Transition Networks SISPM1040-582-LRT User manual

TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 1of 46

SISPM1040‐582‐LRT
ManagedHardenedPoE++Switch(8)10/100/1000Base‐TPoE++
Ports+(2)100/1000Base‐XSFPSlot

InstallGuide
33755Rev.B




TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 2of 46

Trademarks
Alltrademarksandregisteredtrademarksarethepropertyoftheirrespectiveowners.
Copyright Notice/Restrictions
Copyright©2018TransitionNetworks.Allrightsreserved.Nopartofthisworkmaybereproducedorusedin
anyformorbyanymeans(graphic,electronicormechanical)withoutwrittenpermissionfromTransition
Networks.PrintedintheU.S.A.
Contact Information
TransitionNetworks
10900RedCircleDrive
Minnetonka,MN55343USA
tel:+1.952.941.7600|tollfree:1.800.526.9267|fax:952.941.2322
[email protected]|[email protected]|[email protected]
SISPM1040‐582‐LRTManagedHardenedPoE++SwitchInstallGuide,33755Rev.B
Revision History
RevDateDescription
A9/20/18InitialreleaseforFWv7.10.1492.
B 10/17/18Addsafetywarning.
CautionsandWarnings
Cautionsindicatethatthereisthepossibilityofpoorequipmentperformanceorpotentialdamagetotheequipment.
Warningsindicatethatthereisthepossibilityofinjurytoperson.
CautionsandWarningsappearhereandmayappearthroughoutthismanualwhereappropriate.Failuretoreadand
understandtheinformationidentifiedbythissymbolcouldresultinpoorequipmentperformance,damagetothe
equipment,orinjurytopersons.
Cautions:Whileinstallingorservicingthepowermodule,wearagroundingdeviceandobserveallelectrostatic
dischargeprecautions.Failuretoobservethiscautioncouldresultindamageto,orfailureofthepowermodule.
Warning:Donotconnectthepowermoduletoanexternalpowersourcebeforeinstallingitintothechassis.Failure
toobservethiswarningcouldresultinanelectricalshock,evendeath.
WARNING:Equipmentgroundingisvitaltoensuresafeoperation.Theinstallermustensurethatthepowermoduleis
properlygroundedduringandafterinstallation.Failuretoobservethiswarningcouldresultinanelectricshock,evendeath.
WARNING:Areadilyaccessible,suitableNationalElectricalCode(NEC)orlocalelectricalcodeapproveddisconnectdevice
andbranch‐circuitprotectormustbepartofthebuilding'sinstalledwiringtoaccommodatepermanentlyconnected
equipment.Failuretoobservethiswarningcouldresultinanelectricshock,evendeath.
WARNING:TurnanyexternalpowersourceOFFandensurethatthepowermoduleisdisconnectedfromtheexternalpower
sourcebeforeperforminganymaintenance.Failuretoobservethiswarningcouldresultinanelectricalshock,evendeath.
WARNING:EnsurethatthedisconnectdevicefortheexternalpowersourceisOPEN(turnedOFF)beforedisconnectingor
connectingthepowerleadstothepowermodule.Failuretoobservethiswarningcouldresultinanelectricshock,even
death.
SeeElectricalSafetyWarningsonpage43forElectricalSafetyWarningstranslatedintomultiplelanguages.

TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 3of 46

TableofContents
1.Introduction..................................................................................................................................................5
KeyFeatures.............................................................................................................................................................5
Benefits....................................................................................................................................................................5
Specifications...........................................................................................................................................................6
SoftwareFeatures....................................................................................................................................................8
ManualOverview...................................................................................................................................................11
RelatedManuals....................................................................................................................................................11
2.ProductDescription......................................................................................................................................12
Overview................................................................................................................................................................12
BackPanel..............................................................................................................................................................12
FrontPanel.............................................................................................................................................................13
LEDIndicators........................................................................................................................................................14
DIPSwitchforRingSettings...................................................................................................................................16
RESETButton..........................................................................................................................................................17
3.Installation...................................................................................................................................................18
PackageContents...................................................................................................................................................18
MountingtheSwitchonaDINRail........................................................................................................................19
MountingtheSwitchonaWall(Optional)............................................................................................................20
InstallingSFPModules...........................................................................................................................................21
ConnectingDevices................................................................................................................................................21
ConnectingtheDI/DO(DigitalInput/DigitalOutput)Relay.................................................................................22
GroundingScrew....................................................................................................................................................23
ConnectingP1andP2(54VDCPowerInputs).......................................................................................................23
PowerSupplySpecifications..................................................................................................................................24
480WDinRailPowerSupply(25160)................................................................................................................24
PowerSupplyViews(25160)..............................................................................................................................25
PowerSupplyDimensions(25160)....................................................................................................................26
PowerSupplyPinDescriptions(25160).............................................................................................................27
240WDinRailPowerSupply(25104)................................................................................................................28
PowerSupplyFeatures(25104).........................................................................................................................28
PowerSupplySpecifications(25104).................................................................................................................28
4.InitialSwitchConfiguration...........................................................................................................................29
InitialSwitchConfigurationviaWebBrowser.......................................................................................................29
InitialSwitchConfigurationviaCLI.........................................................................................................................29
5.Troubleshooting,Warranty,SupportandCompliance...................................................................................30
Troubleshooting.....................................................................................................................................................30
GeneralTroubleshooting...................................................................................................................................30
LEDTroubleshooting..........................................................................................................................................31
PoEModesandCompliance...................................................................................................................................32
PoEHistory.........................................................................................................................................................32
PoEStandardsComparison................................................................................................................................32
PoETypes...........................................................................................................................................................33
RelatedInformation...........................................................................................................................................33
PoEClasses.........................................................................................................................................................34
PoEDeploymentEnvironmentsAandB............................................................................................................34

TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 4of 46

ModeAvs.ModeB............................................................................................................................................35
802.3af/atStandard“compliant”vs"compatible"PDs.....................................................................................35
TypicalPDPowerRequirements........................................................................................................................35
CalculatePoEPowerBudget..............................................................................................................................35
VoIPvsSIP..........................................................................................................................................................35
MixingPOEandNon‐POEDevices.....................................................................................................................35
EthernetandPoEIntra‐BuildingCablingWarnings...........................................................................................36
LegacyPDDetection/CapacitorDetection.......................................................................................................36
PoE++Connectivity,Arcing,andTemperatureIssues......................................................................................36
PoE/PoE+/PoE++ComparisonChart..................................................................................................................37
NotesfromDraftStandardforEthernetAmendment2:PoEover4Pairs(IEEE802.3bt)................................37
TermDefinitions.................................................................................................................................................38
GeneralSafety....................................................................................................................................................38
NetworkSafety...................................................................................................................................................39
PatchPanelConsiderations................................................................................................................................39
ElectromagneticEmissions................................................................................................................................39
TemperatureandHumidity................................................................................................................................39
Labeling..............................................................................................................................................................39
BackwardCompatibility..........................................................................................................................................40
RecordingDeviceandSystemInformation............................................................................................................41
LimitedLifetimeWarranty.....................................................................................................................................42
ContactUs..............................................................................................................................................................42
TechnicalSupport...............................................................................................................................................42
ComplianceInformation........................................................................................................................................42
FCCRegulations..................................................................................................................................................42
CanadianRegulations.........................................................................................................................................42
DeclarationofConformity(DoC).......................................................................................................................43
ClassI,Division2/classeI,division2....................................................................................................................43
HighRiskActivitiesDisclaimer...............................................................................................................................43
CautionsandWarnings..........................................................................................................................................44
ElectricalSafetyWarnings......................................................................................................................................45
ElectricalSafety..................................................................................................................................................45
ElektrischeSicherheit.........................................................................................................................................45
Elektrisksikkerhed.............................................................................................................................................45
Elektrischeveiligheid..........................................................................................................................................45
Sécuritéélectrique.............................................................................................................................................45
Sähköturvallisuus...............................................................................................................................................45
Sicurezzaelettrica..............................................................................................................................................45
Elektrisksikkerhet..............................................................................................................................................45
Segurançaeléctrica............................................................................................................................................45
Seguridadeléctrica.............................................................................................................................................45
Elsäkerhet...........................................................................................................................................................45

TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 5of 46

1.Introduction
TheSISPM1040‐582‐LRTindustrialL2+managedGbEPoE++switchisthenextgenerationindustrialgrade
EthernetswitchofferingpowerfulL2andbasicL3featuresforbetterfunctionalityandusability.Alongwithits
extensivemanagementfeatures,theSISPM1040‐582‐LRTalsoprovidesCarrierEthernetfeaturessuchasOAM,
CFM,ERPS,EPS,andPTPv2,makingitsuitableforindustrialandCarrierEthernetapplications.
TheSISPM1040‐582‐LRTdelivers8(10M/100M/1G)RJ45withPoE++(802.3at/af/btforupto480Wtotal)ports,2
GbESFPportsandanRJ45Consoleport.TheSISPM1040‐582‐LRTprovideshighhardwareperformanceand
operatingenvironmentflexibilityforIndustrialandCarrierEthernetapplications.
TheembeddedDeviceManagedSystem(DMS)featuremakesiteasytouse,configure,install,andtroubleshoot
invideosurveillance,wirelessaccess,andotherindustrialapplications.TheSISPM1040‐582‐LRTdeliversideal
managementsimplicity,userexperience,andlowtotalcostofownership(TCO).
Key Features
• RapidRing/RingToRing/RapidChain
• DMS(DeviceManagementSystem)builtin
• ITU‐TG.8031EthernetLinearProtectionSwitching(EPS)
• ITU‐TG.8032EthernetRingProtectionSwitching(ERPS)
• IEEE1588v2PTP
• IEEE802.3ahOAM
• IEEE802.1agCFM(ITU‐TY.1731Performancemonitoring)
• DHCPServer,DHCPRelay,DHCPSnooping,DHCPPerPort
• IEEE802.3azEnergyEfficientEthernet(EEE)forgreenEthernetapplication
• IEEE802.3af/at/PoE++PoweroverEthernet(IEEE802.3bt)
• IPv4/IPv6L3staticroute
Benefits
Feature‐richSpecificationstosupportvariousapplications:Theswitchdeliverextensiveindustrialand
carriergradefunctionalities,includingR‐Ring,ITU‐TG.8031,ITU‐TG.8032,IEEE1588v2PTP,OAM,CFM,
etc.ItalsohasenhancedL2/L3featuresforbettermanageabilityandusability.TheSISPM1040‐582‐LRT
providesadvancedPoEfeaturessuchasPoEauto‐checking,PoEscheduling,PoEAutoPowerReset,and
PoEpowerdelaytomanagePDsmoreeasily.
ExceptionalPrecisionwithIEEE1588v2PTP:TheswitchperformsIEEE1588v2PTPwithtransparentclock
capability,implementationsinhardware,sothereisnoperformancepenaltyonpacketprocessing.
Thehardwarearchitectureensureslowlatencyandhightimeaccuracy,criticalfordelay‐sensitivefinancial
andmobileapplications.
SuperiorReliabilitywithOAMandCFMforServiceAssurance:Serviceassuranceisprovidedwitharich
featuresetofoperations,administration,andmaintenance(OAM)functions.Itcansimplifyandfacilitate
themanagementofCarriernetwork,resultingindiminishingoperationalcosts.TheEthernetaccessdevice
alsooffersstandards‐basedfaultandperformancemanagementinadherencewithITU‐TY.1731PM
(PerformanceMonitoring)andIEEE802.1agconnectivityfaultmanagement(CFM)standards.These
featurescontributetosignificantreductioninoperationalexpendituresandallowsfortroubleshooting
withoutexpensivetruckrolls.

TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 6of 46

EasytoInstall,ConfigureandTroubleshootwithDMS:theembeddedDeviceManagementSystem(DMS)
providesembeddedfunctionstofacilitatedevicesmanagementatanytimeandanywhere.Itsuser‐friendly
interfacehelpsmanagedevicesintuitively.ItsupportsvariousIPdevicetypes(e.g.PC,IP‐phones,PTZ
cameras,WiFi‐AP)toenhancemanageabilityandsavetimeandcostduringinstallationandmaintenance.
LowerTCOwithEnergy‐efficientdesign:Theswitchisdesignedtohelpcompaniessavepowerandreduce
TCObyEnergyEfficientEthernet(IEEE802.3az).ItcanhelpbuildagreenEthernetnetworkenvironment.
Ordering Information
SKUDescription
SISPM1040‐582‐LRTHardenedPoE++Switch.(8)10/100/1000Base‐TPoE++and(2)100/1000Base‐XSFP
slots;52V‐57VDC.
OptionalAccessories(soldseparately)
HardenedSFPsSeeTransitionNetworkswebpageforHardenedSFPs.
25160IndustrialPowerSupply.Input90‐264VAC,127‐370VDC.Output:48~55VDC,10A,
480Watts
25104IndustrialPowerSupply.Input:85‐264VAC,124‐370VDC.Output:48~55VDC,5A,
240Watts.
WMBH‐01WallMountBracket.

