Mercia Garden Products 01OVLPA0406DDNW-V Instruction manual

P 1
2mm Drill bit
x2 Winter = High Moisture = Expansion
Summer = Low Moisture = Contraction
All building’s should be
erected by two adults
For ease of assembly, you
MUST pilot drill all screw
holes and ensure all screw
heads are countersunk.
For assistance please contact customer care on: 01636 821215
Mercia Garden Products Limited,
Sutton On Trent,
Newark,
Nottinghamshire,
NG23 6QN
www.merciagardenproducts.co.uk
CAUTION
Every eort has been made during the
manufacturing process to eliminate the
prospect of splinters on rough surfaces of the
timber. You are strongly advised to wear gloves
when working with or handling rough sawn
timber.
**Protim Aquatan T5 (621)**
Your building has been dip treated with Aquatan.
Aquatan is a water-based concentrate which is diluted with water, the building as been treated by the correct
application of Aquatan solution and then allowed to dry.
Aquatan is a decorative nish to colour the wood, which is applied industrially to timber fence panels and
garden buildings.
Aquatan undiluted contains: boric acid, sodium hydroxide 32% solution, aqueos mixture of sodium dioctyl
sulphosuccinat and alcohols: 2, 4, 6-trichlorophenol.
Please retain product label and instructions for future reference
General Instructions
BEFORE YOU START PLEASE READ INSTRUCTIONS CAREFULLY
- Check the pack and make sure you have all the parts listed.
- When you are ready to start, make sure you have the right tools at hand (not supplied) including a Phillips
screwdriver, Stanley knife, Wood saw, Step ladder, Hammer and a Drill with 2mm bit.
- Ensure there is plenty of space and a clean dry area for assembly.
LOCATION FOR YOUR GARDEN BUILDING
A minimum of 60cm should be left around the perimeter of your garden building to allow access for
maintenance, annual treatment and to allow air ow around the building.
Where possible you should avoid placing your garden building underneath large trees to prevent the tree
causing damage to the building.
TIMBER
As with all natural materials, timber can be aected during various weather conditions. For the duration of
heavy or extended periods of rain, swelling of the wood panels may occur. Warping of the wood may also
occur during excessive dry spells due to an interior moisture loss. Unfortunately, these processes cannot be
avoided but can be helped. It is suggested that the outdoor building is sprayed with water during extended
periods of warm sunshine and sheltered as much as possible during rain or snow.
Once your garden building has been installed it will need to be treated as soon as possible and annually to
prevent the timber from deteriorating and to waterproof it. This is required to maintain the anti-rot guaran-
tee.
Dip Treated buildings - Require a preservative treatment to protect against rot and decay and a waterproof
treatment to prevent water ingress
Pressure Treated buildings - Require a waterproof treatment to prevent water ingress
Log Cabins - Are supplied untreated and require a preservative and waterproong treatment.
BUILDING A BASE
When thinking about where the building and base is going to be constructed:
Ensure that there will be access to all sides for maintenance work and annual
treatment.
Ensure the base is level and is built on rm ground, to prevent distortion. Refer to diagrams for the base
dimensions, The base should be slightly smaller than the external measurement of the building, i.e. The
cladding should overlap the base, creating a run o for water. It is also recommended that the oor be at
least 25mm above the surrounding ground level to avoid ooding.
TYPES OF BASE
- Concrete 75mm laid on top of 75mm hard-core.
- Slabs laid on 50mm of sharp sand.
Whilst all products manufactured are made to the highest standards of Safety and in the case of
childrens products independently tested to EN71 level, we cannot accept responsibility for your safety
whilst erecting or using this product.
01OVLPA0406DDNW-V1: 4x6 overlap shed with double doors and no window
REGISTER FOR YOUR
ANTI-ROT
GUARANTEE TODAY
PLEASE SCAN HERE:

P 2
01OVLPA0406DDNW-V
Please retain product label and instructions for future reference
Before assembly
please make sure you have a
suitable base ready to erect your
building
MADE IN GREAT BRITAIN
Overall Dimensions:
Width = 1888mm
Depth = 1234mm
Height = 1984mm
Base Dimensions:
Width = 1763mm
Depth = 1185mm
Building content
9
10
11
12
13
Fascia 12x60x1000mm QTY 4
S1260-1000mm
Cover Trims 12x45x1575mm QTY 4
S1245-1575mm
Door Strip 12x60x1016mm QTY 1
S1260-1016mm
Ridge Bar 28x28x1128mm QTY 1
F2828-1128mm
Door Strip 12x60x530mm QTY 1
S1260-530mm
Door Block 28x28x140mm QTY 2
F2828-140mm
Finial QTY 2
SHED DIAMOND FINIAL
Door Gable QTY 1
AI-01OVLPDG170X1961-V1
Back Gable QTY 1
AI-01OVLPPG1707X1961-V1
Plain Side QTY 2
AI-01OVLPPS1185X1567-V1
Floor QTY 1
AI-01OVLPF1753X1175-V2
Roof QTY 2
PI-03-0235
Door QTY 2
AI-01-11B437X1660-V1
7
1 2 3
4 5 6
8
Door Beading Strip 7x28x1590mm QTY 2
S728-1590mm
T Hinge Qty 4
PI-02-1043
Felt
16
19
L-Bracket Qty 2
PI-07-0012
15
Turn Button Qty 3
PI-07-0034
17
14 Eaves Frame 28x28x1210mm QTY 2
F2828-1210mm
18
Nail Bag
Felt Tacks x 100
20mm Screw x 13
30mm Screw x 63
50mm Screw x 26
40mm Screw x 36

