Winmate 7'' S-Series User manual

S-Series Panel PC
AMD Geode LX 800 3.5” SBC, Ultra
Low Power, Fanless Design with
CPU, UXGA/LCD, Gigabit Ethernet
and Mini-PCI Interface.
USER’S MANUA
L
Version 1.3

AMDGeodeLXPanelPC User’sManual
I
FCC Statement
THIS DEVICE COMPLIES WITH PART 15 FCC RULES.
OPERATION IS SUBJECT TO THE FOLLOWING TWO
CONDITIONS：
zTHIS DEVICE MAY NOT CAUSE HARMFUL INTERFERENCE.
zTHIS DEVICE MUST ACCEPT ANY INTERFERENCE RECEIVED
INCLUDING INTERFERENCE THAT MAY CAUSE UNDESIRED
PERATION.
THIS EQUIPMENT HAS BEEN TESTED AND FOUND TO COMPLY
WITH THE LIMITS FOR A CLASS "A" DIGITAL DEVICE, PURSUANT
TO PART 15 OF THE FCC RULES. THESE LIMITS ARE DESIGNED TO
PROVIDE REASONABLE PROTECTION AGAINTST HARMFUL
INTERFERENCE WHEN THE EQUIPMENT IS OPERATED IN A
COMMERCIAL ENVIRONMENT. THIS EQUIPMENT GENERATES,
USES, AND CAN RADIATE RADIO FREQUENCY ENERGY AND, IF
NOT INSTATLLED AND USED IN ACCORDANCE WITH THE
INSTRUCTION MANUAL, MAY CAUSE HARMFUL INTERFERENCE
TO RADIO COMMUNICATIONS. OPERATION OF THIS EQUIPMENT
IN A RESIDENTIAL AREA IS LIKELY TO CAUSE HARMFUL
INTERFERENCE IN WHICH CASE THE USER WILL BE REQUIRED TO
CORRECT THE INTERFERENCE AT HIS OWN EXPENSE.

AMDGeodeLXPanelPC User’sManual
II
Copyright Notice
Copyright © 2006 Winmate Technology Inc., ALL RIGHTS RESERVED. No part of
this document may be reproduced, copied, translated, or transmitted in any form or by
any means, electronic or mechanical, for any purpose, without the prior written
permission of the original manufacturer.
Trademark Acknowledgement
Brand and product names are trademarks or registered trademarks of their respective
owners.
Disclaimer
Winmate Communication Inc. reserves the right to make changes, without notice, to
any product, including circuits and/or software described or contained in this manual
in order to improve design and/or performance. Winmate Communication assumes no
responsibility or liability for the use of the described product(s), conveys no license or
title under any patent, copyright, or masks work rights to these products, and makes
no representations or warranties that these products are free from patent, copyright, or
mask work right infringement, unless otherwise specified. Applications that are
described in this manual are for illustration purposes only. Winmate Communication
Inc. makes no representation or warranty that such application will be suitable for the
specified use without further testing or modification.

AMDGeodeLXPanelPC User’sManual
III
Packing List
Before using this Panel PC, please make sure that all the items listed below are
present in your package：
zPanel PC
zPower adapter
zPower cord
zKeyboard and Mouse Y cable
zCD-ROM disc with Driver Utility and User's Manual
zMounting of screws (Option)
If any of these items are missing or damaged, contact your distributor or sales
representative immediately.
Winmate Customer Service
Winmate provide service guide for any problem as follow steps：First, visit the
Winmate website at http://www.winmate.com to find the update information about the
product. Second, contact with your distributor, sales representative, or Winmate｀s
customer service center for technical support if you need additional assistance. You
may have the following information ready before you call：
zProduct serial number
zPeripheral attachments
zSoftware (OS, version, application software, etc.)
zDescription of complete problem
zThe exact wording of any error messages
In addition, free technical support is available from Winmate’s engineers every
business day. We are always ready to give advice on application requirements or
specific information on the installation and operation of any of our products. Please
do not hesitate to call or e-mail us.

AMDGeodeLXPanelPC User’sManual
IV
Safety Precautions
Warning!
Always completely disconnect the power cord from your chassis
whenever you work with the hardware. Do not make connections while
the power is on. Sensitive electronic components can be damaged by
sudden power surges. Only experienced electronics personnel should
open the PC chassis.
Caution!
Always ground yourself to remove any static charge before touching
the CPU card. Modern electronic devices are very sensitive to static
electric charges. As a safety precaution, use a grounding wrist strap at
all times. Place all electronic components in a static-dissipative surface
or static-shielded bag when they are not in the chassis.

