Volvo R8902705 User manual

Instruction No Version Part. No.
8641363 1.0
Table in the cargo compartment opening
R8902705
Instruction No Version Part. No.
8641363 1.0
Table in the cargo compartment opening
R8902705
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Table in the cargo compartment opening- 8641363 - V1.0
Page 1 / 6

Equipment
A0000162 A0000165
R8902707
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Table in the cargo compartment opening- 8641363 - V1.0
Page 2 / 6

INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
1
R8902710
Open the upper and lower tailgates
Fold up and lock the floor extension in the upright position
Remove the two inner screws in the hinge on the lower tailgate
Install the mounting bracket (from the kit) between both hinges.
Tighten the mounting bracket using the two screws. Tighten the
screws. Tighten to 50 Nm (37 lbf. ft).
2
R8504108
Saw out the centre of the floor extension inside the inner
marking on the underneath
Even off the edges using a file
Remove any swarf.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Table in the cargo compartment opening- 8641363 - V1.0
Page 3 / 6

3
R8902720
Remove the table top from the kit. Turn the table top upside
down
Take the knob and table leg from the kit. Secure the table leg to
the table top using the nut in the plate profile. See the
illustration. Do not tighten the knob yet.
4
M8901885
Adjust the position of the table leg sideways as desired. Tighten
the knob.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Table in the cargo compartment opening- 8641363 - V1.0
Page 4 / 6

5
R8902708
Ensure that both locking knobs (3) on the lower section of the
table leg are unscrewed from the mounting as far as possible
without the leg detaching
Install the table on the mounting bracket, as illustrated (1). Fold
out the support leg (2). Lower the table so that the support leg
rests against the lower tailgate
Lock the table using both locking knobs (3).
6
R8504109
When the table is not being used
Press the panel (from the kit) over the hole in the floor
extension.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Table in the cargo compartment opening- 8641363 - V1.0
Page 5 / 6

7
M8901981
Note!
The maximum permitted load of the table is 12 kg.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Table in the cargo compartment opening- 8641363 - V1.0
Page 6 / 6