WaterLogic CUBE User manual

CUBEManual Page4–Revision10‐8‐2018

SAFETYALERTSYMBOLS

Readandfollowallsafetyinformationcarefully.Thesignalwordsusedinthismanualareselectedas
shownbelowandbasedonanassessmentofthedegreeofpotentialinjuryordamage(severeorminor)
andtheoccurrenceofinjury(definitelyoccursorhasthepotentialtooccur)whenthewarningis
ignored:

DANGER!
Indicatesasituationwhich,whennotavoided,resultsindeathorsevereinjury.

WARNING!
Indicatesasituationwhich,whennotavoided,hasthepotentialtoresultindeathorsevere
injury;and/orseverepropertydamage.


CAUTION!
Indicatesasituationwhich,whennotavoided,resultsorhasthepotentialtoresultinminor
injury;and/orminorpropertydamage.

SAFETYPRECAUTIONS

Basicsafetyprecautionsshouldbefollowed,includingthefollowing:
Ensurealllocal,state,andfederallawsandcodesincludinghealthandsafetyguidelinesaremetwhen
installingWaterlogicEquipment.Onlyqualifiedservicetechniciansshouldattemptinstallationand
serviceofWaterlogicEquipment.Alwaysreadtheentireoperatinginstructionsbeforeusingthe
applianceandsavetheseinstructionsforfutureuse.

DANGER!ELECTRICALSHOCKHAZARD.Alwaysuseadedicatedandproperlygroundedoutlet.Unit
shouldbeprotectedbyground‐faultcircuitinterrupter(GFCI)orresidualcurrentdevice(RCD)having
aratedresidualoperatingcurrentnotexceeding30mA.UseonlyWaterlogicsuppliedpowercord.
Neveruseextensioncordsorpowerstripstoconnectunit.Donotuseifthepowersupplycordis
damaged.Alwaysunplugfrompowersupplypriortoservicing.

WARNING!AUTHORIZEDUSEONLY.Thisapplianceistobeusedforitsintendedpurposeas
describedinthismanualanduntrainedindividualswhousethismanualassumetheriskofany
resultingpropertydamageorpersonalinjury.Thisappliancecan’tbeusedbychildrenandpersons
withreducedphysical,sensoryormentalcapabilitiesorlackofexperience.

WARNING!UV‐CEMITTER(UVLAMP).ThisappliancecontainsaUV‐Cemitter(UVLamp).
UV‐Cradiationmay,eveninlittledoses,causeharmtotheeyesandskin.Unintendeduseordamage
tothehousingmayresultintheescapeofdangerousUV‐Cradiation.NeveroperatetheUV‐C
emitterifdamagedorremovedfromenclosure.Donottouchorlookdirectlyintothefaucet.

WARNING!DONOTOPERATEIFDAMAGED.Unplugandisolatewatersupplyifabnormalconditions
exist.ContactWaterlogicorauthorizeddealerforrepair,service,andinstallationtoavoidhazards.


CUBEManual Page5–Revision10‐8‐2018

WARNING!HOTWATER.UnitproducesHotWaterinexcessof87
o
C(188
o
F).Waterabove52
o
C
(125
o
F)cancausesevereburnsorscalding.Keepunauthorizedpeopleandchildrenawayfromthe
unittoavoidaccidentaldispensingofhotwater.

WARNING!CONNECTTOPOTABLEWATERSUPPLY.Thissystemistobeusedforwateronlyandis
notintendedforusewherewaterismicrobiologicallyunsafeorwithwaterofunknownquality
withoutadequatedisinfectionbeforeorafterthesystem.

