warning,highvoltageignition.Disconnecttheunitfrompowerbeforeservicing
ContinuousmainspowerisrequiredforthisspotlightasaninternaldimmercontrolstheintensityviaDMXorlocal
rotaryknob.Useofaphasecontroldimmedmainssupplymaydamagetheinternalelectronics.
Useofaphasecontroldimmedmainssupplymaydamagetheinternalelectronics
Thisproductfeaturesfan‐assistedventilation.Makesureyoudonotcoverthefansorobstructtheairflowatanyone
time.
Makesurethefansareworkingcorrectly.Shouldyoudetecteventheslightestmalfunction,switchtheluminaireoff
andcarryoutthenecessaryservicing.Replacethefanifnecessary.
Repairingandreplacementofanycomponentofthisproductmustbecarriedoutexclusivelybyprofessional
personnelinconformitywiththerelevantsafetyandhealthstandardsandonlywithoriginalLucidellaRibaltasrl
components.
Replacementofanypartofthewiringsystemmustbecarriedoutexclusivelybyprofessionalpersonnelincompliance
withtheoriginalwiringdiagramandwithcomponentsidenticaltoorcompatiblewiththoseoriginallyfitted.
Installationofthisproductmustbeexclusivelycarriedoutbyprofessionalpersonnelincompliancewiththesafety
normsinforceinthecountrywheretheproductisused.

Thisproductmustbefittedwithasecondaryfixingsystemsuchasasafetychainorbond.Shouldthisnotbesupplied
asastandardaccessory,pleasemakesureyoubuyitseparatelyandinstallitbeforeusingtheproduct.



WARNING:DANGEROFELECTRICALSHOCK
DONOTOPERATEONLIVEEQUIPMENT
Disconnectpowerbeforeopeningthisfixturetoaccessitslightsourceorelectronics.

CetraF&PC100LEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
3
ThereplacementoftheLEDsourceoranyofitselectroniccomponentscanbecarriedoutexclusivelybyprofessional
personneluponLDR’swrittenauthorizationandonlywithoriginalLucidellaRibaltasrlcomponents.Failuretoobtain
themanufacturer’sauthorizationtocarryoutthereplacement/repair,willimmediatelyinvalidatetheproduct’s
warranty




WARNING:EYEDAMAGEHAZARD
Makesurethisfixtureisinstalledsoastoavoidprolongeddirectstaringatitsoperatinglightsource(LED)fromadistance
oflessthan7m/23ft.




WARNING:FIREHAZARD
Neverlocatethisfixtureonanyflammablesurface.
Minimumdistanceofanypartofthebodyoftheluminairefromanyflammablesurfaceorobject:0,5m
Minimumdistancefromlitsurface,pleaserefertoproductlabel
Makesurethemainspowersupplythefixturewillbeconnectedtoisprotectedbyasuitablethermalmagneticcircuit
breaker

2.BOXCONTENTS

Uponopeningthepackaging,pleasemakesureitcontainsthefollowing:
a. lightingunitinthechosenmodel
b. metalcolourframe150x150mm,fitted
c. 160cmmainspowercablewithfittedNeutrikPower‐Conblueconnector

Shouldoneormoreitemsmiss,wekindlyaskyoutocontactyourdealerimmediately.


3.WEIGHTANDDIMENSIONS


    

Cetraf100LEDCetrapc100LED
netweight:5,9kgnetweight:6,1kg
grossweight:7,3kggrossweight:7,1kg
packingdimensions:48x32x32hcmpackingdimensions:48x32x32hcm






CetraF&PC100LEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
4
4. IMPORTANTNOTICEBEFORETHEINSTALLATION/INSTALLATION

Beforeinstallingthisfixturecheckitsweightontheproductlabelandtheweightofeachaccessoryyouareaddingand
makesurethestructureyouareinstallingittowithstandsthetotalweight.
Themountingstirruprotatesaroundthebodyoftheluminaireandisdesignedtoallowthespotlighttobesuspended
fromaboveusingaC‐clamporsimilar,orsupportedonastandorbracketfrombelow.

CAUTION
DONOTTURNTHELUMINAIREUPSIDE‐DOWNBUTALWAYSTURNTHESTIRRUP
IFYOUNEEDTOMOUNTITONASTANDORBRACKET

Note:thespotlight’slocationmustprovidesuitableventilationfortheLEDmodule.

Ifnotsuppliedchooseasuitableclampandmakesureitiscorrectlyfixedandstronglytightenedtothestirrup
accordingtotheclamp’smanufacturer’sinstructions
Ifnotsuppliedchooseasuitablesafetycableorbond.Clampittotheeyeletprovidedontheupperrearpartofthe
luminaire(seepictureherebelow),runittwicearoundthestirrupandthestructuretheluminaireishungtosoasto
bondthemtogetherandclosetheloop.



