STEINEL HBS 200 User manual

RoHS
Compliant
HBS-DC
HBS 300 HBS 200
HBS 200
HBS 300
HBS-DC
Installation Instructions
Wireless High Bay Controls
English
I
o
T
E
N
A
B
L
E
D
B
Y

www.autani.com www.autani.com
23
Autani HBS-DC Wireless System
Intended uses
• Forindooruseonly
• Forindividualxturelightingcontrol
withgrouping(zonecontrol)capability
• HBS200orHBS300
• HBS-DC
• Two1/2”KOlocknuts
• Installationinstructions
• HBS-DCRadioModule
Needed for installation
• Wirenutsfortermination
Applications
• HBS300withinstalledHBS-DC:Open
areaswhere360degreecoverageand
wirelesscontrolisdesired,suchas
inwarehouses,distributioncenters,
gymnasiums
• HBS200withinstalledHBS-DC:High
bayaislewayswhereaislecoverage
andwirelesscontrolisdesired
Package Contents
Installation Overview
WARNING
• Turnpoweroatthecircuitbreakerbeforeinstallingthesensor
• Sensormustbeinstalledandusedinaccordancewithappropriateelectricalcodes
and regulations
• Installationbyaqualiedelectricianisrecommended
Communication
Frequency
Transmission Range
2.4GHz

600ft(182.8m)dependingonlineofsight.Rangemaybeless
ifsignalneedstopassthroughobstacles.
Autani HBS-DCWirelessSystemSpecications
Autaniwirelesslightingcontroldeviceswork
togethertocreategroups(orcontrolzones)
withouttheneedforadditionalwiring.
ThedevicesareRFbased,operatingata
frequencyof2.4GHz.

www.autani.com www.autani.com
45
Product Overview HBS 300 with installed HBS-DC Product Overview HBS 200 with installed HBS-DC
120/
230/
277 VAC
50/60Hz
120/
230/
277 VAC
50/60Hz WirelessWireless
PIRPIR Aisle
way
360°
Voltage
Load rating
 
Time delay
Light level
Coverage
RF
Environment
Dimensions
UL and CUL Listed, RoHS Compliant, FCC and IC Compliant
Voltage
Load rating
 
Time delay
Light level
Coverage
RF
Environment
Dimensions
UL and CUL Listed, RoHS Compliant, FCC and IC Compliant
120/230/277VAC,50/60Hz
120VAC:0-800wattballastorTungsten-1/4hp  
230/277VAC:0-1200wattballast
35secto30min
.2-200footcandles;2-2000lux
100x13ft(30.48x3.96m)diameterreach
Seepage3
IP20rated,-4°Fto+122°F,-20°Cto+50°C
3.9x3.9x2.72in;99x99x69.1mm  
nipplelength.62in(15.75mm)
120/230/277VAC,50/60Hz
120VAC:0-800wattballastorTungsten-1/4hp  
230/277VAC:0-1200wattballast
35secto30min
.2-200footcandles;2-2000lux
360°,upto22ft(6.7m)radialreach,   
upto60ft(18.2m)tangentialreach
Seepage3
IP20rated,-4°Fto+122°F,-20°Cto+50°C
3.9x3.9x2.6in;99x99x66mm   
nipplelength.62in(15.75mm)
Product descriptionProduct description
Specications
Specications
TheHBS200HighBayOccupancySensor
providesoccupancybasedlightingcontrol
inhighbayapplicationsandcommunicates
wirelesslytootherdevicestocreategroups
(lightingzones).Thesensorcontainstwo
dual-elementpyroelectricdetectorsandis
engineeredtoperformatawiderangeof
mountingheights,upto45feet.Itmounts
directlytoahighbaylightingxtureor
junctionbox.
TheHBS300withinstalledHBS-DC
HighBayOccupancySensorprovides
occupancybasedlightingcontrolinhigh
bayapplicationsandcommunicates
wirelesslytootherdevicestocreategroups
(lightingzones).Thesensorcontainsthree
dual-elementpyroelectricdetectorsandis
engineeredtoperformatawiderangeof
mountingheights,upto45feet.Itmounts
directlytoahighbaylightingxtureor
junctionbox.
1/2 inch threaded nipple
Lock nuts
Group address DIP switch
Detection lens
Time delay setting DIP switch
Light level trimpot
1/2 inch threaded nipple
Lock nuts
Group address DIP switch
Detection lens
Time delay setting DIP switch
Light level trimpot
1
1
2
2
3
3
4
4
5
5
6
6
IP20IP20
Fixture
or J Box
Mount
Fixture
or J Box
Mount
2
21
1
5
56 6
4
4
3
3
Time
ON
Low
High
1234
Time
ON
1234 Low
High
ON DIP
12345