Specifications
PortConfiguration
TotalPortsRJ45
(10M/100M/1G)
Uplinks
(100M/1G)ConsoleRingMgmt.DI/DO
1082SFPRJ45DIPswitch1/1
HardwarePerformance
Forwarding
Capacity(Mpps)
Switching
Capacity(Gbps)
MacTable
(K)
JumboFrames
(Bytes)
14.882089216
EnvironmentalRange
OperatingTemperatureStorageTemperatureOperating
HumidityAltitude
FahrenheitCentigradeFahrenheitCentigrade5%to95%
non‐condensing
FeetMeters
‐40°to+167° ‐40°to+75° ‐40°to+185° ‐40°to+85°<10000<3000


TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 7of 46

Dimensions,Weight,Mounting
Dimensions(WxHxD)Weight
MountingType
MillimetersInchesKilogramsPounds
62x135x1302.4x5.3x5.10.81.7DINrail;Wall(Optional)
VoltageandFrequency
PrimaryPowerSupply‐DCInputVoltage
DCNominal54VDCdualinputs
DCOperatingRange48to57VDC
PowerConsumption13WwithoutPoE
PoESupport:Theswitchcansupplyupto90Wattsperportonfourportsor60Wattsperportoneightports
simultaneously.
AvailablePoEPowerNumberofPortsthatsupport
PoE(15.4W),PoE+(30.0W),PoE++(60W),PoE++(90W)
480WEachofport1‐8supportPoE++withinavailablePoEPower.MaxPoEBudget480Watts
60Wattsfor(8)portssimultaneously;upto90Wattson(4)portssimultaneously.
MTBF
HoursEnvironment
296,997GB,GC‐GroundBenign,Controlled25°C
82,976GB,GC‐GroundBenign,Controlled75°C
Certifications
Compliance
EMS EN61000‐4‐2ESD,EN61000‐4‐3RS,EN61000‐4‐4EFT,EN61000‐4‐5(forRJ45Port,Surge6KV),
EN61000‐4‐6CS,EN61000‐4‐8PFMF
EMIFCCPart15ClassA
SafetyCE,EN60950
MechanicalStability
VibrationIEC60068‐2‐6
Shock IEC60068‐2‐27
Freefall IEC60068‐2‐32
Compliant
TransportationNEMATS2(trafficsignalingequipment)
SubstationIEC61850‐3,IEEE1613,UL,ClassIDiv2

TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 8of 46

Software Features
RingManagement
ITU‐TG.8031SupportsITU‐TG.8031EthernetLinearProtectionSwitching(EPS)
ITU‐TG.8032SupportsITU‐TG.8032EthernetRingProtectionSwitching(ERPS)
RapidRing
Enablesself‐recoverytimeinlessthan20ms;configurableviaDIPswitch,CLIorWebUI:
SingleRing
RingtoRing
DualRing
RapidChain
DeviceManagementSystem(DMS)
Graphical
Monitoring
Topologyview:Intuitivewaytoconfigureandmanageswitchesanddevicesvisually
Floorview:EasilydraganddropPoEdevicestohelpyoubuildasmartworkforce
Mapview:EffectivelydraganddropdevicesandmonitoroperationonGoogleMaps
FindmySwitchSearchandlocateaspecificswitchquickly
TrafficMonitoringDisplayvisualchartofnetworktrafficofalldevicesandmonitoreveryportatanytime
fromswitches
Troubleshooting
Networkdiagnosticbetweenmasterswitchanddevices
Supportprotectionmechanism,suchasrate‐limitingtoprotectyourdevicesfrom
brute‐forcedownloading
SupportperformancemanagementandlinkmanagementthroughIEEE802.3ahand
IEEE802.1ag(Y.1731)
GoogleMapAPIKey
SetupGoogleMapAPIKeyfromhttps://console.developers.google.com/touse
DMSMapViewforenterpriseapplications
EthernetOAM
IEEE802.3ahOAMSupportsOperations,Administration&Management
IEEE802.1ag&ITU‐T
Y.1731FlowOAM
SupportsIEEE802.1agEthernetCFM(ConnectivityFaultManagement)
SupportsITU‐TY.1731PerformanceMonitoring
Layer2Switching
SpanningTree
Protocol(STP)
StandardSpanningTree802.1d
RapidSpanningTree(RSTP)802.1w
MultipleSpanningTree(MSTP)802.1s
TrunkingLinkAggregationControlProtocol(LACP)IEEE802.3ad
Upto6groupsandupto4portspergroup
LACPonAir
SetupLACPonAirportsandtheCoupleIPaddressforaccessmanagement.
Apple’sAirPortExpressprovidessimultaneousdual‐bandwireless802.11nWi‐Fi
networkingforwirelessdevices
VLAN
Port‐basedVLAN
802.1Qtag‐basedVLAN
MAC‐basedVLAN
ManagementVLAN
PrivateVLANEdge(PVE)
Q‐in‐Q(doubletag)VLAN
VoiceVLAN

TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 9of 46

GARPVLANRegistrationProtocol(GVRP)
DHCPRelay RelayofDHCPtraffictoDHCPserverindifferentVLAN.
WorkswithDHCPOption82
IGMPv1/v2/v3
Snooping
IGMPlimitsbandwidth‐intensivemulticasttraffictoonlytherequesters.
Supports1024multicastgroups
IGMPQuerierIGMPquerierisusedtosupportaLayer2multicastdomainofsnoopingswitchesinthe
absenceofamulticastrouter
IGMPProxyIGMPsnoopingwithproxyreportingorreportsuppressionactivelyfiltersIGMPpackets
inordertoreduceloadonthemulticastrouter
MLDv1/v2SnoopingDeliversIPv6multicastpacketsonlytotherequiredreceivers
MulticastVLAN
Registration(MVR)
ItusesadedicatedmanuallyconfiguredVLAN,calledthemulticastVLAN,toforward
multicasttrafficoverLayer2networkinconjunctionwithIGMPsnooping.
Layer3Switching
IPv4StaticRoutingIPv4Unicast:Staticrouting
IPv6StaticRoutingIPv6Unicast:Staticrouting
Security
SecureShell(SSH)SSHsecuresTelnettrafficinoroutoftheswitch;SSHv1andv2aresupported
SecureSocketsLayer
(SSL)
SSLencryptsthehttptraffic,allowingadvancedsecureaccesstothebrowser‐based
managementGUIintheswitch
IEEE802.1X
IEEE802.1X:RADIUSauthentication,authorizationandaccounting,MD5hash,
guestVLAN,single/multiplehostmodeandsingle/multiplesessions
SupportsIGMP‐RADIUSbased802.1X
DynamicVLANassignment
Layer2Isolation
PrivateVLANEdge
PVE(akaprotectedports)providesL2isolationbetweenclientsinthesameVLAN.
Supportsmultipleuplinks.
PortSecurityLocksMACaddressestoportsandlimitsthenumberoflearnedMACaddress
IPSourceGuardPreventsillegalIPaddressfromaccessingtospecificportintheswitch
RADIUS/TACACS+ SupportsRADIUSandTACACS+authentication.Switchasaclient
StormControlPreventstrafficonaLANfrombeingdisruptedbyabroadcast,multicast,orunicast
stormonaport
DHCPSnoopingFeatureactsasafirewallbetweenuntrustedhostsandtrustedDHCPservers
ACLs
Supportsupto256entries.Droporratelimitationbasedon:
SourceanddestinationMAC,VLANIDorIPaddress,protocol,port,
Differentiatedservicescodepoint(DSCP)/IPprecedence
TCP/UDPsourceanddestinationports
802.1ppriority
Ethernettype
InternetControlMessageProtocol(ICMP)packets
TCPflag
LoopProtectionTopreventunknownunicast,broadcast,andmulticastloopsinLayer2switching
configurations.
QualityofService
HardwareQueuesSupports8hardwarequeues
SchedulingStrictpriorityandweightedround‐robin(WRR)

TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 10 of 46

QueueassignmentbasedonDSCPandclassofservice
Classification
Portbased
802.1pVLANprioritybased
IPv4/IPv6precedence/DSCPbased
DifferentiatedServices(DiffServ)
Classificationandre‐markingACLs
RateLimiting
Ingresspolicer
Egressshapingandratecontrol
Perport
Management
HWMonitoringTemperatureDetectionandAlarm
HWWatchdogSupportedtoresumeoperationafterCPUhangup.
IEEE1588v2PTPSupportIEEE1588v2PTP(PrecisionTimeProtocol)
Switch2goRemoteswitchcontrolviaWebUI,anywhere,anytime.Remoteswitchtroubleshooting
tosolvenetworkproblemsefficientlyandeffectively.
iPushThereal‐timealarmnotificationcanlowertechnicalsupportcosts
WorkswithiOSandAndroiddevicestomakequickworkofdemandingtasks.
DHCPServerSupportDHCPservertoassignIPtoDHCPclients
RemoteMonitoring
(RMON)
EmbeddedRMONagentsupportsRMONgroups1,2,3,9(history,statistics,alarms,and
events)forenhancedtrafficmanagement,monitoringandanalysis
PortMirroring
Trafficonaportcanbemirroredtoanotherportforanalysiswithanetworkanalyzeror
RMONprobe.UptoN‐1(NisSwitch’sPorts)portscanbemirroredtoasingle
destinationport.Asinglesessionissupported.
UPnPTheUniversalPlugandPlayForum,anindustrygroupofcompaniesworkingtoenable
device‐to‐deviceinteroperabilitybypromotingUniversalPlugandPlay
s‐Flow
Theindustrystandardformonitoringhighspeedswitchednetworks.Itgivescomplete
visibilityintotheuseofnetworksenablingperformanceoptimization,accounting/billing
forusage,anddefenseagainstsecuritythreats
IEEE802.1ab(LLDP)
Usedbynetworkdevicesforadvertisingtheiridentities,capabilities,andneighbors
onanIEEE802ablocalareanetwork
SupportLLDP‐MEDextensions
WebGUIInterfaceBuilt‐inswitchconfigurationutilityforbrowser‐baseddeviceconfiguration
CLIToconfigure/manageswitchesincommandlinemodes
DualImageIndependentprimaryandsecondaryimagesforbackupwhileupgrading
SNMP SNMPversion1,2cand3withsupportfortraps,andSNMPversion3user‐basedsecurity
model(USM)
FirmwareUpgradeWebbrowserupgradeviaHTTP/HTTPsandTFTP
UpgradeviaConsoleport/CLI
NTPNetworkTimeProtocol(NTP)forclocksynchronizationbetweencomputersystemsover
packet‐switched
OtherManagement
HTTP/HTTPs;SSH
DHCPClient/DHCPv6Client
CableDiagnostics
Ping
Syslog
IPv6Management

TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 11 of 46

PoweroverEthernet(PoE)
PortConfigurationSupportsperportPoEconfigurationfunction
PoESchedulingSupportsperportPoEschedulingtoturnon/offthePoEdevices(PDs)
AutoPowerReset
(Auto‐checking)ChecksthelinkstatusofPDsandrebootPDsiftherearenoresponses
PowerDelay
TheswitchprovidespowertothePDsbasedonadelaytimewhenPoEswitchbootsup,
toprotectswitchfrommisuseofthePDs.Whenrebooting,thePoEportwillstartto
providepowertothePDafteraconfigurabledelaytime.
Manual Overview
Thismanualdescribeshowtoinstall,initiallyconfigure,andtroubleshoottheSISPM1040‐582‐LRTSwitch,
including:
ChecktheswitchLEDstatus,
Resettheswitchortorestoretheswitchtofactorydefaults,
Installtheswitch,and
Troubleshoottheswitch.
Related Manuals
SISPM1040‐582‐LRTQuickStartGuide,33754
SISPM1040‐582‐LRTInstallGuide,33755(thismanual)
SISPM1040‐582‐LRTWebUserGuide,33756
SISPM1040‐582‐LRTCLIReference,33757
ForTransitionNetworks’Drivers,Firmware,etc.gototheProductSupportwebpage(logonrequired).
ForTransitionNetworks’Manuals,Brochures,DataSheets,etc.gototheSupportLibrary(nologonrequired).
ForSFPorSFP+informationseeTransitionNetworksSFPwebpage.

TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 12 of 46

2.ProductDescription
Overview
ThissectiondescribestheSISPM1040‐582‐LRTswitch,includingdescriptionsof:
FrontandBackPanels
LEDs
RESETbutton
DIPSwitch
GroundingScrew
D1DigitalInput/DigitalOutputRelay)
P1andP2(DCPowerInputs)
Back Panel
TheSISPM1040‐582‐LRTbackpanelprovidesformountingtheswitchonawallorina19‐inchrack.
SeeMountingtheSwitchonpage20orMountingtheSwitchonaWallonpage21.



TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 13 of 46

Front Panel
TheSISPM1040‐582‐LRTfrontpanelports,LEDs,PowerInputterminalblock,DI/DOterminalblock,CONSOLE
port,DIPSwitch,RESETbutton,andGroundscrewareshownanddescribedbelow.

TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 14 of 46

LED Indicators
ThefrontpanelLEDsprovideforswitchstatusmonitoring.ThetypesofLEDsinclude:
PowerLEDs:indicateiftheswitchispoweredupcorrectlyornot.
SystemLED:indicatesifthesystemisreadyornotready.
AlarmLED:indicatesifthesystemisnormalornot.
RingMasterLEDandRapidChainLED:indicateiftheRapidRingisreadyornotready.
PortStatusLEDs:indicatesthecurrentstatusofeachport.UserscanchecktheseLEDstounderstandtheport
status.
ThefollowingtablesdetailthevariousLEDfunctions.
Table1:PowerLEDs
LEDColorStateDescription
P1(Power1)Green
OnTheswitchispoweredONcorrectly.
OffTheswitchisnotreceivingpowerfrompower1.
P2(Power2)Green
OnTheswitchispoweredONcorrectly.
OffTheswitchisnotreceivingpowerfrompower2.
Table2:SystemLED
LEDColorStateDescription
SYS(System)Green
OnTheswitchisready.
OffTheswitchisnotready.
Table3:AlarmLED
LEDColorStateDescription
ALM(Alarm)Red
OnAnabnormalstate,suchastemperature,voltageorDC
power1/2,hasbeendetectedintheswitch.
OffThesystemstateisnormal.

TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 15 of 46

YoucanchecktheportstatusbyreadingtheLEDbehaviorsperthetablebelow.
Table4:PortStatusLEDs
LEDColorStateDescription
RJ45
Ports
UP
GreenOnTheportisenabledandestablishedalinktoconnecteddevice,andthe
connectionspeedis1000Mbps.
GreenBlinkingTheportistransmitting/receivingpackets,andtheconnectionspeedis
1000Mbps.
AmberOnTheportisenabledandestablishedalinktoconnecteddevice,andthe
connectionspeedis10/100Mbps.
AmberBlinkingTheportistransmitting/receivingpackets,andtheconnectionspeedis
10/100Mbps.
‐‐ Off
Theporthasnoactivenetworkcableconnected,oritisnotestablishedalinkto
connecteddevice.Otherwise,theportmayhavebeendisabledthroughthe
switchuserinterface.
RJ45
Ports
Down
GreenOnTheportisenabledandsupplyingpowertoconnecteddevice.
AmberOnAnabnormalstate,suchasoverloadstatus,hasbeendetectedintheswitch.
‐‐ Off
Theporthasnoactivenetworkcableconnected,oritisnotconnectedaPoEPD
device.Otherwise,theportmayhavebeendisabledthroughtheswitchuser
interface.
SFP
Ports
GreenOnTheportisenabledandhasestablishedalinktotheconnecteddevice,andthe
connectionspeedis1000Mbps.
GreenBlinkingTheportistransmitting/receivingpackets,andtheconnectionspeedis
1000Mbps.
AmberOnTheportisenabledandestablishedalinktoconnecteddevice,andthe
connectionspeedis100Mbps.
AmberBlinkingTheportistransmitting/receivingpackets,andtheconnectionspeedis
100Mbps.
‐‐ Off
Theporthasnoactivenetworkcableconnected,oritisnotestablishedalinkto
connecteddevice.Otherwise,theportmayhavebeendisabledthroughthe
switchuserinterface.


TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 16 of 46

Table5:RingMasterandRapidChainLED
LEDColorStateDescription
RM
(RingMaster)
GreenOnRingMasterhasbeendetectedintheswitch.
AmberOnRingMemberhasbeendetectedintheswitch.
‐‐ OffDisable
RC
(RapidChain)
GreenOnRapidChainhasbeendetectedintheswitch(Activepath).
AmberOnRapidChainhasbeendetectedintheswitch(Backuppath).
BlinkingError:ThereisnocorrespondingRapidChainswitchfound.
‐‐ OffDisable