Whentiltingtheunitmakesuretheknobblockingthestirrupisstronglytightenedandthattheluminairecanholdthe
desiredtiltangle

5.MECHANICALOPERATION
Focuscontrol:islocatedontherearendoftheproduct.Turntheknobclockwisetonarrowthebeam(SPOT).Turntheknob
anticlockwisetowidenthebeam(FLOOD).
Thebeamdistribution(peak/flat)isfixed.
Beam‐shaping:a4leafbarndoor(A20100301)canbefittedonthefrontoftheCetratocontrolandshapethebeam
Tilt:thestirrupisfittedwithapositivefrictionclampcontrolledbyalargeknob.Turntheknobanticlockwisetoreleaseit,
positiontheluminaireatthedesiredtiltangleandturntheknobclockwisetoholdthedesiredposition.Makesuretheknobis
stronglytightenedatanytimeduringoperation

6. WIRING

Beforebeingconnectedtothemainspower,thisunitmayneedtobewiredwithasuitableplugifnotalreadyinstalled.Make
suretheplugyouareusingisratedfortheproperpowerloadanditconformstotherelevantlocalelectricalstandards

MakesuretheplugyouarefittingwithstandstheLEDpowerload.
Thisfixturemustbegrounded
Toperformacorrectwiring,pleasenotethatthecoresinthismainsleadarecolour‐codedasfollows:

Ground:green+yellow–Neutral:blue‐Phase:brown

Incasethecoloursofthewiresdonotcorrespondtothecolouroftheconnectionpointsonyourplug,pleaseproceedas
follows:
ThegreenorgreenandyellowwiremustbeconnectedtotheconnectionpointmarkedwiththeletterEorwiththe
symbolorcolouredingreenoringreen‐yellow
ThebluewiremustbeconnectedtotheconnectionpointmarkedwiththeletterNorcolouredinblack

CetraF&PC100LEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[e-mail]–webwww.ldr.it
5
ThebrownwiremustbeconnectedtotheconnectionpointmarkedwiththeletterLorcolouredinred

7. VOLTAGE

Beforeoperatingthisunitpleaserefertotheproductlabelmountedatthebackoftheluminairetocheckyouareoperating
withthecorrectvoltage.
Thisunitcanbeoperatedbetween90Vand260VandtheelectronicPSUinsidethefixturewillautomaticallyswitchtothe
availablevoltage.


8. FREQUENCY

FrequencyonthisproductisautomaticallyselectedbytheelectronicPSU(50/60Hz)

9. CONNECTTOTHEPOWERSUPPLY

Connecttheunittoacontinuousmainspowersource
Makesurethepowersupplyisprotectedbyasuitablethermalmagneticcircuitbreaker
Thisfixturemustbegrounded

10. CONTROLFUNCTIONSANDOPERATION

OPERATION:LCDdisplayforDMXaddress,systemsetupandstatusdetails.
POWER:powerLEDstatusindicator,redcolor.ON=power
DMX:DMXLEDstatusindicator,greencolor.LEDOFF=DMXOFFandmanualcontrolactivated,LEDON=DMXMODE
activatedwithnoDMXsignal,FLASHINGLED=receivingDMX
MENU:rotaryswitchselectortoselectandmodifytheoperationalmodes.Turnleftorrighttonavigatethroughthemenuand
presstoselectortoconfirm
DMXIN:inputDMXsignal(pin1=0,pin2=DATA‐,pin3=DATA+).
DMXOUT:LoopthroughDMXsignaloutput
POWERIN:Mainspowerinput
POWEROUT:Mainspoweroutput

11. MENU

TherearethirteendifferentmenustocontrolthesettingsoftheCETRALED.Therotaryselectorisusedtoadjustthesettings
andtonavigatethroughthemenu.Turnleftorrighttoselectthemenuandpushtoaccessortoconfirmtheselecteddataor
functions.
11.1DMXORMANUAL(Mode)
SelecttheLEDcontrolmodebetweenDMX(factorysetting)andmanual.Tochangethecontrolmodepressoncethe
rotaryselectoruntilanarrow()appearsonthemenu.Turntheselectortotherightorthelefttoselectthedesired
modeofoperationandpresstoconfirmyourselection.




