Volt VFL-4002-ABZ User manual

VOLT®Low Voltage Landscape Lighting
VOLT® LED Floodlights
VFL-12V Series
INSTALLATION INSTRUCTIONS
Specications and product details subject to change without notice.
© Copyright 2017, VOLT® Lighting, Lutz FL USA 33549 • All rights reserved.
[email protected] • 813.978.3700
Help Hotline:
1-813-978-3700 • Mon-Fri 8am-8pm • Sat-Sun 10am - 6pm (EST)
- 1 -

VOLT®Low Voltage Landscape Lighting
VFL 12V Floodlights
Important: Please Read Before Installation
Important Safety Instructions
INSTALLATION INSTRUCTIONS
This luminaire is intended for installation in accordance with local codes and the
National Electric Code (NEC). Failure to adhere to these codes and instructions may
result in serious injury, property damage and void the warranty.
These instructions do not intend to cover all variations in installation, operation
maintenance or mounting situation.
1. Make sure that the power is turned OFF before installing or servicing this
luminaire.
2. WARNING: risk of electrical shock. Install all luminaires 10 feet (3.05M) or more
from pool, spa or fountain.
3. This luminaire is intended to be used only with a power supply (transformer)
rated maximum of 300 watts (25 AMPS) at 15 volts.
4. Wiring connections must be made with wire connectors that are suitable for
outdoor use.
5. Position the low voltage wire and wire connector so that it is located within 6
inches (15.2 cm) from a building structure, a luminaire or tting.
6. The main low voltage cable is intended for shallow burial - less than 6 inches
(152 mm)
7. If additional lengths of low voltage cable are required, please contact www.
voltlighting.com or call 1-813-978-3700.
INSTRUCTIONS PERTAINING TO A RISK OF FIRE, OR INJURY TO PERSONS
Lighted lamp is HOT!
WARNING – TO REDUCE THE RISK OF FIRE OR INJURY TO PERSONS.
1. Turn off/unplug and allow to cool before replacing lamp.
2. Lamp gets HOT quickly! Contact only switch/plug when turning on.
3. Do not touch the hot lens, guard or enclosure.
4. Keep lamp away from materials that may burn.
5. Do not touch lamp at any time. Use a soft cloth. Oil from skin may damage
lamp.
6. Do not operate the luminaire tting with a missing or damaged shield.
SAVE THESE INSTRUCTIONS
!
!
www.voltlighting.com
- 2 -

Package Contents
Products Model #
A. (1) Lampbody
B. (1) Stake
[email protected] • 813.978.3700
C. (1) Coupler
D. (1) Hex Nut
- 3 -
Product Dimensions
5.59”
4.25” 4.52”
Model Input
Voltage
Power
Factor Watt Input Current Mounting
VFL-4002-ABZ
12V ≥0.95
10W 0.75A
YokeVFL-4004-ABZ 30W 2.3A
VFL-4006-ABZ 7W 0.57A
4.23”
1.89”
2.79”
0.77”
0.45”
VFL-4002-ABZ
VFL-4006-ABZ
8”
6.25” 9”
8.12”
2.67”
5.21”
0.83”
1.29”
VFL-4004-ABZ

www.voltlighting.com
INSTALLATION INSTRUCTIONS
- 4 -
Install Fixture to Stake
2
VOLT®Low Voltage Landscape Lighting
VFL 12V Floodlights
Install Stake
1
Determine the desired location for
mounting the xture. Hammer the
stake into the ground until ange
of stake is ush to grade. To avoid
damage to the stake, place a board
on top of the stake while hammering.
NOTE: If the ground is hard and the
stake is difcult to install, make a
crosscut in the ground using a at
shovel.
Board
Stake
Soil
Ground
Fixture
Coupler
Stake
Pigtail
Wireway Slot Hex Nut
Clear away an area in the ground
at the wireway slot on top of the
stake. Pass the supply wires from
the xture through the hex nut,
yoke mount and coupler. Then, lay
the supply wires pigtail into the
wireway slot and screw the coupler
onto the stake. Place the yoke
mount onto the coupler and secure
it with the hex nut. Tighten until
snug to secure the xture.
Yoke
Mount

[email protected] • 813.978.3700
- 5 -
Wire Connection
3
Strip both leads from the luminaire pigtail. Using two wire connectors
(sold separately), connect the leads from the luminaire to the main
supply cable leads.
Pigtail
Main Supply Cable
Wire Connectors
Adjust Fixture
4
Adjust the xture to the desired
orientation and tighten the screws
with the spanner.
Fixture
Screw
Spanner
After installation,
A. Check whether the lighting xture is rmly xed.
B. Check whether the wires are connected correctly.
Lastly, turn on the power and check if the lighting xture works correctly.
If not, turn off the power and contact your local electrician.

INSTALLATION INSTRUCTIONS
www.voltlighting.com
- 6 -
VOLT®Low Voltage Landscape Lighting
VFL 12V Floodlights

[email protected] • 813.978.3700
- 7 -
Specications and product details subject to change without notice.
© Copyright 2017, VOLT® Lighting, Lutz FL USA 33549 • All rights reserved.
[email protected] • 813.978.3700
www.voltlighting.com
Help Hotline:
1-813-978-3700 • Mon-Fri 8am-8pm • Sat-Sun 10am - 6pm (EST)

IS-VFL-12V-ver1.pdf
Specications and product details subject to change without notice.
© Copyright 2017, VOLT® Lighting, Lutz FL USA 33549 • All rights reserved.
[email protected] • 813.978.3700
www.voltlighting.com
Help Hotline:
1-813-978-3700 • Mon-Fri 8am-8pm • Sat-Sun 10am - 6pm (EST)
- 8 -