Quadratec 92034.1018 User manual

Quadratec® Tailgate BikePad
for 2019-Current Jeep JT Gladiator
Item #92034.1018
PART LIST:
Tailgate Bike Pad QTY 1
REQUIRED TOOLS:
Safety Glasses
WARNING
CAUTION
NOTICE Before traveling, make sure the front tire assembly of your bike is only resting on the Bike pad. If your
bike is touching the tailgate off the pad, damage to the vehicles paint can occur
NOTICE It is extremely important that you keep the back side of the Bike Pad Clean. Wash the Bike pad with
warm Soapy water often to keep dirt and road grime from building up and potentially causing paint
damage.
Never install this product while the engine is running. Before installing this product, put the vehicle in
park and set the emergency brake. Always secure your bike(s) with the safety straps attached to the
front of the pad before traveling.
RISK OF EYE INJURY. Safety glasses should be worn at all times while installing or maintaining this
product.

Tailgate Bike Pad Installation:
After unpacking the tailgate Bike Pad lay it flat on the ground. With the tailgate closed,
position the bike pad on top of the tailgate. Adjust the pad so that the panel rests flat
on the tailgate while the pad’s lower straps dangling below. Fig 2.
FIG 1
FIG 2
Important Safety information
Your QuadraTop® Tailgate Bike Pad is in-
tended to provide tailgate protection from
carrying bikes on your o-road capable
vehicle. Before installation,
please take a moment to review the fol-
lowing safety information and installation
instructions. Important safety information
is generally preceded by one of three
signal words indicating the relative risk of
injury. The signal words mean:
a hazardous situation which, if not avoided, could result in death or serious in-
jury. You CAN be KILLED or SERIOUSLY HURT if you don’t follow instructions.
WARNING
CAUTION
NOTICE
a hazardous situation which, if not avoided, could result in minor or moderate
injury. You CAN be moderately HURT and also may su󰀨er property damage if
you don’t follow instructions.
Careful attention is required to this instruction or operation but does general-
ly not relate to personal injury. Damage to your Quadratec® product or other
property may result if you don’t follow instructions.
Threading Straps through Buckles:
Throughout the installation, you will need to thread webbing
straps through buckles several times. Please review the pic-
ture for correct strap routing through the buckles. As a rule
of thumb, run the strap below and through the sewn side
of the buckle rst and then back down through the end of
the buckle. Tighten the strap by simply pulling the exposed
webbing after threading the strap through the buckle.
Pre-Installation of Tailgate Bike Pad
When unpacking, carefully check to make sure all parts are included. If any part is missing
or broken, please call Quadratec customer service at 800-745-6037.

Loading the bikes. Place the bikes on the tailgate, starting from the left side first. Make sure
your bike’s disc (where applicable)brake is facing out from the pad and the wheel is tilted out
where possible. Position the bicycles so the front forks are resting on the bike pad and the
back wheels touch the bed of the truck (FIG10). Use great care when placing the bikes inside
the rear of your vehicle as not to scratch your truck bed with the pedals. Secure the bikes by
hooking the safety straps around the bike frame as shown in FIG's11 & 12. See Warning
above
Repeat this procedure for the two outside straps. (Fig’s 7 & 8). Tighten and secure all four of
the straps (FIG 9-Circled). Adjust the pad by rotating it or pulling it in the direction needed so
the front facing safety straps are positioned as shown in FIG 9.
FIG 7 FIG 8 FIG 9
FIG 10 FIG 11 FIG 12
Open the tailgate of your vehicle slightly. Through the bottom of the tailgate, slip the two
hanging center straps in-between the tailgate and the bed of the truck. Make sure your straps
Go through the tailgate opening. Fig’s 3 & 4.
CAUTION: When using both hands to both hold the tailgate open and slip the strap under the
tailgate, be careful not to pinch your fingers as you slip the straps between the tailgate and
truck bed.
Bring the straps towards the top of the tailgate and loosely connect the strap to buckle (Fig 5 &
6). Do not tighten these straps yet.
FIG 3 FIG 4 FIG 5 FIG 6
WARNING
Before traveling with the bikes in the back of your truck, the rear
safety straps must be secured to the frame(s) of your bike(s). See
FIG's 11 & 12 below. Failure to secure your Bike(s) with these straps
can cause damage to your vehicle or other vehicles and possible
injury or death.
NOTICE
It is extremely important that you frequently remove the bike pad and clean the
back side of the pad that touches your tailgate paint. Use warm soapy water
and a soft cloth often to clean and keep dirt and road grime from building up
and potentially causing paint damage. After washing the bike pad, let it dry in
the sun before re-installing.

