
Part 1044199−04 E2015 Nordson Corporation
Table of Contents
Safety 1-1....................................
Introduction 1-1...............................
Qualified Personnel 1-1........................
Intended Use 1-1..............................
Regulations and Approvals 1-1..................
Personal Safety 1-2...........................
Fire Safety 1-2................................
Grounding 1-3................................
Action in the Event of a Malfunction 1-3..........
Disposal 1-3..................................
Description 2-1...............................
Introduction 2-1................................
Front Panel Controls and Indicators 2-1..........
Keypad 2-2...................................
Display 2-3...................................
Operating Modes 2-3...........................
Back Panel 2-4................................
Specifications 2-5..............................
Installation 3-1................................
Mounting 3-1..................................
Power and Ground Connections 3-1.............
Spray Gun Cable/Adapter Installation 3-2.........
Sure Coat or
Versa Spray II Automatic Spray Guns 3-2......
Tribomatic II Automatic Spray Guns 3-3........
Trigger Configuration 3-5.......................
Pneumatic Connections 3-6.....................
PLC Connection 3-7...........................
Operation 4-1.................................
Startup 4-1...................................
Initial Gun Usage 4-3...........................
Air Pressure Adjustments 4-4....................
Flow Rate Air Pressure 4-4...................
Atomizing Air Pressure 4-4...................
Fluidizing Air Pressure 4-4....................
Shutdown 4-5.................................
Daily Maintenance 4-5..........................
Troubleshooting 5-1..........................
Wiring Diagram 5-4............................
Repair 6-1....................................
Spray Gun Cable/Adapter Replacement 6-1.......
Sure Coat or
Versa Spray II Automatic Spray Guns 6-1......
Tribomatic II Automatic Spray Guns 6-3........
Check Valve Replacement 6-4...................
Solenoid Replacement 6-5......................
Gun Board Replacement 6-7....................
Interface Display Board Replacement 6-8.........
Regulator and Gauge Replacement 6-10..........
Fuses 6-12....................................
Rear Panel Fuses 6-12.......................
Power Supply Fuse 6-12
......................
Power Supply Replacement 6-13..................
Pneumatic Diagram 6-14........................
Parts 7-1.....................................
Introduction 7-1...............................
Using the Illustrated Parts List 7-1............
Vantage Powder Controller 7-2..................
Front Panel 7-5................................
Rear Panel 7-9................................
Spray Gun Cables 7-10.........................
Contact Us
Nordson Corporation welcomes requests for information, comments, and
inquiries about its products. General information about Nordson can be
found on the Internet using the following address:
http://www.nordson.com.
Address all correspondence to:
Nordson Corporation
Attn: Customer Service
300 Nordson Drive
Amherst, OH 44001
Notice
This is a Nordson Corporation publication which is protected by copyright.
Original copyright date 2004. No part of this document may be
photocopied, reproduced, or translated to another language without the
prior written consent of Nordson Corporation. The information contained
in this publication is subject to change without notice.
Trademarks
Nordson, the Nordson logo, Sure Coat, Tribomatoc, Vantage, and
Versa-Spray are registered trademarks of Nordson Corporation.