WARNING!STOREANDTRANSPORTUNITEMPTY.ALWAYSSANITIZEBEFOREUSE.
Theunitmustbecompletelydrainedandsealedbeforestoringtoavoidstagnationandreduce
microbiologicalcontamination(potentialbacterialgrowth).Sanitizebeforeusetoeliminateany
potentialmicrobiologicalcontaminates 

CAUTION!INDOORUSEONLY.Intendedforhouseholduseonly.Neverexposetodirectsunlight,
heatsources,orambientairtemperatureabove37°C(100°F)orbelow2°C(35°F).Installindoorsand
keepunitawayfromexcessivehumidity.Neverexposetofreezingtemperatures.Ensurethereis
adequateclearancearoundtheunittoallowrefrigerationsystemcondensertodissipateheat.
Warmerenvironmentsrequiremoreclearancearoundtheunit.Minimumclearancearoundall
surfacesofthemachineis2‐inches.Installswheretheambienttemperatureexceeds27°C(80°F),
requireaminimumof4‐inchesclearanceforproperheatdissipationandefficientoperation.

CAUTION!USEAWATERPRESSUREREGULATOR.Waterlogicwillnotberesponsibleforinjuryor
damagecausedbyexcessivewaterpressure.Inputorfeedpressuremustbe40psito60psi.Be
awareofanypotentialpressuresurgescausedbybuilding/municipalpumpingstations.

CAUTION!USEUVSTABILIZEDSUPPLYLINES.Feedtheunitwithapotableambientorcoldwater
supplyonly.Feedwaterover37°C(100°F)candamagethetreatmentcomponents.Waterblock
devicesandexternalleakdetectorsarestronglyrecommended.Locatetheunitasclosetothewater
supplyandtheelectricalconnectionsaspossible.Locatetheunitasclosetothewatersupplyand
theelectricalconnectionsaspossible.Immediatelyisolateorclosewatersupplyvalveandcontact
servicerepresentativeifleakisnoticed.



ContactWaterlogicforassistanceorhelpfindinganAuthorizedServiceRepresentative.


CUBEManual Page6–Revision10‐8‐2018

CUBEFEATURESANDBENEFITS


Firewall™UVPurification
Firewall™proprietarytechnologypurifiesoutgoingwateratthepoint‐of‐
dispense.Firewall™keepsthedispensenozzlefreefromexternalcontamination
aswellaspurifyingtheoutgoingwater,makingthesafestwaterpossibleevery
singledispense.

Cold,Ambient,Hot,andExtraHotWater
PressureFedAmbient,Cold,Hot,andExtraHotSelectionstomeetawiderangeofcustomerdemands.

VolumeStorageandWaterCapacity
1.4litersofCold,1.3litersofHotWaterStorage.

BioCote®Anti‐MicrobialProtection
Certainplastic,silicon,andpaintedsurfacessurroundingthedispensingareasanddrip
trayareinfusedwithanexclusiveadditivecalledBioCote®.BioCote®providesan
effectivebarrieragainstmicrobeslikebacteriaandmold,whichmaycauseodorsor
staining.

LargeDispenseAreawithRecessedFaucet
6.4inchdispenseheightwithBioCote®recessedfaucettoprotectfromcross‐contamination.

LeakSensorandAlarm
LeakSensorandAlarmFullFaultModethathaltssupplytopreventoverflowandsoundsalarmto
reduceaccidentpotential.

DigitalDisplay
TheCUBE WaterTreatmentSystem hasaninnovativeuserinterfaceutilizingaLCDdisplayforeasyuse
andprogramming.

AdvancedProgramming
CustomizablesettingsforoptimizingeachCUBE WaterTreatmentSystem including;ColdTempSetPoint,
HotTempSetPoint,UVTimer,FilterTimerSetting,FilterLifeMonitor, EnergySavingSleepMode ,and
DefaultSelectionMode.

EnergySavingSleepMode
EnergySavingSleepModecanbeprogrammedtoturnoffHeaterafter3houror72hoursofHot
Dispenseinactivity.

FilterTimer
Selectionincludesthechoiceof3differentfilterreplacementsettingsvariationsprogrammedfor3,9or
12months.TheFilterTimeralsohasanoptiontobeturnedoff,whichisthedefaultsetting.

ChildSafeguard
CUBE WaterTreatmentSystem requiresselectionfollowedbymaindispenseanddefaultsbacktocold
waterselectionafter3secondsofinactivitytopreventaccidentaldispensingofhotwater.

