Mercia Garden Products Wessex 03WES0808-V3 Instruction manual

P 1
03WES0808-V3
8x8 Wessex Summerhouse
2mm Drill bit
x2 Winter = High Moisture = Expansion
Summer = Low Moisture = Contraction
All buildings should be
erected by two adults
For ease of assembly, you
MUSTpilot drill all screw
holes and ensure all screw
heads are countersunk.
For assistance please contact customer care on: 01636 880514
Mercia Garden Products Limited,
Sutton On Trent,
Newark,
Nottinghamshire,
NG23 6QN
www.merciagardenproducts.co.uk
CAUTION
Every eort has been made during the
manufacturing process to eliminate the
prospect of splinters on rough surfaces of the
timber. You are strongly advised to wear gloves
when working with or handling rough sawn
timber.
**Protim Aquatan T5 (621)**
Your building has been treated with Aquatan.
Aquatan is a water-based concentrate which is diluted with water, the building as been treated by the correct
application of Aquatan solution and then allowed to dry.
Aquatan is a decorative nish to colour the wood, which is applied industrially to timber fence panels and
garden buildings.
Aquatanundilutedcontains:boric acid, sodium hydroxide 32% solution, aqueos mixture of sodium dioctyl
sulphosuccinat and alcohols: 2, 4, 6-trichlorophenol.
Please retain product label and instructions for future reference
General Instructions
BEFORE YOU START PLEASE READ INSTRUCTIONS CAREFULLY
- Check the pack and make sure you have all the parts listed.
- When you are ready to start, make sure you have the right tools at hand (not supplied) including a Phillips
screwdriver, Stanley knife, Wood saw, Step ladder, Hammer and a Drill with 2mm bit.
- Ensure there is plenty of space and a clean dry area for assembly.
TIMBER
As with all natural materials, timber can be aected during various weather conditions. For the duration of heavy
or extended periods of rain, swelling of the wood panels may occur. Warping of the wood may also occur during
excessive dry spells due to an interior moisture loss. Unfortunately, these processes cannot be avoided but can be
helped. It is suggested that the outdoor building is sprayed with water during extended periods of warm
sunshine and sheltered as much as possible during rain or snow.
Once your garden building has been installed it will need to be treated as soon as possible and annually to
prevent the timber from deteriorating and to waterproof it. This is required to maintain the anti-rot guarantee.
Dip Treated buildings - Require a preservative treatment to protect against rot and decay and a waterproof treat-
ment to prevent water ingress
Pressure Treated buildings - Require a waterproof treatment to prevent water ingress
Log Cabins - Are supplied untreated and require a preservative and waterproong treatment.
BUILDING A BASE
When thinking about where the building and base is going to be constructed:
Ensure that there will be access to all sides for maintenance work and annual
treatment.
Ensure the base is level and is built on rm ground, to prevent distortion. Refer to diagrams for the base
dimensions, The base should be slightly smaller than the external measurement of the building, i.e. The cladding
should overlap the base, creating a run o for water. It is also recommended that the oor be at least 25mm
above the surrounding ground level to avoid ooding.
TYPES OF BASE
- Concrete 75mm laid on top of 75mm hard-core.
- Slabs laid on 50mm of sharp sand.
Whilst all products manufactured are made to the highest standards of Safety and in the case of childrens
products independently tested to EN71 level, we cannot accept responsibility for your safety whilst erecting or
using this product.
Refer to the instructions pages for your specic product code
For ease of assembly, you
will need a tape measure to
check dimensions of
components.
REGISTER FOR YOUR
ANTI-ROT
GUARANTEE TODAY
PLEASE SCAN HERE:

