Motomaster Eliminator User manual

TABLE OF CONTENTS
2
*/530%6$5*0/ ............................................... 3
4"'&5:*/'03."5*0/
Important Safety Instructions ............................. 3
Personal Safety Instructions ...............................
 "$&MFDUSJDBM$POOFDUJPOT .................................
 1SFQBSJOHUP$IBSHF........................................ 6
$0//&$5*/(:063#"55&3:
 #BUUFSZ*O7FIJDMF/FHBUJWF(SPVOEFE ..................
 #BUUFSZ*O7FIJDMF1PTJUJWF(SPVOEFE.................... 8
 #BUUFSZ3FNPWFEGSPN7FIJDMF ............................ 9
$)"3(*/(:063#"55&3:.................................... 10
6/%&345"/%*/($0/530-4'&"563&4 ................ 11
 /PSNBM0QFSBUJPO.......................................... 11
 0UIFS-&%T.................................................. 12
 $IBOHJOH%JTQMBZ.PEFT .................................. 13
 $IBOHJOH$IBSHF3BUFT....................................
 6OEFSTUBOEJOH$IBSHJOH5JNFT ...........................
 0UIFS'FBUVSFT.............................................. 16
+6.145"35*/(:0637&)*$-& .............................. 16
5306#-&4)005*/('"6-5$0%&4 .......................... 18
."*/5&/"/$&"/%$"3& ................................... 20
-*.*5&%8"33"/5:........................................... 20
SAVE THESE INSTRUCTIONS.
5IJTNBOVBMDPOUBJOTJNQPSUBOUTBGFUZBOEPQFSBUJOHJOTUSVDUJPOT
3FBEBMMJOTUSVDUJPOTBOEGPMMPXUIFNXIFOVTJOHUIJTQSPEVDU
2VFTUJPOT $BMM$VTUPNFS4FSWJDF
TABLE OF CONTENTS

SAFETY INFORMATION
3
5IF.PUP.BTUFS¥*OUFMMJHFOU#BUUFSZ$IBSHFSTGFBUVSFBEWBODFE
NJDSPQSPDFTTPSUFDIOPMPHZNBLJOHCBUUFSZDIBSHJOHGBTUFSFBTJFSBOE
TBGFSUIBOFWFSCFGPSF5IJTNBOVBMXJMMFYQMBJOIPXUPVTFUIF
DIBSHFSTTBGFMZBOEFòFDUJWFMZ
Please read and follow these instructions and precautions carefully.
Important Safety Instructions
t 3FBEBMMJOTUSVDUJPOTXBSOJOHTBOEDBVUJPOTQSJOUFEPOUIFCBUUFSZ
 DIBSHFSCBUUFSZBOEWFIJDMFPSFRVJQNFOUVTJOHCBUUFSZ
t 6TFUIFDIBSHFSGPSDIBSHJOHMFBEBDJECBUUFSJFTPOMZTVDIBTUIPTFVTFE
 JODBSTUSVDLTNPUPSDZDMFTCPBUTFUD
t #BUUFSZDIBSHFSTBSFOPUJOUFOEFEUPTVQQMZQPXFSUPBMPXWPMUBHF
 FMFDUSJDBMTZTUFNPSUPDIBSHFESZDFMMCBUUFSJFTDPNNPOMZVTFEJO
 IPVTFIPMEBQQMJBODFTTVDIBTSBEJPTUPZTDBNFSBFUD$IBSHJOHESZDFMM
 CBUUFSJFTNBZDBVTFUIFNUPCVSTUBOEDBVTFJOKVSZUPQFSTPOTBOE
damage to property.
t 6TFPGBOBUUBDINFOUOPUSFDPNNFOEFECZUIFCBUUFSZDIBSHFS
 NBOVGBDUVSFSNBZSFTVMUJOUIFSJTLPGöSFPSFMFDUSJDBMTIPDL
WARNING
INTRODUCTION
SAFETY INFORMATION
RISK OF EXPLOSIVE GASES
WORKING IN THE VICINITY OF A LEAD-ACID BATTERY IS
DANGEROUS. BATTERIES GENERATE EXPLOSIVE GASES
DURING NORMAL BATTERY OPERATION. FOR THIS
REASON IT IS OF THE UTMOST IMPORTANCE THAT EACH TIME
BEFORE USING YOUR CHARGER, YOU READ AND FOLLOW THE
INSTRUCTIONS PROVIDED EXACTLY. TO REDUCE RISK OF BATTERY
EXPLOSION, FOLLOW THESE INSTRUCTIONS AND THOSE PUBLISHED
BY THE BATTERY MANUFACTURER.
Handling the cord on this product or objects associated with the use
of this product may expose you to lead. Wash hands after handling.
WARNING