CUBEManual Page7–Revision10‐8‐2018

CUBECERTIFICATIONS

WaterlogicWaterTreatmentSystemshavebeentested,andcertifiedtorigorousNSFandUL
Standards.WebelievethatperformancetestingandcertificationsvalidateWaterlogicasaworld‐
leaderinwatertreatmentsystems.
CUBEWaterTreatmentSystemCertificationsInclude

UL399–CertifiedDrinkingWaterCooler
IntertekLabs(ETL)CertifiedtheCUBEWaterTreatmentSystemtoANSI/UL399Standardfor
DrinkingWaterCoolers.

CSAC22.2No.120CSAStandardforRefrigeration.

NSF/ANSI‐55ClassA–UltravioletMicrobiologicalWaterTreatmentSystems
WaterQualityAssociationisaninternationalstandardsorganization.Firewall™Technology
containsourlatest,mostinnovativeandpatentedbreakthrough,“TheFirewall™”,themost
comprehensiveUVpurificationsystemforpoint‐of‐usewatertreatmentsystemsever
developed.TheWaterlogicFirewall™componentshasbeentestedandcertifiedbythe
WaterQualityAssociation(WQA)toNSF/ANSI‐55ClassA–UltravioletMicrobiologicalWater
TreatmentSystems,andtoNSF/P231andtheUSEPAStandardforMicrobiologicalWater
Purifiers.

NSFP231–ProtocolforMicrobiologicalPurifiers
ThePublicHealthandSafetyOrganizationestablishesminimumrequirementsforhealthand
sanitationcharacteristicsofmicrobiologicalwaterpurifiers.Therequirementsarebasedon
therecommendationsoftheU.S.EnvironmentalProtectionAgency'sTaskForceReport.

NSF/ANSI‐42–Chlorine,TasteandOdorReduction
NSF/ANSI‐53–LeadandCystReduction
ThePublicHealthandSafetyOrganizationestablishesminimumrequirementsformaterials,
design,construction,andperformanceofdrinkingwatertreatmentunitsthataredesigned
toreducespecificaesthetic‐relatedcontaminantsinpublicorprivatewatersupplies.

BPAFree‐WaterlogictestsforBPAanddeclaresthatallofitsproductsareBisphenol‐AFREE
andcontainnoharmfulBPAplastics.


WaterlogiciscertifiedtoISO9001:2015–QualityManagementSystems(certified
byIntertek).ISO9001istheinternationallyacceptedstandardforwellmanaged
organizationsthathaveadoptedthekeyqualitymanagementprinciplestoits
operationstobringconsistentqualityproductsandacultureofcontinuousimprovement.

SafeDrinkingWaterAct
WaterlogicwatertreatmentsystemsconformtotheSafeDrinkingWaterAct(SWDA)“lead‐free”
amendmenteffectiveJanuary4,2014,andWaterlogichastestedforBPAanddeclaresthatallofits
productsareBisphenol‐AFREEandcontainnoharmfulBPAplastics.

CUBEManual Page8–Revision10‐8‐2018

MODEL/PARTDESIGNATIONS

BRANDNAME DESCRIPTION
CUBEWaterTreatmentSystem
WaterlogicCUBE–Ambient,Cold,Hot,andExtraHot
ModelF‐FWCU1‐M‐HCA‐TT‐SB‐IN1
SerialNumberPrefix:81orTC2H316SB


SPECIFICATIONS
ITEM

SPECIFICATION
Water ¼”QuickConnect
ColdWaterTemperature ColdWaterTemperature
–
FactorySetPoint5°C(41°F)
(Adjustable)10°Cor15°C(50°For60°F)
ColdWaterCapacity 1.4Liter(0.37Gallons)ColdTank
HotWaterTemperature FactorySetPoint86
°
C (187°F)
Programmable70°‐95°C(158°‐203°F)
HotWaterCapacity 1.3Liter(0.34Gallons)HotTank
ExtraHotWaterTemperature FactorySetPoint95°C(203°F)
HotTankManualResetOverload 105°C(221°F)
RecommendedIncomingFeed
Pressure 40‐60psi(275‐414kPa)–UsePressureRegulator
MaximumWorkingPressure 60psi(414kPa)–UsePressureRegulator
RatedServiceFlowOut 0.42gallonsperminute(1.6Lpm)‐Firewall™Purification
EnvironmentalTemperature2°‐37°C(35°‐100°F)
RefrigerantGas R134a‐55grams(1.94oz.)‐Hi(280psi)Low(90psi)
R134aPressures High(230psi),Low(90psi)