P 2
03WES0808-V3
Overall Dimensions:
Width = 2494mm
Depth = 2457mm
Height = 2293mm
Base Dimensions:
Width = 2379mm
Depth = 2395mm
Please retain product label and instructions for future reference
Before assembly
please make sure you have a
suitable base ready to erect your
building
MADE IN GREAT BRITAIN
Door Gable QTY 1
AI-03WESDG2298X2206-V3
Plain Gable QTY 1
AI-03WESG2298X2206-V3
Window Panel QTY 1
AI-03WESWP1757X1698-V3
Plain Panel QTY1
AI-03WESPP1757X1698-V3
Floor QTY 1
AI-03WESF2350X1753-V3
Window QTY 1
AI-03FW540X1132-V1
Veranda QTY1
AI-03WESV2379X628-V3
Roof QTY 2
AI-03WESR2409X1345-V3
Rail QTY 2
AI-03WESRAIL-V3
Master Door QTY 1
AI-03FGMD1720X475-V1
Slave Door QTY 1
AI-03FGD1720X475-V1
Fascia - 12x95x1365mm QTY 4
S1295-G-1365mm angled
Veranda Upright - 27x44x1699mm QTY 2
F2744-G-1719mm angled
Cover Strips - 12x40x1694mm QTY 4
S1240-1694mm
Window Cross A - 16x27x500mm QTY 6
WC1627-500mm
Window Cross B - 16x27x1094mm QTY 3
WC1627-1094mm
Press Lock QTY 1
PI-07-0018
Ring Pull QT Y2
PI-07-0032
Hinge QTY 6
PI-07-0004
Turn Button QTY 2
PI-07-0182
2
134
567
20
8
12
9 10 11
14
16
17
18
19
13
21
Gable Trims - 12x28x624mm QTY 4
S1228-624mm
15
22
Window Blocks QTY 4
PI-07-0011
23
Shed Finial QTY 2
SHED DIAMOND FINIAL
Felt
24
Building Content:

P 3
Please retain product label and instructions for future reference
50mm Screw x 32
40mm Screw x 18
Felt Tacks x 100
20mm Screw x 18
30mm Screw x 68
20mm Black Screw x 14
10mm Screw x 6
Nail Bag
30mm Black Screw x 48
Pre Assembly
Remove the transportation blocks from
the bottom and top of each panel
before beginning assembly
5
Step 1
Place the Floor (No. 5) onto a at,
level base, ensuring the base has
suitable drainage, free from areas
where standing water can collect.
2
4
Step 2
Place the Plain Gable (No. 2) and Plain
Panel (No. 4) onto the Floor. Secure the
Panels together with 3x50mm screws as
shown.
**Do not x to the Floor until the Roof is
itted.
3x50mm screws.
Pre drill
hole
50mm
screw

P 4
Please retain product label and instructions for future reference
3
Step 3
Place Window Panel (No. 3) against the
oor and the back Gable.
Fix the Window panel (No. 3) into position
with 3x50mm screws.
**Do not x to the Floor until the Roof is
itted.
3x50mm screws.
Pre drill
hole
50mm
screw
Step 4
Place Door Gable (No. 1) against the
oor and the two side panels.
Fix the Door Gable (No. 1) into position
with 3x50mm per corner.
**Do not x to the Floor until the
Roof is itted.
6x50mm screws.
Pre drill
hole
50mm
screw
1
Step 5
Place the Veranda (No. 6) at the
front of the building, ush to the
front of the Door Gable (No. 1).
**Do not x to the Floor until the
Roof is tted.
6
Step 6
Place one Roof panel (No. 7) onto
the building, making sure the Roof
rests into the gaps in the framing in
the front and back panel.
Fix by screwing through the framing
into the gables, as shown with
6x30mm screws.
**Do not x to the Floor until the
Roof is itted.
6x30mm screws.
Pre drill
hole
30mm
screw
7
For assistance please contact customer care on: 01636 880514
Mercia Garden Products Limited,
Sutton On Trent,
Newark,
Nottinghamshire,
NG23 6QN
www.merciagardenproducts.co.uk

P 5
Please retain product label and instructions for future reference
Step 7
Fix the Veranda Upright (No. 13)
to the building by screwing
through the roof into the top of
the framing using 1x50mm screw
and through the framing into the
verands using 1x50mm screws, as
shown.
**Do not x to the Floor until
the Roof is itted.
2x50mm screws.
Pre drill
hole
50mm
screw
13
Step 8
Place the Right Roof (No. 7) onto the
building, making sure the Roof rests
into the gaps in the framing on the
front and back panel.
Fix as shown with 6x30mm screws.
Fix the Veranda Upright (No. 13) to
the building as shown with 2x50mm
screws.
**Do not x to the Floor until the
Roof is itted.
6x30mm screws.
2x50mm screws.
Pre drill
hole
30mm
screw
7
13
50mm
screw
Step 9
Fix the Gable Trims (No. 15) to the
building with 2x30mm screws per Trim.
Fix the Cover Strips (No. 14) to the
corners of the building with 3x30mm
screws per trim. The Trims attached to
the front of the building will need to be
cut to t at angle.
Repeat for the rear of the building.
**Do not x to the Floor until the
Roof is itted.
28x30mm screws.
Pre drill
hole
30mm
screw
15
15
15
15
*Cut down
trims to t
14 14
Step 10
Fix the building to the Floor with
4x50mm screws per panel.
16x50mm screws.
Pre drill
hole
50mm
screw

