Robustel GoRugged R3000 Lite User manual

Robustel GoRugged R3000 Wireline
Industrial VPN Router - 4 Ethernet Ports
User Guide
Document Name: User Guide
Firmware: 1.2.8
Date: 2015-07-02
Status: Confidential
Doc ID:RT_UG_R3000 Wireline- 4 Ethernet Ports_v.1.1.0
www.robustel.com

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 1 / 116
Confidential
About This Document
This document describes hardware and software of Robustel R3000 Wireline, Industrial VPN Router.
Copyright© Guangzhou Robustel Technologies Co., Limited
All Rights Reserved.
Trademarks and Permissions
Robustel are trademark of Guangzhou Robustel Technologies Co., Limited.
All other trademarks and trade names mentioned in this document are the property of their respective holders.
Disclaimer
No part of this document may be reproduced in any form without the written permission of the copyright owner.
The contents of this document are subject to revision without notice due to continued progress in methodology,
design and manufacturing. Robustel shall have no liability for any error or damage of any kind resulting from the use
of this document.
Technical Support Contact Information
Tel: [phone]
Fax: [phone]
E-mail: [e-mail]
Web: www.robustel.com

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 2 / 116
Confidential
Important Notice
Due to the nature of wireless communications, transmission and reception of data can never be guaranteed. Data
may be delayed, corrupted (i.e., have errors) or be totally lost. Although significant delays or losses of data are rare
when wireless devices such as the router is used in a normal manner with a well-constructed network, the router
should not be used in situations where failure to transmit or receive data could result in damage of any kind to the
user or any other party, including but not limited to personal injury, death, or loss of property. Robustel accepts no
responsibility for damages of any kind resulting from delays or errors in data transmitted or received using the
router, or for failure of the router to transmit or receive such data.
Safety Precautions
General
The router generates radio frequency (RF) power. When using the router, care must be taken on safety issues
related to RF interference as well as regulations of RF equipment.
Do not use your router in aircraft, hospitals, petrol stations or in places where using cellular products is
prohibited.
Be sure that the router will not be interfering with nearby equipment. For example: pacemakers or medical
equipment. The antenna of the router should be away from computers, office equipment, home appliance, etc.
An external antenna must be connected to the router for proper operation. Only uses approved antenna with
the router. Please contact authorized distributor on finding an approved antenna.
Always keep the antenna with minimum safety distance of 20 cm or more from human body. Do not put the
antenna inside metallic box, containers, etc.
RF exposure statements
1. For mobile devices without co-location (the transmitting antenna is installed or located more than 20cm
away from the body of user and nearby person)
FCC RF Radiation Exposure Statement
1. This Transmitter must not be co-located or operating in conjunction with any other antenna or transmitter.
2. This equipment complies with FCC RF radiation exposure limits set forth for an uncontrolled environment.
This equipment should be installed and operated with a minimum distance of 20 centimeters between the
radiator and human body.
Note: Some airlines may permit the use of cellular phones while the aircraft is on the ground and the door is open.
Router may be used at this time.
Using the router in vehicle
Check for any regulation or law authorizing the use of cellular devices in vehicle in your country before installing
the router.
The driver or operator of any vehicle should not operate the router while driving.
Install the router by qualified personnel. Consult your vehicle distributor for any possible interference of
electronic parts by the router.
The router should be connected to the vehicle’s supply system by using a fuse-protected terminal in the
vehicle’s fuse box.
Be careful when the router is powered by the vehicle’s main battery. The battery may be drained after extended
period.
Protecting your router
To ensure error-free usage, please install and operate your router with care. Do remember the following:

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 3 / 116
Confidential
Do not expose the router to extreme conditions such as high humidity / rain, high temperatures, direct sunlight,
caustic / harsh chemicals, dust, or water.
Do not try to disassemble or modify the router. There is no user serviceable part inside and the warranty would
be void.
Do not drop, hit or shake the router. Do not use the router under extreme vibrating conditions.
Do not pull the antenna or power supply cable. Attach/detach by holding the connector.
Connect the router only according to the instruction manual. Failure to do it will void the warranty.
In case of problem, please contact authorized distributor.

