peerless-AV DS-VWM770 User manual

12013-08-27 #:125-9465-5 2014-04-21
DS-VWM770
ENG
46" - 70"
(1168 - 1778 cm)
125 lb
(56 kg)
MAX

22013-08-27 #:125-9465-5 2014-04-21
ENG - This product is designed to be installed on wood stud, solid concrete or cinder block walls. Hardware is
included for wood stud, solid concrete and cinder block installation. Before installing make sure the supporting
surface will support the combined load of the equipment and hardware. Screws must be tightly secured. Do
not overtighten screws or damage can occur and product may fail. Never exceed the Maximum Load Capacity.
Always use an assistant or mechanical lifting equipment to safely lift and position equipment. This product is
intended for indoor use only. Use of this product outdoors could lead to product failure or personal injury. Be
careful not to pinch ngers when operating the mount. For support please call customer care at 1-800-865-2112.
WARNING
Symbols
ENG
WARNING
ENG
#
Skip to step.
ENG
x3
Screws must get at least three
full turns and t snug.
ENG
Do not overtighten screws.
ENG

32013-08-27 #:125-9465-5 2014-04-21
5/32"
(4mm)
5/16"
(8mm)
Tools Needed for Assembly.
ENG
1
2
ENG To properly tighten screws: Tighten until screw
head makes contact, then tighten another 1/2
turn. Do not overtighten screws.
+1/2
4
3
3/8"
(10mm)

42013-08-27 #:125-9465-5 2014-04-21
B (4)
concrete anchor
locking tab
D (1)
C (4)
wood screw
.219" spacer
E (1)
polyester sleeve
F (2)
A (1)
wall plate
Parts (Before beginning, make sure you have all parts shown below).
ENG
Parts List
Part Description Qty. Part #
Awall plate 1 201-0387
Bconcrete anchor 4 590-0320
Cwood screw 4 5S1-015-C03
Dlocking tab 1 200-1871
E.219" spacer 1 540-1032
Fpolyester sleeve 2 600-1014
Gcable tie 4 560-9711
HM5 x 10mm screw 5 520-1063
IM4 x 12mm screw 4 510-1079
JM5 x 40mm screw 1 510-1001
K4mm allen wrench 1 560-9646
Ladaptor bracket 2 145-1779
Mplate assembly 1 145-1784
NM10 x 15mm 4 520-9262
OM5 x 8mm 4 520-1167
PM6 x 12mm 4 520-1050
Qshoulder washer 4 590-2233
RM8 x 15mm 4 520-1068

52013-08-27 #:125-9465-5 2014-04-21
M5 x 10mm M4 x 12mm M5 x 40mm cable tie
H (5) I (4) J (1) G (4)
L (2)
adaptor bracket
plate assembly
M (1) M10 x 15mm
N (4)
M5 x 8mm
O (4)
M6 x 12mm
P (4)
shoulder washer
Q (4)
M8 x 15mm
R (4)
4mm allen wrench
K (1)

62013-08-27 #:125-9465-5 2014-04-21
2a
ENG - When installing Peerless wall mounts on a
wood stud wall covered with gypsum board (drywall),
verify that the woods studs are a minimum of 2" x
4" nominal size. Do not install over gypsum board
thicker than 5/8".
WARNING
1
A
Remove
ENG
2
2a
Wood stud wall.
ENG
2b
Concrete/Cinder block.
ENG
2a-1 Use stud nder to locate
and mark stud center lines.
ENG
ENG

72013-08-27 #:125-9465-5 2014-04-21
2.5"
(64mm)
5/32"
(4mm)
Mounting hole must center on stud.
ENG
2a-3
5/32"
(4mm)
Drill mounting holes into supporting surface
(2.5" (64mm) minimum depth required).
ENG
A
3
A
C (4)
2a-4
Level wallplate. Install using wood screws provided.
ENG
Maximum 80 in. • lb (9 N.M.).
ENG
2a-2
Level wallplate. Mark mounting holes on stud
centerlines (studs must be 16" (406mm) on
center).
ENG
16.00"
(406mm)

82013-08-27 #:125-9465-5 2014-04-21
2b-1
2b-2
5/16"
(8mm)
2.5"
(64mm)
5/16"
(8mm)
Level wallplate. Mark mounting holes.
ENG
Do not drill into mortar joints.
ENG
A
Drill mounting holes into supporting surface
(2.5" (64mm) minimum depth required).
ENG
2b
ENG • When installing Peerless wall mounts on a concrete wall, the wall must be at least 8" thick with a minimum
compressive strength of 2000 psi.
• When installing Peerless wall mounts on a cinder block wall, the cinder blocks must meet ASTM C-90
specications and have a minimum nominal width of 8". Do not drill into mortar joints! Be sure to mount in a solid
part of the block, generally 1" (25 mm) minimum from the side of the block. It is suggested that a standard electric
drill on slow setting is used to drill the hole instead of a hammer drill to avoid breaking out the back of the hole
when entering a void or cavity.
• Never attach expansion anchors to concrete or cinder block covered with plaster, drywall or other nishing
material.
WARNING

92013-08-27 #:125-9465-5 2014-04-21
B (4)
A
C (4)
1b-42b-4
2b-32b-3
Level wallplate. Install using concrete
anchors and wood screws provided.
ENG
Maximum 80 in. • lb (9 N.M.).
ENG
B
Insert anchor ush to concrete.
ENG

10 2013-08-27 #:125-9465-5 2014-04-21
3
A