TaptherotaryselectorandtheLCDscreenwilldisplaythemodestatusandthecurrentvalue:





1 M:
Manual
1 M: DMX
XX %
1 Mode
DMX
1 Mode
MANUAL
TAPTHEROTARY
SELECTORTODISPLAY
THEVALUE
TAPTHEROTARY
SELECTORTODISPLAY
THEVALUE
00%=LEDOFF
FF%=LEDFULL
00%=LEDOFF
FF%=LEDFULL
PRESSTOACTIVATE
THEMENU,AN
ARROWSHOULD
APPEAR
1 Mode
DMX
1 Mode
DMX 
1 Mode
MANUAL 
TURNTOSELECT
MANUALORDMX
ANDPRESSTO
CONFIRM

CetraF&PC100LEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
6

11.2DMXADDRESS(Addr)
ItallowstoselecttheinitialDMXstartingaddresstoremotelycontroltheLEDfunctions.TochangetheinitialDMX
addresspresstherotaryswitchuntilanarrowappears,thenturntochangetothedesiredDMXstartingaddress.Pressto
confirmyourselection.Factorysettingis001.





11.3DIMMERRESOLUTION(8/16b)
Thedimmingresolutioncanbecontrolledat8bitsfromoneDMXchannelto16bitswith2DMXchannels.
Factorysetting8Bit.





11.4DMXFREQUENCYCONTROL(DMXCfg)
IfturnedONitallowstoremotelycontroltheLEDFrequencyorthestrobespeedthroughadedicatedDMXchannel.
FactorysettingOFF.





11.5LOSTDMXSIGNAL(DMXMem)
IncaseofsignalfailurethisfunctionallowstostoreinmemorythelastDMXvalue.FactorysettingON.
Threeoptionsareavailable:








11.6STROBE(Strobe)
Thisfunctionenablestoactivatethestrobefunction.FactorysettingDISABLE.







2 Addr
001
2 Addr
001 
1 Addr
###
TURNTOASSIGN
THEMXADDRESS
ANDPRESSTO
CONFIRM
3 8/16b
8 BITS
PRESSTHEROTARY
SELECTORTO
ACTIVATE
3 8/16b
8 BITS 
3 8/16b
16 BITS
TURNTOSELECT
MANUALORDMX
ANDPRESSTO
CONFIRM
PRESSTOACTIVATE
THEMENU,AN
ARROWSHOULD
APPEAR
4 DMXCfg
OFF
PRESSTHEROTARY
SELECTORTO
ACTIVATE
4 DMXCfg
OFF 
4 DMXCfg
ON
TURNTOSELECT
MANUALORDMX
ANDPRESSTO
CONFIRM
PRESSTOACTIVATE
THEMENU,AN
ARROWSHOULD
APPEAR
5 DMXMem
ON

LASTSCENEHOLD
1 Mode
ON 
5 DMXMem
OFF=0%

DIMTHELEDTO0%
6 Strobe
DISABLE
6 Strobe
DISABLE 
6 Strobe
ENABLE
TURNTOSELECT
MANUALORDMX
ANDPRESSTO
CONFIRM
PRESSTOACTIVATE
THEMENUAN
ARROWSHOULD
APPEAR

CetraF&PC100LEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
7
11.7STROBESPEED(SetStr)
Itallowstosetthestrobespeed.Thismenuisnotactivewhenthestrobefunctionisdisabledorwhenitisremotely
controlledthroughDMX(requiredDMXCfgfunctionenabled).FactorysettingOPEN.













11.8DIMMINGCURVE(Curves)
ThisfunctionallowstoselectaresponsecurvefortheCetraLED.Achoiceofthreecurvesisavailable:LED‐HAL
toreproducehalogenbehavior,squareandlinear.FactorysettingLED‐HAL.












11.9CUTOFFDIMMINGRESPONSE(CutOff)
ThisfunctionallowstoselectanLEDbehavioursimulatingatungsten‐halogenlampduringthedimmingcutoff.
FactorysettingOFF.









11.10DIMMINGBEHAVIOUR(Smooth)
ThisfunctionallowstosettheLEDdimmingresponse.FactorysettingSLOW.
PRESSTOACTIVATE
THEMENU,AN
ARROWSHOULD
APPEAR
7 SetStr
OPEN
WITHSTROBEENABLE
THELIGHTISSETTO
ON
7 SetStr
OPEN 
7 SetStr
SPEED #
CHOOSETHESTROBE
SPEEDVALUEFROM
1(SLOW)TO10(FAST)
7 SetStr
CLOSED
WITHSTROBEENABLE
THELIGHTISSETTO
OFF
PRESSTOACTIVATE
THEMENU,AN
ARROWSHOULD
APPEAR
8 Curves
LED_HALO
REPRODUCEHALOGEN
LAMPBEHAVIOUR
8 Curves
LED_HALO 
8 Curves
LINEAR
LINEARDIMMING
CONTROL
8 Curves
SQUARE
SQUARETOINCREASE
VOLTAGERESPONSE
ATLOWERVALUE
PRESSTOACTIVATE
THEMENU,AN
ARROWSHOULD
APPEAR
9 CutOff
SLOW