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 4 / 116
Confidential
Regulatory and Type Approval Information
Table 1: Directives
2011/65/EC
Directive 2011/65/EU of the European Parliament and of the Council of 8 June 2011
on the restriction of the use of certain hazardous substances in electrical and
electronic equipment (RoHS)
2012/19/EU
Directive 2012/19/EU the European Parliament and of the Council
of 4 July 2012 on waste electrical and electronic equipment (WEEE)
Table 2: Standards of the Ministry of Information Industry of the People’s Republic of China
SJ/T
11363-2006
“Requirements for Concentration Limits for Certain Hazardous Substances in Electronic
Information Products” (2006-06).
SJ/T
11364-2006
“Marking for Control of Pollution Caused by Electronic Information Products”
(2006-06).
According to the “Chinese Administration on the Control of Pollution caused
by Electronic Information Products” (ACPEIP) the EPUP, i.e., Environmental
Protection Use Period, of this product is 20 years as per the symbol shown here, unless otherwise
marked. The EPUP is valid only as long as the product is operated within the operating limits
described in the Hardware Interface Description.
Please see Table 3 for an overview of toxic or hazardous substances or elements that might be
contained in product parts in concentrations above the limits defined by SJ/T 11363-2006.
Table 3: Toxic or hazardous substances or elements with defined concentration limits
Name of the part
Hazardous substances
(Pb)
(Hg)
(Cd)
(Cr (VI) )
(PBB)
(PBDE)
Metal Parts
o
o
o
o
o
o
Circuit Modules
x
o
o
o
o
o
Cables and Cable Assemblies
o
o
o
o
o
o
Plastic and Polymeric parts
o
o
o
o
o
o
o:
Indicates that this toxic or hazardous substance contained in all of the homogeneous materials for this part is
below the limit requirement in SJ/T11363-2006.
x:
Indicates that this toxic or hazardous substance contained in at least one of the homogeneous materials for this
part might exceed the limit requirement in SJ/T11363-2006.

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 5 / 116
Confidential
Revision History
Updates between document versions are cumulative. Therefore, the latest document version contains all updates
made to previous versions.
Release Date
Firmware Version
Doc Version
Details
2015-01-06
1.02.00
V1.0.0
First Release
2015-07-02
1.2.8
V1.1.0
Increase section: Download MIB Moudles File, GpsGate
portal
Modify section: Mount the Route, file format, Sentence
Revision, Approval & Certification, Regulatory and Type
Approval Information, SDK Management, CLI command

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 6 / 116
Confidential
Contents
Chapter 1 Product Concept......................................................................................................................................... 8
1.1 Overview .................................................................................................................................................... 8
1.2 Packing List ................................................................................................................................................. 8
1.3 Specifications ........................................................................................................................................... 10
1.4 Selection and Ordering Data ....................................................................................................................12
Chapter 2 Installation................................................................................................................................................ 13
2.1 LED Indicators........................................................................................................................................... 13
2.2 PIN assignment......................................................................................................................................... 14
2.3 USB interface............................................................................................................................................15
2.4 Reset Button............................................................................................................................................. 15
2.5 Ethernet ports .......................................................................................................................................... 16
2.6 Mount the Router .................................................................................................................................... 17
2.7 Ground the Router ................................................................................................................................... 18
2.8 Power Supply............................................................................................................................................ 18
Chapter 3 Configuration settings over web browser ................................................................................................19
3.1 Configuring PC in Windows 7 ................................................................................................................... 19
3.2 Factory Default Settings ...........................................................................................................................21
3.3 Control Panel............................................................................................................................................ 22
3.4 Status -> System .......................................................................................................................................23
3.5Status -> Network..................................................................................................................................... 25
3.6 Status -> Route ......................................................................................................................................... 26
3.7 Status -> VPN............................................................................................................................................26
3.8 Status -> Services ..................................................................................................................................... 27
3.9 Status -> Event/Log .................................................................................................................................. 28
3.10 Configuration -> Link Management..........................................................................................................29
3.11 Configuration -> Ethernet.........................................................................................................................30
3.12 Configuration -> WiFi ............................................................................................................................... 35
3.13 Configuration -> Serial.............................................................................................................................. 40
3.14 Configuration -> USB ................................................................................................................................ 47
3.15 Configuration -> GPS ................................................................................................................................ 47
3.16 Configuration -> NAT/DMZ .......................................................................................................................50
3.17 Configuration -> Firewall .......................................................................................................................... 52
3.18 Configuration -> QoS ................................................................................................................................ 54
3.19 Configuration -> IP Routing ......................................................................................................................58
3.20 Configuration -> DynDNS ......................................................................................................................... 60
3.21 Configuration -> IPSec .............................................................................................................................. 61
3.22 Configuration -> Open VPN ...................................................................................................................... 66
3.23 Configuration -> GRE ................................................................................................................................ 71
3.24 Configuration -> L2TP............................................................................................................................... 72
3.25 Configuration -> PPTP............................................................................................................................... 75
3.26 Configuration -> SNMP.............................................................................................................................79
3.27 Configuration -> VRRP..............................................................................................................................81