SAFETY INFORMATION
4
t DO NOTEJTBTTFNCMFDIBSHFS5BLFJUUPBRVBMJöFETFSWJDFQSPGFTTJPOBM
 JGTFSWJDFPSSFQBJSJTSFRVJSFE*ODPSSFDUBTTFNCMZNBZSFTVMUJOöSFPS
 FMFDUSJDBMTIPDL
t 5PSFEVDFSJTLPGFMFDUSJDBMTIPDLVOQMVHUIFDIBSHFSGSPNUIFPVUMFU
before attempting any maintenance or cleaning.
t DO NOTFYQPTFDIBSHFSUPSBJOPSTOPX
t NEVERDIBSHFBGSP[FOCBUUFSZ*GCBUUFSZBDJECFDPNFTGSP[FOCSJOH
 CBUUFSZUPBXBSNBSFBBOEBMMPXJUUPUIBXCFGPSFZPVCFHJODIBSHJOH
t NEVERUPVDIUIFCBUUFSZDMBNQTUPHFUIFSXIFOUIFDIBSHFSJTPO
 5IJTNBZDBVTFBTQBSL
t NEVERPQFSBUFBDIBSHFSJGJUIBTSFDFJWFEBIBSECMPXCFFOESPQQFEPS
 PUIFSXJTFEBNBHFE5BLFJUUPBRVBMJöFEQSPGFTTJPOBMGPSJOTQFDUJPO
t NEVERQVMMPVUUIFQMVHCZUIFDPSEXIFOVOQMVHHJOHUIFDIBSHFSBT
 UIJTNBZDBVTFEBNBHFUPUIFDPSEPSQMVH
Personal Safety Instructions
t .BLFTVSFUIBUTPNFPOFJTXJUIJOSBOHFPGZPVSWPJDFUPDPNFUPZPVSBJE
 JGOFFEFEXIJMFZPVXPSLXJUIPSBSFOFBSBMFBEBDJECBUUFSZ
t 8FBSDPNQMFUFFZFBOEDMPUIJOHQSPUFDUJPOXIFOXPSLJOHXJUIMFBEBDJE
batteries.
t "WPJEUPVDIJOHZPVSFZFTXIJMFXPSLJOHXJUIBCBUUFSZ)BWFQMFOUZPG
 GSFTIXBUFSBOETPBQOFBSCZGPSVTFJODBTFCBUUFSZBDJEDPOUBDUTZPVS
 FZFTTLJOPSDMPUIJOH*GUIJTIBQQFOTXBTIJNNFEJBUFMZXJUITPBQBOE
 XBUFSUIFOHFUNFEJDBMBUUFOUJPO
t NEVERTNPLFPSBMMPXBOPQFOTQBSLPSøBNFJOUIFWJDJOJUZPGUIF
 CBUUFSZPSFOHJOF#BUUFSJFTHFOFSBUFFYQMPTJWFHBTFT
t 5BLFDBSFOPUUPESPQBOZNFUBMUPPMPSPCKFDUPOUPUIFCBUUFSZ5IJTNBZ
 SFTVMUJOBTQBSLPSTIPSUDJSDVJUBDSPTTUIFCBUUFSZPSBOPUIFSFMFDUSJDBM
 EFWJDFUIBUNBZDBVTFBOFYQMPTJPO
t 3FNPWFBMMQFSTPOBMNFUBMJUFNTTVDIBTSJOHTCSBDFMFUTOFDLMBDFTBOE
 XBUDIFTGSPNZPVSCPEZXIJMFXPSLJOHXJUIBMFBEBDJECBUUFSZ"CBUUFSZ
 DBOQSPEVDFBTIPSUDJSDVJUDVSSFOUIJHIFOPVHIUPXFMETVDIPCKFDUTUP
 NFUBMDBVTJOHBTFWFSFCVSO
t NEVERBUUFNQUUPDIBSHFBGSP[FOCBUUFSZ(see bullet point under
Important Safety Instructions).
t NEVERPWFSDIBSHFBCBUUFSZ
t ALWAYSPQFSBUFUIFCBUUFSZDIBSHFSJOBOPQFOXFMMWFOUJMBUFEBSFB
SAFETY INFORMATION DPOUE

SAFETY INFORMATION
5
AC Electrical Connections
PLUGGING CHARGER IN
:PVSDIBSHFSSFRVJSFTBQJOHSPVOEFE7"$FMFDUSJDBMXBMMPVUMFU
receptacle installed according to local codes and ordinances.
NEVER alter AC cord or plug provided. If it does not t
the outlet, have a proper outlet installed by a qualied
electrician. Improper connection can result in a risk of
re or electric shock.
DO NOT operate the charger if it has a damaged power cord or plug.
Have the cord replaced.
USING AN EXTENSION CORD
5IFVTFPGBOFYUFOTJPODPSEJTNOTSFDPNNFOEFE*GBOFYUFOTJPODPSE
NVTUCFVTFEGPMMPXUIFTFHVJEFMJOFT
t .BLFTVSFUIBUUIFQJOTPOUIFDIBSHFSTQPXFSDPSEöUöSNMZJOUPUIF
 FYUFOTJPODPSEBOEUIBUUIFFYUFOTJPODPSEöUTöSNMZJOUPUIFSFDFQUBDMF
t $IFDLUIBUUIFFYUFOTJPODPSEJTQSPQFSMZXJSFEBOEJOHPPEFMFDUSJDBM
condition.
t .BLFTVSFUIBUUIFXJSFTJ[FJTMBSHFFOPVHIGPSJUTMFOHUIBOEGPSUIF"$
 BNQFSFSBUJOHPGUIFDIBSHFSBTTQFDJöFEJOUIFDIBSUCFMPX
MINIMUM RECOMMENDED EXTENSION CORD
"8("NFSJDBO8JSF(BVHF
Use of an improper extension cord could result in a risk of re
and electric shock.
LENGTH OF CORD, METRES FEET AWG* SIZE OF CORD
 18
 16
 12
 10
SAFETY INFORMATION DPOUE
WARNING
WARNING
WARNING

