Volvo 30758234 User manual

Instruction No Version Part. No.
8639661 1.1 30758234, 8639658, 31439072
ISOFIX mounting child seat, rear
Instruction No Version Part. No.
8639661 1.1 30758234, 8639658, 31439072
ISOFIX mounting child seat, rear
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation ISOFIX mounting child seat, rear- 8639661 - V1.1
Side 1 / 12

Equipment
A0000162 A0000161
J8903389
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation ISOFIX mounting child seat, rear- 8639661 - V1.1
Side 2 / 12

INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
Note!
The following text describes how to install the ISOFIX
mounting on the left-hand side, it can, however, also be
installed on the right-hand side of the rear seat in the
corresponding way.
1
J8504621
Steps 1-6 apply to the S40 (04-) and V50
Fold the left-hand seat cushion and rear seat backrest forward.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation ISOFIX mounting child seat, rear- 8639661 - V1.1
Side 3 / 12

2
J8504626
Grasp the upper edge of the left-hand side cushion A. Pull the
side cushion forward so that the clips on the reverse release.
Remove the side cushion by sliding it upwards.
3
J8903474
Remove the screw for the left-hand rear backrest mounting in
the body. Fold up the bracket over the mounting in the backrest.
Lift up the free end of the backrest and pull it off from the right.
Position the backrest behind the backrest of the front seats.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation ISOFIX mounting child seat, rear- 8639661 - V1.1
Side 4 / 12

4
J8903431
Pull off the rear edge of the floor carpet from the floor support.
Fold the carpet to one side to expose the attachment points for
the ISOFIX mounting in the floor.
Remove the screws from the support bracket, new screws are in
the kit.
Remove the cover plug from the floor, it will no longer be used.
5
J8903390
Install the ISOFIX mounting, from the kit, over the weld nuts.
Tighten the mounting using the two screws. Tighten to 40 Nm
(30 lbf.ft.).
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation ISOFIX mounting child seat, rear- 8639661 - V1.1
Side 5 / 12

6
J8903391
Fold the floor carpet back into place and insert the ISOFIX
mounting's eyelets in the two cut-outs. Insert the rear edge of
the floor carpet under the floor support. If necessary, pry up the
floor support to make room.
Reinstall the backrest. Tighten the screws to 40 Nm (30 lbf.ft).
Reinstall the side bolster.
Fold the seat cushion back into place.
7
IMG-241185
Steps 7-19 apply to the C30
Pull off the seat cushion, first at the rear edge where it is
secured by one holder. Then at the front edge where it is
secured by two holders.
Remove the seat cushion.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation ISOFIX mounting child seat, rear- 8639661 - V1.1
Side 6 / 12

8
IMG-246643
Fold the central arm rest forward.
Remove the central arm rest by grasping each end and pulling
upwards until it releases at the rear edge from the backrest's
lugs (1).
Then pull forwards until the holders (2) on the sides of the
backrest have slid out of the corresponding cut-out (3) in the
central arm rest.
9
IMG-241186
Fold the backrest forward.
Remove the panel for the backrest's left-hand mounting.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation ISOFIX mounting child seat, rear- 8639661 - V1.1
Side 7 / 12

10
IMG-241187
11
IMG-241188
Fold the backrest away from the left-hand mounting.
Pull it out from the mounting at the armrest and remove it.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation ISOFIX mounting child seat, rear- 8639661 - V1.1
Side 8 / 12

12
IMG-251863
Insert the mounting under the insulation panel and move the
brackets up in the slots in the insulation panel
13
IMG-251864
Take the two screws from the kit. Tighten the mounting. Tighten
to 40 Nm (30 lbf. ft.).
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation ISOFIX mounting child seat, rear- 8639661 - V1.1
Side 9 / 12

14
IMG-241371
Reinstall the backrest. Check that it is securely in its mountings.
15
IMG-252251
Secure the backrest in the left-hand mounting with the screw
and lock pin.
Tighten the backrest and check that it is securely in its
mountings. Torque tighten the screw to 25 Nm (18.5 lbf.ft.).
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation ISOFIX mounting child seat, rear- 8639661 - V1.1
Side 10 / 12