DIP Switch for Ring Settings
ERPS(EthernetRingProtectionSwitching)isdefinedinITU/TG.8032.Itprovides
fastprotectionandrecoveryswitchingforEthernettrafficinaringtopologywhile
alsoensuringthattheEthernetlayerremainsloop‐free.
Thetwo‐positionDIPswitchislabeledRC(1)(RapidChain)andRM(2)(Ring
Master).
TheDIPswitchletsyoumanuallysetDIPswitchsettingsandnothavetoaccesstheWebUIortheCLItoconfigure
aring.ThetablebelowshowsDIPswitchsettingsforRingMasterandRapidChainsetupviatheDIPswitch.
Table5:RingMasterandRapidChainConfiguration
RMRFRapidRingSettingRingPort1RingPort2
RM
(RingMaster)
LED
RF
(Rapid‐Chain)
LED
OffOffRapidRingSlaveThemaximumodd
Portnumber
Themaximumeven
PortnumberLitAmberOff
ONOffRapidRingMasterThemaximumodd
Portnumber
Themaximumeven
PortnumberLitGreenOff
OffONRapid‐ChainThemaximumodd
Portnumber
Themaximumeven
PortnumberOff
LitGreen
(ActivePath)
LitAmber
(BackupPath)
ONONRapidRingsettingsby
Software
‐‐ ‐‐ ‐‐ ‐‐





TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 17 of 46

RESET Button
BypressingtheRESETbuttonforcertainperiodoftime,youcanperformthefollowingtasks.
ResettheSwitchtorebootandgettheswitchbacktothepreviouslysavedconfiguration
settings.
RestoretheSwitchtoFactoryDefaults:torestoretheoriginalfactorydefaultsettingsbackto
theswitch.
Note:UsethetablebelowtodeterminewhichtaskisbeingperformedbyreadingLEDstatuswhilepressingthe
RESETbutton.OncetheLEDbehaviorsarecorrectlydisplayed,justreleasetheRESETbutton.

Table6:RESETButtonOperation
Task PressRESETbuttonforSYSLEDBehaviorPortStatusLED
Behavior
ResettheSwitch2~7secondsBlinkingGreenALLLEDsareOFF
RestoretoDefaults7~12secondsBlinkingGreenALLLEDsstayON


TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 18 of 46

3.Installation
Package Contents
Carefullyunpackthepackagecontentsintheirfinallocation.
Verifythatyouhavereceivedtheitemsbelow.
OneSwitchwithTerminalBlockattached
OnePowerSupply(packagedseparately)
OneDB‐9toRJ‐45Cable
Fouradhesiverubberfeet
OnePrintedQuickStartGuide
19”RackMountbrackets
Contactyoursalesrepresentativeifanypartsaremissingordamaged.Pleasesavethepackagingforpossible
futureuse.
Caution:Theswitchisanindoordevice.IfitistobeusedwithoutdoordevicessuchasoutdoorIPcamerasor
outdoorWi‐FiAPs,thenyouarestronglysuggestedtoinstallasurgeprotectororsurgesuppressorinorderto
protecttheswitch.
Compliantwith802.3atinEnvironmentAwhenusinganisolatedpowersupply.For802.3atEnvironmentB
applications,i.e.buildingtobuilding,coppertocopperendpointconnections:1)useanEthernetnetworkisolator
module(PoEdisabled),or2)usemid‐spaninjector(s),e.g.MIL‐L100i,L1000i‐at,betweenthisswitch’sPSEport
andlinkpartnerPDport.
Warning:SafetyFirst:Turnthepoweroffbeforeconnectingordisconnecting
modulesorwires.Thecorrectpowersupplyvoltageislistedontheproductlabel.
Checkthevoltageofyourpowersourcetomakesurethatyouareusingthecorrect
voltage.DoNOTuseavoltagegreaterthanwhatisspecifiedontheproductlabel.


TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 19 of 46

Mounting the Switch on a DIN Rail
1. AttachtheDINRailmountingkittotherearpanelofthechassis.Insertscrewsandtightenthenwitha
screwdrivertosecurethekit.

2. InserttheupperlipoftheDINrailintotheDIN‐railmountingkitandpresstheswitchtowardstheDINrail
untilitsnapsintoplace.

3. MakesurethattheswitchisattachedsecurelytoDINRail.



TransitionNetworks SISPM1040‐582‐LRTInstallGuide

33755 Rev. B https://www.transition.com Page 20 of 46

Mounting the Switch on a Wall (Optional)
1. Attachthewallmountingplatestorearpanelofthechassis.Insertscrewsandtightenthemwitha
screwdrivertosecuretheplates.

2. Installuser‐suppliedscrewsontheappropriatelocationonthewall.

3. Makesurethattheswitchisattachedsecurelytothewall.