SAFETY INFORMATION
6
Preparing to Charge
CHARGER LOCATION
t DO NOTFYQPTFDIBSHFSUPSBJOPSTOPX
t -PDBUFUIFDIBSHFSBTGBSBXBZGSPNUIFCBUUFSZCFJOHDIBSHFEBTUIF
 DBCMFTXJMMQFSNJU
t #FTVSFUPQPTJUJPOUIFQPXFSDPSEUPQSFWFOUJUGSPNCFJOHTUFQQFEPO
 USJQQFEPWFSPSEBNBHFE
t NEVERQMBDFDIBSHFSEJSFDUMZBCPWFCBUUFSZCFJOHDIBSHFE(BTFTGSPN
 UIFCBUUFSZXJMMDPSSPEFBOEEBNBHFUIFDIBSHFS
t NEVERTFUBCBUUFSZPOUPQPGBDIBSHFS
t NEVERBMMPXCBUUFSZBDJEUPESJQPODIBSHFS
t ALWAYSDIBSHFBCBUUFSZJOBXFMMWFOUJMBUFEBSFB
Battery chargers may get hot during operation. DO NOT set charger
on ammable materials like carpeting, upholstery, paper, cardboard,
etc. Charger may damage leather and plastic.
BATTERY PREPARATION
t 8IFOSFNPWJOHCBUUFSZGSPNWFIJDMFUPDIBSHFJUBMXBZTSFNPWF
 HSPVOEFEUFSNJOBMGSPNCBUUFSZöSTU
t .BLFTVSFBMMBDDFTTPSJFTJOUIFWFIJDMFBSFOFFJOPSEFSUPQSFWFOUTQBSLT
t #FTVSFUIBUUIFBSFBBSPVOEUIFCBUUFSZJTXFMMWFOUJMBUFEXIJMFCFJOH
 DIBSHFE
t $MFBOUIFCBUUFSZUFSNJOBMT#FDBSFGVMUPLFFQDPSSPTJPOPSCBUUFSZBDJE
from getting in or around your eyes.
t 'PSCBUUFSJFTXJUISFNPWBCMFWFOUDBQTJGSFRVJSFEBEEEJTUJMMFEXBUFSUP
 FBDIDFMMVOUJMUIFCBUUFSZøVJESFBDIFTUIFMFWFMTQFDJöFECZUIFCBUUFSZ
manufacturer.
t DO NOTPWFSöMM
t 'PSCBUUFSJFTXJUIPVUSFNPWBCMFWFOUDBQTDBSFGVMMZGPMMPXUIF
 NBOVGBDUVSFSTDIBSHJOHJOTUSVDUJPOT
t 4UVEZBMMPGUIFCBUUFSZNBOVGBDUVSFSTTQFDJöDQSFDBVUJPOTBOE
 SFDPNNFOEBUJPOTGPSDIBSHJOHBOEGPSSFDPNNFOEFESBUFTPGDIBSHF
t .BLFTVSFUIBUZPVIBWFB7MFBEBDJECBUUFSZ%FUFSNJOFWPMUBHFPG
 CBUUFSZCZSFGFSSJOHUPUIFWFIJDMFPXOFSTNBOVBM*GUIFDIBSHFSIBTBO
 BEKVTUBCMFDIBSHFSBUFDIBSHFCBUUFSZBUUIFMPXFTUSBUFöSTU
SAFETY INFORMATION DPOU
WARNING

CONNECTING YOUR BATTERY
7
1. Before connecting and
EJTDPOOFDUJOHUIF%$PVUQVU
DMBNQTSFNPWFUIF"$QMVH
GSPNUIFFMFDUSJDBMPVUMFU
NEVER BMMPXUIF%$
output clamps to
UPVDIFBDIPUIFS5IJT
NBZDBVTFBTQBSL
To reduce the risk of a spark near
battery:
t 1PTJUJPO"$BOE%$DPSETUP
SFEVDFUIFSJTLPGEBNBHFCZ
IPPEEPPSPSNPWJOHFOHJOF
part.
t 4UBZDMFBSPGGBOCMBEFTQVMMFZT
BOEPUIFSQBSUTUIBUDBODBVTF
JOKVSZ
t $IFDLQPMBSJUZPGCBUUFSZQPTUT
"QPTJUJWF1041CBUUFSZ
QPTUVTVBMMZIBTBMBSHFSEJBN-
FUFSUIBOBOFHBUJWF/&(/
battery post.
2 $POOFDUUIFQPTJUJWFSFEDMJQ
GSPNBCBUUFSZDIBSHFSUPB
QPTJUJWF1041VOHSPVOEFE
post of battery.
3 $POOFDUUIFOFHBUJWFCMBDL
DMJQUPWFIJDMFDIBTTJTNVTUCF
BIFBWZHBVHFNFUBMQBSUPGUIF
GSBNFPSFOHJOFCMPDLBXBZ
from battery. DO NOT connect
clip to carburetor, fuel lines, or
TIFFUNFUBMCPEZQBSUT
4 $POOFDUDIBSHFS"$TVQQMZ
DPSEUPFMFDUSJDPVUMFU3FWFSTF
QSPDFTTUPSFNPWFDIBSHFS
++–
+
+–
0.0.0.
4
2
3
1
WARNING
A SPARK NEAR A BATTERY MAY CAUSE A BATTERY EXPLOSION.
NOTE: A marine battery installed in a boat must be removed and charged on shore.
To charge it on board requires equipment specially designed for marine use.
CONNECTING YOUR BATTERY
Battery In Vehicle (Negative Grounded)

