Whalen WSWB60-3DR-E User manual

Date: 2017-06-13 Rev. 0001-A
Whalen Furniture Manufacturing 1 Factory # HAIOFF
IMPORTANT, RETAIN FOR FUTURE REFERENCE: READ CAREFULLY
Customer Service: 1-866-942-5362
English, Spanish and French only
Monday - Friday, 8:30 a.m. - 4:30 p.m. PST
www.whalenfurniture.com
190 cm
74.8 in
74.8 po
91.7cm
36.1 in
36.1 po
77.5 cm
30.5 in
30.5 po
152.4 cm
60 in
60 po
60'' Workbench with Cabinet
MODEL # WSWB60-3DR-E

2
1. Please read instructions prior to assembly. Please note that there are recommended tools not included in this package.
2. Verify that there are no missing parts.
3. Keep instructions for future reference.
4. Two people are recommended for assembly.
5. Gently set parts on a flat, smooth surface.
6. For indoor use.
7. Please remove the protective film after assembly complete.
Entire unit maximum capacity:
600
kg
/
1320
lb
A
20 kg / 44 lb
LOAD CAPACITY
A
D
E
B
C
C
6.4 kg / 14 lb
E
136.4 kg / 300 lb
B
38.2 kg / 84 lb
D
340.2 kg / 750 lb
Failure to follow these guidelines can result in property damage or personal injuries.

A
B
C
N
D
EN
F
G
H
I
J
K
L
M
N
N
O
O
R
Q
ST
U
U
V
V
P
H
K
AA
CC
BB
P
W
W
A - Top Panel x 1 pc
B - Mid Panel x 1 pc
C - Back Panel x 1 pc
D - Left Side Panel x 1 pc
Parts List
3
DD
EE
GG FF
HH
HH

E - Bottom Panel x 1 pc F - Peg Board x 1 pc G - Wood Panel x 1 pc H - Top Beam x 2 pcs I - Wire Deck x 1 pc
J - Left Side Frame x 1 pc K - Bottom Beam x 2 pcs L - Right Side Panel x 1 pc M - Shelf x 1 pc N - Triangle Decorate x 4 pcs
O - Mid Decorate x 2 pcs P - Tie Support x 2 pcs Q - Right Door Panel x 1 pc R - Mid Door Panel x 1 pc S - Left Door Panel x 1 pc
Parts List
4

Assembly Instructions
Please wait until all steps are completed before fully tightening bolts
6
x 18 pcs
x 10 pcs
BB
A
DE
L
B
C
BB
Philips Head Bolt M5x15mm
BB
Philips Head Bolt M5x15mm
x 3 pcs
HH
Magnet Block
HH
A
HH

x 24 pcs
AA
Hex Bolt M10 x 20mm
x 24 pcs
FF
M10 Spring Washer
x 24 pcs
GG
M10 Nut
H
K
K

x 16 pcs
CC
G
U
U
CC
Screw M5 x 20mm
V
EE
x 4 pcs
EE
M20 Spring Washer

x 6 pcs
BB
Philips Head Bolt M5x15mm

BB
x 10 pcs
F
BB
Philips Head Bolt M5x15mm

I
P

Care and Maintenance
 Use a soft, clean cloth that will not scratch the surface when dusting.
 Using solvents of any kind on your product may damage the finish.
 Do not use any harsh abrasives or chemicals to clean any metal surfaces as it may damage the protective coating.
 Metal will rust if the finish is scratched or if your product is exposed to excessive humidity, particularly in salt water locations
LIMITED LIFETIME WARRANTY
This product is warranted to the original purchaser. If there is a failure in this unit due to defects in materials or workmanship, the
manufacturer will repair or replace this item at our discretion without charge. Warranty is void if product has been assembled incorrectly,
misused, abused by overloading, altered in any way or damaged due to accident. This warranty is not transferable and does not cover
chipping, flaking, scratches, rust, dents, or other damages to the surfaces of this product. Responsibility of the manufacturer is limited to
repair or replacement of this product. The manufacturer is not responsible for consequential, incidental, or other damages or losses
resulting from product failure.
This warranty is in lieu of all other expressed warranties. Some states do not allow the exclusion or limitation of incidental or
consequential damages, so the above limitation may not apply to you. This warranty gives you specific legal rights and you may have
other rights which vary from state to state.
In case of product failure, damage or defective parts refer to:
Whalen Furniture manufacturing
1578 Air Wing Rd.
San Diego, CA. 92154 USA
1-866-942-5362
Made in China
E
AUSTRALIA: Our goods come with guarantees that cannot be excluded under the Australian Consumer Law. You are entitled to a replacement or
refund for a major failure and for compensation for any other reasonably foreseeable loss or damage. You are also entitled to have the goods
repaired or replaced if the goods fail to be of acceptable quality and the failure does not amount to a major failure.
14