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 7 / 116
Confidential
3.28 Configuration -> Reboot........................................................................................................................... 82
3.29 Configuration -> Portal ............................................................................................................................. 82
3.30 Configuration -> Syslog............................................................................................................................. 84
3.31 Configuration -> Event..............................................................................................................................84
3.32 Configuration -> USR LED ......................................................................................................................... 85
3.33 Configuration -> RobustVPN.....................................................................................................................86
3.34 Administration -> Profile ..........................................................................................................................86
3.35 Administration -> Tools ............................................................................................................................87
3.36 Administration -> Clock ............................................................................................................................91
3.37 Administration -> Web Server.................................................................................................................. 92
3.38 Administration -> User Management.......................................................................................................93
3.39 Administration -> SDK Management........................................................................................................94
3.40 Administration -> Update Firmware......................................................................................................... 95
Chapter 4 Configuration Examples ........................................................................................................................... 97
4.1 Interface ...................................................................................................................................................97
4.1.1 Console port .....................................................................................................................................97
4.1.2 RS232 ................................................................................................................................................98
4.1.3 RS485 ................................................................................................................................................98
4.2 Network.................................................................................................................................................... 99
4.2.1 NAT....................................................................................................................................................99
4.2.2 L2TP ................................................................................................................................................ 100
4.2.3 PPTP................................................................................................................................................ 101
4.2.4 IPsec VPN ........................................................................................................................................ 103
4.2.5 OpenVPN ........................................................................................................................................ 106
Chapter 5 Introductions for CLI...............................................................................................................................109
5.1 What’s CLI and hierarchy level Mode..................................................................................................... 109
5.2 How to configure the CLI........................................................................................................................111
5.3 Commands reference ............................................................................................................................. 113
Glossary......................................................................................................................................................................... 114

Chapter 1 Product Concept
1.1 Overview
Robustel GoRugged R3000 Wireline is a rugged VPN router offering state-of-the-art secure connectivity for machine
to machine (M2M) applications.
WAN link management: Ethernet WAN/WLAN WAN backup.
VPN tunnel: IPSec/OpenVPN/PPTP/L2TP/GRE.
Supports Modbus gateway (Modbus RTU/ASCII to Modbus TCP).
Supports GPS&GLONASS (optional), provides real time location and tracking.
Supports 802.11 b/g/n Wi-Fi (optional), AP and client mode.
Supports SDK, provides user programmatic interface.
Supports 802.1Q VLAN Trunk.
Auto reboot via Timing.
Supports RobustLink (Centralized M2M management platform, to remote monitor, configure and update
firmware).
Supports RobustVPN (Cloud VPN Portal, to provide easy and secure remote access for PLCs and machines).
Flexible Management methods: Web/CLI/SNMP/RobustLink.
Firmware upgrade via Web/CLI/USB/RobustLink.
Various interfaces: RS232/RS485/Console/USB/Ethernet.
Wide range input voltages from 9 to 60 VDC and extreme operating temperature.
The metal enclosure can be mounted on a DIN-rail or on the wall, also with extra ground screw.
1.2 Packing List
Check your package to make sure it contains the following items:
Robustel GoRugged R3000 Wireline router x 1

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 9 / 116
Confidential
3-pin pluggable terminal block with lock for power connector x 1
7-pin pluggable terminal block with lock for serial port and console port x 1
CD with user guide x 1
Note: Please notify your sales representative if any of the above items are missing or damaged.
Ethernet cable x 1
Wall Mounting Kit
35mm Din-Rail mounting kit