CONNECTING YOUR BATTERY
8
++–
+
+–
0.0.0.
2
3
4
1
1Before connecting and
EJTDPOOFDUJOHUIF%$PVUQVU
DMBNQTSFNPWFUIF"$QMVH
GSPNUIFFMFDUSJDBMPVUMFU
NEVER BMMPXUIF%$
output clamps to
UPVDIFBDIPUIFS5IJT
NBZDBVTFBTQBSL
To reduce the risk of a spark near
battery:
t 1PTJUJPO"$BOE%$DPSETUP
SFEVDFUIFSJTLPGEBNBHFCZ
IPPEEPPSPSNPWJOHFOHJOF
part.
t 4UBZDMFBSPGGBOCMBEFTQVMMFZT
BOEPUIFSQBSUTUIBUDBODBVTF
JOKVSZ
t $IFDLQPMBSJUZPGCBUUFSZQPTUT
"QPTJUJWF1041CBUUFSZ
QPTUVTVBMMZIBTBMBSHFS
EJBNFUFSUIBOBOFHBUJWF
/&(/CBUUFSZQPTU
2 $POOFDUUIFOFHBUJWFCMBDL
DMJQGSPNCBUUFSZDIBSHFSUP
OFHBUJWF/&(/VOHSPVOEFE
post of battery.
3 $POOFDUUIFQPTJUJWFSFEDMJQUP
WFIJDMFDIBTTJTNVTUCFBIFBWZ
HBVHFNFUBMQBSUPGUIFGSBNF
PSFOHJOFCMPDLBXBZGSPN
battery. DO NOT connect clip to
DBSCVSFUPSGVFMMJOFTPSTIFFU
metal body parts.
4 $POOFDUDIBSHFS"$TVQQMZ
DPSEUPFMFDUSJDPVUMFU3FWFSTF
QSPDFTTUPSFNPWFDIBSHFS
CONNECTING YOUR BATTERY DPOUE
Battery In Vehicle (Positive Grounded)
WARNING
A SPARK NEAR A BATTERY MAY CAUSE A BATTERY EXPLOSION.
NOTE: A marine battery installed in a boat must be removed and charged on shore.
To charge it on board requires equipment specially designed for marine use.

CONNECTING YOUR BATTERY
9
1. Before connecting and
EJTDPOOFDUJOHUIF%$PVUQVU
DMBNQTSFNPWFUIF"$QMVH
GSPNUIFFMFDUSJDBMPVUMFU
NEVER BMMPXUIF%$
output clamps to
UPVDIFBDIPUIFS5IJT
NBZDBVTFBTQBSL
t $IFDLQPMBSJUZPGCBUUFSZQPTUT
"QPTJUJWF1041CBUUFSZ
QPTUVTVBMMZIBTBMBSHFS
EJBNFUFSUIBOBOFHBUJWF
/&(/CBUUFSZQPTU
2 "UUBDIBUMFBTUBDNHBVHF
"8(JOTVMBUFECBUUFSZDBCMF
UPBOFHBUJWF/&(/CBUUFSZ
post.
3 $POOFDUUIFQPTJUJWFSFE
 DIBSHFSDMJQUPUIFQPTJUJWF
 1041QPTUPGCBUUFSZ
4 1PTJUJPOZPVSTFMGBOEUIFGSFF
FOEPGDBCMFBTGBSBXBZGSPN
CBUUFSZBTQPTTJCMFUIFO
DPOOFDUUIFOFHBUJWFCMBDL
DIBSHFSDMJQUPUIFGSFFFOEPG
cable. DO NOT face battery
when making nal connection.
5 $POOFDUDIBSHFS"$TVQQMZ
DPSEUPFMFDUSJDPVUMFU3FWFSTF
QSPDFTTUPSFNPWFDIBSHFS
8IFOEJTDPOOFDUJOHDIBSHFST
ALWAYSEPTPJOSFWFSTFTFRVFODF
PGDPOOFDUJOHQSPDFEVSFBOECSFBL
öSTUDPOOFDUJPOXIJMFTUBOEJOHBT
GBSBXBZGSPNCBUUFSZBTQSBDUJDBM
++ +
–
0.0.0.
23
5
1
4
Battery Removed from Vehicle
CONNECTING YOUR BATTERY DPOUE
WARNING
A SPARK NEAR A BATTERY MAY CAUSE A BATTERY EXPLOSION.

CHARGING YOUR BATTERY
10
++ +
–
0.0.0.
CHARGING YOUR BATTERY
6TJOHUIJTCBUUFSZDIBSHFSJTFYUSFNFMZTJNQMF5IFCVJMUJONJDSPQSPDFTTPS
XBTEFTJHOFEUPTFBNMFTTMZXPSLXJUIBMMUZQFTPG7MFBEBDJECBUUFSJFT
TPZPVEPOUOFFEUPTFMFDUXIFUIFSZPVSCBUUFSZJTDPOWFOUJPOBMMPX
NBJOUFOBODFNBJOUFOBODFGSFFEFFQDZDMF(FM$FMMPS"(.
IMPORTANT NOTE: If your charger detects ANY problems with the
battery you are attempting to charge, it WILL show a fault code in the
Digital Display and WILL NOT begin charging automatically.
 4PNFUJNFTUIFDIBSHFSEFUFDUTBQSPCMFNXJUIPMEEFGFDUJWFCBUUFSJFT
BOEXJMMøBTIUIF888'BVMU$PEFJOUIF%JHJUBM%JTQMBZ
Refer to the Troubleshooting/Fault Codes chart (pages 18-19) for
causes and solutions for ALL fault codes (888, F01-F06).
8.8.8.