P3
Remove transportation
blocks from the bottom of
each panel before beginning
assembly. Each Panel should
have two blocks.
Pre Assembly
Fix the T Hinges onto the
doors and door frame as
shown. Ensure that the
screws go through the
cladding and into the
framing behind.
28x30mm screws
1
6
6
16
30mm
screw
Pre drill
hole
*Please note: These instructions are for illustrative purposes and may dier from your product
regarding cladding. Nevertheless, despite any dierences the size(s) shown and process to
build your product is identical to method outlined.
Place the oor on a rm and level base, ensure the
base has suitable drainage free from areas where
standing water can collect. See the front page for
base requirments.
Step 1
4
Do not secure the building to the
oor until the roof is tted.
Fix the corners with 50mm
screws as shown in diagram.
Position the panels so there is
equal spacing between the oor
and cladding on all 4 sides
Step 2
2
3
3x50mm Screws
Pre drill
hole
50mm
screw

P 4
Step 3
9x50mm Screws
Fix the corners with 50mm
screws as shown in diagram.
1
Pre drill
hole
50mm
screw 3
Step 4
8x20mm Screws
Place the ridge bar in between the
front and back gables. Ensure the top
corners of the ridge bar sit ush with
the top points of the door gable. Fix
the ridge bar to the gable using one L
bracket for each end.
Fix with 4x20mm screws each
13
18
20mm
screw
Pre drill
hole
14
5
30mm
screw
Step 5
Fix two eaves frames to each roof
sheet using 4x30mm screws per eave.
Fix the roof sheets to the roof ensuring
they come together at the top using
40mm screws directly through the
roof sheet at the top. Make sure to
attach the roofs to the ridge bar.
40mm
screw
Pre drill
hole
8x 30mm Screws
20x 40mm Screws
Step 6
bOnce the roof is xed
attach the building to
the oor with 50 mm
screws.
14x 50mm Screws
50mm
screw
Pre drill
hole
For assistance please contact customer care on: 01636 821215
Mercia Garden Products Limited,
Sutton On Trent,
Newark,
Nottinghamshire,
NG23 6QN
www.merciagardenproducts.co.uk

P 5
HANDLE
WITH CARE
12
3
4
56x Tacks
Felt
tacks
19 19
19
19
19
Step 7
Cut the felt into two 1310mm long
sheets and lay onto roof as shown in
diagram ensuring there is overhang
around the sides. Lay the felt over
the centre of the apex as shown in
the diagram ensuring there is over-
hang around the sides.
8
8
8
8
Fit the Cover Trims to the front and back of
the building as shown in the illustration
using 30mm screws. Trim the length of the
cover trims to the required size before
tting if necessary.
12x30mm Screws
Step 8
30mm
screw
Pre drill
hole
Step 9
16x40mm Screws
Attach the faiscas to the roof
leaving a slight overhang at the
top.
Fit the fascias to the roof over
the felt and secure in place
with 40mm screws as shown.
Pre drill to avoid splitting.
Pre drill
hole
7
15
7
40mm
screw

P 6
Step 10
b
c
Use 4x30mm Screws to x
each beading strip onto the
door gable. Ensure that the
screw is parallel with the
door frame when xing the
strip to the door gable as
shown in the close up view.
Attach the turn button
to the top and bottom
door blocks with
1x30mm screw for each
one.
First line up the door blocks
at the top and bottom of the
doors. Then x with 2x30mm
screws by screwing through
the outside of the door into
the block.
8x30mm Screws
2x30mm Screws
4x30mm Screws
b ca
11
17
a
11
30mm
screw
30mm
screw
12
30mm
screw
30mm
screw
Use 5x20mm screws to x
the door strips to the right
hand door.
Note - Door Strips must be
attached to right hand door
Use 1x30mm black screw to
x the turn button onto the
left hand door.
5 x 20mm Screws
1x 30mm Screw
Step 11
10
9
17
It is ESSENTIAL that you apply wood
treatment immediately after the building
has been assembled.
AFTER TREATMENT:
score around protective
cover on glazing and
carefuly peel
covering back
20mm
screw





















































2





1












3
4














REGISTER FOR YOUR
ANTI-ROT
GUARANTEE TODAY
PLEASE SCAN HERE:



















¡




1




2























¡