www.autani.com www.autani.com
67
Product Overview HBS-DC
Communicationfrequency
Operating temperature
Dimensions
Transmission range
5 year warranty, RoHS compliant
2.4GHz
-4°Fto+122°F;-20°Cto+50°C
2.96x1.38x.62in(75.2x35.05x15.75mm)
Specications
2.4GHz
Wireless
600ft(182.8m)dependingonlineofsight.Rangemaybe
lessifsignalneedstopassthroughobstacles.
Installation
Setup & Commissioning
TheHBS-DCtypicallyisfactorypre-
installedtoawirelesscontroldevice.If
installationisnecessary,themodulejust
snapsintotheconnectionterminal.No
toolsarerequired.
Thissensoriscommissionedremotely
throughtheEnergyCentersoftware.
Product description
TheHBS-DCWirelessControlModule
workswithSTEINEL’sHBS200andHBS
300wirelesslightingcontroldevicesto
createcontrolzoneswithouttheneedfor
additionalwiring.
TheHBS-DCtypicallycomespreinstalled
intheSTEINELwirelessdevice.Devices
arecontrolledviaautaniNet,providing
wirelessxturecontrolonanindividualor
groupbasis.ThroughAutani’seasy-to-use
EnergyCenterinterface,userscanchoose
howindividualxturesorgroupswill
behavebasedonchangesinscheduleand
occupancy.Userscaneasilymodifyxture
behaviorandhowlightsaregrouped.

www.autani.com www.autani.com
89
Mounting
Endofxturemounting-
HBS 300, HBS 200
EM 1 Extender Module
Placement guidelines - HBS 300, HBS 200
TheHBS300andHBS200typically
mounttoa1/2”knockoutattheendofa
high/lowbaylightingxture.Thesensor’s
lensshouldbemountedbelowthe
bottomedgeofthexture.
TheEM 1 Extender Moduleis
recommendedforusewiththeHBS300
andHBS200iftheknockoutattheend
ofthextureislocatedgreaterthan1/2”
fromthebottomedgeofthexture.
HBS Sensor
Fixture
• Sensormodulemountstoa1/2”
knockoutofalightingxtureor
junctionbox.
• Detectionlensmusthaveaclear,
unobstructedviewofcontrolledarea
andmustprojectbeyondthelamps.
• Sensorshouldbe6to8feetawayfrom
heating/coolingsupplyducts.
• Idealmountingheightisupto45feet.
• Mustbemountedonastableplatform.
EM 1
Fixture
HBS Sensor
Junctionboxmounting-HBS300,
HBS 200
Wiring - HBS 300, HBS 200
Wheninstalling,makesurepowerhas
beenswitchedoatthebreakerand
checkthatthecircuitisdeadwitha
voltagetester.
Theleadsconsistofthreewires:
Black =line
White =neutral
Red =load
WhentheHBS-DCisinstalled:
Violet =DIM+
Gray =DIM-
Ifindoubt,identifytheindividual
conductorswithavoltagetesteror
contactaqualiedelectrician.
Note1:Dimmingwiresareonlyavailable
withHBS-DCinstalled.
Note2:AllHBSandHBS-DCareClass1
rated.
Ifmountingtotheendofaxtureisnot
possible,theHBS300,HBS200canbe
mountedtoanyjunctionboxwitha1/2”
(tradesize)knockout.WiththeHBS300
andHBS200,thismaybenecessaryif
thexturelocationhasanobstruction
thatwouldblocktheviewofthesensor
(forexample:rackingisdirectlybeneath
thexture).
Junction
box
HBS 300, HBS 200
HBS 300, HBS 200
LINE (BLACK)
NEUTRAL (WHITE)
NEUTRAL
HOT
LOAD (RED)
DIM + (VIOLET)
DIM – (GRAY)
LOAD
DRIVER
Mounting (continued)