CUBEManual Page9–Revision10‐8‐2018

SHIPPINGSPECIFICATIONS
ITEM

SPECIFICATION
Width/Depth/Height#356mm(14inches)x483mm(19inches)x432mm(17inches)#
Weight–Dry(w/o
packaging) 15kg(30pounds)
ShippingInformation
Width/Depth/Height
508mm(20inches)x560mm(22inches)x560mm(22inches)
8unitsperpallet
ShippingWeight–Dry 19kg.(41pounds)


#CUBEis17inchestallandmaynotfitbetweencountertopsandcabinets‐Checkinstallationtoensureadequateclearance.
ELECTRICALSPECIFICATIONS
ELECTRICALSUPPLY 120V/60Hz 15AmpService+
COMPONENT POWER(approximate) AMPDRAW(approximate)
Heater500Watts4.2Amps
Compressor 210Watts 1.75Amps
UVLampSystem 13Watts 0.11Amps
CUBETOTAL723Watts6.06Amps




CUBEManual Page10–Revision10‐8‐2018

OPERATINGINSTRUCTIONS
















TheabovepictureshowsfrontLCDdisplayandcontrolpanelfortheWaterlogicCUBEWaterTreatment
System.

Button OperationalUse

 

SelectColdWaterSelection+PressandHoldDispensingButtontostart
dispensinguntildesiredfill.

 

SelectAmbientWaterSelection+PressandHoldDispensingButtonto
startdispensinguntildesiredfill.

 
Holdfor3seconds 
PressandHoldHotWaterSelectionfor3seconds,untiltheHotWater
Iconisilluminated.Press+PressandHoldDispensingButtonuntil
desiredfill.Thedelayisasafetyfeaturethatpreventshotwaterfrom
beingaccidentlydispensed.






HoldExtraHotSelectionuntil
buttonstopsflashingwhich
indicatesthetemperaturehas
beenreached.

PressandHoldExtraHotWaterSelection.TheExtraHotSelection
Buttonwillflashredtoindicatethewaterisheating.Whenthered
flashingiconturnsoff,thisindicatesthatthewateristothe
temperature.

PresstheHotWaterSelectionButton+PressandHoldDispensingButton
untildesiredfill.

WARNING!UnitproducesVeryHotWaterupto95°C(203°F).Water
above52°C(125°F)cancausesevereburnsorscalding.Keep
unauthorizedpeopleandchildrenawayfromtheunittoavoid
accidentaldispensingofhotwater.Childrenshouldnotusewithout
supervision.
 
Holdfor3seconds 

CUBEManual Page11–Revision10‐8‐2018

Dispensingyourchoiceofwaterisverysimple.

1. Placeyourcupcentrallyinthedispenseareawhichis163
mm(6.4inch)dispenseheight.TheDripTraycanbe
removedforfillingbottlesorothercontainerslargerthan
thedispensearea.

2. Selectthetypeofwateryouwishtobedispensedby
press/touchingtheCold,AmbientorHotwaterselecticon
untilitilluminates.

3. SelecttheDispenseButtoninthemiddleofthepanelto
dispensewater.

4. WaterSelectionisdispensedviaaPush‐To‐Dispense
method.Pressandholdthedispensebuttonuntilyourcup
hasreachedthedesiredlevel.


WARNING!UnitproducesVeryHotWaterupto95°C(203°F).Waterabove52°C(125°F)cancause
severeburnsorscalding.Keepunauthorizedpeopleandchildrenawayfromtheunittoavoid
accidentaldispensingofhotwater.Childrenshouldnotusewithoutsupervision.