Your Quadratec® branded accessories are
covered by the following Limited Warranty
provided exclusively by Quadratec, Inc.,
1028 Saunders Lane, West Chester PA
19380..
This Limited Warranty is the only warranty
made in connection with purchase. Qua-
dratec neither assumes nor authorizes any
vendor, retailer or other person or entity to
assume for it any other obligation or liability
in connection with this product or Limited
Warranty.
What is Covered:
Subject to the terms, exclusions and limita-
tions herein and with respect only to soft tops
rst sold in the United States, Quadratec
warrants to the initial retail purchaser only
that your QuadraTop soft top shall be free of
defects in material and workmanship for a
period of 3 years from date of initial retail
sale.
All other warranties are hereby disclaimed,
except to the extent prohibited by applicable
law in which case any implied warranty of
merchantabil- ity or tness for a particular
purpose on this prod- uct is limited to 3 years
from date of initial retail sale. Quadratec
reserves the rights to: (a.) require invoice or
other proof your soft top is within the terms
of this Limited Warranty as a condition of
warranty service and, (b.) make future revi-
sions to this product and Limited Warranty
without prior notice or obligation to upgrade
your soft top.
What is Not Covered:
Your Quadratec Limited Warranty does not
cover products or parts Quadratec determi-
nes to have been damaged by or subjec-
ted to: (a.) installation damage, alteration,
modication, failure to maintain or attempted
repair or service by anyone not authorized
by Quadratec, (b.) normal wear and tear,
cosmetic damage or damage from
water immersion, (c.) Acts of God, accidents,
misuse, negligence, inadequate mounting
or impact with vehicle(s), obstacles or other
aspects of the environment, (d.) theft, vanda-
Remedy Limited to Repair/Replacement:
The exclusive remedy provided hereun-
der shall, upon Quadratec inspection and
at Quadratec’s option, be either repair or
replacement of product or parts (new or
refurbished) covered under this Limited
Warranty. Customers requesting warranty
consideration on QuadraTop soft top should
rst contact Quadratec to obtain a RGA
number (610-701-3336). All labor, removal,
shipping and installation costs are custo-
mer’s responsibility.
Other Limitations - Exclusion of Damages
- Your Rights Under State Law:
In consideration of the purchase price paid,
neither Quadratec nor any independent
Quadratec distributor/licensee are responsi-
ble for any time loss, rental costs, or for any
incidental, consequen- tial, punitive or other
damages you may have or incur in connec-
tion with any part or product purchased. Your
exclusive remedy hereunder
for covered parts is repair/replacement as
described above.
This Limited Warranty gives you specic
rights. You may also have other rights that
vary from state to state. For example, some
states do not allow limitations of how long an
implied warranty lasts and/or do not allow the
exclusion or limitation of incidental or con-
sequential damages, so the limitations and
exclusions herein may not apply to you.
The terms Quadratec®, QuadraTop®
Essentials® and Essential® are Registered
Trademarks of Quadratec Inc. Registered in
U.S. Patent and Trademark Oce.
©Quadratec, Inc. 2021. All Rights Reserved.
Version 12.14.21
Part # 92034.1018
Quadratec®Exclusive Three
Year Limited Warranty