www.autani.com www.autani.com
10 11
Operation – Without HBS-DC Installed Operation – With HBS-DC Installed
Operation - HBS 300, HBS 200
TheHBS300andHBS200operateby
turninglightsONautomaticallywhen
occupancyisdetectedandOFFwhenthe
spaceisleftvacantandthetimedelay
haselapsed.Thesensorcommunicates
wirelesslytootherwirelessdevices
programmedtothesamegrouptoturn
lightsONorOFF.
Light level function - HBS 300, HBS 200
TheHBSsensor’slightlevelfeature
keepslightingOFFduringdaylighthours,
regardlessofoccupancy.Alightlevel
delay-ofunctionpreventsthesensor
fromrespondingtotemporarychanges
inambientlightlevel.Iftheambientlight
levelisbrighterthanthesettargetvalue,
thesensorwillwaitforoneminutebefore
turninglightsOFF.Ifmotionisdetected
withinthistime,lightswillremainON.
Afternomotionisdetectedforoneminute
andthelightlevelhasbeengreaterthan
thetargetvalue,thelightswillturnOFF
andremainOFFuntilthedaylightlevel
dropsbelowthetargetsetpointand
motionisdetected.
Operation - HBS 300, HBS 200
TheHBS300andHBS200operateby
turninglightsonanddimminglights
inresponsetoscheduledormanual
overridesinitiatedfromtheAutaniEnergy
Manager.
MultipleHBS300andHBS200unitsmay
begroupedtogetherinthemanagerso
thatoccupancytransitionsaresharedby
thegroup,turninglightsONandOFFin
unison.
Light level function - HBS 300, HBS 200
TheHBSsensor’slightlevelfeaturewill
dimthextureautomaticallyifenabledin
theAutaniEnergyManager.
Thelightharvestingfeatureallowseach
lighttomaintainaconstantlevelof
illuminationdirectlyunderthexture.
Thesesettingsmustbeconguredinthe
AutaniEnergyManageriftheHBS-DC
radioisinstalled.
Initial power up - HBS 300, HBS 200
Uponinitialpowerup,theloadwillturn
ONforuptooneminute.Ifnomotion
isdetected,theloadwillswitchOFF.If
motionisdetectedandthetargetlight
levelsettingislessthanthedaylightlevel,
theloadwillstayONfortheselectedtime
delaysetting(perDIPswitchsetting).If
thedaylightlevelatpowerupisgreater
thanthetargetlightlevelsetting,theload
willswitchOFFregardlessofoccupancy.
Surge protection - HBS 300, HBS 200
TheHBSsensorscontainsbuiltinsurge
protection.Thisfeaturewillresetthe
unitautomaticallyafter:powersurges,
poweroutages,andpowershortages.
Surgeprotectionprotectsthesensorifit
ismiswiredaswell.Ifmiswired,shuto
power,correctthewiring,andthesensor
willthenoperatecorrectly.
Initial power up - HBS 300, HBS 200
Uponinitialpowerup,theloadwill<check
withBobBelz/Ibrahimforlogic>
Surge protection - HBS 300, HBS 200
TheHBSsensorscontainsbuiltinsurge
protection.Thisfeaturewillresetthe
unitautomaticallyafter:powersurges,
poweroutages,andpowershortages.
Surgeprotectionprotectsthesensorifit
ismiswiredaswell.Ifmiswired,shuto
power,correctthewiring,andthesensor
willthenoperatecorrectly.
Light level - HBS 300, HBS 200
Thelightlevelfeatureallowslightingto
remainOFFduringdaylight,regardlessof
occupancy.Daytimeoperationisat200
footcandles(factorysetting).Nighttime
operationisat.2footcandles.
See Autani Manager documentation.
Light level teach mode - HBS 300, HBS 200
Thelightlevelteachmodereadsthe
ambientlightlevelinthespaceandselects
thisamountforthelightlevelsetting.
• Turnthelightlevelsettingto
• After10seconds,thevalueofthe
ambientbrightnessissaved.
• Thisvalueisalsoavailableafterapower
failureifthepotentiometerissetto
teachmodeatpowerup.
Aftersetupandcommissioningare
complete,adjustthelightlevelsettingsto
ttheapplicationneeds.
Light level: .2 (night) to 200 (day) footcandles
Time
ON
1234
Low
High
Low
High
Setup & Commissioning – Without HBS-DC Installed Setup & Commissioning – With HBS-DC Installed