SOFTLEDDIMMINGAT
SHUTDOWN
9 CutOff
SLOW 
9 CutOff
OFF
DIRECTDIMMING
RESPONSEATSHUT
DOWN

CetraF&PC100LEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
8











11.11LEDFREQUENCYADJUSTMENT(Freq)
ThisfunctionallowstoadjusttheLEDfrequencytoavoidinterferencewithTVcameras.Thefrequencycanbeadjusted
fromaselectionof13thdifferentvaluesbetween2KHzto460Hz.WhenDMXCfgfunctionisenabled,thefrequencyis
controlledthroughthededicatedDMXchannelandthismenubecomesinactive.Factorysetting2kHz.






11.12LCDSCREENILLUMINATION(BackL)
ThisfunctionallowstoturnofftheLCDbacklightafter1’30”fromlastsetting.FactorysettingAutoOFF.






11.13SOFTWAREVERSIONANDTEMPERATURECONTROL(V1.0)
ThisfunctionallowstovisualizethesoftwareversionandtheLEDtemperaturein°C.

11.14PROorBASICCONTROL(ProBasic)
ThePRO‐BASICcontrolisaspecialfunctionwhichallowstolimittheaccesstothecontrolmenu.Toactivatethisfunction
turnOFFandONtheCetraandpresstherotaryswitchatpoweron.SelectProBasicwiththerotaryswitchandpressto
accessthemenu.Select:
PRO,toenableaccesstoallthefunctions
BASIC,tolimitaccesstofunctions11.1DMXorMANUALMODE,11.2DMXADDRESSand11.13Softwareversionand
temperaturecontrol
FactorysettingPRO.

11.15RESET
TheRESETcontrolisaspecialfunctionwhichallowstoRESETtheproducttofactorysettings.Toactivatethisfunctionturn
OFFandONtheCetraandpresstherotaryswitchatpoweron.SelectRESETwiththerotaryswitchandpresstoRESET
Cetratofactorysettings.


PRESSTOACTIVATE
THEMENU,AN
ARROWSHOULD
APPEAR
10 Smooth
SLOW

SLOWDIMMING
RESPONSE=300ms
10 Smooth
SLOW 
10 Smooth
OFF
IMMEDIATEDIMMING
RESPONSE
11 Freq
2.0 kHz
11 Freq
2.0 kHz 
11 Freq
XXX kHz
TURNTOSELECT
ONEOFTHE13TH
PRESETVALUEAND
PRESSTOCONFIRM
PRESSTOACTIVATE
THEMENU,AN
ARROWSHOULD
APPEAR
12 BackL
AutoOFF
12 BackL
AutoOFF 
PRESSTOACTIVATE
THEMENU,AN
ARROWSHOULD
APPEAR
10 Smooth
FAST
FASTDIMMING
RESPONSE=150ms
LCDBACKLIGHTOFF
AFTER1MINUTEAND
30SECONDS

CetraF&PC100LEDUser’sManual–2.0
LucidellaRibaltasrl,ViaBerna14,46042CastelGoffredo(MN)Italy
Tel.+390376771777–fax+390376772140–email[email protected]–webwww.ldr.it
9
12.CLEANINGANDMAINTENANCE

Toensuremaximumperformanceoftheproduct,aregularmaintenanceserviceshouldbecarriedout.Pleasemakesurethe
productiscoldanddisconnectedfrompowersupplywhendoingthis.

Generalmaintenance
*Cleanallreflectivepartssuchaslensesopeningtheproduct,ifnecessary.
*Checkthelensesandreplaceanyvisiblydamagedcomponent.
*Cleanairductsandfansinordertoallowproperventilationactivityontheproduct.
*Checkinternalandexternalwiringandreplaceanycablewhichshouldbedamagedbyheatormechanicalagents.

13. SPAREPARTS

Allcomponentsareavailableasspareparts.WestronglyrecommendyoualwaysuseoriginalLDRcomponentsasspareparts.
Pleaserefertoourtechnicalassistanceshouldyouneedtoorderand/orreplaceanypartoftheunit.

14. WARRANTY

Ourwarrantycoversallstructuralandmanufacturedefectsforoneyearfromthedateyoupurchasedthisproduct.Incaseof
complaintswestronglyrecommendyouusethecomplaintformattheendofthismanualorcontactthelocaldealerwho
suppliedtheproducttoyou.Inanycasepleasereporttheserialnumberoftheproduct.
