0.0.0.
0.1.0.
Digital Display
11
UNDERSTANDING CONTROLS & FEATURES
UNDERSTANDING CONTROLS & FEATURES
Normal Operation
If the battery you are charging is in good condition and is properly
connected to the charger you will see the following on your charger’s
display panel:
DIGITAL DISPLAY
5IFDIBSHFSXJMMCFDPOUJOVPVTMZNPOJUPSJOHUIFDPOEJUJPOPGUIF
DPOOFDUFECBUUFSZBOENBZEJTQMBZDIBSHJOHGBJMVSFTBTGBVMUDPEFTPO
UIFEJHJUBMEJTQMBZ4FF“Troubleshooting/Fault Codes” DIBSUQBHFBOE
GPSQPTTJCMFDBVTFTBOETPMVUJPOT
CHARGE STATUS LED
"CMJOLJOHHSFFO-&%JOEJDBUFTUIBUUIFCBUUFSZJTCFJOHDIBSHFE"TPMJE
HSFFO-&%JOEJDBUFTUIBUUIFCBUUFSZJTGVMMZDIBSHFEPSUIBUUIFDIBSHFSJTJO
MaintenanceNPEF5IFEJHJUBMEJTQMBZXJMMBMTPTIPXBFUL message, and
UIFDIBSHFSXJMMTXJUDIUP.BJOUFOBODFNPEF
4-25 A OPTIMAL CHARGE
5IFDIBSHFSBMXBZTCFHJOTJOUIFOptimal ChargeNPEFXJUIUIF
DPSSFTQPOEJOH-&%POJOEJDBUJOHUIFDIBSHFSJTDIBSHJOHUIFCBUUFSZ
JOUIJTNPEF
CURRENT LED
5IFDIBSHFSBMXBZTCFHJOTJOUIF$VSSFOUNPEFXJUIUIFDPSSFTQPOEJOH-&%
POBOEUIF%JHJUBM%JTQMBZTIPXJOHUIFDIBSHJOHDVSSFOU

UNDERSTANDING CONTROLS & FEATURES
12
Other LEDs
%VSJOHUIFJOJUJBMPQFSBUJPOT/PSNBM0QFSBUJPOZPVSDIBSHFSMAY detect
ZPVSCBUUFSZOFFETiSFDPOEJUJPOJOHwPSUIBUZPVIBWFUIFDIBSHFST
DBCMFTDPOOFDUFEUPUIFXSPOHUFSNJOBMTPOZPVSCBUUFSZ5IFGPMMPXJOH
-&%TXJMMMJHIUUPJOEJDBUFXIBUZPVSDIBSHFSIBTEFUFDUFE
BATTERY RECONDITIONING LED
*GUIFDIBSHFSEFUFDUTBTVMQIBUFECBUUFSZJUXJMMBVUPNBUJDBMMZBDUJWBUFUIF
Battery ReconditioningNPEFJOEJDBUFECZBCMJOLJOHZFMMPX-&%*GB
CBUUFSZJTMFGUEJTDIBSHFEGPSBOFYUFOEFEQFSJPEPGUJNFJUDPVMECFDPNF
TVMQIBUFEVOBCMFUPBDDFQUBDIBSHF3FDPOEJUJPOJOHNPEFNBZIFMQ
SFWFSTFUIFFòFDUTPGTVMQIBUJPOBOESFTUPSFBCBUUFSZTBCJMJUZUPBDDFQUB
DIBSHF*GTVDDFTTGVMOPSNBMSFDIBSHJOHXJMMSFTVNFBGUFSUIFCBUUFSZJT
EFTVMQIBUFE*GUIFöSTUBUUFNQUBUEFTVMQIBUJPOJTVOTVDDFTTGVMUIFCBUUFSZ
DIBSHFSXJMMNBLFVQUPGPVSNPSFBUUFNQUTXJUIBCPVUIPVSTFBDIUJNF
*GTUJMMVOTVDDFTTGVMBUEFTVMQIBUJOHUIFCBUUFSZGBVMUDPEFF01XJMMCF
EJTQMBZFEJOEJDBUJOHCBUUFSZXJMMOPUBDDFQUBDIBSHFBOETIPVMECFSFQMBDFE
REVERSE POLARITY LED
*GUIFDBCMFTBSFJODPSSFDUMZDPOOFDUFEUPUIFCBUUFSZUIFReverse Polarity
JOEJDBUPSXJMMJMMVNJOBUFNote: Charger will not begin charging if the Reverse
Polarity indicator is lit.
UNDERSTANDING CONTROLS & FEATURES DPOUE

13
0.0.0.
0.1.0.
1 4.6.
0.8.0.
Current
Voltage
Battery
Capacity %
UNDERSTANDING CONTROLS & FEATURES
Changing Display Modes
5IFDIBSHFSTUBSUTVQJOUIFCurrent NPEFXJUIUIFEJHJUBMEJTQMBZTIPXJOH
UIFDIBSHJOHDVSSFOU1SFTTJOHUIFDisplay Mode ButtonXJMMBMMPXZPVUP
DZDMFUISPVHIUPUIFPUIFSNPEFT(Voltage and Battery Capacity %) and
UIF-&%TXJMMJOEJDBUFXIJDINPEFUIFDIBSHFSJTJOXIJMFUIFDigital
DisplayXJMMJOEJDBUFUIFDPSSFTQPOEJOHMFWFMTGPSFBDINPEF
CURRENT MODE
5IJTNPEFTIPXTUIFDIBSHJOHDVSSFOUCFJOHVTFECZUIFDIBSHFSJOUIF
EJHJUBMEJTQMBZBOEOPUUIFDIBSHFSBUFTFMFDUFE5IFDIBSHFSEFUFDUTBOE
EFMJWFSTUIFDPSSFDUBNPVOUPGBNQFSBHFOFFEFEUPDIBSHFUIF
connected battery.
VOLTAGE MODE
5IJTNPEFXJMMTIPXUIFDIBSHJOHWPMUBHFJOUIFEJHJUBMEJTQMBZUIBUJTVTVBMMZ
IJHIFSUIBOUIFCBUUFSZTSFTUJOHWPMUBHF
BATTERY CAPACITY % MODE
5IJTNPEFXJMMJOEJDBUFUIFBQQSPYJNBUFQFSDFOUUIFCBUUFSZJTDIBSHFEPO
UIFEJHJUBMEJTQMBZ
 P "UMFTTUIBOCBUUFSZDBQBDJUZUIFEJTQMBZXJMMSFBELO.
 P 5IFEJTQMBZXJMMJODSFBTFJOJODSFNFOUTCFUXFFOUP
capacity.
 P "UGVMMDIBSHFUIFEJTQMBZXJMMSFBE FUL.
UNDERSTANDING CONTROLS & FEATURES DPOUE