www.autani.com www.autani.com
12 13
Setup & Commissioning
HBS 300 Coverage
TheHBS300containsthreepyroelectric
sensorstodetectoccupancy.Atan
installationheightof8to45feet,maximum
reachis22feetradialand60feettangential.
Ifneeded,thedetectionzonecanbe
adjusted(seebelow).
Coveragemayvarydependingonmounting
heightandenvironmentalconditions.
HBS 200 Coverage
TheHBS200containstwopyroelectric
sensorstodetectoccupancyandhasan
aislewaycoverageofupto100feetwhen
mountedat40ft.Ifneeded,thedetection
zonecanbeadjustedwithalenscover(see
below).
Inaddition,theviewoftheHBS200can
berotated90degrees.Todothis,remove
thesensorhousingfromthebackbox
bypressingthetabsoneithersideofthe
sensor.
Coveragemayvarydependingonmounting
heightandenvironmentalconditions.
10
20
30
40
LC3
40 ft
50 5040 4035 ft
22 ft 22 ft
35 ft
10
20
30
40
Aisle
LC3
radial
tangential
40 ft
13 ft
50 ft
53 ft 53 ft
50 ft
Setup & Commissioning
Lens Covers
Lenscoverscanbeusedtoadjustthe
HBS300’scoverageasneeded.The
coversareplasticandsnaptothefrontof
anHBS300orHBS200sensor.
LC4 reduced range lens
cover for HBS 300
LC1 aisle starter cover for HBS 200
LC5 180° half moon lens
cover for HBS 300
10
20
30
40
40 ft
13 ft
50 ft
53 ft
LC1
radial
tangential
10
20
30
40
40 ft
LC4
30 ft
22 ft 22 ft
30 ft
10
20
30
40
40 ft
LC4
30 ft
22 ft 22 ft
30 ft
10
20
30
40
LC5
40 ft
35 ft
22 ft
40 50