1
WSWB60-3DR-E-01-TP Top Panel Pcs
18
WSWB60-3DR-E-18-MDP Mid Door Panel Pcs
2
WSWB60-3DR-E-02-MP Mid Panel Pcs
19
WSWB60-3DR-E-19-LDP Left Door Panel Pcs
3
WSWB60-3DR-E-03-BP Back Panle Pcs
20
WSWB60-3DR-E-20-RSF Right Side Frame Pcs
4
WSWB60-3DR-E-04-LSP Left Side Panel Pcs
21
WSWB60-3DR-E-21-SC Svivel Caster Pcs
5
WSWB60-3DR-E-05-BP Bottom Panel Pcs
22
WSWB60-3DR-E-22-CL Caster with Locking Pcs
6
WSWB60-3DR-E-06-PB Peg Board Pcs
23
WSWB60-3DR-E-23-H Handle Pcs
7
WSWB60-3DR-E-07-WP Wood Panel Pcs
24
WSWB60-3DR-E-24-K
Key
Pcs
8
WSWB60-3DR-E-08-TB Top Beam Pcs
25
WSWB60-3DR-E-25-TP Touch-up Pen Pcs
9
WSWB60-3DR-E-09-WD Wire Deck Pcs
26
WSWB60-3DR-E-26-HBM10 Hex Bolt M10x20mmL Pcs
10
WSWB60-3DR-E-10-LSF Left Side Frame Pcs
27
WSWB60-3DR-E-27-PHBM5 Philips Head Bolt M5 x15mmL Pcs
11
WSWB60-3DR-E-11-BB Bottom Beam Pcs
28
WSWB60-3DR-E-28-SM4 Screw M5x20mmL Pcs
12
WSWB60-3DR-E-12-RSP Right Side Panel Pcs
29
WSWB60-3DR-E-29-FHBM4 Flat Head Bolt M4x12mmL Pcs
13
WSWB60-3DR-E-13-S Shelf Pcs
30
WSWB60-3DR-E-30-L Lock Pcs
14
WSWB60-3DR-E-14-TD Triangle Decorate Pcs
31
WSWB60-3DR-E-31-TRHK Tipping Restraint Hardware Kit Pcs
15
WSWB60-3DR-E-15-MD Mid Decotate Pcs
32
WSWB60-3DR-E-32-M20SW M20 Spring Washer Pcs
16
WSWB60-3DR-E-16-TS Tie Support Pcs
33
WSWB60-3DR-E-33-M10SW M10 Spring Washer Pcs
17
WSWB60-3DR-E-17-RDP
Right Door Panel
Pcs
34
WSWB60-3DR-E-34-M10N
M10 Nut
Pcs
35
WSWB60-3DR-E-35-MB
Magnet Block
Pcs
36
WSWB60-3DR-E-36-LS
Lock System
Set
37
WSWB60-3DR-E-36-CH
Complete Hardware
Set
WSWB60-3DR-E 60" Workbench with Cabinet
IF YOU NEED TO ORDER REPLACEMENT PARTS, PLEASE USE THE LIST BELOW
01 03 02 04 05 06 07 08
09 11 10 12 13 14 15 16
24
17 19 18 20 21 23
25 26 27 28 30
22
29 31 35
32 33 34 35 36