14
UNDERSTANDING CONTROLS & FEATURES
UNDERSTANDING CONTROLS & FEATURES DPOUE
Changing Charging Rates
5IFDIBSHFSTUBSUTVQJOUIFOptimal ChargeNPEF1SFTTJOHUIFCharge
Rate Button XJMMBMMPXZPVUPDZDMFUISPVHIUPUIFPUIFSDIBSHFSBUFT
(4 A, 12 A, 25 A
Understanding Charge Rates
o 4-25 A Optimal Chargeo5PIFMQFYUFOEUIFMJGFPGZPVSCBUUFSZBOE
FOTVSFJUJTEFMJWFSJOHJUTNBYJNVNQPUFOUJBMJUJTJNQPSUBOUUPDIBSHFUIF
CBUUFSZBUBSBUFUIBUJTBQQSPQSJBUFBOETBGFGPSJUTDBQBDJUZ$IBSHJOHB
CBUUFSZBUUPPIJHIBDIBSHFSBUFXIJMFGBTUNBZTIPSUFOUIFFYQFDUFE
MJGFPGBCBUUFSZ$IBSHJOHBCBUUFSZBUUPPMPXBDIBSHFSBUFXIJMFTBGFS
UBLFTMPOHFSBOEEPFTOPUFOTVSFUIFCBUUFSZXJMMSFBDIPGJUT
DBQBDJUZ0QUJNBMDIBSHFMPHJDBVUPNBUJDBMMZTFMFDUTUIFJEFBMDIBSHF
rate for your battery
o 12 A and 25 A Charge Rateo6TFGPSGBTUFSDIBSHJOHPGTNBMMUPMBSHF
DBQBDJUZBVUPNPUJWFNBSJOFEFFQDZDMFBOEGBSNUSBDUPSCBUUFSJFT
o 4 A Charge Rateo6TFGPSTMPXDIBSHJOHTNBMMUPMBSHFDBQBDJUZ
BVUPNPUJWFNBSJOFEFFQDZDMFBOEGBSNUSBDUPSCBUUFSJFT"MTPGPS
garden tractor batteries.
0.0.0.

15
UNDERSTANDING CONTROLS & FEATURES
UNDERSTANDING CONTROLS & FEATURES DPOUE
Understanding Charge Rate Times
5IFCVJMUJOJOUFMMJHFOUNJDSPQSPDFTTPSXJMMDPOUJOVPVTMZNPOJUPSBOE
BEKVTUUIFDIBSHFSUPQSPWJEFBGBTUTBGFBOEFóDJFOUDIBSHF/PUFUIBU
CBUUFSZDIBSHFUJNFTXJMMWBSZEFQFOEJOHPOTFWFSBMGBDUPSTJODMVEJOH
1. Battery Stateo*GBCBUUFSZIBTCFFOPOMZTMJHIUMZEJTDIBSHFEJUDBOCF
DIBSHFEJOMFTTUIBOBGFXIPVST5IJTTBNFCBUUFSZDPVMEUBLFVQUP
IPVSTJGWFSZEJTDIBSHFE
2. Battery Ratingo"IJHIFSSBUFECBUUFSZXJMMUBLFMPOHFSUPDIBSHFUIBO
BMPXFSSBUFECBUUFSZVOEFSUIFTBNFDPOEJUJPOT"CBUUFSZJTSBUFEJO
BNQFSFIPVST"ISFTFSWFDBQBDJUZ3$BOEDPMEDSBOLJOHBNQT$$"
3. Charge Rateo5IFDIBSHFSBUFJTNFBTVSFEJOBNQT"CBUUFSZDIBSHFE
BUBMPXFSSBUFXJMMUBLFMPOHFSUIBOBCBUUFSZDIBSHFEBUBIJHIFSSBUF
)PXFWFSTNBMMFSCBUUFSJFTDBOCFFBTJMZEBNBHFECZDIBSHJOHBUBSBUF
XIJDIJTUPPIJHIGPSUIFDBQBDJUZPGUIFCBUUFSZ
Temperatureo$PMEUFNQFSBUVSFTXJMMBòFDUBCBUUFSZTBCJMJUZUPBDDFQU
BDIBSHF$IBSHJOHJODPMEUFNQFSBUVSFTXJMMJODSFBTFUIFBNPVOUPGUJNF
SFRVJSFEUPDIBSHFBCBUUFSZ
Other Features
MAINTENANCE MODE
0ODFDIBSHJOHJTDPNQMFUFUIFDIBSHFSXJMMBVUPNBUJDBMMZHPJOUP
MaintenanceNPEFBMTPLOPXOBT'MPBU.PEF.POJUPSJOH*OUIJT
NPEFUIFDIBSHFSLFFQTUIFCBUUFSZGVMMZDIBSHFECZEFMJWFSJOHBTNBMM
BNPVOUPGDVSSFOU"GUFSTXJUDIJOHUPUIFMaintenanceNPEFUIFDIBSHFS
XJMMMJNJUUIFDIBSHJOHDVSSFOUUPBWPJEUIFSJTLPGPWFSDIBSHJOH
ABORTED CHARGES
*GDIBSHJOHDBOUCFDPNQMFUFEOPSNBMMZDIBSHJOHXJMMCFBCPSUFE5IF
EJHJUBMEJTQMBZNBZTIPXBGBVMUDPEF5PSFTFUUIFDIBSHFSBGUFSBOBCPSUFE
DIBSHFEJTDPOOFDUUIFCBUUFSZPSVOQMVHUIFDIBSHFS
BATTERY DIAGNOSTICS
5IFDIBSHFSDPOUJOVPVTMZNPOJUPSTCBUUFSZDPOEJUJPOBOENBZSFQPSU
DFSUBJODIBSHJOHGBJMVSFTBTGBVMUDPEFT3FGFSUPUIFTFDUJPODBMMFE
“5SPVCMFTIPPUJOH'BVMU$PEFT”for a complete list.