P 6
Please retain product label and instructions for future reference
Please retain product label and instructions for future reference
Step 11
Fix the Rails (No. 8) to the building by:
- Screwing 3x40mm screws down
through the rails into the veranda
- Screwing 4x40mm screws through
the rails into the building and into the
veranda upright.
Secure the veranda (No. 6) by screwing
4x40mm screws at an angle through
the veranda into the door gable
18x40mm screws.
Pre drill
hole
40mm
screw
8
8
6
HANDLE
WITH CARE
12
3
4
1. 2.
Step 12
Cut the Felt (No. 24) into 3 sheets
measuring:
2510mm (L) x 1000mm (W)
and lay onto the roof in the order
shown in the diagram. Making sure
there is 50mm of overhang on each
side.
Fix to the buildings using evenly
spaced felt tacks.
100 x Felt tacks.
Felt
tacks
24
3.

P 7
Please retain product label and instructions for future reference
Step 13
To x the Window (No. 11) into the
Window Panel (No. 3), rst x the
Window Blocks (No. 22) to the sides, top
and bottom (internally) of the Window
as shown with 1x30mm screw per block.
4 Window blocks should be used per
window
Place the Window into the window hole
in the Window Panel (No. 3) and x by
screwing though the Window Block
(No.22) into the framing using 2x30mm
screws per block, as shown.
*Screw into the Window rst.
**Door Gable windows come secured
within the panel.
12x30mm screws.
Pre drill
hole
30mm
screw
22
11
3
Step 14
Fix 3 Hinges (No. 20) to each Door
(No. 9 & No. 10) securing with
4x30mm black screws per hinge.
Position as shown.
Fix each Door to the building with
4x30mm black screws per hinge.
Ensure the doors open and close
freely.
48x30mm Black screws.
Pre drill
hole
30mm
screw 20
9
10
Step 15
Fix the Fasicas (No. 12) to the
building with 3x30mm screws per
Fascia.
12x30mm screws.
Pre drill
hole
30mm
screw
12
12
12
12

P8
Please retain product label and instructions for future reference
Step 16
Fix the Finials (No. 23) to the
building with 2x30mm screws
per Finial.
4x30mm screws.
Pre drill
hole
30mm
screw
23
23
Step 17
Fix a Ring Pull (No. 19) to the front of
each door using 4x20mm black
screws per ring pull.
8x20mm black screws.
Pre drill
hole
20mm
screw
19 19
18
Step 18
Fix the Press lock (No. 18) to the
back (internally) of the Master
door (No. 9) with 4x20mm black
screws. Making sure to align the
key holes.
4x20mm Black screws.
Pre drill
hole
20mm
screw
9
Step 19
Fix the Turn Buttons (No. 21)
above each door (externally)
using 1x20mm black screw per
Turn Button.
2x20mm Black screws.
Pre drill
hole
20mm
screw
21

P9
Please retain product label and instructions for future reference
Step 20
Locate the Window Crosses (No.16 & No.17)
into the windows.
Fix by screwing through the Cross into the
Window framing using 6x20mm screws, as
shown in the diagram.
Further secure the crosses by screwing
1x10mm screw at each meeting point, as
shown in the diagram.
18x20mm screws.
6x10mm screws.
Pre drill
hole
10mm
screw
20mm
screw
16
16 16
16
16
16
17
17
17
16
16
17
AFTER TREATMENT:
score around protective
cover on glazing and
carefuly peel
covering back
It is ESSENTIAL that you apply wood
treatment immediately after the building
has been assembled.





















































2





1












3
4