AMDGeodeLXPanelPC User’sManual
V
Safety and Warranty
1. Please read these safety instructions carefully.
2. Please keep this user's manual for later reference.
3. Please disconnect this equipment from any AC outlet before cleaning. Do not use
liquid or spray detergents for cleaning. Use a damp cloth.
4. For pluggable equipment, the power outlet must be installed near the equipment
and must be easily accessible.
5. Keep this equipment away from humidity.
6. Put this equipment on a reliable surface during installation. Dropping it or letting
it fall could cause damage.
7. The openings on the enclosure are for air convection. Protect the equipment from
overheating. DO NOT COVER THE OPENINGS.
8. Make sure the voltage of the power source is correct before connecting the
equipment to the power outlet.
9. Position the power cord so that people cannot step on it. Do not place anything
over the power cord.
10. All cautions and warnings on the equipment should be noted.
11. If the equipment is not used for a long time, disconnect it from the power source
to avoid damage by transient over-voltage.
12. Never pour any liquid into an opening. This could cause fire or electrical shock.
13. Never open the equipment. For safety reasons, only qualified service personnel
should open the equipment.
14. If any of the following situations arises, get the equipment checked by service
personnel:
A. The power cord or plug is damaged.
B. Liquid has penetrated into the equipment.
C. The equipment has been exposed to moisture.
D. The equipment does not work well, or you cannot get it to work according to
the user’s manual.
E. The equipment has been dropped and damaged.
F. The equipment has obvious signs of breakage.
15. DO NOT LEAVE THIS EQUIPMENT IN AN UNCONTROLLED
ENVIRONMENT WHERE THE STORAGE TEMPERATURE IS BELOW -20°
C (-4°F) OR ABOVE 60° C (140° F). IT MAY DAMAGE THE EQUIPMENT.

AMDGeodeLXPanelPC User’sManual
VI
Revision History
Version Date Note Author
1.0 2006.05.01 9First Version Wayne Lin
1.1 2006.09.20 9Revise the
specification of
Ethernet and
Watchdog.
9ForA830ver.11
0
Wayne Lin
1.2 2006.10.31 9Revise the
specification for A830
ver. 120
9Update new BIOS
setting for ver. 00F
Wayne Lin
1.3 2006.11.27 9Update new BIOS
setting for ver. 00I
Wayne Lin

AMDGeodeLXPanelPC User’sManual
VII
Contents
Chapter 1 General Information……….…… 1
1.1 Introduction……………………………… 2
1.2 System Specifications………………….. 3
1.3 LCD Specifications……………………… 4
1.4 Mechanical Drawing……………………. 5
1.5 Input / Output Devices………………….. 17
1.6 Mounting…………………………………. 18
Chapter 2 System Installation……………... 19
2.1 HDD Installation………………………… 21
2.2 Memory Module Installation…………… 22
2.3 I/O Equipment Installation……………... 23
2.4 Running the BIOS Setup Program……. 24
Chapter 3 The Engine of the PPC…………. 25
3.1 Introduction……………………………… 26
3.2 Features…………………………………. 26
3.3 Jumpers and Connectors List…………. 27
3.4 Clear CMOS…………………………….. 31
3.5 LVDS Voltage Select…………………… 31
3.6 RS 232 / RS 422 / RS 485 Selector….. 32
Chapter 4 Ethernet Interface………………. 33
4.1 Introduction……………………………… 34
4.2 Installation of Ethernet Driver…………. 34
4.3 Further Information……………………... 36
Chapter 5 VGA Setup……………………….. 37
5.1 Introduction……………………………… 37
5.2 Installation of VGA Driver………………. 37
5.3 Further Information……………………... 41

