Travis Industries Revolution 36CF User manual

36 CF / 1080 CF Firebacks
Two-Sided (Brick or Herringbone) Arched 96100166 – Rectangular 96100172
Two-Sided (Diamond or Stucco) Arched 96100168 – Rectangular 96100174
Whidbey Rock Creek – 96100252 Constitution Basket Weave / Quilt - 96100175
Page 1 of 4 9/15/08 Travis Industries, Inc.
WARNING The firebacks must be installed prior to operating your fireplace. See the
installation manual for further details.
Packing List
Upper Rear
Fireback
Lower
Rear Fireback
Right
Fireback
Left
Fireback
Left Floor
Fireback
Right Floor
Fireback
The arched
version has a
larger notch here.
NOTE Make sure the rear brick is correctly positioned (see the illustration below)
UP UP
Herringbone Pattern Brick Pattern Diamond Pattern

36 CF / 1080 CF Firebacks
Two-Sided (Brick or Herringbone) Arched 96100166 –Rectangular 96100172
Two-Sided (Diamond or Stucco) Arched 96100168 –Rectangular 96100174
Whidbey Rock Creek –96100252 Constitution Basket Weave / Quilt - 96100175
Page 2 of 4 9/15/08 Travis Industries, Inc.
36 CF Installation
1 Remove the glass frame logs and grate (see installation manual for details).
2 Install the firebacks following the directions below.
Remove the clip and screw located on the firebox
ceiling near the front (both sides).
b
Right Floor Fireback
Place the floor firebacks in the gap in
front of the burner. Bend the 3 tabs
on the burner down to secure the
floor firebacks.
a
c
Upper Rear
Fireback
Lower
Rear Fireback
Place the rear firebacks in
place. Note how the lower
fireback rests on the ledge
at the back of the firebox.
Side Fireback
While holding the rear firebacks in
place, slide the side firebacks
between the burner and side wall of
the firebox. The side firebacks hold
the back firebacks in place.
Replace the clip to secure the
side fireback (both sides).
d
e
Left Floor
Fireback
3 Restore the fireplace to the correct configuration.

36 CF / 1080 CF Firebacks
Two-Sided (Brick or Herringbone) Arched 96100166 –Rectangular 96100172
Two-Sided (Diamond or Stucco) Arched 96100168 –Rectangular 96100174
Whidbey Rock Creek –96100252 Constitution Basket Weave / Quilt - 96100175
Page 3 of 4 9/15/08 Travis Industries, Inc.
1080 CF Installation
1 Remove the glass frame logs and grate (see installation manual for details).
2 Remove and discard the ember tray and burner tray cover following the directions below.
Loosen the screw and remove the clips located on
the firebox ceiling (both sides).
a
Remove and discard
the ember tray and
the burner tray cover.
c
b
Remove this clip on
the firebox floor.
d
Remove this clip on the firebox
floor. Bend the clip upwards to
form a 90° angle.

36 CF / 1080 CF Firebacks
Two-Sided (Brick or Herringbone) Arched 96100166 –Rectangular 96100172
Two-Sided (Diamond or Stucco) Arched 96100168 –Rectangular 96100174
Whidbey Rock Creek –96100252 Constitution Basket Weave / Quilt - 96100175
Page 4 of 4 9/15/08 Travis Industries, Inc.
3 Install the firebacks following the directions below.
Right Floor Fireback
Left Floor Fireback
Upper Rear
Fireback
Lower
Rear Fireback
Place the floor
firebacks in place.
a
b
Place the rear firebacks in
place. The lower fireback
rests on the tabs on the back
wall of the firebox. Hold
them in place while installing
the side firebacks.
Side Fireback
c
Slide the side
firebacks into place
and replace the clip to
secure (both sides).
Replace these clips.
d