Over Armour Offroad BC-3400-WD05 Installation manual

Over Armour Offroad
2515 Bypass Rd. Flemingsburg, KY 41041
606-845-7439
Instructions for Installation and Care of
Bobcat 3400
Aero-Vent Polycarbonate Windshield
BC-3400-WD05
NOTICE: Please check contents of package for any damage and make sure all parts fit correctly
and you are happy with the product before removing protective film. Once the film is removed
you cannot return the product for a full refund.
Be sure to read these instructions thoroughly before opening and installing the Polycarbonate
Windshield.
1. Start by pulling it out of the box and find a clean area to lay it down and install the hardware.
Check over the parts included in the cartons with the parts list shown below:
1 ¾” Loom Clamps 8 each
1” Stainless Steels Bolts 14 each
Stainless Steel Washers 20 each
Slide fasteners 8 each
Lock Nuts 4 each
Plastic Thumb Nuts 10 each
Sliding Vent Panels 2 each
52” Rubber Gasket 1 each
55” Rubber Gasket 1 each
Bent Polycarbonate Braces 1 each
Polycarbonate Windshield 2 Pieces
2. Next take the rubber gasket and starting at one end firmly place along entire bottom and top
edges of the lower Windshield Section. You will need to peel back the protective film from the
edge to install the gasket. If you leave the bulk of the protective film on while installing you can
keep from scratching the windshield. Please see photo below:

3. Next Install the Aero-Vent sliders as shown in the diagram below.

4. Next take the bent Polycarbonate brace and install it on the windshield. Please see diagram
Below.

5. Now you are ready to place the windshield on the Bobcat and attach to the roll cage. NOTE:
THE BEND AT THE TOP OF THE WINDSHIELD SHOULD GO BELOW THE TOP TUBE.
The diagram on the next page shows the proper placement for the hardware. Install the clamps
as shown for the top two slots in the windshield only. Use the 1” bolts for this application.
6. Now Place the two halves onto the frame as shown below. (diagram not Bobcat)

7. Now you are ready to take it out and enjoy. To clean the windshield, always clean using a liquid
of some sort to decrease the chance of scratches. We recommend using micro fiber cloths that
are readily available at any dollar store. Any window cleaner will work fine; just remember to
use a soft clean rag or micro-fiber cloth to clean it.

Return Policy
Over Armour Offroad
2515 Bypass Rd, Flemingsburg, KY 41041
Phone: [phone]
If for any reason you choose to return this product it must be returned within 30 days
from date item is received. You MUST package the product exactly as it was
originally packaged from the factory to get a full refund for the product!
The vinyl windows should never be folded when packaging in the box or for storage
purposes. Lay all the windows on top of each other with the canvas folded in between
and the paper (if available) on both sides of the windows.
All returned products will be inspected upon arrival at the production facility and
must be in unused, factory new condition to receive refund - a 20% restocking fee
will apply.
If ordered from Over Armour Offroad please call at 606-845-7439 to gain a return
authorization number, use our preferred shipping carrier (UPS) to return the item (unless
the item is defective, you are responsible for paying the shipping to return the item.) Any
returns submitted to Over Armour Offroad without a return authorization number
will be charged a 20% restocking fee. If ordered from one of Over Armour Offroads
many distributors’, you must first call them and see what their return policy is. Once your
item reaches our production facility, our customer satisfaction team will inspect your
item to ensure unused, factory new condition. NOTE: All windshields must be
returned with the original protective film intact and not removed. Do NOT
REMOVE if you have any intentions of returning the item. Refund/ replacement of
a windshield will only be processed on items with original protective film or if the
windshield is defective.
Items must be properly packaged in the original shipping carton to protect them during
transit and ensure your returned item arrives back factory fresh, and in new resalable
condition (any returned items that have been used, altered or damaged in any way
will not be subject for a refund.) All contents including instruction manuals,
accessories, hardware, Velcro, etc. must be included in your return shipment. Only items
in OEM factory new condition will be approved. Once returned items are received, credit
will be issued to the original credit card/ payment method used for the purchase.
Outbound shipping and return shipping cost will not be refunded. Please allow 4 to 6
weeks for your refund to be processed.

Warranty
Over Armour Offroad
2515 Bypass Rd, Flemingsburg, KY 41041
Phone: [phone]
To The Owner of this Product:
Thank you for purchasing one of Over Armour Offroad Cab Enclosures &/or Windshields! Below are
the terms under which your product is covered under our manufacturer’s warranty.
30 Day Warranty which includes and is not limited to replacing the enclosure and/or windshield due to
defect of the product. Please refer to the return policy in this case for more information.
1 Year Warranty includes any defect in material or workmanship within this time frame we will gladly
correct the problem or replace the enclosure &/or windshield. Upon submitting for the correction or
replacement we will need to receive pictures of the defect in material or workmanship along with the
receipt from the date of purchase.
Thank you,
Darren Royse
Owner/Operator
www.overarmouroffroad.com