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 10 / 116
Confidential
AC/DC Power Supply Adapter (12VDC, 1.5A) x 1 (EU, US, UK, AU plug optional)
1.3 Specifications
Ethernet Interface
Number of Ports: 4 x 10/100 Mbps, 3 LAN+1 WAN
Magnet Isolation Protection: 1.5KV
WLAN Interface (Optional)
Standards: 802.11b/g/n up to 65 Mbps, AP and Client mode
Frequency Band: 2.400 - 2.500 GHz (2.4 GHz ISM band)
Security: Open ,WPA, WPA2
Encryption: AES, TKIP
Antenna Interface: SMA Female
Transmission Power: 802.11b: 17dBm, 802.11g/n: 15dBm
Reception Sensibility: 1M: -97dBm, 2M: -93dBm, 6M: -91dBm, 11M: -89dBm, 54M: -75dBm, 65M: -72dBm
GPS&GLONASS Interface (Optional)
Antenna Interface: SMA Female, 50 ohms impedance
Tracking Sensitivity: GPS: better than -148 dBm
GLONASS: better than -140 dBm
Time-To-First-Fix: GPS: 26 s

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 11 / 116
Confidential
GLONASS: 30 s
Protocol: NMEA-0183 V2.3
Serial Interface
Number of Ports: 1 x RS-232 or 1 x RS-485
ESD Protection: ±15KV
Parameters: 8E1, 8O1, 8N1, 8N2, 7E2, 7O2, 7N2, 7E1
Baud Rate: 300bps to 230400bps
RS-232: TxD, RxD, RTS, CTS, GND
RS-485: Data+ (A), Data- (B)
Interface: 3.5mm terminal block with lock
System
LED Indicators: RUN, WLAN, USR
Built-in RTC, Watchdog, Timer
Expansion: 1 x USB 2.0 host up to 480 Mbps
Storage: 1 x MicroSD
Software
Network protocols: PPPoE, TCP, UDP, DHCP, ICMP, NAT, DMZ, RIP v1/v2, OSPF, DDNS, VRRP, HTTP, HTTPs, DNS, ARP,
QoS, SNTP, Telnet, VLAN, SSH2, etc
VPN tunnel: IPSec/OpenVPN/PPTP/L2TP/GRE
Firewall: SPI, anti-DoS, Filter, Access Control
Management: Web, CLI, SNMP v1/v2/v3, RobustLink
Serial Port: TCP client/server, UDP, Modbus RTU/ASCII to Modbus TCP, Virtual COM (COM port redirector)
RobustLink: Centralized M2M management platform
RobustVPN: Cloud VPN Portal
Power Supply and Consumption
Power Supply Interface: 5mm terminal block with lock
Input Voltage: 9 to 60 VDC
Power Consumption: Idle: 100 mA @ 12 V
Data Link: 400 mA (peak) @ 12 V

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 12 / 116
Confidential
Physical Characteristics
Housing & Weight: Metal, 500g
Dimension: (L x W x H): 125 x 108 x 45 mm
Installation: 35mm Din-Rail or wall mounting or desktop
Environmental Limits
Operating Temperature & Humidity: -40 to 85°C , 95% RH
Regulatory and Type Approvals
Approval & Certification: CE, R&TTE, FCC, RCM, RoHS, WEEE
EMI: EN 55022 (2006/A1: 2007) Class B
EMC: EN 61000-4-2 (ESD) Level 3, EN 61000-4-3 (RS) Level 4
EN 61000-4-4 (EFT) Level 4, EN 61000-4-5 (Surge) Level 3
EN 61000-4-6 (CS) Level 4, EN 61000-4-8, Level 4
1.4 Selection and Ordering Data
Please refer to corresponding R3000 Wireline datasheet.

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 13 / 116
Confidential
Chapter 2 Installation
2.1 LED Indicators
With Wi-Fi Without Wi-Fi
Note: User can select display status of USR LED. For details please refer to section 1.3.32.
Name
Color
Status
Function
RUN
Green
Blinking
Router is ready.
On
Router is starting.
Off
Router is power off.
WLAN
Green
Blinking
WLAN Indicator: Data is being transmitted.
On
WLAN Indicator: Wi-Fi AP/Client is enabled.
Off
WLAN Indicator: Wi-Fi AP/Client is disabled.
USR
Green
On/Blinking
VPN tunnel/PPPoE/DynDNS/GPS is up.
Off
VPN tunnel/PPPoE/ DynDNS/GPS is down.

