RealFlame 5757 User manual

Mantel Assembly Instructions
Model # 5757
Marco Fireplace
LOT#
PO#

WARNING !!
Read entire label and all instructions included with fireplace fuel and fireplace
If you have questions please call customer service at: 1-800-654-1704
NOTICE: Buyer assumes all responsibility for safety and use that is not in accordance with these instructions and warnings.
1. Never touch logs, fireplace fuel cans or any other surfaces during or immediately after burning fireplace fuel.
They will be extremely HOT. Allow surfaces to cool for 20 minutes before touching or refuelling.
2. Make sure fireplace is operated on a flat, level and stable surface. Keep fireplace stable at all times
3. WARNING: Never alter or dismantle the fireplace, metal firebox or logset in any manner.
4. Never store or use gasoline or any other flammable vapors, liquids, or materials in the vicinity of the fireplace
and fireplace fuel.
5. Burn only Real Flame® fireplace fuel in this fireplace. Never burn trash, paper, or wood in the fireplace.
5. Never leave a burning fire unattended, especially AROUND CHILDREN OR PETS.
6. Fireplace is not to be operated by anyone below age 18. Keep away from children and pets.
7. Never burn fireplace fuel outside the designated burn areas in metal firebox. Wipe up spills right away with a
paper towel or rag.
8. Do not burn more than three cans of fuel in the firebox at any one time.
9. Do not wear flammable or loose clothing when operating the fireplace.
10. Do not place more than 100 lbs. of weight on the top of the fireplace at anytime.
11. Never move fireplace while in use. Do not attempt to move fireplace until 30 minutes after
fireplace fuel has been extinguished.
12. Do not place fireplace in high traffic areas, such as a hallway or entryway.
13. Exercise the same precautions as you would with any open fire.
Fireplace fuel is flammable. Failure to follow warnings can result in property damage or serious burns.
Do not attempt to pourany kind of fuel on a fire that is already burning. Flare-ups or flashbacks can
occur if you do. Allow unit to cool for 20 minutes before refueling or removing cans of fuel.
Use only Real Flame® Fireplace fuel in this unit. Do not use with any other fuel or flammable material. Do not
attempt to refill cans of fireplace fuel.
Do not store or use gasoline or other flammable materials, including fireplace fuel, near this product. Vapors from
these types of items may collect and increase the risk of fire, explosion or injury.
In case of an emergency use a CO2 extinguisher or baking soda to extinguish the fire.
RF Mantle WARNINGS Rev7 050812
-
-
-
-
-
Using your
Fireplace
-Fireplace is designed to be used indoors, there is no need for ventilation.
-Before using unit, be sure you have read and understood all of the
step-by-step instructions.
-After several burns, soot may develop on the inside of the firebox. Clean with
a damp soapy rag or any household glass cleaner.
-During the initial burn you may experience a slight odor. Odor is temporary
and will be absent on following burns.
FLAMMABLE Real Flame Fireplace Fuel contains isopropyl alcohol.
Avoid contact with eyes, mucous membranes or prolonged contact with skin. May
irritate eyes. Store in a cool, dry place. Keep away from flame, heat or items that
spark. Use in well-ventilated areas. Keep out of reach of children and pets. In case
of fire, use a CO2 fire extinguisher or baking soda.
FIREPLACE
FUEL
If fuel gets in eyes, flush with water for 15 minutes; get medical attention. If ingested,
do not induce vomiting; call a poison control center a doctor.
FIRST AID
HAZARDS
PROPERTY DAMAGE, SERIOUS INJURY OR DEATHmay result if these warnings are not followed
Precautions
2

3
PARTS LIST
Number Description alnut Black Quantity
Box 1 includes-
1 Base Panel 57571101J 57570101J 1
7 Base Panel Support 57570007J 57570007J 2
11 Top Panel 57571111J 57570111J 1
12 Shelf Panel 57571112J 57570112J 3
Box 3 includes-
2 Left Outside Panel 57571102J 57570102J 1
3 Right Outside Panel 57571103J 57570103J 1
4 Left Inside Panel 57571104J 57570104J 1
5 Right Inside Panel 57571105J 57570105J 1
6 Foot 57571106J 57570106J 4
8 Lower Firebox Trim 57571108J 57570108J 1
9 Upper Firebox Trim 57571109J 57570109J 1
10 Firebox Support 57570010J 57570010J 1
12 Shelf Panel 57571112J 57570112J 1
13 Back Panel 57571113J 57570113J 2
14 Hardware Kit 57570014J 57570014J 1
HARDWARE KIT – 5757001 JW
A x 24
3 in 1 Bolt
B x 24
Excenter Fitting
C x18
Long Allen Screw
D x 4
asher
E x 1
Allen rench
F x 26
Back Panel Screw
G x 16
Shelf Panel Support
1
2 3
4 5
6
8
7
6
6
6
7
9
10
11
12
12
12
12
13
13