16
Other Features DPOUE
COOLING FAN OPERATION
5IFDIBSHFSJTEFTJHOFEUPDPOUSPMJUTIJHITQFFEDPPMJOHGBOGPSFóDJFOU
PQFSBUJPO$POTFRVFOUMZJUJTOPSNBMGPSUIFGBOUPTUBSUBOETUPQEVSJOH
DIBSHJOH
OVERHEAT PROTECTION
5IFDIBSHFSJTEFTJHOFEUPTIVUJUTFMGPòJGPWFSIFBUJOHJTEFUFDUFE0ODF
UIFDIBSHFSDPPMTEPXOJUXJMMSFTVNFDIBSHJOHBVUPNBUJDBMMZ
JUMPSTARTING YOUR VEHICLE
:PVSCBUUFSZDIBSHFSDBOCFVTFEUPKVNQTUBSUZPVSWFIJDMFJGUIFCBUUFSZ
JTMPX
IMPORTANT:5IFEngine Start feature cannot be used if a battery is not
JOTUBMMFEJOUIFWFIJDMF5IFDIBSHFS.645EFUFDUTPNFWPMUBHFGSPNUIF
CBUUFSZPSJUXJMM/05HPJOUPEngine StartNPEF.BLFCBUUFSZBOE"$
connections as outlJOFEJOi#BUUFSZ*O7FIJDMFwTFDUJPO
1SFTTUIF75 A Engine Start button P0ODFUIFEngine Start button P
JTQSFTTFEUIFDIBSHFSXJMMCFHJOUPDIBSHFUIFCBUUFSZBUVQUP"VOUJMBO
BUUFNQUJTNBEFUPDSBOLUIFFOHJOF
0.0.0.
75 A Engine
Start
/./ /
++ –
1
++ –
5.5 5
0.0.0.
2a
UNDERSTANDING CONTROLS & FEATURES DPOUE
JUMP-STARTING YOUR VEHICLE

17
JUMP-STARTING YOUR VEHICLE
JUMPSTARTING YOUR VEHICLE DPOUE
$SBOLUIFFOHJOFGPSOPNPSFUIBOTFDPOET*GUIFFOHJOFEPFTOPUTUBSU
XBJUBUMFBTUNJOVUFTCFGPSFBUUFNQUJOHUPDSBOLBHBJO
P 0OMZXIFOBDUVBMFOHJOFDSBOLJOHJTEFUFDUFEXJMMUIFDIBSHFSUIFO
BVUPNBUJDBMMZEFMJWFSBQQSPYJNBUFMZ"GPSVQUPTFDPOETPSVOUJMUIF
DSBOLJOHTUPQTUIFCBUUFSZWPMUBHFJTPGUFOSFRVJSFEUPCFMFTTUIBO7
5IFEJHJUBMEJTQMBZXJMMDPVOUEPXOUIFDSBOLUJNFJOTFDPOETTUBSUJOH
BUyEPXOUP
P "GUFSTFDPOETPGDSBOLJOHUIFDIBSHFSBVUPNBUJDBMMZFOUFSTDPPMEPXO
NPEFGPSNJOVUFTUPQSPUFDUUIFDIBSHFSCBUUFSZBOETUBSUFSGSPN
EBNBHF5IFEJHJUBMEJTQMBZXJMMCFHJODPVOUJOHEPXOJOTFDPOETGSPN
EPXOUP%VSJOHUIJTUJNFUIFDIBSHFSXJMMDPOUJOVFUPDIBSHFUIF
CBUUFSZBUBSBUFPGVQUP"
"GUFSUIFFOHJOFTUBSUTVOQMVHUIF"$DPSEBOEEJTDPOOFDUUIFDBCMFTGSPN
UIFCBUUFSZ
NOTE: A severely discharged battery may not be able to start an engine even
with the assistance of the 75 A Engine Start. If your rst few attempts to boost
the vehicle are unsuccessful, try charging the battery at 25 A for 20 minutes
before attempting to boost again.
++ –
5.5 5
18 0 180
0.0 0
++ –
0.0.0.
/./ /
2b
0.0.0.

