Sealey LED3602R.V3 User manual

360° 4W & 3W SMD LED RECHARGEABLE
INSPECTION LIGHTS
MODEL NO: LED3602.V3, LED3602R.V3, LED3602G.V3,
LED3602B.V3, LED3602Y.V3, LED3602CF.V3
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGEAND/OR
PERSONAL INJURYAND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY
9Inspect the cable and connector for wear and damage to ensure items are safe before connecting to the power supply. If worn or
damaged DO NOT use.
9Ensure the light is fully charged before initial use.
8DO NOT charge in damp conditions.
8DO NOT turn the light on when it is being charged.
8DO NOT shine directly into your, another person’s or an animal’s eyes.
8DO NOT allow children to use the light.
8DO NOT handle or move the light whilst it is being charged.
8DO NOT use the light if you suspect that the battery or the light casing is damaged.
8DO NOT leave battery in a discharged state, recharge battery immediately. Before storage, fully recharge the battery, subsequently
recharge the battery at least once every six months of non-use.
8DO NOT attempt to open, disassemble, modify or service the battery pack.
8DO NOT crush, puncture, short external contacts or dispose of in re or water.
8DO NOT expose to temperatures above 60°C (140°).
9Replace only with the battery pack designated for this product.
9Recycle or dispose of used battery as stipulated by local regulation.
9If the electrolyte in the cells gets on your skin, thoroughly wash with soap and water. If it gets in your eyes, rinse thoroughly with
cool water and seek immediate medical attention.
2. INTRODUCTION
Unique and innovative 360° swivel and tilt function enables the light source to be positioned in any direction. Exclusive patented design
owned by and registered to Sealey. 4W SMD LED with magnied lens providing up to 400 lumens output with 120° spread of light,
illuminating the whole work area. Includes an additional high power 3W LED directional torch. Features two swivel hooks and three
rubber covered magnets, two on the rear and one on the end, which allow hands-free operation. High quality 2.2Ah lithium-ion battery
for longer life, no memory e󰀨ect and a much slower discharge than traditional Ni-MH batteries. Micro USB charging port. Supplied with
USB cable. (Mains charger not included).
3. SPECIFICATION
IMPORTANT WARRANTY INFORMATION
The battery tted to this light is considered to be a consumable item and its ability to accept a charge will reduce over time. We will
provide warranty against mechanical and electrical defect for a period of one year - this does not cover fair wear and tear. If the battery
is not properly charged before rst use, or regularly conditioned, its capacity will diminish. Under these circumstances we will not
replace the battery regardless of whether the battery less than one year old.
LED3602R.V3, LED3602.V3, LED3602G.V3, LED3602B.V3, LED3602Y.V3, LED3602CF.V3, Issue 3 (H,3) 27/09/23
Original Language Version
© Jack Sealey Limited
Refer to
instructions
Model No: LED3602.V3 LED3602.V3 LED3602.V3 LED3602.V3 LED3602.V3 LED3602.V3
Battery: 3.7V 2.2Ah Li-Ion 3.7V 2.2Ah Li-Ion 3.7V 2.2Ah Li-Ion 3.7V 2.2Ah Li-Ion 3.7V 2.2Ah Li-Ion 3.7V 2.2Ah Li-Ion
Charging Time: 3.5hr 3.5hr 3.5hr 3.5hr 3.5hr 3.5hr
IP Rating: IP54 IP54 IP54 IP54 IP54 IP54
LED Type: 4W + 3W SMD 4W + 3W SMD 4W + 3W SMD 4W + 3W SMD 4W + 3W SMD 4W + 3W SMD
Lumen Output Side(High/Low)/Top: (400/200)/120lm (400/200)/120lm (400/200)/120lm (400/200)/120lm (400/200)/120lm (400/200)/120lm
Maximum Length: 270mm 270mm 270mm 270mm 270mm 270mm
Minimum Length: 255mm 255mm 255mm 255mm 255mm 255mm
Operating Time Side(High/Low)/Top: (3/7)8hr (3/7)8hr (3/7)8hr (3/7)8hr (3/7)8hr (3/7)8hr
Case Colour: Red Black Green Blue Yellow Carbon Fibre

4. OPERATION
4.1. Connect the USB lead to the socket on the rear of the light. Plug into USB power supply and turn on, the charging LED (g.2.) on the
light will light RED to show that charging has commenced.
4.2. When the battery has fully charged the LED will turn GREEN.
4.3. Direct the lens away from your eyes before switching on.
4.4. Toggle the light between the end light and side light using the ON/OFF switch, (g.1). The light may be suspended by the hooks or
attached to any ferrous surface by using the magnets.
4.5. When the light is hanging from the hook it can be rotated through 360° for more precise positioning.
4.6. Separate the top and bottom sections by pulling apart. When attached to a ferrous surface, using the base magnet, the light can
be rotated to shine in any direction.
Note: Mains charger not included.
g.1 g.2
Hooks
Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR
01284 757500 [e-mail] www.sealey.co.uk
WEEE REGULATIONS
Dispose of this product at the end of its working life in compliance with the EU Directive on Waste Electrical and Electronic
Equipment (WEEE). When the product is no longer required, it must be disposed of in an environmentally protective way. Contact
your local solid waste authority for recycling information.
NOTE: It is our policy to continually improve products and as such we reserve the right to alter data, specications and component parts
without prior notice.
IMPORTANT: No Liability is accepted for incorrect use of this product.
WARRANTY: Guarantee is 12 months from purchase date, proof of which is required for any claim.
ENVIRONMENT PROTECTION
Recycle unwanted materials instead of disposing of them as waste. All tools, accessories and packaging should be
sorted, taken to a recycling centre and disposed of in a manner which is compatible with the environment. When
the product becomes completely unserviceable and requires disposal, drain any uids (if applicable) into approved
containers and dispose of the product and uids according to local regulations.
LED3602R.V3, LED3602.V3, LED3602G.V3, LED3602B.V3, LED3602Y.V3, LED3602CF.V3, Issue 3 (H,3) 27/09/23
Original Language Version
© Jack Sealey Limited