4
Step One
-Join two base panel supports (7) with base panel (1) by securing 4 long allen screws (C).
-Attach four feet (6) by securing 8 long allen screws (C).
Step Two
-Screw twelve 3-in-1 bolts (A) to base panel (1).
-Screw twelve 3-in-1 bolts (A) to top panel (11).
1
6
6 6
6
7 7
C C
1
11
A
A

5
Step Three
-Set base panel (1) on a flat surface as shown.
-Join panel (2), (3), (4), (5) by inserting 12 bolts (A) in the holes of the four panels. Using 12
excenter fittings (B) to lock the bolts.
Step Four
-Attach lower firebox trim (8) to inside panel (4), (5) by securing 2 long allen screws (C) through
2 washers (D).
-Repeat with upper firebox trim (9).
-Attach firebox support (10) to base panel (1) by securing 2 long allen screws (C).
1
3 5 4 2
B
A
1
10
9
8
C
C
D
C D
5 4

6
Step Five
-Locate top panel (11) to above finished parts.
-Join panel (2), (3), (4), (5) by inserting twelve bolts (A) in the holes of the four panels. Using twelve
excenter fittings (B) to lock the bolts.
Step Six
-Insert 4 shelf panel support (G) to the holes of the panel (2), (3), (4), (5) respectively. Keep every 2
supports on parallel.
-Put on four shelf panels (12) on the shelf panel supports.
5 3 4 2
11
B
A
12
12
12
12
G

7
Step Seven
-Attach two back panels (13) to above finish parts by securing 26 back panel screws (F).
Step Eight
For next step reference the instruction manual included with your firebox.
If you do not have an instruction manual included with your firebox do not attempt to
assemble or operate. Immediately call our customer service department
at 1-800-654-1704 for a replacement manual.
ARNING: Do not operate your firebox without reading all instructions and warnings
prior to use.
13 13
F

8
Customer Service: 1-800-654-1704 in USA
Service à la clientèle: 1-800-363-6443 in Canada
custserv@realflame.com
Warranty & Return Policies
Real Flame®
7800 Northwestern Ave.
Racine, WI 53403
Warranty
Jensen Metal Products, Inc., doing business as Real Flame®, warrants Real Flame vent-less
fireplaces and accessories to be free from defects in parts and workmanship under normal use and
service for a period of 90 days from the date of purchase. In the event of such defects Real Flame
will, at its option, replace the defective product or refund the purchase price. The foregoing is the
exclusive remedy and Real Flame disclaims all other warranties, including any implied warranty of
merchantability or fitness for a particular purpose. In addition, Real Flame will not be responsible
for consequential damages in excess of the purchase price of the product on which such liability is
based. Electric fireplaces carry a one-year warranty on the electric firebox only.
Return Policy
You may return your purchase within 90 days of receipt. No refunds will be issued for incomplete
or unauthorized returns. All returned products must be 100% complete, adequately packaged in
original packaging and in resalable condition. Products that have been assembled or modified will
not be eligible for return. All items must be returned in their entirety, meaning all items included
must be returned together. No returns or exchanges on discontinued items. Please begin the return
process by contacting the store or company where you bought your Real Flame item.
Replacement Parts
In the event that an item has been lost or damaged either by the manufacturer or in shipping you
may request a replacement. Replacement parts are not available for all units and only given at Real
Flame’s discretion. We will assess any damage and find a solution, which could include ordering
and shipping a replacement to you. No replacements are available for discontinued items or
repackaged (open box) products. Please call Real Flame Customer Service at 800-654-1704 for
replacement parts before returning the damaged item. Please have the following information,
which can be found in your instruction manual, ready before you call Customer Service.
• Model Number of Item
• 4-8 digit Part Number
• Lot Code Number
• Shipping Address
• A picture of the damaged item may be requested. Pictures should be
sent to custserv@realflame.com
Incorrect Order Received
If you received something other than you ordered, please contact Real Flame Customer Service at
800-654-1704 within 48 hours of receiving the item.
Please refer to www.Realflame.com for our complete return guidelines and policies.