TROUBLESHOOTING/FAULT CODES
18 TROUBLESHOOTING/FAULT CODES
Fault
Codes
Condition Possible Cause Solution
8 8 8
5IFDIBSHFS
does not
detect
a battery
connected
to it.
$IBSHFSEPFTOPU
SFDPHOJ[FUIF
battery.
$POOFDUCBUUFSZUP
DIBSHFSBEFORE
connecting
DIBSHFSUP"$QPXFS
Poor clamp
connection.
&OTVSFCBUUFSZQPTUT
BSFDMFBO3PDL
DMBNQTCBDLBOE
GPSUIPOCBUUFSZ
posts to ensure a
good connection.
#BUUFSZWPMUBHF
JTVOEFS7
CBUUFSZNVTUIBWF
B.*/*.6.PG7
UPBDUJWBUFDIBSHFS
$IFDLCBUUFSZ
WPMUBHFXJUIBWPMU
meter. If LESSUIBO
7SFQMBDFCBUUFSZ
"CBUUFSZXJUIMFTT
UIBO7JTMJLFMZ
CFZPOETBMWBHF
EVFUPFYUSFNF
TVMQIBUJPOPSTPNF
PUIFSJOUFSOBM
GBJMVSF:PVNBZ
USZUPCPPTUUIF
battery using booster
cables connected to
BOPUIFSWFIJDMF5IJT
NBZSBJTFUIFCBUUFSZ
WPMUBHFBCPWF7
BMMPXJOHUIFCBUUFSZ
DIBSHFSUPBDUJWBUF
F.0 1
5IFCBUUFSZ
WPMUBHFJTMFTT
UIBO7BGUFS
10 minutes of
DIBSHJOH
5IFCBUUFSZJT
EFGFDUJWF
3FQMBDFUIFCBUUFSZ
A load may be
DPOOFDUFEUPUIF
battery.
DO NOTVTFUIF
battery during
DIBSHJOH
F.0 2
#BUUFSZ
WPMUBHFJT
UPPIJHI
#BUUFSZSBUFEBCPWF
12 V.
$POöSNUIBUUIF
battery is rated 12 V
PSCFMPX

TROUBLESHOOTING/FAULT CODES
19
Fault
Codes
Condition Possible Cause Solution
F.0 3
"DUVBMDIBSHF
SBUFFYDFFET
selected
DIBSHJOHSBUF
A load may be
DPOOFDUFEUPUIF
battery.
%JTDPOOFDUUIF
load and attempt to
DIBSHFBHBJO
$IBSHJOHFSSPSPS
EFGFDUJWFDIBSHFS
%JTDPOOFDUUIF
CBUUFSZBOEUIF"$
QPXFSBUUFNQUUP
DIBSHFBHBJO
5IF
temperature
PGUIF
DIBSHFSJT
UPPIJHI
)JHIBNCJFOU
temperature or
QPPSWFOUJMBUJPO
&OTVSFBEFRVBUF
WFOUJMBUJPO5IF
DIBSHFSXJMMSFTVNF
DIBSHJOHBGUFS
cooling.
F.0 5
5IFCBUUFSZ
does not
go into
Maintenance
mode after
CFJOHDIBSHFE
GPSIPVST
Note: When
F05 appears,
disconnect the
battery and AC
power, reconnect
and attempt to
charge again.
5IFDIBSHFDVSSFOU
JTUPPMPX
4FMFDUBIJHIFS
DIBSHFSBUF
5IFSFJTBMPBE
QMBDFEPOUIF
CBUUFSZXIJMF
DIBSHJOH
DO NOTVTFUIF
battery during
DIBSHJOH
#BUUFSZJTEFGFDUJWF
BOEXJMMOPUBDDFQU
BDIBSHF
Replace battery.
F.0 6
3FWFSTF
polarity.
5IFCBUUFSZDMBNQT
are incorrectly
connected.
%JTDPOOFDUDMBNQT
and ensure proper
connection.
F.0 4
TROUBLESHOOTING/FAULT CODES DPOUE

20
t $MFBODPSETBOEDMBNQTFBDIUJNFZPVBSFöOJTIFEVTJOHUIFDIBSHFS
t 8JQFPòBOZCBUUFSZøVJEPSEFCSJTUIBUNJHIUIBWFDPNFJODPOUBDUXJUI
 UIFDMBNQTUPQSFWFOUDPSSPTJPO
t 4UPSFUIFQPXFSBOEPVUQVUDBCMFOFBUMZUPQSFWFOUEBNBHF
t 0DDBTJPOBMDMFBOJOHPGUIFCBUUFSZDIBSHFSDBTFXJUIBTPGUDMPUIXJMMIFMQ
 QSPUFDUUIFöOJTI
t ALWAYSVOQMVHUIFDIBSHFSXIFOOPUJOVTF
t ,FFQUIFDIBSHFSTUPSFEJOBDPPMESZQMBDF
5IJT.PUP.BTUFS¥&MJNJOBUPSQSPEVDUDBSSJFTBUISFFZFBSXBSSBOUZ
BHBJOTUEFGFDUTJOXPSLNBOTIJQBOENBUFSJBMT"UJUTEJTDSFUJPO.PUP.BTUFS
$BOBEBBHSFFTUPIBWFBOZEFGFDUJWFQBSUTSFQBJSFEPSSFQMBDFEGSFFPG
DIBSHFXJUIJOUIFTUBUFEXBSSBOUZQFSJPEXIFOSFUVSOFECZUIFPSJHJOBM
QVSDIBTFSXJUIQSPPGPGQVSDIBTF5IJTQSPEVDUJTOPUHVBSBOUFFEBHBJOTU
XFBSPSCSFBLBHFEVFUPNJTVTFBOEPSBCVTF
LIMITED WARRANTY
MAINTENANCE AND CARE
MAINTENANCE AND CARELIMITED WARRANTY