www.autani.com www.autani.com
14 15
Warranty
HBS-DCCertications
HBS 200, HBS 300
STEINELAmericawarrantsitsproducts
againstdefectsinmaterialorworkmanship
foraperiodofveyears.STEINELwill
replaceorrepairtheitemprovidedthat
ithasnotbeenalteredorsubjectedto
abuse,accident,improperinstallationor
improperuse.Therearenoobligations
orliabilitiesonthepartofSTEINELfor
consequentialdamagesarisingoutofor
inconnectionwiththeuseorperformance
ofthisproductorotherindirectdamages
withrespecttolossofproperty,revenue,
orprot,orcostofremoval,installationor
reinstallation.
HBS-DC
AutaniwarrantsthatAutaniProducts
willbefreefromdefectsinmaterials
andworkmanshipandconformtoits
Specicationsforaspecied,xedperiod
commencingonitsdateofshipment
andcontinuingforve(5)years,except
thexedperiodforAutaniSoftware,
Managers,andanyAutaniProductnot
installedandcommissionedbyAutanior
itsfactoryauthorizedrepresentativesshall
beforone(1)year(the“WarrantyPeriod”),
unlessotherwisespecied.Duringthe
warrantyperiod,ifanAutaniProduct
doesnotfunctionsubstantiallyaccording
toitsSpecication,Autaniwilleither1)
makeitdosoor2)replaceitwithone
thatisatleastfunctionallyequivalent.If
Autaniisnotabletomakethewarranted
productsubstantiallyconformwithits
specications,Buyermayreturnitto
AutaniandtheamountpaidtoAutani
forsuchproductwillberefundedona
proratedbasisrelativetotheWarranty
Periodremainingfromtherstdateof
theclaim.
ComplieswithUL508Standards
FCCID:V8NHBS1000173
IC:7737A-HBS1000173
ThisdevicecomplieswithPart15oftheFCC
Rules.Operationissubjecttothefollowing
conditions:
(1)thisdevicemaynotcauseharmful
interference
(2)thisdevicemustacceptanyinterference
receivedincludinginterferencethatmaycause
undesiredoperation
(3)Changesormodicationsnotexpressly
approvedbythepartyresponsiblefor
compliancecouldvoidtheuser’sauthorityto
operatetheequipment
ThisequipmentcomplieswiththeFCCRF
radiationexposurelimitssetforthforan
uncontrolledenvironment.Thisequipment
shouldbeinstalledandoperatedwithaminimum
distanceof20centimetersbetweentheradiator
andyourbody.
Troubleshooting
Wirelesscommunicationtroubleshooting
• Isthereceiverdevicetoofarawayfromthetransmittingdevice,resultingintooweak
ofasignalatthereceiver?(SeeTransmissionRangeonpage3.)
• Cantheradiosignalleavethetransmitterandreachthereceiverorisitinhibitedby
interference(metalenclosure,etc.)
• Isthereanypossibleinterferencefromothertransmittersoperatingonthesame
frequency?
• Areanyothertransmittersoperatingoutsidethesystemwhich,althoughworkingon
adierentfrequency,aredoingsoatveryhightransmissionpower(hamradioetc.)?
HBS300,HBS200sensortroubleshooting
Nopoweratthe
sensor
Lightsdonotswitch
ON
Lightsdonotswitch
OFF
Lightskeep
switchingON/OFF
LightsswitchON
withoutobvious
movement
breakerhastripped;lightswitchisin
OFFposition
shortcircuit
lightlevelsettingisinnighttime
modeduringdaytimeoperation
lampburnedout
poweriso
detectionzonenotcorrectlyadjusted
abundantheatfromthextureis
withindetectionzoneandkeeps
lightsonasaresultoftemperature
change
thextureismovingfromsidetoside
HVACventiscausingairowto
switchlightson
resetbreaker,turnlightswitch
toONposition,checkwiring
withvoltagetester
checkforproperwiring
connections
adjustlightlevelsetting
replacelamp
turnpoweronatcircuitbreaker
readjust
readjustzoneorapplyshroud
stabilizethexture
redirectairowawayfromthe
sensor
Malfunction Cause Remedy
NOTE:Thisequipmenthasbeentestedandfound
tocomplywiththelimitsforaClassAdigital
device,pursuanttopart15oftheFCCRules.
Theselimitsaredesignedtoprovidereasonable
protectionagainstharmfulinterferencewhen
theequipmentisoperatedinacommercial
environment.Thisequipmentgenerates,uses,
andcanradiateradiofrequencyenergyand,
ifnotinstalledandusedinaccordancewith
theinstructionmanual,maycauseharmful
interferencetoradiocommunications.Operation
ofthisequipmentinaresidentialareaislikely
tocauseharmfulinterferenceinwhichcasethe
userwillberequiredtocorrectinterferenceathis
ownexpense.
ThisClassAdigitalapparatuscomplieswith
CanadianICES-003.
CetappareilnumériquedelaclasseAest
conformeàlanormeNMB-003duCanada.

STEINEL America Inc.
9O51LyndaleAvenueSouth
USA-Bloomington,MN55420
Tel:[phone]
Fax:[phone]
www.steinel.net
Autani, LLC
7090ColumbiaGatewayDrive
Suite140
Columbia,MD21046
Tel:[phone]
www.autani.com
I
o
T
E
N
A
B
L
E
D
B
Y