AMDGeodeLXPanelPC User’sManual
VIII
Chapter 6 AUDIO Setup…………………….. 42
6.1 Introduction………………………………. 43
6.2 Installation of Audio Driver……………... 44
6.3 Further Information……………………… 46
Chapter 7 BIOS Setup………………………. 47
7.1 Starting Setup…………………………… 48
7.2 Award BIOS Setup……………………… 49
7.3 Standard CMOS Features Setup……… 51
7.4 Advanced BIOS Features Setup………. 53
7.5 Advanced Chipset Features Setup……. 55
7.6 Integrated Peripherals………………….. 57
7.7 Power Management Setup…………….. 58
7.8 PNP/PCI Configuration Setup…………. 59
7.9 PC Health Status………………………... 59
7.10 Load Fail-Safe Defaults………………… 60
7.11 Load Optimized Defaults………………. 60
7.12 Supervisor / User Password Setting….. 61
7.13 Save and Exit Setup……………………. 62
7.14 Exit Without Saving……………………... 63
Chapter 8 Touch Screen……………………. 64
8.1 Introduction………………………………. 65
8.2 Installation of Drive for Elo AccuTouch .. 65
8.3 Installation of Drive for Premier Touch... 68
Appendix A Pin Assignments…………………… 72

AMDGeodeLXPanelPC User’sManual
IX
Figures
Figure 1.1 Product Overview……………………….. 2
Figure 1.2 6.4 “ Mechanical Rear View 5
Figure 1.3 6.4 “ Connector Description 5
Figure 1.4 6.4 “ Mechanical Drawing 6
Figure 1.5 6.5 “ Mechanical Rear View 7
Figure 1.6 6.5 “ Connector Description 7
Figure 1.7 6.5 “ Mechanical Drawing 8
Figure 1.8 8.4 “ Mechanical Rear View 9
Figure 1.9 8.4 “ Connector Description 9
Figure 1.10 8.4 “ Mechanical Drawing 10
Figure 1.11 10.4 “ Mechanical Rear View 11
Figure 1.12 10.4 “ Connector Description 11
Figure 1.13 10.4 “ Mechanical Drawing 12
Figure 1.14 12.1 “ Mechanical Rear View 13
Figure 1.15 12.1 “ Connector Description 13
Figure 1.16 12.1 “ Mechanical Drawing 14
Figure 1.17 15 “ Mechanical Rear View 15
Figure 1.18 15 “ Connector Description 15
Figure 1.19 15 “ Mechanical Drawing 16
Figure 1.20 Input / Output Devices………………….. 17
Figure 2.1 DVD ROM Drawing……………………… 23
Figure 3.1
Locating Jumpers and Connectors (front side)
30
Figure 3.2
Locating Jumpers and Connectors (rear side). 31
Figure 7.1 BIOS Setup Main Menu………………… 50
Figure 7.2 Standard CMOS Features……………… 52
Figure 7.3 Advanced BIOS Features………………. 54
Figure 7.4 Advanced Chipset Features……………. 56
Figure 7.5 Integrated Peripherals………………….. 58
Figure 7.6 Power Management Setup…………….. 60

AMDGeodeLXPanelPC User’sManual
X
Figure 7.7 PC Health Status………………………… 62
Figure 7.8 Supervisor / User Password Setting…... 64
Figure 7.9 Save and exit setup screen…………….. 65
Figure 7.10 Exit without Saving setup screen………. 66

AMDGeodeLXPanelPC User’sManual
XI
Tables
Table 1.1 LCD Specifications………………………. 4
Table 1.2 Input / Output Devices…………………... 17
Table 3.1 Jumpers…………………………………… 27
Table 3.2 Connectors……………………………….. 28
Table 3.3 Clear CMOS (J5)………………………… 31
Table 3.4 LVDS Voltage Select (JP10)……………. 31
Table 3.5 RS 232 / 422 / 485 Selector (JP13)……. 32
Table 3.6 RS 232 / 422 / 485 Selector (JP14)……. 32

AMDGeodeLXPanelPC User’sManual
1
General Information
This chapter includes the PPC background information.
Sections include:
zIntroduction
zSystem Specification
zLCD Specification
zMechanical Drawing
zInput / Output Devices
zMounting
CAP T E R
1

AMDGeodeLXPanelPC User’sManual
2
1.1 Introduction
The Panel PC is high performance, fanless, low power PC with AMD CS 5536
chipset combine with a TFT LCD Panel. The AMD LX 800 fanless, high
performance CPU delivers the most performance per watt available in the
market. The Panel PC is designed to satisfy most of the applications in the
industrial market, such as POS, KIOSK, Industrial Automation, Programmable
Control System, and HMI. It’s a PC-based system with DDR SDRAM,
VGA/LCD controller, multi-COM port interface, and on-board Gigabit
Ethernet. The Panel PC supports one Mini-PCI, one CF socket for function
upgrade. It is a compact design to meet the demanding performance
requirements of today’s business and industrial applications.
Panel PC combines a motherboard, the digital display using TFT LCD within a
compact chassis. Panel PC offers any option to add on HDD and Touchscreen
as a matter of user’s preference. The compact design and extensive function
make the Panel PC a dedicated system for all kinds of application.
Figure 1.1 Product Overview