WARNING!Alwaysuseaceramiccuporacupsuitableforusewithhotwater.

WARNING!Donotholdcuporplacehandsindispensingareawhiledispensinghotwater.

WARNING!Nevertrytofillmorethanonecupatatime.






CUBEManual Page12–Revision10‐8‐2018

WATERLOGICMANUFACTUREDWATERTREATMENTSYSTEMLIMITEDWARRANTY
UNITEDSTATESANDCANADAONLY


Waterlogicwatertreatmentsystemsareguaranteedtotheoriginalpurchasertobefreeofdefectsin
materialsandworkmanshipforaperiodofthree(3)yearsfromthedateofpurchase,butinnoevent
longerthanforty‐eight(48)monthsfromthedateofmanufacture.WaterlogicCommercialProducts,LLC
(“Waterlogic”)basedintheU.S.A.anditsaffiliatedcompaniesarenotliableforanycostofremoval,
installation,transportation,oranyotherchargeswhichmayariseinconnectionwithawarrantyclaim.

Thiswarrantydoesnotcoverdamageorweartoproductscausedbyabnormaloperatingconditions,
accident,abuse,misuse,unauthorizedorimproperalterationorrepair,damagecausedbyorresulting
fromshippingoraccident,damagecausedbyhotwater,freezing,flood,fire,oractsofGod.Theeffects
fromchlorinecorrosion,scalingandnormalweararespecificallyexcludedfromthiswarranty.This
warrantydoesnotcoverproductsusedoutsidethecountrieswheretheunitwaspurchased,anddoesnot
coverproductsthatwerenotinstalledinaccordancewithWaterlogicprintedinstallationandoperating
instructionsobtainedintrainingorfromwww.waterlogic.us.Failuretofollowallinstructionsforoperation
andmaintenancevoidsthewarranty.Thiswarrantyisnottransferable.

Toobtainwarrantyrepairsorreplacement,youmustobtainaReturnAuthorizationfromWaterlogic.To
obtainaReturnAuthorization,youmustsubmitaReturnAuthorizationformwithsupporting
documentationtoWaterlogicforevaluation.Theformisavailableatwww.waterlogic.us.Supporting
documentationmustinclude,butisnotlimitedto;proofofpurchase,installationdate,failuredate,and
supportinginstallationandmaintenancedata.AfteryousubmitaReturnAuthorizationformand
supportingdocumentation,Waterlogicwilldeterminewhetherareasonablyapparentdefectinmaterials
orworkmanshipcoveredbythislimitedwarrantyexists.IfWaterlogicdeterminestheclaimeddefectis
coveredbythiswarranty,Waterlogicwill,atitssolediscretion,determinewhethertocorrectthedefector
replacetheunit,freeofchargetoyou.IfWaterlogicdeterminesthattheunitshouldbereturnedfor
warrantyservice,WaterlogicwillapproveofreturninwritingandwillissueaReturnAuthorizationwhich
youmustobtainpriortoshippingtheproduct.YouareresponsibleforthecostoffreightintoWaterlogic.

Waterlogicanditsaffiliatedcompaniesherebylimitthedurationofanyandallimpliedwarrantiestoa
maximumperiodofthree(3)yearsfromthedateofpurchaseincluding,butnotlimitedto,theimplied
warrantiesofmerchantabilityandfitnessforaparticularpurpose.Somestatesdonotallowlimitationson
howlonganimpliedwarrantylasts,sotheabovelimitationmaynotapplytoyou.Consequentialand
incidentaldamagesarenotrecoverableunderthiswarranty.Somestatesdonotallowtheexclusionor
limitationofincidentalorconsequentialdamages,sotheabovelimitationorexclusionmaynotapplyto
you.

Thiswarrantygivesyouspecificlegalrightsandyoumayalsohaveotherrightswhichmayvaryfromstate
tostate.

NewWarrantyPolicyissuedbyWaterlogicCommercialProductsLLC,USA‐January10,2014

WaterlogicCommercialsProductsLLCTel:(800)288‐1891
11710StonegateCircle Website:waterlogic.us
Omaha,NE68164
