Rhino-Rack SX029 User manual

!
! !
üü
km/h
X
X
WARNING! Important Load Carrying Instructions
With utility vehicles, the cabin and the canopy move independently.
Roofracks and vehicle can be damaged if the item transported is
rigidly xed at points on both the cabin and canopy. Instead, rigidly
x to either the cabin roofracks or the canopy roofracks.
YES
YES
NO
2 x Crossbars = 5kg/11lbs
Max. 100kg/220lbs
Urban road
Max. 66kg/145lbs
Off-road
- Any load transported on Roof Racks must be evenly distributed.
- Instructions are to remain with the vehicle.
- Do not attempt to t the roof racks to your vehicle unless you fully read and understand the tting instructions provided.
- Please direct any questions to the dealer from where the roof racks were purchased.
-Check the contents of this kit before commencing tment and report any discrepancies.
WARNING!
ü
ü
?? kg
?? lbs
Maximum load capacity: 50/100kg - 110/220lbs. Please refer to your vehicle manufacturers handbook for
maximum roof load capacity, always use the lower of the two gures. Load gures shown reect the use of two
bars.
Recommendations:
It is essential that all bolt connections be checked after driving a short distance when you rst install your crossbars.
Bolt connections should be checked and lubricated at regular intervals (probably once a week is enough, depending
on road conditions, usage, loads and distances travelled). You should also check the crossbars each time they are
retted. Make sure to fasten your load securely. Please ensure that all loads are evenly distributed and that the centre
of gravity is kept as low as possible. Crossbars must be removed when putting vehicle through an automatic car
wash. Use only non-stretch fastening ropes or straps.
Caution: The handling characteristics of the vehicle changes when you transport a load on the roof. For safety rea-
sons we recommend you exercise extreme care when transporting wind-resistant loads. Special consideration must
be taken into account when cornering and braking.
Off-road Load Rating:
When crossbars are to be used in off-road conditions, please build a safety factor of 1.5 into this load limit for off-road
use, two crossbars = 33/66kg - 73/145lbs. Although the crossbars are tested and approved to AS1235-2000, off-road
conditions can be much more rigorous. However, increasing the number of crossbars does not increase the
vehicles maximum permissible roof loading.
SX029

SX029
1
1
1
2
3
3
OK!
Open
4
X X = Y Y
1
1
2
3
3
OK!
Open
4
X X = Y Y
Care Instruction:
Wash and clean vehicle roof rails prior to tting
the roof racks.
Item Component Name Qty Part No.
1Vortex Generating Strip 2-4 M626
2 Crossbar 2 VA---
3 End Cap 4 M645
4a* End Cap Locking 4 VA-LEC4
4b* Lock Barrel Key 3 CA1069
5Crossbar Under bar Strip 4 M641
6 Foot Unit 4 3701
7Plastic Lock Key Suit 3121091
8Torque Security Key for
SXB 1TORKEY-SXB
9Fitting Instruction 1R405
Tools:
1
2
3
4a,b*
5
6
7
8
Important: Items 1,2,3 and 5 sold as separate kit.
*Optional Extra

SX029
Fit legs as shown.
3
2
1
1
2
3
3
OK!
Open
4
X X = Y Y
1
1
2
3
3
OK!
Open
4
X X = Y Y
4
5 Nm
Open
OK!
OK!
BMW
Volvo
Open
Locked
5
1
1
2
3
3
OK!
Open
4
X X = Y Y

SX029
1
1
2
3
3
OK!
Open
4
X X = Y Y
5 Nm
Open
OK!
OK!
BMW
Volvo
Open
Locked
67
1
1
2
3
3
OK!
Open
4
X X = Y Y
8
9
5 Nm
Open
OK!
OK!
BMW
Volvo
Open
Locked
5 Nm
Open
OK!
OK!
BMW
Volvo
Open
Locked
1
1
2
3
3
OK!
Open
4
X X = Y Y
Accept no compromises, choose only quality roof racks.