Volvo 31210148 User manual

Instruction No Version Part. No.
31285433 1.1 31210148, 30775917
Handsfree, Bluetooth mute kit
Instruction No Version Part. No.
31285433 1.1 31210148, 30775917
Handsfree, Bluetooth mute kit
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 1 / 29

Equipment
A0000162 IMG-242205
IMG-251783
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 2 / 29

IMG-213320
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 3 / 29

INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
Note!
Cars with Performance Sound audio system have an internal
amplifier that is located in the media player.
Cars with High Performance and Premium Sound audio
systems have an external amplifier, which is located on the
right side by the rear seat.
Note!
Steps 1-13 apply to all cars
Steps 14-34 apply to cars with internal amplifier
Steps 35-44 apply to cars with external amplifier
Steps 45-50 apply to all cars
Note!
Steps 14-44 show installation on a left-hand drive car. When
installing on a right-hand drive car, the operations are
performed on the opposite side and/or mirrored. Where the
steps differ, the right-hand drive car is also shown with text
and illustration.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 4 / 29

1
IMG-214981
Turn the ignition switch to position 0.
Note!
Wait at least three minutes before unplugging the connectors
or removing other electrical equipment.
2
IMG-250925
Pull off the seat cushion for the rear seat, first at the rear edge
where it is secured by one holder. Then at the front edge where
it is secured by two holders.
Remove the seat cushion.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 5 / 29

3
IMG-250926
Fold the central arm rest forward.
Remove the central arm rest by grasping each end and pulling
upwards until it releases at the rear edge from the backrest's
lugs (1).
Then pull forwards until the holders (2) on the sides of the
backrest have slid out of the corresponding cut-out (3) in the
central arm rest.
4
IMG-250927
Fold the backrest forward.
Remove the cover for the backrest's right-hand mounting.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 6 / 29

5
IMG-250928
Remove the screw and the locking sleeve.
6
IMG-250929
Fold the backrest away from the right-hand mounting.
Note!
The backrest may be securely attached.
Pull it out from the mounting at the arm rest and remove it.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 7 / 29

7
IMG-250930
Pull off the rubber molding at the rear edge of the right-hand
door opening.
8
IMG-251368
Detach the B pillar panel at the rear edge by prying the sides
using a weatherstrip tool until the two clips release.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 8 / 29

9
IMG-251369
Unhook the safety clip from the panel.
Angle out the panel at the lower edge, and then unhook it at the
upper edge so that the upper clip releases.
10
IMG-251370
Remove the screw from the right-hand panel in the rear seat.
Carefully pull off the panel from the body side. It is secured by
eleven clips on the inside.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 9 / 29

11
IMG-240957
Lift out the floor carpet.
12
IMG-241183
Remove the tailgate's sill panel by pulling it up until the four clips
on the upper side and the eight catches at the lower edge
release.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 10 / 29

13
IMG-253759
Remove the clips at the rear edge of the right-hand rear side
panel.
Carefully pull the side panel off, starting at the front edge/upper
edge and then straight back until all clips at the top edge have
released.
Fold the panel inwards. Release it from the anchorage eyelets
and lift it out of the load floor support.
14
J8504532
Applies to cars with internal amplifier
Open the glovebox.
Pry off the panel in front of the center console. It is secured with
two clips on each short side.
Pull the panel away downwards.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 11 / 29

15
IMG-239762
Apply tape to the center console to protect it during removal and
installation of the glove compartment.
16
IMG-240082
Remove the panel.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 12 / 29

17
IMG-244221
Detach the clip holding the vent from the glove compartment.
18
J8803318
Remove the rubber mat from the glovebox.
Remove the five screws in the opening.
Pull the glovebox straight back to release the two hidden clips at
the upper edge.
Remove the outer section of the glovebox.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 13 / 29

19
IMG-222669
Unplug the connectors on the top.
20
IMG-239763
Remove the screws for the vent.
Pull off the vent to the right and place to one side.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 14 / 29

21
IMG-250923
Detach the front sill molding by first pulling it backwards at the
front edge and then straight up so that the clips release.
22
IMG-250924
Detach the rear sill molding by first pulling it up at the front edge,
and then unhooking it at the rear edge.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 15 / 29

23
IMG-239780
Fold the carpet to the right of the center console.
24
IMG-239783
Locate the relay and lift it out.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 16 / 29

25
IMG-258623
Lift off the foam tape slightly and remove the connectors.
26
IMG-258624
Take the two cable harnesses from the kit and connect them to
the disconnected connectors.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 17 / 29

27
IMG-258625
Connect the new cable harnesses to the relay.
Fold the tape back into place.
28
IMG-258626
Take the foam tape from the kit and cut it off in the middle. Tape
one piece around each connector.
Reinstall the relay.
Fold back the carpet.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 18 / 29

29
IMG-248570
Route the yellow cable on the impact pipe and continue along to
the sill.
Secure the cable using two tie straps
30
J8504868
Unscrew the clips holding the floor carpet.
Fold the carpet to one side.
Note!
Take care not to create folds in the carpet.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 19 / 29

31
IMG-251374
Applies to left-hand drive cars
Route the wire from the bottom edge of the A-pillar, backward
under the floor mat, under the seat raiser and on backward in
the car.
32
IMG-251423
Applies to right-hand drive cars
Route the wire from the bottom edge of the A pillar, continue
under the floor mat, and behind the large side panel.
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Handsfree, Bluetooth mute kit- 31285433 - V1.1
Page 20 / 29