Over Armour Offroad Can-1000-WD05 Installation manual

Over Armour Offroad
2515 Bypass Rd. Flemingsburg, KY 41041
606-845-7439
Instructions for Installation and Care of
Can Am Aero-Vent Polycarbonate Windshield
Can-1000-WD05
NOTICE: Please check contents of package for any damage and make sure all parts fit correctly
and you are happy with the product before removing protective film. Once the film is removed
you cannot return the product for a full refund.
1. Be sure to read these instructions thoroughly before opening and installing the Can Am Areo-
Vent Polycarbonate Windshield.
2. Check over the parts included in the cartons with the parts list shown below:
2” Loom Clamps------------------------6 each
1” Stainless Steels Bolts--------------12 each
Stainless Steel Washers---------------16 each
Plastic Thumb Nuts---------------------8 each
Lock Nuts--------------------------------4 each
Slide Fasteners---------------------------8 each
50” Rubber Gasket----------------------1 each
Polycarbonate Brace--------------------1 each
Polycarbonate Vent Sliders------------2 each
Polycarbonate Windshield-------------1 each
3. Start by pulling it out of the box and find a clean area to lay it down and install the hardware.
Begin by peeling off the protective film. Next take the 50” piece of rubber gasket and starting at
one end firmly place across the bottom of the windshield. You may need to trim off excess
gasket. The diagram below shows where to install the gasket.

4. Next install the sliding vent panel on the inside of the windshield as shown in the diagram below.
To install slide fasteners, push through holes with thumbs until it is completely through the hole
in the windshield and locked in place.

5. Now the Windshield is ready to be installed. With the help of a friend, place the Windshield on
the Commander, setting it up onto the hood.
6. Take the remaining hardware and install the windshield to the roll cage as shown in the diagram
below.

7. Now you can install the top brace if you want. If you do not have an Over Armour Offroad Cab
enclosure to work with this windshield, the top brace is not needed but can be installed for extra
strength. Below is a diagram showing how the brace is to be installed.
8. If you are using this windshield with an Over Armour Offroad Cab enclosure, then you will use
the Top Brace to sandwich the cab material and seal off the inside from the wind. The diagram
below shows how it will work.

9. Now you are ready to take it out and enjoy. To clean the windshield, always clean using a liquid
of some sort to decrease the chance of scratches. We recommend using micro fiber cloths that
are readily available at any dollar store. Any window cleaner will work fine; just remember to
use a soft clean rag or micro-fiber cloth to clean it.
Completed Windshield –Outside view

Completed Windshield –Inside view

Return Policy
Over Armour Offroad
2515 Bypass Rd, Flemingsburg, KY 41041
Phone: [phone]
If for any reason you choose to return this product it must be returned within 30 days
from date item is received. You MUST package the product exactly as it was
originally packaged from the factory to get a full refund for the product!
The vinyl windows should never be folded when packaging in the box or for storage
purposes. Lay all the windows on top of each other with the canvas folded in between
and the paper (if available) on both sides of the windows.
All returned products will be inspected upon arrival at the production facility and
must be in unused, factory new condition to receive refund - a 20% restocking fee
will apply.
If ordered from Over Armour Offroad please call at 606-845-7439 to gain a return
authorization number, use our preferred shipping carrier (UPS) to return the item (unless
the item is defective, you are responsible for paying the shipping to return the item.) Any
returns submitted to Over Armour Offroad without a return authorization number
will be charged a 20% restocking fee. If ordered from one of Over Armour Offroads
many distributors’, you must first call them and see what their return policy is. Once your
item reaches our production facility, our customer satisfaction team will inspect your
item to ensure unused, factory new condition. NOTE: All windshields must be
returned with the original protective film intact and not removed. Do NOT
REMOVE if you have any intentions of returning the item. Refund/ replacement of
a windshield will only be processed on items with original protective film or if the
windshield is defective.
Items must be properly packaged in the original shipping carton to protect them during
transit and ensure your returned item arrives back factory fresh, and in new resalable
condition (any returned items that have been used, altered or damaged in any way
will not be subject for a refund.) All contents including instruction manuals,
accessories, hardware, Velcro, etc. must be included in your return shipment. Only items
in OEM factory new condition will be approved. Once returned items are received, credit
will be issued to the original credit card/ payment method used for the purchase.
Outbound shipping and return shipping cost will not be refunded. Please allow 4 to 6
weeks for your refund to be processed.

Warranty
Over Armour Offroad
2515 Bypass Rd, Flemingsburg, KY 41041
Phone: [phone]
To The Owner of this Product:
Thank you for purchasing one of Over Armour Offroad Cab Enclosures &/or
Windshields! Below are the terms under which your product is covered under our
manufacturer’s warranty.
30 Day Warranty which includes and is not limited to replacing the enclosure and/or
windshield due to defect of the product. Please refer to the return policy in this case for
more information.
1 Year Warranty includes any defect in material or workmanship within this time frame
we will gladly correct the problem or replace the enclosure &/or windshield. Upon
submitting for the correction or replacement we will need to receive pictures of the defect
in material or workmanship along with the receipt from the date of purchase.
Thank you,
Darren Royse
Owner/Operator
www.overarmouroffroad.com