Toyota 55405-05160 User manual

Model year: 2006
Vehicle code: **T25*R-*****W
Part number: • Navigation System 08545-00950
• Audio Frame 55405-05160
Manual ref. no: AIM 001 067-0
Avensis
TNS700
RHD installation instructions

Avensis (T25) TNS 700
Avensis (RHD) - 201-07
PRECAUTIONS
• Do not pinch the rear wiring or
harness in the tightened part.
PLEASE READ THOROUGHLY THESE PRECAUTIONS BEFORE THE INSTALLATION
• Be sure to disconnect the negative
(-) lead from the battery terminals.
• When passing the wires through the
dashboard or other panels, use a
grommet to ensure waterproofing.
• Protect the wiring with tape when it
is passed through a hole.
• When disconnecting the connectors,
be sure to grip the connector body.
Do not tug on the wiring.
• Do not forcibly pull any car wiring
harness. Rough tugging may result
in opened connections, or a broken
wire or harness.
• Confirm that lamps, horn, wiper and
other car accessories operate normally.
• Protect your car with fender cov-
ers, seat and so on.
• Use the correct tool when tight-
ening bolts or nuts.
• Before drilling a hole, check
that the rear of the mounting
wall is clear.
• Be sure to firmly tighten connec-
tors and terminals.
• Before connecting the power
wiring to the battery, check the
wiring connections, harness,
etc. to see that they are properly
secured.
• Check body and trim near area of installation to be certain no
dirt or scratches resulted from the installation.
Stop it !
Waterproof - O.K. !!
Grommet
Taping
Insert completely

Avensis (T25) TNS 700
Avensis (RHD) - 301-07
Precautions ............................................................................................................................................. 2
Component parts ................................................................................................................................... 4
Navigation Kit ........................................................................................................................................ 5
How to connect ..................................................................................................................................... 6
Installation Overview .............................................................................................................................. 7
Vehicle Disassembly ................................................................................................................................ 8
Installation of the GPS-Antenna .............................................................................................................. 10
Wire Harness Installation ......................................................................................................................... 12
Installation of the Navigation Disc .......................................................................................................... 17
Post-Installation Inspection ..................................................................................................................... 17
Reassembling ......................................................................................................................................... 17
Be sure to read the General Installation Instructions (Common Section) before installing
TNS 700.
REMARK
TABLE OF CONTENTS

Avensis (T25) TNS 600
Avensis (RHD) - 401-07
Avensis (T25) TNS 700
AUDIO DISPLAY TILT OPEN
MENU
SEEK
TRACK
DEST
MAP
VOICE
DISC
TUNE
VOICE NAVIGATION
PWR•VOL
TA
INFO
FM
AM
B-9001
TOYOTA
1 2 3
46
7 8
5
NODescription Qty
1TNS700 1
2WIRE HARNESS 1
3GPS ANTENNA 1
4NAVIGATION DISC 1
5WIRE CLAMP 2
6FOAM TAPE 2 + 3
7WIRE TIE 10
8EARTH PLATE 1
COMPONENT PARTS 08545-00950

Avensis (T25) TNS 600
Avensis (RHD) - 501-07
Avensis (T25) TNS 700
OWNER’S MANUAL
To be ordered separately.
Refer to ATA database for partnumbers
COMPONENT PARTS 55405-05160

Avensis (T25) TNS00
Avensis (RHD) - 601-07
Avensis (T25) TNS 700
Refer to the repair manual for information on removal of vehicle parts, installation methods, tightening
torque etc.
Vehicle wire harness
Splicing connector
(Reverse sensor wire)
Antenna wire
GPS antenna
3
5P
TNS 700 Tuner with LCD Display
8P
10P 6P
Splicing connector
(Speed sensor wire)
HOW TO CONNECT

Avensis (T25) TNS 700
Avensis (RHD) - 701-07
GPS antenna
Antenna wire
Splicing connector (Speed reverse Sensor with pre wire)
Splicing connector (Reverse Sensor without pre wire)
Splicing connector (Speed Sensor without pre wire)
INSTALLATION OVERVIEW

Avensis (T25) TNS 700
Avensis (RHD) - 801-07
1
2
1.
a) Remove the gear lever knob .
1.
b) Remove the gear lever hole cover .
: Clip (4x)
2
1
FOR M/T MODELS
Fig. 2
Fig. 1
3
2. Remove the instrument panel cluster
moulding .
: Clip (5x)
3
FOR ALL MODELS
Fig. 3
3. Remove the heater control assembly .
: Bolt (4x)
104
7
7
104
VEHICLE DISASSEMBLY

Avensis (T25) TNS 700
Avensis (RHD) - 901-07
Fig. 4
4. Remove the storage box .
: Screw (2x)
: Clip (2x)
105
8
8
105

Avensis (T25) TNS 700
Avensis (RHD) - 1001-07
Fig. 5
12x
1. Cut the foam (d) into 12 pieces as
shown in the illustration.
A
A
(d)
Fig. 6
2.
a) Remove the release paper of the earth
plate and attach the butyl tape as
shown.
b) Apply the tapes to the adhesive side
of the earth plate .
10
11
11
10
11
10
INSTALLATION OF THE GPS-ANTENNA
3.
a) Attach the earth plate to the air
duct as shown and mount the GPS-
antenna to the earth plate .
b) Attach the antenna wire using the
foam tapes (3x).
8
3
10
3
8
10
Fig. 7
8
83
10
Centre
When affixing the earth plate make
sure to carefully wipe of any dirt,
moisture or oil from the surface of the
location where it is to be affixed.
10
CAUTION