AMDGeodeLXPanelPC User’sManual
3
1.2 System Specifications
CPU: AMD Embedded LX-800 Micro-processor,
¾Ultra-low power about 3.9Watts
Chips set: AMD CS5536 Companion Device
BIOS : AWARD Flash memory
System memory: One 200-pin SODIMM socket accepts up to 1GB
SDRAM
Enhanced IDE interface : Supports up one channel two EIDE devices
¾BIOS auto-detected for DMA33 mode(ATA-4)
¾One 44pins hard disk interface
Serial Ports:
¾One serial RS-232 port
¾Three serial RS-232 pin headers, one for RS-232/422/485 jumper.
Keyboard/mouse connector: Mini-DIN connector supports PS/2
interface
USB interface : Two USB ports onboard, two USB pin header
Video interface:
¾Chipset : LX-800 including
¾Display type: Support CRT and TFT LCD displays
¾CRT and flat panel can display simultaneously
¾Panel resolution support up to 1280 x 1024 @18bpp or 24bpp
Audio function:
¾Chipset: Realtek ALC203 AC97 compliant interface
¾Audio interface: Microphone in, CD audio in, Earphone out
Ethernet interface
¾Chipset: Realtek RTL8110S
¾Ethernet interface : PCI 10/100/1000 Mbps Ethernet protocol
compatible
¾Connection: On-board RJ-45 connector
Mechanical and environmental
¾Dimensions (L x W) : 145 mm x 102 mm(5.9” x 4.2”) (Mainboard)
¾Power supply voltage: +8 ~ +19Volts DC-input
¾Power consumption (typical): +19V/5A@70Watts
¾Operating temperature : 0 ~ 60。C(32 ~ 140。F)
¾Operating Humidity: 0% ~ 90% Relative humidity,
non-condensing

AMDGeodeLXPanelPC User’sManual
4
1.3 LCD Specifications
Item
Size Resolution (Recommended) Display Color
R06A83S-
XXP1 640x480 262144
(6bit / colors)
R06A83S-
XXM1 640x480 260K
R08A83S-
XXM1 640x480 262144
(6bit / colors)
R08A83S-
XXU1 800x600 262144
(6bit / colors)
R08A83S-
XXT1 800x600 262144
(6bit / colors)
R10A83S-
XXP1 800x600 262144
(6bit / colors)
R10A83S-
XXP3 640x480 260K
R10A83S-
XXU1 800x600 262144
(6bit / colors)
R10A83S-
XXM1 640x480 262144
(6bit / colors)
R10A83S-
XXH1 1024x768 262144
(6bit / colors)
R12A83S-
XXL1 800x600 262,144
(6bit/colors)
R12A83S-
XXM1 800x600 262144
(6bit / colors)
R12A830S-
XXM2 1024x768 262,144
(6bit/colors)
R15A83S-
XXC3 1024x768 16.2M
(6bit+FRC)
R15A83S-
XXM4 1024x768 16.2M
(6bit+FRC)
R15A83S-
XXA1 1024x768 262,144
(6bit/colors)
R17A83S-
XXM1 1280x1024 16.2M
(8bit / colors)
R19A83S-
XXM1 1280x1024 16.2M
(8bit / colors)
Table 1.1 LCD Specifications

AMDGeodeLXPanelPC User’sManual
5
1.4 Mechanical Drawing
1. R06A83S-PMP1
Figure 1.2 6.4 “ Mechanical Rear View
Figure 1.3 6.4 “ Connector Description

AMDGeodeLXPanelPC User’sManual
6
Figure 1.2 Mechanical Drawing(8.4”For Example)
Figure 1.4 6.4 “ Mechanical Drawing

AMDGeodeLXPanelPC User’sManual
7
2. R06A83S-PMM1
Figure 1.5 6.5 “ Mechanical Rear View
Figure 1.6 6.5 “ Connector Description

AMDGeodeLXPanelPC User’sManual
8
Figure 1.7 6.5 “ Mechanical Drawing