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 14 / 116
Confidential
2.2 PIN assignment
PIN assignment of R3000-QLA
PIN assignment of R3000-QLB
PIN
Debug
RS232
Direction
1
RXD
Device R3000
2
TXD
R3000 Device
3
GND
GND
4
TXD
R3000 Device
5
RXD
Device R3000
6
RTS
R3000 Device
7
CTS
Device R3000
PIN
Power
Digital I/O
RS485
8
Positive
9
Negative
10
GND
PIN
Debug
RS485
Direction
1
RXD
Device R3000
2
TXD
R3000 Device
3
GND
4
Data+(A)
5
Data- (B)
6
7
PIN
Power
Digital I/O
RS485
8
Positive
9
Negative
10
GND

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 15 / 116
Confidential
2.3 USB interface
2.4 Reset Button
Function
Operation
Reset
Push the button for 5 seconds under working status.
Restore to factory
default setting
Push the button for 60 seconds once you power on the
router until all the three LEDs at the left side (RUN,
PPP, USR) blink at the same time for 5 times.
USB Interface
USB interface is used for batch firmware upgrade, cannot used to send or
receive data from slave devices which with USB interface.
Users can insert a USB storage device, such as U disk or hard disk, into the
router’s USB interface, if there is configuration file or firmware of R3000
inside the USB storage devices, R3000 will automatically update the
configuration file or firmware. For details please refer to section 1.3.14.
Reset Button

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 16 / 116
Confidential
2.5 Ethernet ports
Each Ethernet port has two LED indicators (please check the following
picture). The yellow one is Speed indicator and the green one is Link
indicator. There are three status of each indicator. For details please refer
to the form below.
Indicator
Status
Description
Speed Indicator
Off
10 Mbps mode.
On
100 Mbps mode.
Link Indicator
Off
Connection is down.
On
Connection is up.
Blink
Data is being transmitted
Ethernet ports
Ethernet Ports

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 17 / 116
Confidential
2.6 Mount the Router
Two ways of mounting the router
1. Use 3 pcs of M3 screw to mount the router on the Wall mounting Kit.
And then use 2 pcs of M3 screw to mount the Wall mounting Kit on the wall.
2. Mount the router on a DIN rail with 3 pcs of M3 screws, and then hang the DIN-Rail on the holder.
You need to choose a standard holder.

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 18 / 116
Confidential
2.7 Ground the Router
Grounding and wire router helps limit the effects of noise due to electromagnetic interference (EMI). Run the ground
connection from the ground by screwing to the grounding surface before connecting devices.
Note: This product is intended to be mounted to a well-grounded mounting surface, such as a metal panel.
2.8 Power Supply
The power supply range is 9 to 60 VDC.
Note: Please take care about the polarity, and do not make reverse connection. There are two lines connecting to the
power supply adapter, as it illustrates on the power supply adapter label, the line printed with letters needs to be
connected with the positive polarity, and the striped line needs to be connected with the negative polarity.
Screw

Robustel GoRugged R3000 Wireline - 4 Ethernet Ports User Guide
RT_UG_R3000 Wireline- 4 Ethernet Ports _v.1.1.0 02.07.2015 19 / 116
Confidential
Chapter 3 Configuration settings over web browser
The router can be configured through your web browser that include IE 8.0 or above, Chrome and Firefox. A web
browser is included as a standard application in the following operating systems: Linux, Mac OS, Windows
98/NT/2000/XP/Me/Vista/7/8, etc. It provides an easy and user-friendly interface for configuration.
There are various ways to connect the router, either through an external repeater/hub or connect directly to your PC.
However, make sure that your PC has an Ethernet interface properly installed prior to connecting the router.
You must configure your PC to obtain an IP address through a DHCP server or a fixed IP address that must be in the
same subnet as the router. If you encounter any problems accessing the router web interface it is advisable to
uninstall your firewall program on your PC, as this tends to cause problems accessing the IP address of the router.
3.1 Configuring PC in Windows 7
The configuration for windows system is similar.
1. Go to Start / Control Panel (in Classic View). In the Control Panel, double-click Network Connections.
2. Double-click Local Area Connection.
3. In the Local Area Connection Status window, click Properties.