Volt VWL-705-BBZ User manual

VOLT®Low Voltage Landscape Lighting
VOLT®Salty Dog Brass MR16 Well Light
VWL-705-BBZ
INSTALLATION INSTRUCTIONS
Specications and product details subject to change without notice.
© Copyright 2019, VOLT® Lighting, Lutz FL USA 33549 • All rights
reserved. [email protected] • 813.978.3700
Help Hotline:
1-813-978-3700 • Mon-Fri 8am-8pm • Sat-Sun 10am - 6pm (EST)
–1–

VOLT®Salty Dog Brass MR16 Well Light
VWL-705-BBZ
INSTALLATION INSTRUCTIONS
www.voltlighting.com [email protected] • 813.978.3700
Package Contents
Parts Required (sold separately)
A. (1) Fixture
A. (1) MR16 Lamp
B. (1) PVC Tube
Product Dimensions
Important: Please Read Before Installation
Important Safety Instructions
!
!
This luminaire is intended for installation in accordance with local
codes and the National Electric Code (NEC). Failure to adhere to these
codes and instructions may result in serious injury, property damage
and void the warranty.
These instructions do not intend to cover all variations in installation,
operation maintenance or mounting situations.
1. Make sure that the power is turned OFF before installing or servicing
this luminaire.
2. WARNING: risk of electrical shock. Install all luminaires 10 feet (3.05M)
or more from pool, spa or fountain.
3. This luminaire is intended to be used only with a power supply
(transformer) rated maximum of 300 watts (25 AMPS) at 15 volts.
4. Wiring connections must be made with UL listed wire connectors that
are suitable for outdoor use.
5. Position the low voltage wire and wire connector so that it is
located within 6 inches (15.2 cm) from a building structure, a luminaire
or tting.
6. The main low voltage cable is intended for shallow burial - less than 6
inches (152 mm).
7. If additional lengths of low voltage cable are required, please call
1-813-978-3700.
INSTRUCTIONS PERTAINING TO A RISK OF FIRE, OR INJURY TO PERSONS
Lighted lamp is HOT!
WARNING – TO REDUCE THE RISK OF FIRE OR INJURY TO PERSONS.
1. Turn o/unplug and allow to cool before replacing lamp.
2. Lamp gets HOT quickly! Contact only switch/plug when turning on.
3. Do not touch the hot lens, guard or enclosure.
4. Keep lamp away from materials that may burn.
5. Do not touch lamp at any time. Use a soft cloth. Oil from skin may
damage lamp.
6. Do not operate the luminaire tting with a missing or damage shield.
–2– –3–
8.25”
6.25”
5.5”

INSTALLATION INSTRUCTIONS
www.voltlighting.com [email protected] • 813.978.3700
VOLT®Salty Dog Brass MR16 Well Light
VWL-705-BBZ
–4– –5–
Install Lamp
2
Remove Faceplate and Lens
1
Wire Connection
5
Install Lens and Faceplate
3
Dig Hole
4
3”3”
3”
PVC Tube
Hole
Soil
Loosen the thumb screws and
slide the housing down to
the end of the bars. Unscrew
the screws and remove the
faceplate, gasket, and lens from
the housing.
Screw
Faceplate
Gasket
Lens
Thumb Screw
Housing
Insert the lamp with the correct
wattage and type marked on the
xture label.
CAUTION: Do not exceed maximum
wattage marked on luminaire label.
NOTE: DO NOT touch lamp with
bare hands. Use soft cloth to handle
lamp.
MR16 Lamp
Socket
Place the lens, gasket and
faceplate back onto the housing.
Secure them with the screws
previously removed. Hand tighten
until snug, then use a screwdriver
to secure the screws using a star
pattern. Adjust housing to your
desired height and angle, then
secure it in place with the thumb
screws.
Screw
Faceplate
Gasket
Lens
Thumb Screw
Housing
Dig a hole in the ground making
sure there is approximately
3 inches of room on all sides
surrounding the PVC tube for pea
gravel or sand.
Place the xture onto the PVC
Tube. Pass the luminaire pigtail
through the PVC tube.
Strip both leads from the
luminaire pigtail. Using two wire
connectors (sold seperately),
connect the leads from the
luminaire to main supply cable
leads.
PVC Tube
Wire Connector
Main Supply Wire
Soil
Pigtail
Fixture

INSTALLATION INSTRUCTIONS
www.voltlighting.com
VOLT®Salty Dog Brass MR16 Well Light
VWL-705-BBZ
–6–
Fill Pea Gravel or Sand
6
[email protected] • 813.978.3700
–7–
Soil
PVC Tube
with Fixture
Pea Gravel
or Sand
Install the PVC tube with
xture in the hole and ll the
extra space with pea gravel or
sand for proper water drainage.

IS-VWL-705-BBZ-ver2.pdf
Specications and product details subject to change without notice.
© Copyright 2019, VOLT® Lighting, Lutz FL USA 33549 • All rights
reserved. [email protected] • 813.978.3700
www.voltlighting.com
Help Hotline:
1-813-978-3700 • Mon-Fri 8am-8pm • Sat-Sun 10am - 6pm (EST)
–8–